Table of Content:
1 Introduction
1.1 Foreword
1.2 Look For Supplemental Information
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator?s Manual
4.2 Instructional Seat (If Equipped)
4.3 Seat Belt
4.4 Starter
4.5 Engine Block Heater?13.5 L Engine
4.6 Engine Block Heater?15 L Engine
4.7 Park Brake (Stored Energy)
4.8 Rotating Driveline
4.9 Hinge Area
4.10 Rear PTO Shield (If Equipped)
4.11 Quick Coupler (If Equipped)
4.12 Track Accumulators
4.13 Trash Build-Up
5 Vehicle Overview
5.1 9RX Series Tractor
6 Operator?s Manual Use
6.1 Operator?s Manual Use
7 General Vehicle Description
7.1 9RX Series Tractor
8 Engine Operation
8.1 Required Machine Stop Warning
8.2 Engine Fuel System and Power Rating
8.3 Battery Disconnect Switch
8.4 Start the Engine
8.5 Run the Engine
8.6 Stop the Engine
8.7 Restart Engine That Has Run Out of Fuel
8.8 Reduce Fuel Consumption
8.9 Use Battery Booster or Charger
9 Cold Weather Operation
9.1 Cold Weather Starting?With Starting Aid
9.2 Cold Weather Starting And Operation?Internal Starting Aid
9.3 Change Starting Fluid Canister
9.4 Engine Coolant Heater Use?13.5 L Engine
9.5 Engine Coolant Heater Use?15 L Engine
10 Emissions Equipment
10.1 Exhaust Filter System Overview?Final Tier 4/Stage IV Engine
10.2 Aftertreatment Indicators Overview
10.3 Selective Catalytic Reduction (SCR) System Overview
10.4 Auto Exhaust Filter Cleaning Mode?Final Tier 4/Stage IV Engine
10.5 Parked Exhaust Filter Cleaning?Final Tier 4/Stage IV Engine
10.6 Selective Catalytic Reduction (SCR) System?Final Tier 4/Stage IV Engine
10.7 Low Fuel or Low DEF Warning
10.8 Disconnect Battery?Final Tier 4/Stage IV Engine
11 Controls and Instruments
11.1 Front Console
11.2 CommandARM? ISOBUS Shortcut Button (ISB)
11.3 Foot Decelerator
12 Corner Post Display
12.1 Corner Post Display
12.2 Information Indicators
12.3 Digital Indicators?Tachometer, Ground Speed and Transmission
12.4 Gauges?Coolant Temperature, DEF Level and Fuel Level
13 CommandARM? Controls
13.1 CommandARM? with Generation 4 CommandCenter? Display
13.2 CommandARM? Hitch Controls
13.3 CommandARM? SCV Control Levers
13.4 CommandARM? Climate, Radio and Lighting Controls
13.5 CommandARM? PTO Control Levers
13.6 CommandARM? Left-Hand Side Controls
14 CommandCenter?
14.1 Onscreen Help
14.2 Generation 4 CommandCenter?
14.3 Generation 4 CommandCenter? Processor
14.4 Generation 4 CommandCenter? 4600 Processor Wi-Fi? Capabilities
14.5 Federal Communications Commission and Industry Canada Notification
14.6 Run Page Structure
14.7 Menu
14.8 Machine Settings Overview
14.9 Operating System Applications Overview
14.10 AMS Applications Overview
14.11 CommandCenter? Activations
14.12 Demo Activations
14.13 Automation Status Overview
14.14 Navigate Generation 4 CommandCenter?
14.15 Power Display On and Off
14.16 Navigate Run Pages on Main Page
14.17 Shortcut Buttons
14.18 Navigate to Display & Sound
14.19 Display and Sound
14.20 Brightness
14.21 Sound
14.22 Multiple Displays
14.23 Display Calibration
14.24 Navigate to Date & Time
14.25 Date and Time
14.26 Change Current Date
14.27 Change Current Time
14.28 Navigate to Language & Units
14.29 Language and Units
14.30 Language and Units Settings
14.31 Change Pages and Values
14.32 Status Center
14.33 Shortcut Softkeys
14.34 Navigate to Software Manager
14.35 Software Manager
14.36 Factory and Service ADVISOR? Installed Onscreen Help
14.37 Update Display Software
14.38 Activations
14.39 Service ADVISOR? Remote
14.40 Vehicle Reprogramming
14.41 Troubleshooting ? Reprogramming
14.42 System Recovery
14.43 Remote Display Access
14.44 Navigate to File Manager
14.45 File Manager
14.46 USB Drive
14.47 Capture Screen Shots
14.48 Navigate to Diagnostics Center
14.49 Diagnostics Center
14.50 Controller Diagnostics
14.51 Diagnostic Information
14.52 Hide Diagnostic Center
14.53 Diagnostic Trouble Codes
14.54 Display Hardware
14.55 CAN Bus Information
14.56 CAN Bus Values
14.57 Network
14.58 DataSync
14.59 Navigate to Users & Access
14.60 Users and Access
14.61 User Profiles
14.62 Access Groups
14.63 Navigate to Layout Manager
14.64 Layout Manager
14.65 Active Set
14.66 Shortcut Bar
14.67 All Run Pages
14.68 Add, Edit, or Duplicate Run Pages
14.69 Navigate to Fields
14.70 Fields and Boundaries
14.71 Field Boundaries
14.72 Manage Clients, Farms, and Fields
14.73 AutoTrac? Guidance
14.74 Navigate to Equipment Manager
14.75 Equipment Manager
14.76 Machine Profile
14.77 Implement Profile
14.78 Navigate to Machine Monitor
14.79 Machine Monitor
14.80 Navigate to Work Monitor
14.81 Work Monitor
14.82 Work Recording
14.83 Navigate to Maintenance & Calibrations
14.84 Maintenance and Calibrations
14.85 Calibrations
14.86 Radar Calibration
14.87 Slip Calibration
14.88 Service Intervals
14.89 Steering
14.90 Steering Settings
14.91 Controls Setup
14.92 Settings Manager
14.93 Automation Status
14.94 Read ISOBUS Controller?s Operator?s Manual
14.95 ISOBUS VT
14.96 StarFire? GPS Receiver
14.97 Use Video Display Capability Properly
14.98 Install Video Display Camera
14.99 Navigate to Video Application
14.100 Video
14.101 Video Triggers
15 Radio Operation
15.1 Radio Faceplate Features
15.2 Select Radio Receiver Wave Band
15.3 Federal Communications Commission (FCC) Bluetooth? Information
15.4 Set Clock
15.5 Turn Confirmation Beep On/Off (BEEP)
15.6 Adjust Maximum Volume at Power-On (ONVOL)
15.7 Program Type (PTY)
15.8 Treble Reduction During Interference (HCUT)
15.9 Set Key Function (KEY PRG)
15.10 SiriusXM? Radio?General Information
15.11 Display XM Serial Number
15.12 External Sources (Premium Radio)
15.13 Select Radio Source with Generation 4 CommandCenter?
15.14 AM, FM, Weather Channel Home Page
15.15 Premium Radio CD Home Page
15.16 Premium Radio XM Home Page
15.17 Premium Radio USB Home Page
15.18 Premium Radio Bluetooth? Home Page (If Equipped)
15.19 Auxiliary Home Page
15.20 Pair Bluetooth? Device to Generation 4 CommandCenter?
15.21 Manage Paired Bluetooth? Devices
15.22 Phone Operation
15.23 Phone Signal Strength and Battery Charge
15.24 Contact List
15.25 Recent Calls
15.26 Clear Favorites and Call History
16 AMS? Technology
16.1 Machine Sync
16.2 Mount StarFire? Receiver
16.3 Install GreenStar? System Components
16.4 Install Machine Communications Radio (MCR) Antenna
16.5 Connect AutoTrac? Assisted Steering System
17 Intelligent Total Equipment Control (iTEC?)
17.1 CommandARM? Control Functions
17.2 CommandCenter? Pages Descriptions and Functions
17.3 Status Area
17.4 All Sequence Page
17.5 Add New Sequence
17.6 Sequence Step Status
17.7 Edit or Remove Sequence
17.8 Sequence Sets Page
17.9 Perform Sequence
17.10 Recommendations (AutoLearn)
17.11 iTEC? Functions?Efficiency Manager?
18 Tractor-Implement Automation? (TIA?)
18.1 Tractor-Implement Automation? (TIA?)
18.2 Activate Tractor-Implement Automation? Equipment
18.3 Tractor-Implement Automation? ? Status Page
18.4 Operate Tractor-Implement Automation?
18.5 PTO Requirements
18.6 SCV Requirements
18.7 Powershift Transmission Requirements
18.8 AutoTrac? Guidance Requirements
18.9 Rear Hitch Requirements
18.10 Drive Strategy Requirements
19 Drivetrain
19.1 Drivetrain Overview
19.2 Drivetrain Protection?9420RX, 9470RX, 9520RX, 9570RX, and 9620RX
20 Differential Lock
20.1 Differential Lock
20.2 Change Differential Lock Disengagement Steering Angle
21 Brakes
21.1 Brake Use
21.2 Brake Warning Indicators
21.3 Hydraulic Trailer Brakes
21.4 Trailer Brake Settings
21.5 Engine Brake ? 15 L Engine (If Equipped)
21.6 Foot Decelerator
22 Transmission – General Information
22.1 Warm-Up Transmission-Hydraulic System
22.2 Activate and Set Maximum Set Speed
22.3 Use Maximum Set Speed with Different Transmission Modes
22.4 Backup Alarm
22.5 Come-Home Mode
23 e18? Powershift Transmission
23.1 Operate the e18? Powershift Transmission
23.2 Shift e18? Transmission
23.3 Avoid Tractor Overspeed
23.4 Set Start Gears
23.5 CommandCenter? Transmission Main Page
23.6 Efficiency Manager? on the e18? Transmission
23.7 Custom Transmission Settings
24 PTO, Hitch, and Drawbar
24.1 Attach PTO-Driven Implement
24.2 Hitch External Switches
25 PTO – General Information
25.1 Stay Clear of Rotating Drivelines
26 PTO
26.1 Use PTO Master Shield (If Equipped)
26.2 PTO Engine Speed
26.3 Operate PTO
26.4 PTO Engagement Rate
27 Hitch
27.1 Rear Hitch
27.2 Hitch Control Lever
27.3 Rear Hitch Lock
27.4 Adjust Load/Depth Control (Draft Response)
27.5 Using Position Control
27.6 Using Draft Control
27.7 Adjust Upper Limit
27.8 Adjust Drop Rate
27.9 Adjust Raise Rate
27.10 Slip Sensitivity
27.11 Float Operation
27.12 Hitch Components
27.13 Hitch Remote Switches
27.14 Manual Lowering
27.15 Sway Blocks
27.16 Attach Implement to Quick Coupler
27.17 Adjust Implement Level
27.18 Lateral Float
27.19 Detach Implement From Quick Coupler
27.20 Hitch Conversion ? Category 4/4N Convertible Quick Coupler
27.21 Converting Category 4N/3 Convertible Quick Coupler Lower Hooks
27.22 Converting Category 4N/3 Convertible Quick Coupler Upper Hook
28 Drawbar
28.1 Drawbar Load Limits
28.2 Selecting Drawbar Position
28.3 Adjusting Drawbar Side-to-Side
28.4 Install Clevis Assembly ? Category 4 Drawbar
28.5 Clevis Assembly Use ? Category 4 Drawbar
28.6 Install Clevis Assembly ? Category 5 Drawbar
28.7 Clevis Assembly Use ? Category 5 Drawbar
28.8 Use Correct Drawbar Pin ? Category 5 to 4
29 Hydraulics – General Information
29.1 Hydraulic System Overview
30 Selective Control Valves
30.1 Configure SCV Modes
30.2 Configure SCV – Standard Mode
30.3 Activate Independent Mode
30.4 Configure SCV – Independent Mode
30.5 Configure SCV – Feature Mode
30.6 Total Rear SCV Flow
30.7 Six-Position SCV Control Levers
30.8 SCV Control Lever?Neutral Position
30.9 SCV Control Lever?Extend and Retract Position
30.10 SCV Control Lever?Extend Detent and Retract Detent Position
30.11 SCV Control Lever?Float Position
30.12 Operator Presence Sensor
30.13 Hitch External Switches
30.14 CommandARM? Joystick (If Equipped)
30.15 CommandARM? Joystick (If Equipped) – Custom Setup
30.16 CommandARM? Joystick (If Equipped) – Layout and Joystick Lever Functions
30.17 SCV and Joystick Flow Response Setting
31 Hydraulic Connections
31.1 Connecting Hydraulic Hoses?Rear of Tractor
31.2 Disconnecting Hydraulic Hoses?Rear of Tractor
31.3 Standard Hydraulic Component Identification
31.4 High Flow Hydraulic Component Identification
31.5 Using Load-Sensing Hydraulic System?Power-Beyond
31.6 Examples Using Load-Sensing Hydraulic System?Power-Beyond
31.7 Using Hydraulic Spray Pumps
31.8 Implement Connection Example 1?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)?Less Hitch?Standard Hydraulics
31.9 Implement Connection Example 2?Motor Application Using Motor Case Drain?Less Hitch?Standard Hydraulics
31.10 Implement Connection Example 3?Closed Center Valve, Pump at High Pressure?Less Hitch?Standard Hydraulics
31.11 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip?Less Hitch?Standard Hydraulics
31.12 Implement Connection Example 5?Planter with Vacuum Motor and Return Line to Motor Return?With Hitch?With Lift Assist?Standard Hydraulics
31.13 Implement Connection Example 6?Planter with Vacuum Motor and Return Line to Motor Return?With Hitch?Implement Lift Assist?Standard Hydraulics
31.14 Connecting Implements to High Flow Hydraulic SCV’s
31.15 Implement Connection Example 1?Implement Control Valves?Less Hitch?High Flow Hydraulics
31.16 Implement Connection Example 2?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)?Less Hitch?High Flow Hydraulics
31.17 Implement Connection Example 3?Closed Center Valve, Pump at High Pressure?Less Hitch?High Flow Hydraulics
31.18 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip?With Hitch?High Flow Hydraulics
31.19 Implements Requiring Large Volumes of Oil
32 TouchSet? Depth Control
32.1 Attaching Implement and Control System
32.2 Using TouchSet? Depth Controls
33 Laser Scraper Control
33.1 Laser Scraper?for Scrapers Equipped with Scraper Control Unit
34 Tracks – General Information
34.1 General Track Use Guidelines
34.2 Tracks Service
35 Operator?s Station – General Information
35.1 Avoid Contact with Agricultural Chemicals
35.2 Clean Vehicle of Hazardous Pesticides
35.3 Keep Riders Off Machine
35.4 Keep Operator Station Window and Door Closed
35.5 Use Seat Belts
35.6 Use Emergency Exit
35.7 Monitor Bracket Mounts
36 Seat
36.1 Adjust ComfortCommand? Seat
36.2 Adjust Heated Leather Seat
36.3 Adjust CommandARM? Position
36.4 Use Instructional Seat
36.5 Operator Presence Sensor
37 Steering Column
37.1 Adjust Steering Wheel and Column
37.2 Operate Horn
38 Mirrors
38.1 Manual Mirror
38.2 Electric Mirror
38.3 Telescoping Heated Electric Mirror
39 Wiper Washer
39.1 Operate Front Windshield Wiper and Washer
39.2 Operate Rear Wiper and Washer
39.3 Operate Right-Hand Wiper and Washer
40 Lights
40.1 Light Identification
40.2 Configurable Lights
40.3 Steering Column Light Controls
40.4 Exit Lights
40.5 Operate Turn Signals and High/Low Beam
40.6 Safety Lights and Devices
40.7 CommandARM? Light Buttons
40.8 Hazard Lights and Extremity Warning Lights
40.9 Rotary Beacon Light
40.10 7-Pin Outlet
41 Accessories
41.1 Pull-Down Sunshade
41.2 Install Business Band or Citizens Band (CB) Radio and Antenna
41.3 Auxiliary Power Strip Use
41.4 Accessory Electrical Outlet Use
41.5 Connect Compatible Electronic Equipment
41.6 Configure Tractor for GPS or Radar
41.7 Refrigerator or Storage Space
41.8 Implement Connector Use
42 HVAC
42.1 Climate Controls
42.2 HVAC Settings?Generation 4 CommandCenter?
43 Performance Ballasting
43.1 Ballast Recommendations
43.2 Mounted Attachments
43.3 Measure Track Slip
43.4 Quik-Tatch? Weight Use
44 Transport
44.1 Weight Chart – Narrow Track (If Equipped)
44.2 Driving Tractor on Roads
44.3 Extended Road Transport
44.4 Towed Loads and Transport with Ballast
44.5 Use Safety Lights and Devices
44.6 Use Safety Chains
44.7 Carrier Transport
44.8 Load Extended Axle Width Track Tractor
44.9 Towing with All Wheels on Ground?Engine Will Start
44.10 Towing with All Wheels on Ground?Engine Will Not Start
44.11 Freeing a Mired Machine
45 Fuel, Lubricants, and Coolant – General Information
45.1 Determine Tractor Engine Type
45.2 Minimizing the Effect of Cold Weather on Diesel Engines
45.3 Oil Filters
46 Fuel
46.1 Diesel Fuel
46.2 Supplemental Diesel Fuel Additives
46.3 Lubricity of Diesel Fuel
46.4 Handling and Storing Diesel Fuel
46.5 Avoid Static Electricity Risk When Refueling
46.6 Fill Fuel Tank
46.7 Biodiesel Fuel
46.8 Testing Diesel Fuel
46.9 Fuel Filters
47 Diesel Exhaust Fluid (DEF)
47.1 Fill DEF Tank – FT4/Stage IV Engine
47.2 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
47.3 Storing Diesel Exhaust Fluid (DEF)
47.4 Refilling Diesel Exhaust Fluid (DEF) Tank
47.5 Testing Diesel Exhaust Fluid (DEF)
47.6 Disposal of Diesel Exhaust Fluid (DEF)
48 Engine Oil
48.1 Diesel Engine Oil Service Interval for Operation at High Altitude
48.2 John Deere Break-In Plus? Engine Oil ? Final Tier 4 and Stage IV 13.5 L Engine
48.3 Break-In Engine Oil Use ? Final Tier 4 and Stage IV 15 L Engines
48.4 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
48.5 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 13.5 L Engines
48.6 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 15 L Engine
49 Engine Coolant
49.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
49.2 John Deere COOL-GARD? II Coolant Extender
49.3 Operating in Warm Temperature Climates
49.4 Water Quality for Mixing with Coolant Concentrate
49.5 Testing Coolant Freeze Point
49.6 Disposing of Coolant
50 Other Lubricants
50.1 Transmission and Hydraulic Oil
50.2 Multipurpose Extreme Pressure (EP) Grease
50.3 Lubricant Storage
50.4 Mixing of Lubricants
50.5 Alternative and Synthetic Lubricants
51 Service – General Information
51.1 Service Sections Overview
51.2 Service Tasks Performed As Required
51.3 Identify Tractor Engine Emissions Status
51.4 Open Hood
51.5 Jack Up Tractor – Lifting Points and Support Stand Placement (2010-52-EU)
51.6 Service and Connect STC? (Snap-to-Connect) Fittings
51.7 High-Pressure Washer Use
51.8 Diesel Particulate Filter Service
51.9 Exhaust Filter / Diesel Particulate Filter Ash Handling and Disposal
51.10 Exhaust Filter Disposal
51.11 Transmission Calibration
51.12 Abort Transmission Calibration
51.13 Do Not Modify Fuel System
51.14 Do Not Open High-Pressure Fuel System
51.15 Bleed Fuel System
51.16 Identify Zinc-Flake Coated Fasteners
51.17 Metric Bolt and Screw Torque Values
51.18 Unified Inch Bolt and Screw Torque Values
52 Service – Predelivery Checklist
52.1 Predelivery Checklist
53 Service – Delivery Checklist and Certificate
53.1 Delivery Checklist and Certificate
54 Break-In Service (100 Hours or Less)
54.1 Perform Break-In Services
54.2 Perform Track Systems Break-In
55 Service – Record Charts
55.1 Engine Oil and Filter Change
55.2 As Required Service
55.3 Annual Service
55.4 10 Hour or Daily Service
55.5 50 Hour Service
55.6 250 Hour Service
55.7 400 Hour Service
55.8 500 Hour Service
55.9 750 Hour Service
55.10 800 Hour Service
55.11 1000 Hour Service
55.12 1200 Hour Service
55.13 1250 Hour Service
55.14 1500 Hour Service
55.15 1600 Hour Service
55.16 1750 Hour Service
55.17 2000 Hour Service
55.18 2250 Hour Service
55.19 2400 Hour Service
55.20 2500 Hour Service
55.21 2750 Hour Service
55.22 2800 Hour Service
55.23 3000 Hour Service
55.24 3200 Hour Service
55.25 3250 Hour Service
55.26 3500 Hour Service
55.27 3600 Hour Service
55.28 3750 Hour Service
55.29 4000 Hour Service
55.30 4250 Hour Service
55.31 4400 Hour Service
55.32 4500 Hour Service
55.33 4750 Hour Service
55.34 4800 Hour Service
55.35 5000 Hour Service
55.36 5200 Hour Service
55.37 5250 Hour Service
55.38 5500 Hour Service
55.39 5600 Hour Service
55.40 5750 Hour Service
55.41 6000 Hour Service
55.42 Services – 6250 to 8800 Hours
55.43 9000 Hour Service
55.44 Services Beyond 9000 Hours
56 Service – Clean
56.1 Diesel Particulate Filter (DPF)?Final Tier 4/Stage IV Engine
56.2 Engine Cooling System?13.5 L Engine
56.3 Engine Cooling System?15 L Engine
56.4 DEF Tank
56.5 DEF Tank Filler Neck Filter
56.6 Clean Display
56.7 Dual Beam Radar Sensor
56.8 Optional Fuel Water Separator
56.9 Optional Fuel Water Separator Filter Element
56.10 Aftertreatment Fuel Injector?15 L Engine
57 Service – Check
57.1 Engine Coolant Level
57.2 Engine Coolant Freeze Point
57.3 Optional Fuel/Water Separator
57.4 Water Separator
57.5 Engine and Exhaust Compartments
57.6 Outer Exhaust Screens
57.7 Air Conditioning System
57.8 Engine Water Pump Weep Hole?13.5 L Engine
57.9 Engine Water Pump Seal?15 L Engine
57.10 Fuel Tank Sump
57.11 Engine Oil Level?13.5 L Engine
57.12 Engine Oil Level?15 L Engine
57.13 Transmission-Hydraulic Oil Level
57.14 Track Alignment
57.15 Track Tension
57.16 Track Wear
57.17 Track Trash Buildup
57.18 Cab Suspension Bushings
57.19 Undercarriage
57.20 Undercarriage Articulation Bumper Stops
57.21 Drive, Mid-Rollers, and Idler Wheels
57.22 Mid-Rollers Oil Level
57.23 Idler Wheel Hub Oil Level
57.24 Drive Wheel Scraper Clearance
57.25 NEUTRAL Start System
57.26 Transmission PARK System
57.27 Engine Air Intake System?13.5 L Final Tier 4/Stage IV Engine
57.28 Engine Air Intake System?15 L Engine
57.29 Seat Belts
57.30 Auxiliary Drive Belt and Drive Belt Tensioner
57.31 Engine Valve Clearance
57.32 Vari-Cool? Fan Drive and Belt?13.5L Final Tier 4/Stage IV Engine
57.33 Suspension Mount Clearance (Narrow Track)
57.34 Front Driveshaft Health (FDH) Sensor System
58 Service – Tighten
58.1 Mid-Roller, Drive, and Idler Wheel Fasteners
58.2 Drawbar Support and Cap Screws
59 Service – Change
59.1 Vari-Cool? Fan Belt?13.5 L Final Tier 4/Stage IV Engine
59.2 Auxiliary Drive Belt?13.5 L Engine
59.3 Auxiliary Drive Belt?15 L Engine
59.4 Engine Oil and Filter?13.5 L Engine
59.5 Engine Oil and Filter?15 L Engine
59.6 Fuel Filters?13.5 L Engine
59.7 Fuel Filters?15 L Engine
59.8 Cab Recirculation Air Filter
59.9 Cab Fresh Air Filter
59.10 Engine Primary and Secondary Air Filters
59.11 Fuel Tank Vent Filters
59.12 SCV Pilot Valve Filter
59.13 DEF Tank Vent Filter?Final Tier 4/Stage IV Engine
59.14 DEF Header Filter?Final Tier 4/Stage IV Engine
59.15 Transmission-Hydraulic Oil and Filters
59.16 Engine Cooling System Radiator Cap?15 L Engine
59.17 Transmission-Hydraulic Vent Filter
59.18 Access DEF Dosing Unit Filter?Final Tier 4 or Stage IV Engine
59.19 DEF Dosing Unit Filter?Final Tier 4/Stage IV Engine
59.20 Transmission Drive Shaft Damper
59.21 Engine Coolant?13.5 L Engine
59.22 Engine Coolant?15 L Engine
59.23 Engine Crankshaft Damper?13.5 L Engine
59.24 Engine Crankcase Breather Filter Element?15 L Engine
59.25 Front Drive Shaft U-Joints
60 Service – Lubricate
60.1 Heavy Duty Lift Link Pins (Optional)
60.2 Hinge Pins
60.3 Steering Pins
60.4 Telescoping Drive Shaft
60.5 PTO Drive Shaft
60.6 Track Tension Cylinder
60.7 Heavy-Duty Gudgeon Bearings
60.8 Lower Drive Line Bearings
60.9 Rear Hitch
60.10 Lift Cylinders and Rockshaft
60.11 Vari-Cool? Fan Drive?13.5 L Final Tier 4/Stage IV Engine
61 Service – Electrical
61.1 Service – Electrical Overview
61.2 Welding Near Electronic Control Units
61.3 Keep Electronic Control Unit Connectors Clean
61.4 Compressed Air Use
61.5 High-Pressure Washer Use
61.6 Disconnect Battery?Final Tier 4/Stage IV Engine
61.7 Handling Batteries Safely
61.8 Service Batteries and Connectors?15 L Engine
61.9 Service Batteries and Connectors?13.5 L Engine
61.10 Access Load Center Fuses
61.11 Access Master Fuses
61.12 Access Implement Power Relay Module Fuses
61.13 Handle Halogen Light Bulbs Safely
61.14 Change Front HID/LED Light Assembly
61.15 Change Front Grille Halogen Light Bulbs
61.16 Adjust Front Grille Lights
61.17 Adjust Headlights
61.18 Change Front, Side And Rear Cab Roof Light Bulb
61.19 Change Brake or Turn Signal Light Bulb
61.20 Change Dome Light Bulb
61.21 Change Extremity Warning Light Bulb
62 Troubleshooting – Procedures
62.1 Engine
62.2 Transmission-Hydraulic-Axles
62.3 Hydraulic System
62.4 Brakes
62.5 Hitch
62.6 Selective Control Valve (SCV)
62.7 Electrical System
62.8 Operator Enclosure
62.9 Premium Radio
63 Troubleshooting – Diagnostic Trouble Codes (DTC)
63.1 STOP and Service Alert Indicators
63.2 Information Indicator
63.3 Access Diagnostic Trouble Codes
64 Service – Storage
64.1 Place Tractor in Storage
64.2 Remove Tractor from Storage
64.3 Paint Finish Care
65 Specifications
65.1 Engine: John Deere
65.2 Engine: QSX15 Cummins?
65.3 Capacities
65.4 Hydraulics
65.5 Hitch, Drawbar, and PTO
65.6 Transmission and Power Train
65.7 Electrical
65.8 Other Equipment
65.9 Overall Dimensions
65.10 Ground Speeds?e18? PowerShift Transmission
65.11 Emissions Control System Certification Label
65.12 EPA Non-road Emissions Control Warranty Statement?Compression Ignition
65.13 CARB Non-road Emissions Control Warranty Statement?Compression Ignition
65.14 Required Emission-Related Information
65.15 Cummins? ? CARB Non-road Emissions Control Warranty Statement
65.16 Cummins? ? EPA Non-Road Emissions Control Warranty Statement
65.17 Limited Battery Warranty
66 Identification Numbers
66.1 Identification Plates
66.2 Product Identification Number
66.3 Engine Serial Number
66.4 Cab Serial Number
66.5 Transmission Serial Number
66.6 Track Serial Numbers
66.7 PTO Dropbox Serial Number
66.8 PTO Clutch Serial Number
66.9 Keep Proof of Ownership
66.10 Keep Machines Secure
67 Change of Ownership
67.1 Subsequent Ownership
68 John Deere Service Literature Available
68.1 Technical Information
69 John Deere Service Keeps You on the Job
69.1 John Deere Is At Your Service