Table of Content:
1 Introduction
1.1 Foreword
1.2 Look For Supplemental Information
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator?s Manual
4.2 Instructional Seat (If Equipped)
4.3 Seat Belt
4.4 Starter
4.5 Engine Block Heater?13.5 L Engine
4.6 Engine Block Heater?15 L Engine
4.7 Park Brake (Stored Energy)
4.8 Hinge Area
4.9 Track Accumulators
4.10 Trash Build-Up
5 Vehicle Overview
5.1 9RX Scraper Series Tractor
6 Operator?s Manual Use
6.1 Operator?s Manual Use
7 General Vehicle Description
7.1 9RX Scraper Series Tractor
8 Engine Operation
8.1 Required Machine Stop Warning
8.2 Engine Fuel System and Power Rating
8.3 Engine Fuel System and Power Rating
8.4 Battery Disconnect Switch
8.5 Start the Engine
8.6 Run the Engine
8.7 Stop the Engine
8.8 Restart Engine That Has Run Out of Fuel
8.9 Reduce Fuel Consumption
8.10 Use Battery Booster or Charger
9 Cold Weather Operation
9.1 Cold Weather Starting?With Starting Aid
9.2 Cold Weather Starting And Operation?Internal Starting Aid
9.3 Change Starting Fluid Canister
9.4 Engine Coolant Heater Use?13.5 L Engine
9.5 Engine Coolant Heater Use?15 L Engine
10 Emissions Equipment
10.1 Exhaust Filter System Overview?Final Tier 4/Stage IV Engine
10.2 Aftertreatment Indicators Overview
10.3 Selective Catalytic Reduction (SCR) System Overview
10.4 Qualified Emergency Use ? SCR Override Option
10.5 Auto Exhaust Filter Cleaning Mode?Final Tier 4/Stage IV Engine
10.6 Parked Exhaust Filter Cleaning?Final Tier 4/Stage IV Engine
10.7 Selective Catalytic Reduction (SCR) System?Final Tier 4/Stage IV Engine
10.8 Low Fuel or Low DEF Warning
10.9 Disconnect Battery?Final Tier 4/Stage IV Engine
11 Controls and Instruments
11.1 Front Console
11.2 CommandARM? ISOBUS Shortcut Button (ISB)
11.3 Foot Decelerator
12 Corner Post Display
12.1 Corner Post Display
12.2 Information Indicators
12.3 Digital Indicators?Tachometer, Ground Speed and Transmission
12.4 Gauges?Coolant Temperature, DEF Level and Fuel Level
13 CommandARM? Controls
13.1 CommandARM? with Generation 4 CommandCenter? Display
13.2 CommandARM? SCV Control Levers
13.3 CommandARM? Climate, Radio and Lighting Controls
13.4 CommandARM? Left-Hand Side Controls
14 CommandCenter?
14.1 Onscreen Help
14.2 Generation 4 CommandCenter?
14.3 Generation 4 CommandCenter? Processor
14.4 Generation 4 CommandCenter? 4600 Processor Wi-Fi? Capabilities
14.5 Federal Communications Commission and Industry Canada Notification
14.6 Run Page Structure
14.7 Menu
14.8 Machine Settings Overview
14.9 Operating System Applications Overview
14.10 AMS Applications Overview
14.11 CommandCenter? Activations
14.12 Demo Activations
14.13 Automation Status Overview
14.14 Navigate Generation 4 CommandCenter?
14.15 Power Display On and Off
14.16 Navigate Run Pages on Main Page
14.17 Shortcut Buttons
14.18 Navigate to Display & Sound
14.19 Display and Sound
14.20 Brightness
14.21 Sound
14.22 Multiple Displays
14.23 Display Calibration
14.24 Navigate to Date & Time
14.25 Date and Time
14.26 Change Current Date
14.27 Change Current Time
14.28 Navigate to Language & Units
14.29 Language and Units
14.30 Language and Units Settings
14.31 Change Pages and Values
14.32 Status Center
14.33 Shortcut Softkeys
14.34 Navigate to Software Manager
14.35 Software Manager
14.36 Factory and Service ADVISOR? Installed Onscreen Help
14.37 Update Display Software
14.38 Activations
14.39 Service ADVISOR? Remote
14.40 Vehicle Reprogramming
14.41 Troubleshooting ? Reprogramming
14.42 System Recovery
14.43 Remote Display Access
14.44 Navigate to File Manager
14.45 File Manager
14.46 USB Drive
14.47 Capture Screen Shots
14.48 Navigate to Diagnostics Center
14.49 Diagnostics Center
14.50 Controller Diagnostics
14.51 Diagnostic Information
14.52 Hide Diagnostic Center
14.53 Diagnostic Trouble Codes
14.54 Display Hardware
14.55 CAN Bus Information
14.56 CAN Bus Values
14.57 Network
14.58 DataSync
14.59 Navigate to Users & Access
14.60 Users and Access
14.61 User Profiles
14.62 Access Groups
14.63 Navigate to Layout Manager
14.64 Layout Manager
14.65 Active Set
14.66 Shortcut Bar
14.67 All Run Pages
14.68 Add, Edit, or Duplicate Run Pages
14.69 Navigate to Fields
14.70 Fields and Boundaries
14.71 Field Boundaries
14.72 Manage Clients, Farms, and Fields
14.73 AutoTrac? Guidance
14.74 Navigate to Equipment Manager
14.75 Equipment Manager
14.76 Machine Profile
14.77 Implement Profile
14.78 Navigate to Machine Monitor
14.79 Machine Monitor
14.80 Navigate to Work Monitor
14.81 Work Monitor
14.82 Work Recording
14.83 Navigate to Maintenance & Calibrations
14.84 Maintenance and Calibrations
14.85 Calibrations
14.86 Radar Calibration
14.87 Slip Calibration
14.88 Service Intervals
14.89 Steering
14.90 Steering Settings
14.91 Controls Setup
14.92 Settings Manager
14.93 Automation Status
14.94 Read ISOBUS Controller?s Operator?s Manual
14.95 ISOBUS VT
14.96 StarFire? GPS Receiver
14.97 Use Video Display Capability Properly
14.98 Install Video Display Camera
14.99 Navigate to Video Application
14.100 Video
14.101 Video Triggers
15 Radio Operation
15.1 Radio Faceplate Features
15.2 Select Radio Receiver Wave Band
15.3 Federal Communications Commission (FCC) Bluetooth? Information
15.4 Set Clock
15.5 Turn Confirmation Beep On/Off (BEEP)
15.6 Adjust Maximum Volume at Power-On (ONVOL)
15.7 Program Type (PTY)
15.8 Treble Reduction During Interference (HCUT)
15.9 Set Key Function (KEY PRG)
15.10 SiriusXM? Radio?General Information
15.11 Display XM Serial Number
15.12 External Sources (Premium Radio)
15.13 Select Radio Source with Generation 4 CommandCenter?
15.14 AM, FM, Weather Channel Home Page
15.15 Premium Radio CD Home Page
15.16 Premium Radio XM Home Page
15.17 Premium Radio USB Home Page
15.18 Premium Radio Bluetooth? Home Page (If Equipped)
15.19 Auxiliary Home Page
15.20 Pair Bluetooth? Device to Generation 4 CommandCenter?
15.21 Manage Paired Bluetooth? Devices
15.22 Phone Operation
15.23 Phone Signal Strength and Battery Charge
15.24 Contact List
15.25 Recent Calls
15.26 Clear Favorites and Call History
16 AMS? Technology
16.1 Machine Sync
16.2 Mount StarFire? Receiver
16.3 Install GreenStar? System Components
16.4 Install Machine Communications Radio (MCR) Antenna
16.5 Connect AutoTrac? Assisted Steering System
17 Intelligent Total Equipment Control (iTEC?)
17.1 CommandARM? Control Functions
17.2 CommandCenter? Pages Descriptions and Functions
17.3 Status Area
17.4 All Sequence Page
17.5 Add New Sequence
17.6 Sequence Step Status
17.7 Edit or Remove Sequence
17.8 Sequence Sets Page
17.9 Perform Sequence
17.10 Recommendations (AutoLearn)
17.11 iTEC? Functions?Efficiency Manager?
18 Tractor-Implement Automation? (TIA?)
18.1 Tractor-Implement Automation? (TIA?)
18.2 Activate Tractor-Implement Automation? Equipment
18.3 Tractor-Implement Automation? ? Status Page
18.4 Operate Tractor-Implement Automation?
18.5 SCV Requirements
18.6 Powershift Transmission Requirements
18.7 AutoTrac? Guidance Requirements
18.8 Drive Strategy Requirements
19 Drivetrain
19.1 Drivetrain Overview
19.2 Drivetrain Protection?9470RX Scraper, 9520RX Scraper, and 9570RX Scraper
20 Differential Lock
20.1 Differential Lock
20.2 Change Differential Lock Disengagement Steering Angle
21 Brakes
21.1 Brake Use
21.2 Brake Warning Indicators
21.3 Hydraulic Trailer Brakes
21.4 Trailer Brake Settings
21.5 Engine Brake ? 15 L Engine (If Equipped)
21.6 Foot Decelerator
22 Transmission – General Information
22.1 Warm-Up Transmission-Hydraulic System
22.2 Activate and Set Maximum Set Speed
22.3 Use Maximum Set Speed with Different Transmission Modes
22.4 Backup Alarm
22.5 Come-Home Mode
23 e18? Powershift Transmission
23.1 Operate the e18? Powershift Transmission
23.2 Shift e18? Transmission
23.3 Avoid Tractor Overspeed
23.4 Set Start Gears
23.5 CommandCenter? Transmission Main Page
23.6 Efficiency Manager? on the e18? Transmission
23.7 Efficiency Manager? Custom Transmission Settings
24 Drawbar
24.1 Install Drawbar or Quick-Attach in Short Drawbar Support
24.2 Short Scraper Drawbar Conversion
24.3 Tow Cable
25 Hydraulics – General Information
25.1 Hydraulic System Overview
26 Selective Control Valves
26.1 Configure SCV Modes
26.2 Configuring Selective Control Valves – Standard Mode
26.3 Activate Independent Mode
26.4 Configure SCV – Independent Mode
26.5 Configure SCV – Feature Mode
26.6 Total Rear SCV Flow
26.7 Six Position SCV Control Levers
26.8 SCV Control Lever?Neutral Position
26.9 SCV Control Lever?Extend and Retract Position
26.10 SCV Control Lever?Extend Detent and Retract Detent Position
26.11 SCV Control Lever?Float Position
26.12 Operator Presence Sensor
26.13 CommandARM? Joystick (If Equipped)
26.14 CommandARM? Joystick (If Equipped) – Custom Setup
26.15 CommandARM? Joystick (If Equipped) – Layout and Joystick Lever Functions
26.16 SCV and Joystick Flow Response Setting
27 Hydraulic Connections
27.1 Connecting Hydraulic Hoses?Rear of Tractor
27.2 Disconnecting Hydraulic Hoses?Rear of Tractor
27.3 High Flow Hydraulic Component Identification
27.4 Standard Hydraulic Component Identification
27.5 Using Load-Sensing Hydraulic System?Power-Beyond
27.6 Examples Using Load-Sensing Hydraulic System?Power-Beyond
27.7 Scraper Connection Example: Pulling 1, 2, and 3 Scrapers
27.8 Implements Requiring Large Volumes of Oil
27.9 Scraper Hydraulic Hose Tips
28 TouchSet? Depth Control
28.1 Attaching Implement and Control System
28.2 Reset Implement Connector
28.3 Using TouchSet? Depth Controls
29 Scraper Information
29.1 Scraper Operation Cycle
29.2 Weight Transfer Limits
29.3 Scraper/Tractor Attachment
29.4 Loading Techniques
29.5 Connect AutoLoad? Harness
29.6 AutoLoad? Displays
29.7 Scraper Control Panel Reference
29.8 AutoLoad? Settings – Setting Auto Dimensions
29.9 Using AutoLoad?
29.10 Set Scraper ?Transport? Height
29.11 Set Scraper ?Ready? (Dump) Height
29.12 Set Scraper Ground ?Loading? Entering the Cut Height
29.13 AutoLoad? Operation
29.14 AutoLoad? Set Up Wizard
30 Tracks – General Information
30.1 General Track Use Guidelines
30.2 Tracks Service
31 Operator?s Station – General Information
31.1 Avoid Contact with Agricultural Chemicals
31.2 Clean Vehicle of Hazardous Pesticides
31.3 Keep Riders Off Machine
31.4 Keep Operator Station Window and Door Closed
31.5 Use Seat Belts
31.6 Use Emergency Exit
31.7 Monitor Bracket Mounts
32 Seat
32.1 Adjust ComfortCommand? Seat
32.2 Adjust Heated Leather Seat
32.3 Adjust CommandARM? Position
32.4 Operator Presence Sensor
32.5 Use Instructional Seat
33 Steering Column
33.1 Adjust Steering Wheel and Column
33.2 Operate Horn
34 Mirrors
34.1 Manual Mirror
34.2 Electric Mirror
34.3 Telescoping Heated Electric Mirror
35 Wiper Washer
35.1 Operate Front Windshield Wiper and Washer
35.2 Operate Rear Wiper and Washer
35.3 Operate Right-Hand Wiper and Washer
36 Lights
36.1 Light Identification
36.2 Configurable Lights
36.3 Steering Column Light Controls
36.4 Exit Lights
36.5 Operate Turn Signals and High/Low Beam
36.6 Safety Lights and Devices
36.7 CommandARM? Light Buttons
36.8 Hazard Lights and Extremity Warning Lights
36.9 Rotary Beacon Light
36.10 7-Pin Outlet
37 Accessories
37.1 Pull-Down Sunshade
37.2 Install Business Band or Citizens Band (CB) Radio and Antenna
37.3 Auxiliary Power Strip Use
37.4 Accessory Electrical Outlet Use
37.5 Connect Compatible Electronic Equipment
37.6 Configure Tractor for GPS or Radar
37.7 Refrigerator or Storage Space
37.8 Implement Connector Use
37.9 Use AutoLoad? Harness Connector
38 HVAC
38.1 Climate Controls
38.2 HVAC Settings?Generation 4 CommandCenter?
39 Performance Ballasting
39.1 Ballast Recommendations
40 Transport
40.1 Driving Tractor on Roads
40.2 Extended Road Transport
40.3 Towed Loads and Transport with Ballast
40.4 Use Safety Lights and Devices
40.5 Use Safety Chains
40.6 Carrier Transport
40.7 Towing?Engine Will Start
40.8 Towing?Engine Will Not Start
40.9 Freeing a Mired Machine
41 Fuel, Lubricants, and Coolant – General Information
41.1 Determine Tractor Engine Type
41.2 Minimizing the Effect of Cold Weather on Diesel Engines
41.3 Oil Filters
42 Fuel
42.1 Diesel Fuel
42.2 Supplemental Diesel Fuel Additives
42.3 Lubricity of Diesel Fuel
42.4 Handling and Storing Diesel Fuel
42.5 Avoid Static Electricity Risk When Refueling
42.6 Fill Fuel Tank
42.7 Biodiesel Fuel
42.8 Testing Diesel Fuel
42.9 Fuel Filters
43 Diesel Exhaust Fluid (DEF)
43.1 Fill DEF Tank – FT4/Stage IV Engine
43.2 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
43.3 Storing Diesel Exhaust Fluid (DEF)
43.4 Refilling Diesel Exhaust Fluid (DEF) Tank
43.5 Testing Diesel Exhaust Fluid (DEF)
43.6 Disposal of Diesel Exhaust Fluid (DEF)
44 Engine Oil
44.1 John Deere Break-In Plus? Engine Oil ? Final Tier 4 and Stage IV 13.5 L Engine
44.2 Break-In Engine Oil Use ? Final Tier 4 and Stage IV 15 L Engines
44.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
44.4 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 13.5 L Engines
44.5 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 15 L Engine
44.6 Diesel Engine Oil Service Interval for Operation at High Altitude
45 Engine Coolant
45.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
45.2 John Deere COOL-GARD? II Coolant Extender
45.3 Operating in Warm Temperature Climates
45.4 Water Quality for Mixing with Coolant Concentrate
45.5 Testing Coolant Freeze Point
45.6 Disposing of Coolant
46 Other Lubricants
46.1 Transmission and Hydraulic Oil
46.2 Multipurpose Extreme Pressure (EP) Grease
46.3 Mixing of Lubricants
46.4 Alternative and Synthetic Lubricants
46.5 Lubricant Storage
47 Service – General Information
47.1 Service Sections Overview
47.2 Service Tasks Performed As Required
47.3 Identify Tractor Engine Emissions Status
47.4 Open Hood
47.5 Jack Up Tractor – Lifting Points and Support Stand Placement (2010-52-EU)
47.6 Service and Connect STC? (Snap-to-Connect) Fittings
47.7 High-Pressure Washer Use
47.8 Diesel Particulate Filter Service
47.9 Exhaust Filter / Diesel Particulate Filter Ash Handling and Disposal
47.10 Exhaust Filter Disposal
47.11 Transmission Calibration
47.12 Abort Transmission Calibration
47.13 Do Not Modify Fuel System
47.14 Do Not Open High-Pressure Fuel System
47.15 Bleed Fuel System
47.16 Identify Zinc-Flake Coated Fasteners
47.17 Metric Bolt and Screw Torque Values
47.18 Unified Inch Bolt and Screw Torque Values
48 Service – Predelivery Checklist
48.1 Predelivery Checklist
49 Service – Delivery Checklist and Certificate
49.1 Delivery Checklist (Dealer)
49.2 Delivery Certificate (Dealer)
49.3 Delivery Checklist (Customer)
49.4 Delivery Certificate (Customer)
50 Break-In Service (100 Hours or Less)
50.1 Perform Break-In Services
50.2 Perform Track Systems Break-In
51 Service – Record Charts
51.1 Engine Oil and Filter Change
51.2 As Required Service
51.3 Annual Service
51.4 10 Hour or Daily Service
51.5 50 Hour Service
51.6 250 Hour Service
51.7 400 Hour Service
51.8 500 Hour Service
51.9 750 Hour Service
51.10 800 Hour Service
51.11 1000 Hour Service
51.12 1200 Hour Service
51.13 1250 Hour Service
51.14 1500 Hour Service
51.15 1600 Hour Service
51.16 1750 Hour Service
51.17 2000 Hour Service
51.18 2250 Hour Service
51.19 2400 Hour Service
51.20 2500 Hour Service
51.21 2750 Hour Service
51.22 2800 Hour Service
51.23 3000 Hour Service
51.24 3200 Hour Service
51.25 3250 Hour Service
51.26 3500 Hour Service
51.27 3600 Hour Service
51.28 3750 Hour Service
51.29 4000 Hour Service
51.30 4250 Hour Service
51.31 4400 Hour Service
51.32 4500 Hour Service
51.33 4750 Hour Service
51.34 4800 Hour Service
51.35 5000 Hour Service
51.36 5200 Hour Service
51.37 5250 Hour Service
51.38 5500 Hour Service
51.39 5600 Hour Service
51.40 5750 Hour Service
51.41 6000 Hour Service
51.42 Services – 6250 to 8800 Hours
51.43 9000 Hour Service
51.44 Services Beyond 9000 Hours
52 Service – Clean
52.1 Diesel Particulate Filter (DPF)?Final Tier 4/Stage IV Engine
52.2 Engine Cooling System?13.5 L Engine
52.3 Engine Cooling System?15 L Engine
52.4 DEF Tank
52.5 DEF Tank Filler Neck Filter
52.6 Clean Display
52.7 Dual Beam Radar Sensor
52.8 Optional Fuel Water Separator
52.9 Optional Fuel Water Separator Filter Element
52.10 Aftertreatment Fuel Injector?15 L Engine
53 Service – Check
53.1 Engine Coolant Level
53.2 Optional Fuel/Water Separator
53.3 Water Separator
53.4 Engine and Exhaust Compartments
53.5 Outer Exhaust Screens
53.6 Air Conditioning System
53.7 Engine Water Pump Weep Hole?13.5 L Engine
53.8 Engine Water Pump Seal?15 L Engine
53.9 Fuel Tank Sump
53.10 Engine Oil Level?13.5 L Engine
53.11 Engine Oil Level?15 L Engine
53.12 Transmission-Hydraulic Oil Level
53.13 Undercarriage Articulation Bumper Stops
53.14 Drive, Mid-Rollers, and Idler Wheels
53.15 Track Alignment
53.16 Track Tension
53.17 Track Wear
53.18 Track Trash Buildup
53.19 Undercarriage
53.20 Drive Wheel Scraper Clearance
53.21 Hydraulic Accumulator
53.22 NEUTRAL Start System
53.23 Transmission PARK System
53.24 Engine Air Intake System?13.5 L Final Tier 4/Stage IV Engine
53.25 Engine Air Intake System?15 L Engine
53.26 Engine Coolant Freeze Point
53.27 Seat Belts
53.28 Auxiliary Drive Belt and Drive Belt Tensioner
53.29 Mid-Rollers Oil Level
53.30 Idler Wheel Hub Oil Level
53.31 Engine Valve Clearance
53.32 Vari-Cool? Fan Drive and Belt?13.5L Final Tier 4/Stage IV Engine
53.33 Front Driveshaft Health (FDH) Sensor System
54 Service – Tighten
54.1 Mid-Roller, Drive, and Idler Wheel Fasteners
54.2 Scraper Drawbar Bolts
55 Service – Change
55.1 Vari-Cool? Fan Belt?13.5 L Final Tier 4/Stage IV Engine
55.2 Auxiliary Drive Belt?13.5 L Engine
55.3 Auxiliary Drive Belt?15 L Engine
55.4 Engine Oil and Filter?13.5 L Engine
55.5 Engine Oil and Filter?15 L Engine
55.6 Fuel Filters?13.5 L Engine
55.7 Fuel Filters?15 L Engine
55.8 Cab Recirculation Air Filter
55.9 Cab Fresh Air Filter
55.10 Engine Primary and Secondary Air Filters
55.11 Fuel Tank Vent Filters
55.12 SCV Pilot Valve Filter
55.13 DEF Tank Vent Filter?Final Tier 4/Stage IV Engine
55.14 DEF Header Filter?Final Tier 4/Stage IV Engine
55.15 Transmission-Hydraulic Oil and Filters
55.16 Engine Cooling System Radiator Cap?15 L Engine
55.17 Transmission-Hydraulic Vent Filter
55.18 Engine Crankcase Breather Filter Element?15 L Engine
55.19 Transmission Drive Shaft Damper
55.20 Access DEF Dosing Unit Filter?Final Tier 4 or Stage IV Engine
55.21 DEF Dosing Unit Filter?Final Tier 4/Stage IV Engine
55.22 Engine Coolant?13.5 L Engine
55.23 Engine Coolant?15 L Engine
55.24 Engine Crankshaft Damper?13.5 L Engine
55.25 Front Drive Shaft U-Joints
56 Service – Lubricate
56.1 Steering Pins
56.2 Hinge Pins
56.3 Telescoping Drive Shaft
56.4 Hydraulic Hose Support Bracket
56.5 Heavy-Duty Gudgeon Bearings
56.6 Lower Drive Line Bearings
56.7 Track Tension Cylinder
56.8 Vari-Cool? Fan Drive?13.5 L Final Tier 4/Stage IV Engine
57 Service – Electrical
57.1 Service – Electrical Overview
57.2 Welding Near Electronic Control Units
57.3 Keep Electronic Control Unit Connectors Clean
57.4 Compressed Air Use
57.5 High-Pressure Washer Use
57.6 Disconnect Battery?Final Tier 4/Stage IV Engine
57.7 Handling Batteries Safely
57.8 Service Batteries and Connectors?13.5 L Engine
57.9 Service Batteries and Connectors?15 L Engine
57.10 Access Load Center Fuses
57.11 Access Master Fuses
57.12 Access Implement Power Relay Module Fuses
57.13 Handle Halogen Light Bulbs Safely
57.14 Change Front HID/LED Light Assembly
57.15 Change Front Grille Halogen Light Bulbs
57.16 Adjust Front Grille Lights
57.17 Adjust Headlights
57.18 Change Front, Side And Rear Cab Roof Light Bulb
57.19 Change Brake or Turn Signal Light Bulb
57.20 Change Dome Light Bulb
57.21 Change Extremity Warning Light Bulb
58 Troubleshooting – Procedures
58.1 Engine
58.2 Transmission-Hydraulic-Axles
58.3 Brakes
58.4 Selective Control Valve (SCV)
58.5 Electrical System
58.6 Operator Enclosure
58.7 Premium Radio
59 Troubleshooting – Diagnostic Trouble Codes (DTC)
59.1 STOP and Service Alert Indicators
59.2 Information Indicator
59.3 Access Diagnostic Trouble Codes
60 Service – Storage
60.1 Place Tractor in Storage
60.2 Remove Tractor from Storage
60.3 Paint Finish Care
61 Specifications
61.1 Engine: John Deere
61.2 Engine: QSX15 Cummins?
61.3 Capacities
61.4 Hydraulics
61.5 Electrical
61.6 Transmission and Power Train
61.7 Drawbar
61.8 Overall Dimensions
61.9 Other Equipment
61.10 Ground Speeds?e18? PowerShift Transmission
61.11 Emissions Control System Certification Label
61.12 EPA Non-road Emissions Control Warranty Statement?Compression Ignition
61.13 CARB Non-road Emissions Control Warranty Statement?Compression Ignition
61.14 Required Emission-Related Information
61.15 Cummins? ? CARB Non-road Emissions Control Warranty Statement
61.16 Cummins? ? EPA Non-Road Emissions Control Warranty Statement
61.17 Limited Battery Warranty
62 Identification Numbers
62.1 Identification Plates
62.2 Product Identification Number
62.3 Engine Serial Number
62.4 Cab Serial Number
62.5 Transmission Serial Number
62.6 Track Serial Numbers
62.7 Keep Proof of Ownership
62.8 Keep Machines Secure
63 Change of Ownership
63.1 Subsequent Ownership
64 John Deere Service Literature Available
64.1 Technical Information
65 John Deere Service Keeps You On The Job
65.1 John Deere Is At Your Service