Table of Content:
1 Introduction
1.1 Foreword
1.2 Look For Supplemental Information
1.3 Trademarks
1.4 Traction Class
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Transport Towed Equipment at Safe Speeds
3.26 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.27 Freeing a Mired Machine
3.28 Avoid Contact with Agricultural Chemicals
3.29 Handle Agricultural Chemicals Safely
3.30 Handling Batteries Safely
3.31 Avoid Heating Near Pressurized Fluid Lines
3.32 Remove Paint Before Welding or Heating
3.33 Handle Electronic Components and Brackets Safely
3.34 Practice Safe Maintenance
3.35 Avoid Hot Exhaust
3.36 Clean Exhaust Filter Safely
3.37 Work In Ventilated Area
3.38 Support Machine Properly
3.39 Prevent Machine Runaway
3.40 Park Machine Safely
3.41 Transport Tractor Safely
3.42 Service Cooling System Safely
3.43 Service Accumulator Systems Safely
3.44 Service Tires Safely
3.45 Service Front-Wheel Drive Tractor Safely
3.46 Tightening Wheel Retaining Bolts/Nuts
3.47 Avoid High-Pressure Fluids
3.48 Do Not Open High-Pressure Fuel System
3.49 Store Attachments Safely
3.50 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Park Brake (Stored Energy)
4.4 Track Accumulators
4.5 Engine Cooling System (For China Only)
5 Vehicle Overview
5.1 9RT Scraper Series Tractor
6 Operator?s Manual Use
6.1 Operator?s Manual Use
7 General Vehicle Description
7.1 9RT Scraper Series Tractor
8 Engine Operation
8.1 Required Machine Stop Warning
8.2 Engine Fuel System and Power Rating
8.3 Battery Disconnect Switch (If Equipped)
8.4 Start the Engine
8.5 Theft Deterrent Systems
8.6 Run the Engine
8.7 Stop the Engine
8.8 Restart Engine That Has Run Out of Fuel
8.9 Reduce Fuel Consumption
8.10 Use Battery Booster or Charger
9 Cold Weather Operation
9.1 Cold Weather Starting?With Starting Aid
9.2 Cold Weather Starting And Operation?Internal Starting Aid
9.3 Change Starting Fluid Canister (If Equipped)
9.4 Engine Coolant Heater Use?13.5 L Engine (If Equipped)
9.5 Engine Coolant Heater Use?15 L Engine (If Equipped)
10 Emissions Equipment
10.1 Exhaust Filter System Overview?Final Tier 4/Stage IV Engine
10.2 Aftertreatment Indicators Overview
10.3 Selective Catalytic Reduction (SCR) System Overview
10.4 Qualified Emergency Use ? SCR Override Option
10.5 Auto Exhaust Filter Cleaning Mode?Final Tier 4/Stage IV Engine
10.6 Parked Exhaust Filter Cleaning?Final Tier 4/Stage IV Engine
10.7 Selective Catalytic Reduction (SCR) System?Final Tier 4/Stage IV Engine
10.8 Low Fuel or Low Diesel Exhaust Fluid (DEF) Warning
10.9 Disconnect Battery
11 Controls and Instruments
11.1 Front Console
11.2 CommandARM? ISOBUS Shortcut Button (ISB)
11.3 Foot Decelerator
12 Corner Post Display
12.1 Corner Post Display
12.2 Information Indicators
12.3 Digital Indicators?Tachometer, Ground Speed and Transmission
12.4 Gauges?Coolant Temperature, Diesel Exhaust Fluid (DEF) Level and Fuel Level
13 CommandARM? Controls
13.1 CommandARM? with Generation 4 CommandCenter? Display
13.2 CommandARM? Secondary Brake Lever (If Equipped)
13.3 CommandARM? SCV Controls
13.4 CommandARM? Climate, Radio and Lighting Controls
13.5 CommandARM? Left-Hand Side Controls
14 CommandCenter?
14.1 Onscreen Help
14.2 Generation 4 CommandCenter?
14.3 Generation 4 CommandCenter? Processor
14.4 Generation 4 CommandCenter? 4600 Processor Wi-Fi? Capabilities
14.5 Run Page Structure
14.6 Menu
14.7 Machine Settings Overview
14.8 Operating System Applications Overview
14.9 AMS Applications Overview
14.10 CommandCenter? Premium Activation
14.11 Demo Activations
14.12 Automation Status Overview
14.13 Navigate Generation 4 CommandCenter?
14.14 Power Display On and Off
14.15 Navigate Run Pages on Main Page
14.16 Shortcut Buttons
14.17 Navigate to Display & Sound
14.18 Display and Sound
14.19 Brightness
14.20 Sound
14.21 Multiple Displays
14.22 Display Calibration
14.23 Navigate to Date & Time
14.24 Date and Time
14.25 Change Current Date
14.26 Change Current Time
14.27 Navigate to Language & Units
14.28 Language and Units
14.29 Language and Units Settings
14.30 Change Pages and Values
14.31 Status Center
14.32 Shortcut Softkeys
14.33 Navigate to Software Manager
14.34 Software Manager
14.35 Factory and Service ADVISOR? Installed Onscreen Help
14.36 Update Display Software
14.37 Activations
14.38 Service ADVISOR? Remote
14.39 Vehicle Reprogramming
14.40 Troubleshooting ? Reprogramming
14.41 System Recovery
14.42 Remote Display Access
14.43 Navigate to File Manager
14.44 File Manager
14.45 USB Drive
14.46 Capture Screen Shots
14.47 Navigate to Diagnostics Center
14.48 Diagnostics Center
14.49 Controller Diagnostics
14.50 Diagnostic Information
14.51 Hide Diagnostic Center
14.52 Diagnostic Trouble Codes
14.53 Display Hardware
14.54 CAN Bus Information
14.55 CAN Bus Values
14.56 Network
14.57 Navigate to Users & Access
14.58 Users and Access
14.59 User Profiles
14.60 Access Groups
14.61 Navigate to Layout Manager
14.62 Layout Manager
14.63 Active Set
14.64 Shortcut Bar
14.65 All Run Pages
14.66 Add, Edit, or Duplicate Run Pages
14.67 Navigate to Fields
14.68 Fields and Boundaries
14.69 Field Boundaries
14.70 Manage Clients, Farms, and Fields
14.71 AutoTrac? Guidance
14.72 Navigate to Equipment Manager
14.73 Equipment Manager
14.74 Machine Profile
14.75 Implement Profile
14.76 Navigate to Machine Monitor
14.77 Machine Monitor
14.78 Navigate to Work Monitor
14.79 Work Monitor
14.80 Work Recording
14.81 Navigate to Maintenance & Calibrations
14.82 Maintenance and Calibrations
14.83 Calibrations
14.84 Radar Calibration
14.85 Slip Calibration
14.86 Service Intervals
14.87 Steering
14.88 Steering Settings
14.89 Controls Setup
14.90 Settings Manager
14.91 Automation Status
14.92 Read ISOBUS Controller?s Operator?s Manual
14.93 ISOBUS VT
14.94 StarFire? GPS Receiver
14.95 Use Video Display Capability Properly
14.96 Install Video Display Camera
14.97 Navigate to Video Application
14.98 Video
14.99 Video Triggers
15 Radio Operation
15.1 Radio Faceplate Features
15.2 Declaration of Conformity
15.3 Select Radio Receiver Wave Band
15.4 Mexico Bluetooth? Information
15.5 Russia Bluetooth? Certification
15.6 Set Clock
15.7 Turn Confirmation Beep On/Off (BEEP)
15.8 Adjust Maximum Volume at Power-On (ONVOL)
15.9 Program Type (PTY)
15.10 Treble Reduction During Interference (HCUT)
15.11 Set Key Function (KEY PRG)
15.12 Traffic Information
15.13 External Sources (Premium Radio)
15.14 Select Radio Source with Generation 4 CommandCenter?
15.15 AM/FM Home Page
15.16 Premium Radio CD Home Page
15.17 Premium Radio USB Home Page
15.18 Premium Radio Bluetooth? Home Page
15.19 Auxiliary Home Page
15.20 Pair Bluetooth? Device to Generation 4 CommandCenter?
15.21 Manage Paired Bluetooth? Devices
15.22 Phone Operation
15.23 Phone Signal Strength and Battery Charge
15.24 Contact List
15.25 Recent Calls
15.26 Clear Favorites and Call History
16 AMS? Technology
16.1 Machine Sync
16.2 Mount StarFire? Receiver
16.3 Install GreenStar? System Components
16.4 Install Machine Communications Radio (MCR) Antenna
16.5 Connect AutoTrac? Assisted Steering System
17 Intelligent Total Equipment Control (iTEC?)
17.1 CommandARM? Control Functions
17.2 iTEC? Station Description
17.3 CommandCenter? Pages Descriptions and Functions
17.4 Status Area
17.5 All Sequence Page
17.6 Add New Sequence
17.7 Sequence Step Status
17.8 Edit or Remove Sequence
17.9 Sequence Sets Page
17.10 Perform Sequence
17.11 Recommendations (AutoLearn)
17.12 iTEC? Functions?Efficiency Manager?
18 Tractor Implement Automation (TIA?)
18.1 Tractor-Implement Automation? (TIA?)
18.2 Activate Tractor-Implement Automation? Equipment
18.3 Tractor-Implement Automation? ? Status Page
18.4 Operate Tractor-Implement Automation?
18.5 SCV Requirements
18.6 Powershift Transmission Requirements
18.7 AutoTrac? Guidance Requirements
18.8 Drive Strategy Requirements
19 Drive Train
19.1 Drive Train Overview
19.2 Drivetrain Protection?9470RT Scraper, 9520RT Scraper, and 9570RT Scraper
20 Brakes
20.1 Brake Use
20.2 Brake Warning Indicators
20.3 Hydraulic Trailer Brakes (If Equipped)
20.4 Trailer Brake Settings
20.5 Engine Brake ? 15 L Engine (If Equipped)
20.6 Use Secondary Brake Lever
20.7 Foot Decelerator
21 Transmission – General Information
21.1 Warm-Up Transmission-Hydraulic System
21.2 Activate and Set Maximum Set Speed
21.3 Use Maximum Set Speed with Different Transmission Modes
21.4 Backup Alarm
21.5 Come-Home Mode
22 e18? Powershift Transmission
22.1 Operate the e18? Powershift Transmission
22.2 Shift e18? Transmission
22.3 Set Start Gears
22.4 CommandCenter? Transmission Main Page
22.5 Efficiency Manager? on the e18? Transmission
22.6 Efficiency Manager ? Custom Transmission Settings
23 Drawbar
23.1 Install Drawbar or Quick-Attach in Short Drawbar Support
23.2 Short Scraper Drawbar Conversion
23.3 Tow Cable (If Equipped)
24 Hydraulics – General Information
24.1 Hydraulic System Overview
25 Selective Control Valves
25.1 Configure SCV Modes
25.2 Configure SCV – Standard Mode
25.3 Activate Independent Mode
25.4 Configure SCV – Independent Mode
25.5 Configure SCV – Feature Mode
25.6 Total Rear SCV Flow
25.7 Six Position SCV Control Levers
25.8 SCV Control Lever?Neutral Position
25.9 SCV Control Lever?Extend and Retract Position
25.10 SCV Control Lever?Extend Detent and Retract Detent Position
25.11 SCV Control Lever?Float Position
25.12 Operator Presence Sensor
25.13 CommandARM? Joystick (If Equipped)
25.14 CommandARM? Joystick (If Equipped) – Custom Setup
25.15 CommandARM? Joystick (If Equipped) – Layout and Joystick Lever Functions
25.16 SCV and Joystick Flow Response Setting
26 Hydraulic Connections
26.1 Connecting Hydraulic Hoses?Rear of Tractor
26.2 Disconnecting Hydraulic Hoses?Rear of Tractor
26.3 High Flow Hydraulic Component Identification
26.4 Standard Hydraulic Component Identification
26.5 Using Load-Sensing Hydraulic System?Power Beyond
26.6 Examples Using Load-Sensing Hydraulic System?Power-Beyond
26.7 Scraper Connection Example: Pulling 1, 2, and 3 Scrapers
26.8 Implements Requiring Large Volumes of Oil
26.9 Scraper Hydraulic Hose Tips
27 TouchSet? Depth Control
27.1 Attaching Implement and Control System
27.2 Reset Implement Connector
27.3 Using TouchSet? Depth Controls
28 Scraper Information
28.1 Scraper Operation Cycle
28.2 Weight Transfer Limits
28.3 Scraper/Tractor Attachment
28.4 Loading Techniques
28.5 Connect AutoLoad? Harness
28.6 AutoLoad? Displays
28.7 Scraper Control Panel Reference
28.8 AutoLoad? Settings – Setting Auto Dimensions
28.9 Using AutoLoad?
28.10 Set Scraper ?Transport? Height
28.11 Set Scraper ?Ready? (Dump) Height
28.12 Set Scraper Ground ?Loading? Entering the Cut Height
28.13 AutoLoad? Operation
28.14 AutoLoad? Set Up Wizard
29 Tracks – General Information
29.1 General Track Use Guidelines
29.2 Tracks Service
30 Operator?s Station – General Information
30.1 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer)
30.2 Avoid Contact with Agricultural Chemicals
30.3 Clean Vehicle of Hazardous Pesticides
30.4 Keep Riders Off Machine
30.5 Keep Operator Station Window and Door Closed
30.6 Use Seat Belts
30.7 Use Emergency Exit
30.8 Monitor Bracket Mounts
31 Seat
31.1 Adjust ComfortCommand? Seat
31.2 Adjust Heated Leather Seat
31.3 Adjust CommandARM? Position
31.4 Use Instructional Seat
31.5 Operator Presence Sensor
32 Steering Column
32.1 Adjust Steering Wheel and Column
32.2 Operate Horn
33 Mirrors
33.1 Manual Mirror
33.2 Electric Mirror
34 Wiper Washer
34.1 Operate Front Windshield Wiper and Washer
34.2 Operate Rear Wiper and Washer
34.3 Operate Right-Hand Wiper and Washer
35 Lights
35.1 Light Identification (Version A)
35.2 Light Identification (Version B)
35.3 Configurable Lights
35.4 Steering Column Light Controls (Version A)
35.5 Steering Column Light Controls (Version B)
35.6 Exit Lights
35.7 Operate Turn Signals and High/Low Beam
35.8 Safety Lights and Devices
35.9 CommandARM? Light Buttons
35.10 Hazard Lights and Extremity Warning Lights
35.11 Trailering Lights
35.12 Rotary Beacon Light
35.13 7-Pin Outlet (Equipped with Version A Lighting)
35.14 7-Pin Outlet (Equipped with Version B Lighting)
36 Accessories
36.1 Pull-Down Sunshade
36.2 Install Business Band or Citizens Band (CB) Radio and Antenna
36.3 Auxiliary Power Strip Use
36.4 Accessory Electrical Outlet Use
36.5 Connect Compatible Electronic Equipment
36.6 Configure Tractor for GPS or Radar
36.7 Refrigerator or Storage Space
36.8 Use Chain Box
36.9 Implement Connector Use
36.10 Use AutoLoad? Harness Connector
37 HVAC
37.1 Climate Controls
37.2 HVAC Settings?Generation 4 CommandCenter?
38 Performance Ballasting
38.1 General Performance Guidelines
38.2 Ballasting for Tractive Performance
38.3 Ballast Recommendations
38.4 Determining Maximum Ballast
38.5 Ballasting Recommendations With Implements
38.6 Implement Guidelines
38.7 Installing Quik-Tatch? Front Weights (If Equipped)
38.8 Installing Quik-Tatch? Side Weights (If Equipped)
38.9 Idler Wheel Weights (If Equipped)
38.10 Wheel Weight Holding Wrench (JDG10958)
38.11 Measuring Track Slip (Manually)
38.12 Worksheet to Calculate Ballast Changes
39 Transport
39.1 Driving Tractor on Roads
39.2 Towed Mass
39.3 Towing Loads and Transporting with Ballast
39.4 Transporting Rear Mounted Implements with Ballast
39.5 Use Safety Lights and Devices
39.6 Transport Towed Equipment at Safe Speeds
39.7 Using Safety Chain
39.8 Freeing a Mired Tractor
39.9 Towing Tractor?Engine Will Start
39.10 Towing Tractor?Engine Will Not Start
39.11 Emergency Brake Steering
39.12 Carrier Transport
40 Fuel, Lubricants, and Coolant – General Information
40.1 Determine Tractor Engine Type
40.2 Minimizing the Effect of Cold Weather on Diesel Engines
40.3 Oil Filters
41 Fuel
41.1 Diesel Fuel
41.2 Supplemental Diesel Fuel Additives
41.3 BioDiesel Fuel
41.4 Lubricity of Diesel Fuel
41.5 Handling and Storing Diesel Fuel
41.6 Avoid Static Electricity Risk When Refueling
41.7 Fill Fuel Tank
41.8 Testing Diesel Fuel
41.9 Fuel Filters
42 Diesel Exhaust Fluid (DEF)
42.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
42.2 Storing Diesel Exhaust Fluid (DEF)
42.3 Refilling Diesel Exhaust Fluid (DEF) Tank
42.4 Fill Diesel Exhaust Fluid (DEF) Tank – FT4/Stage IV Engine
42.5 Testing Diesel Exhaust Fluid (DEF)
42.6 Disposal of Diesel Exhaust Fluid (DEF)
43 Engine Oil
43.1 Diesel Engine Oil Service Interval for Operation at High Altitude
43.2 Diesel Engine Oil ? Tier 2 and Stage II
43.3 Engine Oil and Filter Service Intervals ? Tier 2 and Stage II Engines
43.4 John Deere Break-In Plus? Engine Oil ? Final Tier 4 and Stage IV 13.5 L Engines
43.5 Break-In Engine Oil Use ? Final Tier 4 and Stage IV 15 L Engines
43.6 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
43.7 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 13.5 L Engine
43.8 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 15 L Engine
44 Engine Coolant
44.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
44.2 John Deere COOL-GARD? II Coolant Extender
44.3 Operating in Warm Temperature Climates
44.4 Water Quality for Mixing with Coolant Concentrate
44.5 Testing Coolant Freeze Point
44.6 Disposing of Coolant
45 Other Lubricants
45.1 Transmission and Hydraulic Oil
45.2 Grease
45.3 Mixing of Lubricants
45.4 Alternative and Synthetic Lubricants
45.5 Lubricant Storage
46 Service – General Information
46.1 Service Sections Overview
46.2 Service Tasks Performed As Required
46.3 Identify Tractor Engine Emissions Status
46.4 Open Hood
46.5 Jack Up Tractor – Lifting Points and Support Stand Placement
46.6 Service and Connect STC? (Snap-to-Connect) Fittings
46.7 High-Pressure Washer Use
46.8 Diesel Particulate Filter Service
46.9 Exhaust Filter / Diesel Particulate Filter Ash Handling and Disposal
46.10 Exhaust Filter Disposal
46.11 Transmission Calibration
46.12 Abort Transmission Calibration
46.13 Do Not Modify Fuel System
46.14 Do Not Open High-Pressure Fuel System
46.15 Bleed Fuel System
46.16 Identify Zinc-Flake Coated Fasteners
46.17 Metric Bolt and Screw Torque Values
46.18 Unified Inch Bolt and Screw Torque Values
47 Service – Predelivery Checklist
47.1 Predelivery Checklist
48 Service – Delivery Checklist and Certificate
48.1 Delivery Checklist and Certificate
49 Break-In Service (100 Hours or Less)
49.1 Perform Break-In Services
49.2 Perform Track Systems Break-In
50 Service – Record Charts
50.1 Engine Oil and Filter Change
50.2 As Required Service
50.3 Annual Service
50.4 10 Hour or Daily Service
50.5 50 Hour Service
50.6 250 Hour Service
50.7 400 Hour Service
50.8 500 Hour Service
50.9 750 Hour Service
50.10 800 Hour Service
50.11 1000 Hour Service
50.12 1200 Hour Service
50.13 1250 Hour Service
50.14 1500 Hour Service
50.15 1600 Hour Service
50.16 1750 Hour Service
50.17 2000 Hour Service
50.18 2250 Hour Service
50.19 2400 Hour Service
50.20 2500 Hour Service
50.21 2750 Hour Service
50.22 2800 Hour Service
50.23 3000 Hour Service
50.24 3200 Hour Service
50.25 3250 Hour Service
50.26 3500 Hour Service
50.27 3600 Hour Service
50.28 3750 Hour Service
50.29 4000 Hour Service
50.30 4250 Hour Service
50.31 4400 Hour Service
50.32 4500 Hour Service
50.33 4750 Hour Service
50.34 4800 Hour Service
50.35 5000 Hour Service
50.36 5200 Hour Service
50.37 5250 Hour Service
50.38 5500 Hour Service
50.39 5600 Hour Service
50.40 5750 Hour Service
50.41 6000 Hour Service
50.42 Services Beyond 6000 Hours
51 Service – Clean
51.1 Diesel Particulate Filter (DPF)?Final Tier 4/Stage IV Engine
51.2 Engine Cooling System?13.5 L Engine
51.3 Engine Cooling System?15 L Engine
51.4 Diesel Exhaust Fluid (DEF) Tank
51.5 Diesel Exhaust Fluid (DEF) Tank Filler Neck Filter
51.6 Clean Display
51.7 Dual Beam Radar Sensor
51.8 AirCushion? Suspension System Air Compressor Pump and Inlet Filter and Air Bags
51.9 Optional Fuel Water Separator
51.10 Optional Fuel Water Separator Filter Element
51.11 Aftertreatment Fuel Injector?15 L Engine
52 Service – Check
52.1 Engine Coolant Level
52.2 Water Separator
52.3 Tracks
52.4 Engine and Exhaust Compartments
52.5 Air Conditioning System
52.6 Engine Water Pump Weep Hole?13.5 L Engine
52.7 Engine Water Pump Seal?15 L Engine
52.8 Fuel Tank Sump
52.9 Engine Oil Level?13.5 L Engine
52.10 Engine Oil Level?15 L Engine
52.11 Transmission-Hydraulic Oil Level
52.12 Track Alignment
52.13 Track Tension
52.14 Drive and Idler Wheels and Mid-Rollers
52.15 Track Wear
52.16 Track Trash Buildup
52.17 Hydraulic Accumulator
52.18 Secondary Brake
52.19 NEUTRAL Start System
52.20 Transmission PARK System
52.21 AirCushion? Suspension System
52.22 AirCushion? Suspension System Walking Beam Bumper Stops
52.23 Engine Air Intake System?13.5 L Final Tier 4 or Stage IV Engine
52.24 Engine Air Intake System?15 L Engine
52.25 Engine Coolant Freeze Point
52.26 Seat Belts
52.27 Auxiliary Drive Belt and Drive Belt Tensioner?15 L Engine
52.28 Drive Wheel Hub Housing Oil
52.29 Mid-Rollers Oil Level
52.30 Idler Wheel Hub Oil Level
52.31 Engine Valve Clearance
52.32 Vari-Cool? Fan Drive and Belt – 13.5L Final Tier 4 or Stage IV Engine
53 Service – Tighten
53.1 Drive Wheel Nuts, Idler Wheel, and Mid-Roller Cap Screws
53.2 Drawbar Support and Cap Screws
54 Service – Change
54.1 Engine Primary and Secondary Air Filters
54.2 Replace Fan Belt?13.5 L Tier 2 and Stage II Engine
54.3 Vari-Cool? Fan Belt?13.5 L Final Tier 4 or Stage IV Engine
54.4 Auxiliary Drive Belt?15 L Engine
54.5 Engine Oil and Filter?13.5 L Engine
54.6 Engine Oil and Filter?15 L Engine
54.7 Fuel Filters?13.5 L Engine
54.8 Fuel Filters?15 L Engine
54.9 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer)
54.10 Cab Recirculation Air Filter
54.11 Cab Fresh Air Filter
54.12 Walking Beam Stop Bumpers
54.13 Fuel Tank Vent Filters
54.14 SCV Pilot Valve Filter
54.15 Diesel Exhaust Fluid (DEF) Tank Vent Filter?Final Tier 4 or Stage IV Engine
54.16 DEF Header Filter – Final Tier 4 or Stage IV Engine
54.17 Transmission-Hydraulic Oil and Filters
54.18 Engine Cooling System Radiator Cap?15 L Engine
54.19 Transmission Vent Filter
54.20 AirCushion? Suspension System Air Compressor Air Inlet Fitler
54.21 Engine Crankcase Breather Filter Element?15 L Engine
54.22 Access Diesel Exhaust Fluid (DEF) Dosing Unit Filter?Final Tier 4 or Stage IV Engine
54.23 DEF Dosing Unit Filter?Final Tier 4/Stage IV Engine
54.24 Transmission Drive Shaft Damper
54.25 Engine Coolant?13.5 L Engine
54.26 Engine Coolant?15 L Engine
54.27 Engine Crankshaft Damper?13.5 L Engine
55 Service – Lubricate
55.1 Hydraulic Hose Support Bracket
55.2 Track Tension Cylinder
55.3 Vari-Cool? Fan Drive?13.5 L Final Tier 4 or Stage IV Engine
56 Service – Electrical
56.1 Service – Electrical Overview
56.2 Welding Near Electronic Control Units
56.3 Keep Electronic Control Unit Connectors Clean
56.4 Compressed Air Use
56.5 High-Pressure Washer Use
56.6 Disconnect Battery?Final Tier 4/Stage IV Engine
56.7 Handling Batteries Safely
56.8 Service Batteries and Connectors?13.5 L Engine
56.9 Service Batteries and Connectors?15 L Engine
56.10 Service Batteries and Connectors?Tier 2 or Stage II or Interim Tier 4 or Stage III Engine
56.11 Access Load Center Fuses
56.12 Access Master Fuse
56.13 Access Implement Power Relay Module Fuses
56.14 Handle Halogen Light Bulbs Safely
56.15 Change Front HID/LED Light Assembly
56.16 Change Front Grille Halogen Light Bulbs
56.17 Adjust Front Grille Lights
56.18 Adjust Headlights
56.19 Change Front, Side And Rear Cab Roof Light Assembly
56.20 Change Brake or Turn Signal Light Bulb
56.21 Change Dome Light Bulb
56.22 Change Extremity Warning Light Bulb
56.23 Change Trailering Light Bulb
57 Troubleshooting – Procedures
57.1 Engine
57.2 Transmission/Hydraulics/Axle
57.3 Hydraulic System
57.4 Brake System
57.5 Selective Control Valve (SCV)
57.6 Electrical System
57.7 Operator Enclosure
57.8 Steering System
57.9 Premium Radio
58 Troubleshooting – Diagnostic Trouble Codes (DTC)
58.1 STOP and Service Alert Indicators
58.2 Information Indicator
58.3 Access Diagnostic Trouble Codes
59 Service – Storage
59.1 Place Tractor in Storage
59.2 Remove Tractor from Storage
59.3 Paint Finish Care
60 Specifications
60.1 Engine: John Deere
60.2 Engine: QSX15 Cummins?
60.3 Capacities
60.4 Hydraulic
60.5 Electrical
60.6 Transmission and Power Train
60.7 Drawbar
60.8 Other Equipment
60.9 Overall Dimensions
60.10 Loads and Weights
60.11 How to Calculate Permissible Mass
60.12 Sound Level
60.13 Ground Speeds?e18? Powershift Transmission
60.14 Machine Design Life
60.15 Required Emission-Related Information
60.16 Eurasian Economic Union
60.17 Limited Battery Warranty
61 Identification Numbers
61.1 Identification Plates
61.2 Product Identification Number
61.3 Product Identification Number (China Only)
61.4 Engine Serial Number
61.5 Cab Serial Number
61.6 Transmission Serial Number
61.7 Axle Serial Number
61.8 Track Serial Numbers
61.9 Keep Proof of Ownership
61.10 Keep Machines Secure
62 Change of Ownership
62.1 Subsequent Ownership
63 John Deere Service Keeps You On The Job
63.1 John Deere Parts
63.2 The Right Tools
63.3 Well-Trained Technicians
63.4 Prompt Service
