John Deere 7r Tractors Operator Manuals OMTA17295

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Fire Prevention
3.9 In Case of Fire
3.10 Avoid Static Electricity Risk When Refueling
3.11 Use Foldable ROPS and Seat Belt Properly
3.12 Stay Clear of Rotating Drivelines
3.13 Use Steps and Handholds Correctly
3.14 Read Operator?s Manuals for ISOBUS Controllers
3.15 Use Seat Belt Properly
3.16 Vibration
3.17 Operating the Tractor Safely
3.18 Avoid Backover Accidents
3.19 Limited Use in Forestry Operation
3.20 Operating the Loader Tractor Safely
3.21 Keep Riders Off Machine
3.22 Passenger Seat
3.23 Use Safety Lights and Devices
3.24 Towing Trailers/Implements Safely
3.25 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.26 Freeing a Mired Machine
3.27 Avoid Contact with Agricultural Chemicals
3.28 Handle Agricultural Chemicals Safely
3.29 Handling Batteries Safely
3.30 Avoid Heating Near Pressurized Fluid Lines
3.31 Remove Paint Before Welding or Heating
3.32 Handle Electronic Components and Brackets Safely
3.33 Practice Safe Maintenance
3.34 Avoid Hot Exhaust
3.35 Clean Exhaust Filter Safely
3.36 Work In Ventilated Area
3.37 Support Machine Properly
3.38 Prevent Machine Runaway
3.39 Park Machine Safely
3.40 Transport Tractor Safely
3.41 Service Cooling System Safely
3.42 Service Accumulator Systems Safely
3.43 Service Tires Safely
3.44 Service Front-Wheel Drive Tractor Safely
3.45 Tightening Wheel Retaining Bolts/Nuts
3.46 Avoid High-Pressure Fluids
3.47 Do Not Open High-Pressure Fuel System
3.48 Store Attachments Safely
3.49 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Passenger Seat
4.4 Rear Hitch Remote Switch (If Equipped)
4.5 Triple Link Suspension Plus (TLS? Plus) (If Equipped)
4.6 Pick-Up Hitch (If Equipped)
4.7 Front Hitch (If Equipped)
4.8 Front SCVs (If Equipped)
4.9 Rear SCVs
5 Vehicle Overview
5.1 7R Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Engine Set Speed
6.5 Engine Settings?Max Engine Speed
6.6 Engine Settings?Exhaust Filter System Overview
6.7 Engine Settings?AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.9 Engine Settings?Parked Filter Cleaning
6.10 Required Machine Stop Warning
6.11 Engine Fuel System and Power Rating
6.12 Battery Disconnect Switch
6.13 Start the Engine
6.14 Theft Deterrent Systems
6.15 Run the Engine
6.16 Stop the Engine
6.17 Restart Engine That Has Run Out of Fuel
6.18 Reduce Fuel Consumption
6.19 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?With Glow Plug Starting Aid (6.8 L Engine)
7.2 Cold Weather Starting?Without Starting Aid (9.0 L Engine)
7.3 Cold Weather Starting?With Starting Aid (9.0 L Engine)
7.4 Change Starting Fluid Canister
7.5 Auxiliary Heaters Use
8 Emissions Equipment
8.1 Selective Catalytic Reduction (SCR) System Overview
8.2 Restored Operation Option
8.3 Aftertreatment Indicators Overview
8.4 Diesel Particulate Filter (DPF) Service
9 Front Console
9.1 Front Console
9.2 Adjust Steering Wheel and Column
9.3 Operate Horn
9.4 Operate Wipers and Washers
9.5 Key Switch
9.6 Operate Turn Signals
9.7 Pedals
9.8 Operate Lights
10 Corner Post Display
10.1 Corner Post Display
11 CommandARM? Controls
11.1 CommandARM?
11.2 CommandARM? Hitch Controls
11.3 CommandARM? SCV Control Levers
11.4 CommandARM? PTO Control Levers
11.5 CommandARM? Climate, Radio, and Lighting Controls
11.6 Push-To-Talk (PTT)
11.7 CommandARM? Controls?Left Side
11.8 CommandARM? Secondary Brake Lever
11.9 CommandARM? Joystick
11.10 CommandARM? Navigation Bar
11.11 Adjust CommandARM? Position
12 CommandCenter?
12.1 Generation 4 Display
12.2 Machine Settings Overview
12.3 Automation Status Overview
12.4 Navigate Generation 4 CommandCenter?
12.5 Compatible Displays
12.6 Power Display On and Off
12.7 Change Pages and Values
12.8 Factory and Service ADVISOR? Installed Onscreen Help
12.9 Radar Calibration
12.10 Slip Calibration
12.11 Steering Settings?Access
12.12 Steering Settings
12.13 Steering Settings?ACS? 2 Variable Ratio Steering
12.14 Steering Settings?ACS? 2 Sensitivity
12.15 Steering Settings?Steering Wheel Resistance
12.16 Controls Setup
12.17 Automation Status
12.18 Install Video Display Camera
13 CommandCenter? Audio and Phone
13.1 External Sources
13.2 Select Audio Source with Generation 4 CommandCenter?
13.3 FM, MW, LW Home Page
13.4 USB Home Page
13.5 Bluetooth? Home Page
13.6 Auxiliary Home Page
13.7 Pair Bluetooth? Device to Generation 4 CommandCenter?
13.8 Manage Paired Bluetooth? Devices
13.9 Phone Operation
13.10 Contact List
13.11 Recent Calls
13.12 Clear Favorites and Call History
14 Intelligent Total Equipment Control (iTEC?)
14.1 CommandARM? Control Functions
14.2 iTEC? Station Description (Eu 1322/2014)
14.3 CommandCenter? Pages Descriptions and Functions
14.4 Status Area
14.5 All Sequence Page
14.6 Add New Sequence
14.7 Sequence Step Status
14.8 Edit or Remove Sequence
14.9 Sequence Sets Page
14.10 Perform Sequence
14.11 Recommendations (AutoLearn)
14.12 iTEC Functions?IVT?/AutoPowr? Transmission
14.13 iTEC? Functions?Efficiency Manager?
15 Tractor-Implement Automation (TIA)
15.1 Tractor-Implement Automation (TIA)
15.2 Activate Tractor-Implement Automation (TIA) Equipment
15.3 Tractor-Implement Automation (TIA) ? Status Page
15.4 Operate Tractor-Implement Automation (TIA)
15.5 PTO Requirements
15.6 SCV Requirements
15.7 IVT?/AutoPowr? Requirements
15.8 IVT?/AutoPowr? with CommandPRO? Joystick Requirements
15.9 PowerShift? Transmission Requirements
15.10 AutoTrac? Guidance Requirements
15.11 Rear Hitch Requirements
15.12 Drive Strategy Requirements
16 Drivetrain
16.1 Drivetrain Overview
16.2 Suspension Settings?Access
16.3 Suspension Settings
16.4 Suspension Settings?Manual
16.5 Operate Suspension
16.6 Differential Lock
16.7 Mechanical Front-Wheel Drive (MFWD)
16.8 Large Square Baler (LSB) Ride Control
17 Brakes
17.1 Trailer Brake System Settings?Access
17.2 Trailer Brake System Settings
17.3 Trailer Brake System Settings?Brake Gain
17.4 Trailer Brake System Settings?Pre-Brake Offset
17.5 Trailer Brake System Settings?Trailer Brake Test
17.6 Trailer Brake System Settings?Advanced
17.7 Brake Use
17.8 AutoClutch
17.9 Hydraulic Trailer Brakes
17.10 Air Trailer Brakes
18 Transmission – General Information
18.1 Transmission Settings?Access Advanced
18.2 Transmission Settings?Advanced
18.3 Transmission Top Speed Note
18.4 Warm-Up Transmission-Hydraulic System
18.5 Backup Alarm
19 e23? Transmission
19.1 Operate Transmission?e23?
19.2 Shift Transmission?e23?
19.3 e23? Set Speeds and Efficiency Manager?
19.4 e23? Transmission Settings?Access
19.5 e23? Transmission Settings
19.6 e23? Transmission Settings?Mode
19.7 e23? Transmission Settings?Custom
19.8 e23? Transmission Settings?Droop
19.9 e23? Transmission Settings?ECO
19.10 e23? Transmission Settings?Max Speeds
20 IVT?/AutoPowr? Transmission
20.1 Operate Transmission?IVT?
20.2 Shift Transmission?IVT?
20.3 IVT? Set Speeds
20.4 IVT? Transmission Settings?Access
20.5 IVT? Transmission Settings
20.6 IVT? Transmission Settings?Mode
20.7 IVT? Transmission Settings?Pedal Mode
20.8 IVT? Transmission Settings?Custom
20.9 IVT? Transmission Settings?Droop
20.10 IVT? Transmission Settings?ECO
20.11 IVT? Transmission Settings?Max Speeds
21 IVT?/AutoPowr? Transmission with CommandPRO? Joystick
21.1 Operate Transmission?IVT? with CommandPRO? Joystick
21.2 Shift Transmission?IVT? with CommandPRO? Joystick
21.3 CommandPRO? Joystick
21.4 CommandPRO? Joystick?Acceleration/Deceleration Response
21.5 CommandPRO? Joystick?Enable Set Speeds
21.6 CommandPRO? Joystick?Adjust Travel Direction
21.7 CommandPRO? Joystick?Stopping
21.8 CommandPRO? Joystick?Operating on Hillsides
21.9 CommandPRO? Transmission Settings?Access
21.10 CommandPRO? Transmission Settings
21.11 CommandPRO? Transmission Settings?Mode
21.12 CommandPRO? Transmission Settings?Custom
21.13 CommandPRO? Transmission Settings?Droop
21.14 CommandPRO? Transmission Settings?Minimum Engine Speed
21.15 CommandPRO? Transmission Settings?Set Speeds
21.16 CommandPRO? Transmission Settings?Shuttle Shift Speeds
21.17 CommandPRO? Transmission Settings?Speed Limits
22 PTO, Hitch, and Drawbar
22.1 Attach PTO-Driven Implement-Front
22.2 Attach PTO-Driven Implement-Rear
22.3 Hitch, SCV and PTO External Switches
23 PTO – General Information
23.1 PTO Settings?Access
23.2 PTO Settings
23.3 PTO Settings?Advanced
23.4 PTO Settings?Engagement Rate
23.5 PTO Settings?Rear PTO Cruise
23.6 PTO Settings?Auto Disengage
23.7 Operating Instructions (EU 1322-2014)
23.8 Operate PTOs
23.9 External PTO Switches
23.10 Select Correct Engine Speed
24 Front PTO
24.1 Front PTO Disconnect
24.2 PTO Cold Weather Operation
24.3 Change Optional Front PTO Shafts
25 Rear PTO
25.1 Rear PTO Shield?Type 3 PTO
25.2 Operate Shiftable 3-Speed Rear PTO (If Equipped)
25.3 Operate Shiftable 2-Speed Rear PTO (If Equipped)
25.4 Change PTO Stub Shaft (If Equipped)
26 Front Hitch
26.1 Front Hitch Settings?Access
26.2 Front Hitch Settings
26.3 Front Hitch Settings?Upper Limit
26.4 Front Hitch Settings?Drop Rate
26.5 Front Hitch Settings?Raise Rate
26.6 Front Hitch Settings?Position and Set Points
26.7 Front Hitch Use
27 Rear Hitch
27.1 Hitch Capacities (EU 1322/2014)
27.2 Rear Hitch Settings?Access
27.3 Rear Hitch Settings
27.4 Rear Hitch Settings?Upper Limit
27.5 Rear Hitch Settings?Drop Rate
27.6 Rear Hitch Settings?Raise Rate
27.7 Rear Hitch Settings?Load Depth
27.8 Rear Hitch Settings?Slip Sensitivity
27.9 Rear Hitch Settings?Position
27.10 Rear Hitch Settings?Advanced
27.11 Rear Hitch Settings?Position Control
27.12 Rear Hitch Settings?Draft Control
27.13 Hitch Control Lever Adjustments
27.14 Hitch Depth Set Point
27.15 Wagon Hitch Lever
27.16 Float Operation
27.17 Components
27.18 Remote Raise and Lower Switches
27.19 Draft Link Storage Position
27.20 Hitch Manual Lowering
27.21 Correct Center Link Position
27.22 Hydraulic Center Link
27.23 Adjust Sway Blocks
27.24 Adjust Deluxe Stabilizers
27.25 Attach Implement to Quick-Hitch
27.26 Level Implement
27.27 Adjust Lateral Float
27.28 Detach Implement from Quick-Hitch
27.29 Hitch Conversion?Convertible Quick-Hitch
27.30 Operate Wagon Hitch
27.31 Operate Pick-Up Hitch
27.32 Change Pick-Up Hitch Coupler
27.33 3-in-1 Hitch System
28 Drawbar
28.1 Drawbar Load Limitations (2015/208-ANNEX XXXIV)
28.2 Scraper Applications
28.3 Adjust Drawbar Position
28.4 Install and Use Clevis Assembly-Cat 2 Drawbar
28.5 Install and Use Clevis Assembly-Cat 3 Drawbar
28.6 Install and Use Clevis Assembly-High Vertical Load Drawbar Support
29 Hydraulics – General Information
29.1 Hydraulic System Overview
30 Selective Control Valves
30.1 SCV Settings?Access
30.2 SCV Settings
30.3 SCV Settings?Standard Mode
30.4 SCV Settings?Independent Mode
30.5 SCV Settings?Feature Mode
30.6 SCV Settings?Flow Adjustment
30.7 SCV Settings?Time Adjustment
30.8 SCV Settings?Advanced
30.9 SCV Settings?Activating Independent Mode
30.10 SCV Settings?Automation
30.11 SCV Settings?Assignment
30.12 SCV Settings?Flow Adjustment Sensitivity
30.13 SCV Control Lever Adjustments
30.14 Total SCV Flow
30.15 Operate SCVs with CommandARM? Joystick
30.16 CommandARM? Joystick?Layout and Joystick Lever Functions
31 Hydraulic Connections
31.1 Connect/Disconnect Hydraulic Hoses
31.2 Component Identification and Location?Rear SCVs
31.3 Component Identification and Location?Mid-Mount or Front SCVs
31.4 Use Load-Sense Hydraulic System (Power Beyond)
31.5 Examples Using Load-Sensing Hydraulic System?Power-Beyond
31.6 Implement Connections – Active Down Pressure
31.7 Implement Connection – Vacuum Motors with Power Beyond and Motor Case Drain
31.8 Implement Connections – Hydraulic Motor with Motor Return
31.9 Implement Connections – Vacuum Motor with Motor Return Tip
31.10 Implement Connections – Hitch Auxiliary Raise in Parallel with Hitch Valve
31.11 Implement Connections – Hitch Auxiliary Raise in Parallel with SCV
31.12 Hydraulic Motor Return and Case Drain Kits
31.13 Hitch Auxiliary Raise Kit
31.14 Using Implements Requiring Large Volumes of Oil
32 TouchSet? Depth Control
32.1 TouchSet? Depth Control Settings and Adjustments
32.2 Connect/Disconnect the Implement Position Connector
33 Laser Scraper Control
33.1 Laser Scraper?Scrapers Equipped with Scraper Control Unit
34 Wheels and Tires – General Information
34.1 Determine Tire Load Capacity
34.2 Change Tire Size
34.3 Select Tire Combinations
34.4 Tire Load Index
34.5 Tire Inflation Pressure Guidelines
35 Front Wheels and Tires
35.1 Recommended Pressures?Group 42
35.2 Recommended Pressures?Group 43
35.3 Recommended Pressures?Group 44
35.4 Adjust and Tighten – Front Wheel Bolts
35.5 Toe-In Check
36 Steering Stop, Fender, and Tread Settings
36.1 Tire, Steering Stop, and Fender Settings Table Explanation
36.2 Tire, Steering Stop, and Fender Settings?1300 MFWD Axle
36.3 Tire, Steering Stop, and Fender Settings?TLS? Plus Axle
36.4 Tire, Steering Stop, and Fender Settings?1300 MFWD Axle with Front Hitch
36.5 Tire, Steering Stop, and Fender Settings?TLS? Plus Axle with Front Hitch
36.6 Tire, Steering Stop, and Fender Settings?1300 MFWD Axle with Front Loader
36.7 Tire, Steering Stop, and Fender Settings?TLS? Plus Axle with Front Loader
36.8 Determine Rim Type
36.9 Wheel Settings?8-Position
36.10 Wheel Setting?16-Position
36.11 Set Steering Stops
36.12 Fender Settings
37 Rear Wheels and Tires
37.1 Recommended Pressures?Group 47
37.2 Recommended Pressures?Group 48
37.3 Recommended Pressures?Group 49
37.4 16-Position Rear Wheel Settings
37.5 Rear Wheel, Tire, and Tread Guidelines
37.6 Rear Single Drive Wheel Tread Settings?Flanged Wheels
37.7 Minimum Tread Setting with Air Trailer Brakes and Inner Wheel Weights
37.8 Use Wheel Tightening Stand
37.9 Install Rear Drive Wheel to Cast Hub
37.10 Install Rear Steel Wheel to Hub
37.11 Adjust and Tighten Rear Steel Wheels with Cast Hubs
37.12 Adjust and Tighten Rear Wheels?10-Bolt Heavy-Duty Hubs
37.13 Adjust and Tighten Rear Wheels?12-Bolt Heavy-Duty Hubs
37.14 Adjusting and Tightening Rear Wheels?Flanged Axle
37.15 Single Wheel Tread Settings
37.16 Dual Wheel Tread Settings
37.17 Dual Wheel Row Crop Settings and Dual Hub Extensions
37.18 Clamp-on Dual Usage
38 Seats
38.1 Adjust Air Seat
38.2 Adjust ActiveSeat? II
38.3 Operator Presence Sensor
38.4 Adjust Passenger Seat
39 Mirrors
39.1 Adjust Mirrors
40 Steps
40.1 Position Left-hand Steps
40.2 Right-Hand Service Steps
41 Lights
41.1 Light Identification
41.2 Lights Settings?Access
41.3 Lights Settings
41.4 Lights Settings?Field Lights Presets
41.5 Lights Settings?Hood/Belt Line Lights
41.6 Lights Settings?Advanced
41.7 Hazard and Extremity Lights
41.8 Beacon Light
41.9 7-Pin Outlet
42 Accessories
42.1 Right-Hand Side Console
42.2 CommandARM? Storage
42.3 Right-Hand Front Corner Post
42.4 Left-Hand Rear Corner Post
42.5 Right-Hand Rear Corner Post
42.6 Refrigerator and Cool/Storage Box
42.7 Sunshade
42.8 Storage Compartments
42.9 Monitor Bracket Mounts
42.10 Emergency Exit
42.11 Install Business Band/Citizens Band (CB) Antenna and/or Radio
42.12 Mount StarFire? Receiver
42.13 Mount RTK (Real-Time Kinematic) Radio
42.14 Implement Connector
42.15 RS232 Serial Communication Connection
43 HVAC
43.1 HVAC Settings?Access
43.2 HVAC Settings
43.3 HVAC Settings?Climate Control Automation
43.4 HVAC Settings?Set Temperature
43.5 HVAC Settings?Air Flow Mode
43.6 HVAC Settings?Fan Speed
43.7 HVAC Settings?Air Conditioning
44 Performance Ballasting
44.1 How to Calculate Permissible Towed Mass (EU 1322/2014)
44.2 How to Calculate Maximum Permissible Download on Trailer Hitch (EU 1322/2014)
44.3 Mechanical Towed Coupling Load Limitations (2015/208-ANNEX XXXIV)
44.4 General Ballasting Information
44.5 General Guidelines
44.6 General Weight Split Guidelines
44.7 Ballast Options
44.8 Measure Slip
44.9 Ballast Suggestions for Specific Types of Implements used with MFWD Tractors
44.10 Quik-Tatch? Weight Use
44.11 Rear Wheel Weight Use
44.12 Rear Wheel Weight Installation?Flanged Axles
44.13 Rear Wheel Weight Installation?Single Cast Drive Wheel
44.14 Rear Wheel Weight Installation?Dual Drive Wheels
44.15 Controlling Power Hop-MFWD Tractors Without TLS? Plus Front Axle
44.16 Calculate Tractor Ballast Package
44.17 Add Rear Ballast For Front Loader
44.18 Ballast Suggestions-Hitch-Mounted Implements
44.19 Unballasted Tractor Weight Charts (7R: 230, 250, and 270)
44.20 Unballasted Tractor Weight Charts (7R: 290, 310, 330, and 350)
44.21 Implement and Tractor Codes
44.22 Liquid Ballast Use
45 Transport
45.1 Drive Tractor on Roads
45.2 Transport with Ballast
45.3 Towed Mass (EU 1322/2014)
45.4 Tow Loads
45.5 Use Safety Chain
45.6 Tow Tractor
45.7 Tow Points
45.8 Tow Mode
45.9 Come Home Mode
45.10 Transport on Carrier
45.11 Freeing a Mired Tractor
46 Fuel, Lubricants, and Coolant – General Information
46.1 Determine Tractor Engine Type
46.2 Minimizing the Effect of Cold Weather on Diesel Engines
46.3 Oil Filters
47 Fuel
47.1 Diesel Fuel
47.2 Supplemental Diesel Fuel Additives
47.3 Biodiesel Fuel
47.4 Lubricity of Diesel Fuel
47.5 Handling and Storing Diesel Fuel
47.6 Fill Fuel Tank
47.7 Testing Diesel Fuel
47.8 Fuel Filters
48 Diesel Exhaust Fluid (DEF)
48.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
48.2 Storing Diesel Exhaust Fluid (DEF)
48.3 Refilling Diesel Exhaust Fluid (DEF) Tank
48.4 Fill DEF Tank – FT4/Stage V Engine
48.5 Testing Diesel Exhaust Fluid (DEF)
48.6 Disposal of Diesel Exhaust Fluid (DEF)
49 Engine Oil
49.1 Diesel Engine Oil Service Interval for Operation at High Altitude
49.2 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
49.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
49.4 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
50 Engine Coolant
50.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
50.2 John Deere COOL-GARD? II Coolant Extender
50.3 Operating in Warm Temperature Climates
50.4 Water Quality for Mixing with Coolant Concentrate
50.5 Testing Coolant Freeze Point
50.6 Disposing of Coolant
51 Other Lubricants
51.1 Lubricant Storage
51.2 Alternative and Synthetic Lubricants
51.3 Mixing of Lubricants
51.4 Transmission and Hydraulic Oil
51.5 Use Correct Viscosity Front PTO Oil in Cold Weather
51.6 Transmission Recalibration
51.7 Gear Oil
51.8 Multipurpose Extreme Pressure (EP) Grease
52 Service – General Information
52.1 Service Sections Overview
52.2 Service Tasks Performed As Required
52.3 Identify Tractor Engine Emissions Status
52.4 Open Hood
52.5 Remove Engine Access Panel
52.6 Remove Engine Side Shields
52.7 Remove Radiator Shields
52.8 Remove Battery Compartment Cover
52.9 Remove Cab Rear Panel
52.10 Jack Up Tractor – Lifting Points and Support Stand Placement (EU 1322/2014)
52.11 Service and Connect STC? (Snap-to-Connect) Fittings
52.12 High-Pressure Washer Use
52.13 Do Not Modify Fuel System
52.14 Bleed Fuel System
52.15 Identify Zinc-Flake Coated Fasteners
52.16 Metric Bolt and Screw Torque Values
52.17 Unified Inch Bolt and Screw Torque Values
53 Service – Break-In (100 Hours or Less)
53.1 Perform Break-In Checks
54 Service – Record Charts
54.1 Service Record Chart Overview
54.2 Service Interval Chart
54.3 Service Record Chart
55 Service – Clean
55.1 Access DEF Tank Drain Plug
55.2 Cleaning Diesel Exhaust Fluid (DEF) Tank
55.3 Tractor Exterior
55.4 Clean Display
55.5 Clean Seat
55.6 Engine Cooling System
55.7 Dual Beam Radar Sensor
55.8 MFWD or TLS? Plus Axle Vent Filter
56 Service – Check
56.1 Windshield Washer Fluid Level
56.2 Engine Coolant Level
56.3 Engine Coolant Freeze Point
56.4 Water Separator
56.5 Optional Fuel Water Separator (If Equipped)
56.6 Engine Air Filter Precleaner System
56.7 Primary and Secondary Engine Air Filters
56.8 Engine and Exhaust Compartments
56.9 Air Conditioning System
56.10 Engine Water Pump Weep Hole
56.11 Fuel Tank Sump
56.12 MFWD or TLS? Plus Axle Housing Oil Level
56.13 MFWD or TLS? Plus Wheel Hub Oil Level
56.14 Engine Oil Level
56.15 Transmission-Hydraulic Oil Level
56.16 Mechanical Cab Suspension Components
56.17 Front PTO Housing Oil Level
56.18 Engine Air Intake System?6.8 L Engine
56.19 Engine Air Intake System – 9.0 L Engine
56.20 Tires
56.21 TLS? Plus Accumulator Charge Pressure
56.22 Handling Batteries Safely
56.23 Seat Belts
56.24 Fan Belt Tensioner and Fan Belt
56.25 Engine Valve Clearance
56.26 Secondary Brake System
56.27 NEUTRAL Start System
56.28 Transmission PARK System
57 Service – Tighten
57.1 Wheel and Wheel Weight Bolts
57.2 Use Wheel Tightening Stand
57.3 Use Wheel Torque Wrench Adapter
57.4 Rear Wheel Weight Bolts
57.5 Front Wheel Bolts
57.6 Rear Drive Wheel to Cast Hub Bolts
57.7 Rear Steel Wheel to Hub Bolts
57.8 Rear Steel Wheels?Cast Hub Bolts
57.9 Rear Wheel Bolts?Heavy-duty Cast 10-Bolt Hubs
57.10 Rear Wheel Bolts?Heavy-Duty 12-Bolt Hubs
58 Service – Change
58.1 Engine Primary and Secondary Air Filters
58.2 Fan Belt
58.3 Engine Oil and Filter?6.8 L Engine
58.4 Engine Oil and Filter?9.0 L Engine
58.5 Fuel Filters
58.6 Optional Fuel Water Separator Filter Element (If Equipped)
58.7 Cab Recirculation Air Filter
58.8 Cab Fresh Air Filter
58.9 Transmission-Hydraulic Oil and Filter
58.10 MFWD or TLS? Plus Wheel Hub Oil
58.11 MFWD or TLS? Plus Axle Housing Oil
58.12 Front PTO Housing Oil and Filter
58.13 Crankcase Ventilation Filter?6.8 L Engine
58.14 Fuel Tank Vent Filter
58.15 SCV Pilot Valve Filter
58.16 Trailer Air Brake Dryer Filter
58.17 DEF Tank Vent Filter
58.18 Access In-Line DEF Filter
58.19 Change Diesel Exhaust Fluid (DEF) In-Line Filter
58.20 Access DEF Dosing Unit Filter
58.21 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
58.22 Replace Transmission Drive Shaft Damper
58.23 Engine Crankshaft Damper
58.24 Engine Coolant
59 Service – Lubricate
59.1 Rear Hitch
59.2 Front Hitch
59.3 Deluxe Stabilizers
59.4 Wagon Hitch
59.5 Pick-Up Hitch
59.6 MFWD or TLS? Plus Kingpins, Tie Rod Ends, Steering Cylinder, Axle Pivot, and Panhard Rod
59.7 MFWD or TLS? Plus U-Joints
59.8 Draft Link Support Shaft Bushing
60 Service – Electrical
60.1 Service – Electrical Overview
60.2 Welding Near Electronic Control Units
60.3 Keep Electronic Control Unit Connectors Clean
60.4 Compressed Air Use
60.5 High-Pressure Washers Use
60.6 Disconnect Battery
60.7 Service Batteries and Connections
60.8 Access Load Center Fuses
60.9 Access Front Load Center
60.10 Access Master Fuses
60.11 Access Implement Power Relay Module Fuses
60.12 Handle Halogen Light Bulbs Safely
60.13 Change Front HID/LED Light Assembly
60.14 Change Halogen Bulbs
60.15 Adjust Front Grille Lights
60.16 Change Front/Rear Belt Line Work Lights
60.17 Adjust Headlights
60.18 Change Roof Work Lights
60.19 Change Rear Fender Light
60.20 Change Extremity Light?Cab
60.21 Change Cab Dome Light
61 Troubleshooting – Procedures
61.1 Engine
61.2 Transmission
61.3 Hydraulic System
61.4 Hitch
61.5 Selective Control Valve (SCV)
61.6 TouchSet? Depth Control
61.7 Electrical System
61.8 Operator Enclosure
61.9 Tractor Operation
61.10 Steering System
62 Troubleshooting – Diagnostic Trouble Codes (DTC)
62.1 STOP, Service, and Information Alerts on CommandCenter?
62.2 Access Diagnostic Trouble Codes
63 Service – Storage
63.1 Place Tractor in Storage
63.2 Remove Tractor from Storage
64 Specifications
64.1 Engine
64.2 Capacities
64.3 Fluorinated Greenhouse Gas
64.4 Hydraulic
64.5 Transmission and Drive Train
64.6 Hitch, Drawbar, and PTO
64.7 Electrical System
64.8 Integrated Technology
64.9 Overall Dimensions
64.10 Tractor Load/Weights
64.11 Loads and Weights (EU 1322/2014)
64.12 Sound Level (EU 1322/2014)
64.13 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (EU 1322/2014)
64.14 Ground Speeds?e23? Transmission
64.15 Ground Speeds?IVT?/AutoPowr? Transmission
64.16 Front Loader Installation?Front Loader Mounting Frames (EU 1322/2014)
64.17 Required Emission-Related Information
64.18 Carbon Dioxide Emissions (CO?)
65 Identification Numbers
65.1 Identification Plates
65.2 Product Identification Number (PIN)
65.3 Engine Serial Number
65.4 Cab Serial Number
65.5 Transmission Serial Number
65.6 Axle Serial Number
65.7 Keep Proof of Ownership
65.8 Keep Machines Secure
66 Change of Ownership
66.1 Subsequent Ownership
67 Index
68 Predelivery
68.1 Predelivery Checklist
68.2 Delivery Checklist and Certificate
69 John Deere Service Literature Available
69.1 Technical Information
70 John Deere Service Keeps You On The Job
70.1 John Deere Parts
70.2 The Right Tools
70.3 Well-Trained Technicians
70.4 Prompt Service