Table of Content:
1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Transport Towed Equipment at Safe Speeds
3.26 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.27 Freeing a Mired Machine
3.28 Avoid Contact with Agricultural Chemicals
3.29 Handle Agricultural Chemicals Safely
3.30 Handling Batteries Safely
3.31 Avoid Heating Near Pressurized Fluid Lines
3.32 Remove Paint Before Welding or Heating
3.33 Handle Electronic Components and Brackets Safely
3.34 Practice Safe Maintenance
3.35 Avoid Hot Exhaust
3.36 Clean Exhaust Filter Safely
3.37 Work In Ventilated Area
3.38 Support Machine Properly
3.39 Prevent Machine Runaway
3.40 Park Machine Safely
3.41 Transport Tractor Safely
3.42 Service Cooling System Safely
3.43 Service Accumulator Systems Safely
3.44 Service Tires Safely
3.45 Service Front-Wheel Drive Tractor Safely
3.46 Tightening Wheel Retaining Bolts/Nuts
3.47 Avoid High-Pressure Fluids
3.48 Do Not Open High-Pressure Fuel System
3.49 Store Attachments Safely
3.50 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Hinge Area
4.4 HydraCushion? Suspension Accumulators (If Equipped)
4.5 Park Brake (Stored Energy)
4.6 Rear Hitch (If Equipped for China Only) [Ag]
4.7 Rear PTO (If Equipped for China Only) [Ag]
4.8 Engine Cooling System (For China Only)
5 Vehicle Overview
5.1 9R Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Max Engine Speed
6.5 Engine Settings?Exhaust Filter System Overview
6.6 Engine Settings?AUTO Exhaust Filter Cleaning
6.7 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Parked Filter Cleaning
6.9 Engine Settings?Decelerator
6.10 Engine Settings?Advanced
6.11 Required Machine Stop Warning
6.12 Engine Fuel System and Power Rating
6.13 Battery Disconnect Switch
6.14 Start the Engine
6.15 Theft Deterrent Systems
6.16 Run the Engine
6.17 Stop the Engine
6.18 Restart Engine That Has Run Out of Fuel
6.19 Reduce Fuel Consumption
6.20 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?With Starting Aid
7.2 Cold Weather Starting And Operation?Internal Starting Aid
7.3 Change Starting Fluid Canister
7.4 Engine Coolant Heater Use?9.0 L Engine [Ag]
7.5 Engine Coolant Heater Use?13.5 L or 15 L Engines
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
9 Controls and Instruments
9.1 Front Console
9.2 CommandARM? ISOBUS Shortcut Button (ISB)
9.3 Foot Decelerator
10 Corner Post Display
10.1 Corner Post Display
10.2 Information Indicators
10.3 Warning Indicators
10.4 Digital Indicators?Tachometer, Ground Speed, and Transmission
10.5 Gauges?Coolant Temperature, DEF Level, and Fuel Level
11 CommandARM? Controls
11.1 CommandARM? with Generation 4 CommandCenter? Display
11.2 CommandARM? Secondary Brake Lever
11.3 CommandARM? Hitch Controls [Ag]
11.4 CommandARM? SCV Control Levers
11.5 CommandARM? Climate, Radio and Lighting Controls
11.6 CommandARM? PTO Control Lever [Ag]
11.7 CommandARM? Controls?Left Side
12 CommandCenter?
12.1 Generation 4 Display
12.2 Rear Hitch or PTO Availability
12.3 Machine Settings Overview
12.4 Automation Status Overview
12.5 Navigate Generation 4 CommandCenter?
12.6 Compatible Universal Displays
12.7 Power Display On and Off
12.8 Change Pages and Values
12.9 Factory and Service ADVISOR? Installed Onscreen Help
12.10 Radar Calibration
12.11 Slip Calibration
12.12 Steering Settings?Access
12.13 Steering Settings
12.14 Steering Settings?Steering Wheel Resistance
12.15 Controls Setup
12.16 Automation Status
12.17 Install Video Display Camera
13 CommandCenter? – Radio
13.1 Mexico Bluetooth? Information
13.2 External Sources
13.3 Select Audio Source with Generation 4 CommandCenter?
13.4 AM/FM Home Page
13.5 Premium Radio USB Home Page
13.6 Premium Radio Bluetooth? Home Page
13.7 Auxiliary Home Page
13.8 Pair Bluetooth? Device to Generation 4 CommandCenter?
13.9 Manage Paired Bluetooth? Devices
13.10 Phone Operation
13.11 Contact List
13.12 Recent Calls
13.13 Clear Favorites and Call History
14 Intelligent Total Equipment Control (iTEC?)
14.1 CommandARM? Control Functions
14.2 iTEC? Station Description
14.3 CommandCenter? Pages Descriptions and Functions
14.4 Status Area
14.5 All Sequence Page
14.6 Add New Sequence
14.7 Sequence Step Status
14.8 Edit or Remove Sequence
14.9 Sequence Sets Page
14.10 Perform Sequence
14.11 Recommendations (AutoLearn)
14.12 iTEC? Functions?Efficiency Manager?
15 Tractor-Implement Automation? (TIA?)
15.1 Tractor-Implement Automation? (TIA?)
15.2 Activate Tractor-Implement Automation? Equipment
15.3 Tractor-Implement Automation? ? Status Page
15.4 Operate Tractor-Implement Automation?
15.5 PTO Requirements [Ag]
15.6 SCV Requirements
15.7 PowerShift? Transmission Requirements
15.8 AutoTrac? Guidance Requirements
15.9 Rear Hitch Requirements [Ag]
15.10 Drive Strategy Requirements
16 Drivetrain
16.1 Drivetrain Overview
16.2 Differential Lock
16.3 Change Differential Lock Disengagement Steering Angle
16.4 Operate HydraCushion? Front Axle Suspension
16.5 Drivetrain Protection
17 Brakes
17.1 Brake Use
17.2 Trailer Brakes Regulation (EAEU-compliant Tractors Only)
17.3 Hydraulic Trailer Brakes (If Equipped)
17.4 Trailer Brake System Settings?Access
17.5 Trailer Brake System Settings
17.6 Trailer Brake System Settings?Brake Gain
17.7 Trailer Brake System Settings?Pre-Brake Offset
17.8 Trailer Brake System Settings?Trailer Brake Test
17.9 Trailer Brake System Settings?Advanced
17.10 Use Secondary Brake Lever
18 Transmission?General Information
18.1 Warm-Up Transmission-Hydraulic System
18.2 Backup Alarm
18.3 Access Transmission Advanced Settings
18.4 Transmission Advanced Settings
19 e18? PowerShift? Transmission
19.1 Operate Transmission?e18?
19.2 Shift Transmission?e18?
19.3 e18? Set Speeds and Efficiency Manager?
19.4 e18? Transmission Settings?Access
19.5 e18? Transmission Settings
19.6 e18? Transmission Settings?Mode
19.7 e18? Transmission Settings?Custom
19.8 e18? Transmission Settings?Droop
19.9 e18? Transmission Settings?ECO
19.10 e18? Transmission Settings?Max Speeds
20 PTO [Ag], Hitch [Ag], and Drawbar
20.1 Scraper Tractor Drawbar [Scraper]
20.2 Attach PTO-Driven Implement [Ag]
21 PTO – General Information [Ag]
21.1 PTO Settings?Access
21.2 PTO Settings
21.3 PTO Settings?Advanced
21.4 PTO Settings?Engagement Rate
21.5 PTO Settings?Rear PTO Cruise
21.6 PTO Settings?Auto Disengage
21.7 Operate PTOs
21.8 External PTO Switches (If Equipped)
22 Rear PTO [Ag]
22.1 Operating Instructions
22.2 Use PTO Master Shield (If Equipped)
22.3 PTO Engine Speed
23 Rear Hitch [Ag]
23.1 Hitch Lift Capacities
23.2 Rear Hitch Settings?Access
23.3 Rear Hitch Settings
23.4 Rear Hitch Settings?Upper Limit
23.5 Rear Hitch Settings?Drop Rate
23.6 Rear Hitch Settings?Raise Rate
23.7 Rear Hitch Settings?Load Depth
23.8 Rear Hitch Settings?Slip Sensitivity
23.9 Rear Hitch Settings?Position
23.10 Rear Hitch Settings?Position Control
23.11 Rear Hitch Settings?Draft Control
23.12 Hitch Control Lever Adjustments
23.13 Hitch Depth Set Point
23.14 Float Operation
23.15 Hitch Components
23.16 Hitch External Switches
23.17 Hitch Manual Lowering
23.18 Sway Blocks
23.19 Attaching Implement to Quick-Hitch
23.20 Adjusting Implement Level
23.21 Lateral Float
23.22 Detaching Implement From Quick-Hitch
23.23 Hitch Conversion?Category 4/4N/3 Convertible Quick-Hitch
23.24 Converting Category 4N/3 Convertible Quick-Hitch Lower Hooks
23.25 Converting Category 4N/3 Convertible Quick-Hitch Upper Hook
24 Drawbar [Ag]
24.1 Drawbar Load Limitations (Agricultural Tractors)
24.2 Scraper Applications
24.3 Calculate Static Vertical Drawbar Load
24.4 Calculate Vertical Drawbar Load Distance Behind Rear Axle
24.5 Category 4 Heavy-Duty Drawbar Reinforcement Kit Load Limitations
24.6 Category 5 Heavy-Duty Drawbar Support Load Limitations
24.7 Selecting Drawbar Position
24.8 Adjusting Drawbar Side-to-Side
24.9 Install Clevis Assembly?Category 4 Drawbar
24.10 Install Clevis Assembly?Category 4 Heavy-Duty Drawbar
24.11 Install Clevis Assembly?Category 5 Drawbar
24.12 Clevis Assembly Use
24.13 Use Correct Drawbar Pin?Category 5 to 4
25 Drawbar [Scraper]
25.1 Drawbar Load Limitations (Scraper Tractors)
25.2 Scraper Applications
25.3 Calculate Static Vertical Drawbar Load
25.4 Calculate Vertical Drawbar Load Distance Behind Rear Axle
25.5 Install Drawbar or Quick-Attach in Short Drawbar Support
25.6 Short Scraper Drawbar Conversion
25.7 Long Drawbar Support Load Limitations
25.8 Tow Cable
26 Hydraulics – General Information
26.1 Hydraulic System Overview
27 Selective Control Valves
27.1 SCV Settings?Access
27.2 SCV Settings
27.3 SCV Settings?Standard Mode
27.4 SCV Settings?Independent Mode
27.5 SCV Settings?Feature Mode
27.6 SCV Settings?Flow Adjustment
27.7 SCV Settings?Time Adjustment
27.8 SCV Settings?Advanced
27.9 SCV Settings?Activating Independent Mode
27.10 SCV Settings?Automation
27.11 SCV Settings?Assignment
27.12 SCV Settings?Flow Adjustment Sensitivity
27.13 SCV Control Lever Adjustments
27.14 Total SCV Flow
27.15 Flow Sharing
27.16 Operate SCVs with CommandARM? Joystick
27.17 CommandARM? Joystick?Layout and Joystick Lever Functions
28 Hydraulic Connections
28.1 Connect/Disconnect Hydraulic Hoses
28.2 Implements Requiring Large Volumes of Hydraulic Oil
28.3 Using Load-Sensing Hydraulic System?Power-Beyond
28.4 Component Identification and Location [Ag]
28.5 Using Hydraulic Spray Pumps [Ag]
28.6 Implement Connection Example [Ag]: Closed Center Valve and Pump at High Pressure?Less Hitch
28.7 Implement Connection Example [Ag]: Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip
28.8 Implement Connection Example [Ag]: Planter with Vacuum Motor and Return Line to Motor Return?With Hitch and Implement Lift Assist
28.9 Implement Connection Example [Ag]: Pressure Control Valve Applications?Less Hitch (Grain Drills or Air Seeders with Constant Down-Pressure System)
28.10 Implement Connection Example?High-Flow Hydraulics [Ag]: Implement Control Valves?Less Hitch
28.11 Component Identification and Location [Scraper]
28.12 Scraper Hydraulic Hose Tips [Scraper]
28.13 Implement Connection Example [Scraper]: Pulling 1, 2, and 3 Scrapers
29 TouchSet? Depth Control
29.1 TouchSet? Depth Control Settings and Adjustments
29.2 Connect/Disconnect the Implement Position Connector
30 Laser Scraper Control [Ag]
30.1 Laser Scraper?for Scrapers Equipped with Scraper Control Unit
31 Scraper Information [Scraper]
31.1 Scraper Operation Cycle
31.2 Weight Transfer Limits
31.3 Scraper/Tractor Attachment
31.4 Loading Techniques
31.5 Connect AutoLoad? Harness
31.6 AutoLoad? Displays
31.7 Scraper Control Panel Reference
31.8 AutoLoad? Settings – Setting Auto Dimensions
31.9 Using AutoLoad?
31.10 Set Scraper ?Transport? Height
31.11 Set Scraper ?Ready? (Dump) Height
31.12 Set Scraper Ground ?Loading? Entering the Cut Height
31.13 AutoLoad? Operation
31.14 AutoLoad? Set Up Wizard
32 Wheels and Tires – General Information
32.1 Tire Group Sizes
32.2 Change Tire Size
32.3 Using Correct Tire Combinations
32.4 Tire Load Index
32.5 Tire Sidewall Information
32.6 Tire Inflation Pressure Guidelines
33 Wheels and Tires
33.1 Using Dual Tires
33.2 Observe Tread Width Limitations
33.3 Tread Widths
33.4 Triple Wheels [Ag]
33.5 Triple Wheels (Heavy Duty Wheel Hubs)
33.6 Install Wheel Rim to Cast Wheel
33.7 Use Wheel Tightening Stand
33.8 Wheel Weight Holding Wrench?JDG10958
33.9 Use Wheel Torque Wrench Adapter
33.10 Adjust and Tighten?Standard Drive Wheel and Standard Dual Hubs [Ag]
33.11 Adjust and Tighten?Drive (Inner) Wheel Hubs
33.12 Adjust and Tighten?Dual Wheel Hubs
33.13 Install 76×50.00 B-32 Flotation Wheel and Tire Assembly [Scraper]
33.14 Recommended Inflation Pressures?Group 47
33.15 Recommended Inflation Pressures?Group 48
33.16 Recommended Inflation Pressures?Flotation Logger [Scraper]
34 Steering Stop and Tread Settings
34.1 Using Steering Stops
35 Operator?s Station – General Information
35.1 Avoid Contact with Agricultural Chemicals
35.2 Clean Vehicle of Hazardous Pesticides
35.3 Keep Riders Off Machine
35.4 Keep Operator Station Window and Door Closed
35.5 Use Seat Belts
35.6 Use Emergency Exit
35.7 Monitor Bracket Mounts
36 Seat
36.1 Adjust ComfortCommand? Seat
36.2 Adjust Heated Leather Seat
36.3 Adjust ActiveSeat?
36.4 Adjust CommandARM? Position
36.5 Operator Presence Sensor (If Equipped)
36.6 Adjust Instructional Seat
37 Steering Column
37.1 Adjust Steering Wheel and Column
37.2 Operate Horn
38 Mirrors
38.1 Manual Mirror
38.2 Electric Mirror
38.3 Telescoping Heated Electric Mirror
39 Wiper Washer
39.1 Operate Front Windshield Wiper and Washer
39.2 Operate Rear Wiper and Washer
39.3 Operate Right-Hand Wiper and Washer
40 Lights
40.1 Light Identification (Version A)
40.2 Light Identification (Version B)
40.3 Configurable Lights
40.4 Steering Column Light Controls (Version A)
40.5 Steering Column Light Controls (Version B)
40.6 Exit Lights
40.7 Operate Turn Signals and High/Low Beam
40.8 Safety Lights and Devices
40.9 CommandARM? Light Buttons
40.10 Hazard Lights and Extremity Warning Lights
40.11 Trailering Lights
40.12 Rotary Beacon Light
40.13 7-Pin Outlet (Equipped with Version A Lighting)
40.14 7-Pin Outlet (Equipped with Version B Lighting)
41 Accessories
41.1 Pull-Down Sunshade
41.2 Install Business Band or Citizens Band (CB) Radio and Antenna
41.3 Auxiliary Power Strip Use
41.4 Accessory Electrical Outlet Use
41.5 Mount StarFire? Receiver
41.6 Connect Compatible Electronic Equipment
41.7 Configure Tractor for GPS or Radar
41.8 Refrigerator or Storage Space
41.9 Implement Connector
41.10 AutoLoad? Harness Connector [Scraper]
42 HVAC
42.1 HVAC Settings?Access
42.2 HVAC Settings
42.3 HVAC Settings?Climate Control Automation
42.4 HVAC Settings?Set Temperature
42.5 HVAC Settings?Air Flow Mode
42.6 HVAC Settings?Fan Speed
42.7 HVAC Settings?Air Conditioning
43 Performance Ballasting [Ag]
43.1 General Performance Guidelines
43.2 Determining Maximum Ballast
43.3 Ballasting for Engine Horsepower
43.4 Control Power Hop
43.5 Calculating Ballast
43.6 Rear Wheel Weight Use
43.7 Front Weight Frame
43.8 Rear Weight Frame
43.9 Implement Guidelines
43.10 Measuring Wheel Slip (Manually)
43.11 Using Liquid Ballast
43.12 Worksheet to Calculate Ballast Changes
43.13 Unballasted Tractor Weight Chart (9370R)
43.14 Unballasted Tractor Weight Chart (9420R, 9470R, and 9520R)
43.15 Unballasted Tractor Weight Chart (9570R and 9620R)
44 Performance Ballasting [Scraper]
44.1 General Performance Guidelines
44.2 Determining Maximum Ballast
44.3 Ballasting for Engine Horsepower
44.4 Controlling Power Hop
44.5 Calculating Ballast?Without Dolly on Drawbar Hitch
44.6 Calculating Ballast?With Dolly – Wheel Scrapers or Drawn Tillage Implements
44.7 Recommended Ballast?Dual Radial Tires
44.8 Scraper Ballast Package with Duals
44.9 Recommended Ballast?76×50.00B32 and Logger Tires-Singles
44.10 Recommended Ballast?Scraper/Ag Combination Tractor With Radial Tires
44.11 Using Cast Hub Wheel Weights
44.12 Front Weight Frame
44.13 Implement and Scraper Size Guidelines
44.14 Measure Wheel Slip?Manually
44.15 Using Liquid Ballast
44.16 Worksheet to Calculate Ballast Changes
44.17 Unballasted Tractor Weight Chart (9470R and 9520R)
44.18 Unballasted Tractor Weight Chart (9570R and 9620R)
45 Transport
45.1 Driving Tractor on Roads
45.2 Towed Mass
45.3 Towed Loads and Transport with Ballast
45.4 Use Safety Lights and Devices
45.5 Transport Rear Mounted Implements with Ballast
45.6 Safety Chain Use
45.7 Carrier Transport
45.8 Tie Down on Transport Carrier
45.9 Tow Mode?Engine Will Start
45.10 Tow Mode?Engine Will Not Start
45.11 Freeing a Mired Tractor
46 Fuel, Lubricants, and Coolant – General Information
46.1 Determine Tractor Engine Type
46.2 Minimizing the Effect of Cold Weather on Diesel Engines
46.3 Oil Filters
47 Fuel
47.1 Diesel Fuel
47.2 Supplemental Diesel Fuel Additives
47.3 Biodiesel Fuel
47.4 Lubricity of Diesel Fuel
47.5 Handling and Storing Diesel Fuel
47.6 Avoid Static Electricity Risk When Refueling
47.7 Fill Fuel Tank
47.8 Testing Diesel Fuel
47.9 Fuel Filters
48 Diesel Exhaust Fluid (DEF)
48.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
48.2 Storing Diesel Exhaust Fluid (DEF)
48.3 Refilling Diesel Exhaust Fluid (DEF) Tank
48.4 Fill DEF Tank – FT4/Stage V Engine
48.5 Testing Diesel Exhaust Fluid (DEF)
48.6 Disposal of Diesel Exhaust Fluid (DEF)
49 Engine Oil
49.1 Diesel Engine Oil Service Interval for Operation at High Altitude
49.2 John Deere Break-In Plus? Engine Oil ? Final Tier 4/Stage V 9.0 L [Ag] and 13.5 L Engine
49.3 Break-In Engine Oil Use ? Final Tier 4/Stage V 15 L Engines
49.4 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
49.5 Engine Oil and Filter Service Intervals ? Final Tier 4/Stage V – 9.0 L [Ag] and 13.5 L Engines
49.6 Engine Oil and Filter Service Intervals
49.7 Diesel Engine Oil ? Tier 2 and Stage II
49.8 Engine Oil and Filter Service Intervals ? Tier 2 and Stage II Engines
49.9 Diesel Engine Oil ? Tier 3 and Stage IIIA
49.10 Engine Oil and Filter Service Intervals ? Tier 3 and Stage III A ? PowerTech? Plus Engines
50 Engine Coolant
50.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
50.2 John Deere COOL-GARD? II Coolant Extender
50.3 Operating in Warm Temperature Climates
50.4 Water Quality for Mixing with Coolant Concentrate
50.5 Testing Coolant Freeze Point
50.6 Disposing of Coolant
51 Other Lubricants
51.1 Transmission and Hydraulic Oil
51.2 Multipurpose Extreme Pressure (EP) Grease
51.3 Lubricant Storage
51.4 Mixing of Lubricants
51.5 Alternative and Synthetic Lubricants
52 Service – General Information
52.1 Service Sections Overview
52.2 Service Tasks Performed As Required
52.3 Identify Tractor Engine Emissions Status
52.4 Single or Double Reduction Axle Identification
52.5 Open Hood
52.6 Open Hood (If Equipped)
52.7 Remove Engine Access Panel
52.8 Remove Front Engine Side Shield
52.9 Remove Rear Engine Side Shield
52.10 Jack Up Tractor – Lifting Points and Support Stand Placement
52.11 Service and Connect STC? (Snap-to-Connect) Fittings
52.12 High-Pressure Washer Use
52.13 Transmission Calibration
52.14 Abort Transmission Calibration
52.15 Do Not Modify Fuel System
52.16 Bleed Fuel System
52.17 Identify Zinc-Flake Coated Fasteners
52.18 Metric Bolt and Screw Torque Values
52.19 Unified Inch Bolt and Screw Torque Values
53 Break-In Service (100 Hours or Less)
53.1 Perform Break-In Services
54 Service – Record Charts
54.1 Service Record Chart Overview
54.2 Service Interval Chart
54.3 Service Record Chart
55 Service – Clean
55.1 Cleaning Diesel Exhaust Fluid (DEF) Tank
55.2 DEF Tank Filler Neck Filter
55.3 Tractor Exterior
55.4 Clean Display
55.5 Engine Cooling System?9.0 or 13.5 L Engine
55.6 Engine Cooling System?15 L Engine
55.7 Dual Beam Radar Sensor
55.8 Aftertreatment Fuel Injector?15 L Engine
55.9 Optional Fuel Water Separator?13.5 L Engine
55.10 Implement Connector
56 Service – Check
56.1 Vari-Cool? Fan Drive and Belt?9.0 L Final Tier 4/Stage V Engine
56.2 Vari-Cool? Fan Drive and Belt?13.5L Final Tier 4/Stage V Engine
56.3 Engine Coolant Level
56.4 Water Separator?15 L Engine
56.5 Engine and Exhaust Compartments
56.6 Outer Exhaust Screens
56.7 Air Conditioning System
56.8 Engine Water Pump Weep Hole?9.0 L Engine
56.9 Engine Water Pump Weep Hole?13.5 L Engine
56.10 Fuel Tank Sump
56.11 Engine Water Pump Seal?15 L Engine
56.12 Engine Oil Level?9.0 L Engine
56.13 Engine Oil Level?13.5 L Engine
56.14 Engine Oil Level?15 L Engine
56.15 Transmission-Hydraulic Oil Level
56.16 Tires
56.17 Secondary Brake
56.18 NEUTRAL Start System
56.19 Transmission PARK System
56.20 Engine Air Intake System?9.0 L Final Tier 4/Stage V Engine
56.21 Engine Air Intake System?9.0 L Tier II/Stage II
56.22 Engine Air Intake System?13.5 L Final Tier 4/Stage V Engine
56.23 Engine Air Intake System?13.5 L Tier 2/Stage II or Tier 3/Stage IIIA Engines
56.24 Engine Air Intake System?15 L Engine
56.25 Engine Coolant Freeze Point
56.26 Seat Belts
56.27 HydraCushion? Suspended Front Axle Accumulator Charge Pressure
56.28 Engine Auxiliary Drive Belt and Drive Belt Tensioner
56.29 Axle End Play
56.30 Engine Valve Clearance
56.31 Front Driveshaft Health (FDH) Sensor System
56.32 Drawbar Sensor Calibration
56.33 Drawbar Wear
57 Service – Tighten
57.1 Wheel and Wheel Weight Bolts
57.2 Use Wheel Tightening Stand
57.3 Use Wheel Torque Wrench Adapter
57.4 Drawbar Support and Cap Screws
58 Service – Change
58.1 Fan Belt?9.0 and 13.5 Tier 2/Stage II or Tier 3/Stage IIIA Engines
58.2 Vari-Cool? Fan Belt?9.0 L Final Tier 4/Stage V Engine
58.3 Vari-Cool? Fan Belt?13.5 L Final Tier 4/Stage V Engine
58.4 Vari-Cool? Fan Drive Bushings, Seals, and Wear Pads?9.0 L Final Tier 4/Stage V Engine
58.5 Vari-Cool? Fan Drive Bushings and Seals?13.5L Final Tier 4/Stage V Engine
58.6 Vari-Cool? Fan Drive Bearing and Retaining Capscrew?13.5L Final Tier 4/Stage V Engine
58.7 Engine Auxiliary Drive Belt?9.0 L or 13.5 L Engine
58.8 Engine Auxiliary Drive Belt?15 L Engine
58.9 Engine Water Pump Drive Belt?15 L Engine
58.10 Engine Oil and Filter?9.0 L Engine
58.11 Engine Oil and Filter?13.5 L Engine
58.12 Engine Oil and Filter?15 L Engine
58.13 Fuel Filters?9.0 L Engine
58.14 Fuel Filters?13.5 L Engine
58.15 Fuel Filters?15 L Engine
58.16 Optional Fuel Water Separator Filter Element?13.5 L Engine
58.17 Cab Recirculation Air Filter
58.18 Cab Fresh Air Filter
58.19 Engine Primary and Secondary Air Filters?Tier 2/Stage II or Tier 3/Stage IIIA Engine
58.20 Engine Primary and Secondary Air Filters?Final Tier 4/Stage V Engine
58.21 Fuel Tank Vent Filters
58.22 SCV Pilot Valve Filter
58.23 DEF Tank Vent Filter
58.24 Access Diesel Exhaust Fluid (DEF) In-Line Filter
58.25 Change Diesel Exhaust Fluid (DEF) In-Line Filter
58.26 Transmission-Hydraulic Oil and Filters
58.27 Engine Cooling System Radiator Cap?15 L Engine
58.28 Transmission-Hydraulic Vent Filter
58.29 Access Diesel Exhaust Fluid (DEF) Dosing Unit Filter
58.30 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
58.31 Transmission Drive Shaft Damper
58.32 Engine Coolant?9.0L Engine
58.33 Engine Coolant?13.5 L Engine
58.34 Engine Coolant?15 L Engine
58.35 Engine Crankshaft Damper?9.0 L or 13.5 L Engine
58.36 Engine Crankcase Breather Filter Element?15 L Engine
58.37 Front Drive Shaft U-Joints
59 Service – Lubricate
59.1 Heavy Duty Lift Link Pins (Optional)
59.2 Hinge Pins
59.3 Steering Pins
59.4 Telescoping Drive Shaft
59.5 PTO Drive Shaft
59.6 Heavy-Duty Gudgeon Bearings
59.7 Lower Drive Line Bearings
59.8 Rear Hitch
59.9 Lift Cylinders and Rockshaft
59.10 Vari-Cool? Fan Drive?9.0 L Final Tier 4/Stage V Engine
59.11 Vari-Cool? Fan Drive?13.5 L Final Tier 4/Stage V Engine
59.12 HydraCushion? Front Axle Suspension
59.13 Rear Hitch Draft Sensor?9370R Tractor
60 Service – Electrical
60.1 Service – Electrical Overview
60.2 Welding Near Electronic Control Units
60.3 Keep Electronic Control Unit Connectors Clean
60.4 Compressed Air Use
60.5 High-Pressure Washer Use
60.6 Disconnect Battery
60.7 Handling Batteries Safely
60.8 Service Batteries and Connections
60.9 Access Load Center Fuses
60.10 Access Master Fuses
60.11 Access Implement Power Relay Module Fuses
60.12 Handle Halogen Light Bulbs Safely
60.13 Change Front HID/LED Light Assembly
60.14 Change Front Grille Halogen Light Bulbs
60.15 Adjust Front Grille Lights
60.16 Adjust Headlights
60.17 Change Front, Side And Rear Cab Roof Light Bulb
60.18 Change Brake or Turn Signal Light Bulb
60.19 Change Dome Light Bulb
60.20 Change Extremity Warning Light Bulb
60.21 Change Trailering Light Bulb
61 Troubleshooting – Procedures
61.1 Engine
61.2 Transmission-Hydraulic-Axles
61.3 Hydraulic System
61.4 Brakes
61.5 Hitch
61.6 Selective Control Valve (SCV)
61.7 Electrical System
61.8 Operator Enclosure
62 Troubleshooting – Diagnostic Trouble Codes (DTC)
62.1 STOP, Service, and Information Alerts on CommandCenter?
62.2 Access Diagnostic Trouble Codes
63 Service – Storage
63.1 Place Tractor in Storage
63.2 Remove Tractor from Storage
64 Specifications
64.1 Engine: John Deere
64.2 Engine: QSX15 Cummins?
64.3 Capacities
64.4 Hydraulics
64.5 Transmission and Power Train
64.6 PTO [Ag], Hitch [Ag], and Drawbar
64.7 Electrical
64.8 Integrated Technology
64.9 Overall Dimensions
64.10 Loads and Weights
64.11 Sound Level
64.12 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer)
64.13 Ground Speeds?e18? PowerShift? Transmission
64.14 Limited Battery Warranty
64.15 Eurasian Economic Union
64.16 Machine Design Life
64.17 Required Emission-Related Information
64.18 Carbon Dioxide Emissions (CO?)
65 Identification Numbers
65.1 Identification Plates
65.2 Product Identification Number
65.3 Product Identification Number (China Only)
65.4 Engine Serial Number
65.5 Cab Serial Number
65.6 Transmission Serial Number
65.7 PTO Dropbox Serial Number [Ag]
65.8 PTO Clutch Serial Number [Ag]
65.9 Keep Proof of Ownership
65.10 Keep Machines Secure
66 Change of Ownership
66.1 Subsequent Ownership
67 Predelivery
67.1 Predelivery Checklist
67.2 Delivery Checklist and Certificate
68 Index
69 John Deere Service Literature Available
69.1 Technical Information
70 John Deere Service Keeps You On The Job
70.1 John Deere Parts
70.2 The Right Tools
70.3 Well-Trained Technicians
70.4 Prompt Service
