John Deere 9r Tractors Operator Manuals OMRE595630

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Look For Supplemental Information
1.4 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Fire Prevention
3.9 In Case of Fire
3.10 Avoid Static Electricity Risk When Refueling
3.11 Use Foldable ROPS and Seat Belt Properly
3.12 Stay Clear of Rotating Drivelines
3.13 Use Steps and Handholds Correctly
3.14 Read Operator?s Manuals for ISOBUS Controllers
3.15 Use Seat Belt Properly
3.16 Vibration
3.17 Operating the Tractor Safely
3.18 Avoid Backover Accidents
3.19 Limited Use in Forestry Operation
3.20 Operating the Loader Tractor Safely
3.21 Keep Riders Off Machine
3.22 Passenger Seat
3.23 Use Safety Lights and Devices
3.24 Towing Trailers/Implements Safely
3.25 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.26 Freeing a Mired Machine
3.27 Avoid Contact with Agricultural Chemicals
3.28 Handle Agricultural Chemicals Safely
3.29 Handling Batteries Safely
3.30 Avoid Heating Near Pressurized Fluid Lines
3.31 Remove Paint Before Welding or Heating
3.32 Handle Electronic Components and Brackets Safely
3.33 Practice Safe Maintenance
3.34 Avoid Hot Exhaust
3.35 Clean Exhaust Filter Safely
3.36 Work In Ventilated Area
3.37 Support Machine Properly
3.38 Prevent Machine Runaway
3.39 Park Machine Safely
3.40 Transport Tractor Safely
3.41 Service Cooling System Safely
3.42 Service Accumulator Systems Safely
3.43 Service Tires Safely
3.44 Service Front-Wheel Drive Tractor Safely
3.45 Tightening Wheel Retaining Bolts/Nuts
3.46 Avoid High-Pressure Fluids
3.47 Do Not Open High-Pressure Fuel System
3.48 Store Attachments Safely
3.49 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Passenger Seat
4.4 Hinge Area
4.5 HydraCushion? Suspension Accumulators (If Equipped)
4.6 Rear Hitch Remote Switch (If Equipped) [Ag] 4.7 Rear SCVs
4.8 Park Brake (Stored Energy)
5 Vehicle Overview
5.1 9R Series Tractor
6 Engine Operation
6.1 Required Machine Stop Warning
6.2 Engine Fuel System and Power Rating
6.3 Battery Disconnect Switch
6.4 Start the Engine
6.5 Theft Deterrent Systems
6.6 Run the Engine
6.7 Stop the Engine
6.8 Restart Engine That Has Run Out of Fuel
6.9 Reduce Fuel Consumption
6.10 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?With Starting Aid
7.2 Cold Weather Starting And Operation?Internal Starting Aid
7.3 Change Starting Fluid Canister
7.4 Engine Coolant Heater Use?9.0 L Engine [Ag] 7.5 Engine Coolant Heater Use?13.5 L or 15 L Engines
8 Emissions Equipment
8.1 Exhaust Filter System Overview?Final Tier 4/Stage V Engine
8.2 Aftertreatment Indicators Overview
8.3 Selective Catalytic Reduction (SCR) System Overview
8.4 Auto Exhaust Filter Cleaning Mode?Final Tier 4/Stage V Engine
8.5 Parked Exhaust Filter Cleaning?Final Tier 4/Stage V Engine
8.6 Selective Catalytic Reduction (SCR) System?Final Tier 4/Stage V Engine
8.7 Low Fuel or Low DEF Warning
8.8 Disconnect Battery?Final Tier 4/Stage V Engine
8.9 Restored Operation Option
9 Controls and Instruments
9.1 Front Console
9.2 CommandARM? ISOBUS Shortcut Button (ISB)
9.3 Foot Decelerator
10 Corner Post Display
10.1 Corner Post Display
10.2 Information Indicators
10.3 Warning Indicators
10.4 Digital Indicators?Tachometer, Ground Speed, and Transmission
10.5 Gauges?Coolant Temperature, DEF Level, and Fuel Level
11 CommandARM? Controls
11.1 CommandARM? with Generation 4 CommandCenter? Display
11.2 CommandARM? Secondary Brake Lever
11.3 CommandARM? Hitch Controls [Ag] 11.4 CommandARM? SCV Control Levers
11.5 CommandARM? Climate, Radio and Lighting Controls
11.6 CommandARM? PTO Control Lever [Ag] 11.7 CommandARM? Left-Hand Side Controls
12 CommandCenter?
12.1 Rear Hitch or PTO Availability
12.2 Onscreen Help
12.3 Generation 4 CommandCenter?
12.4 Generation 4 CommandCenter? Processor
12.5 Generation 4 CommandCenter? 4600 Processor Wi-Fi? Capabilities
12.6 Run Page Structure
12.7 Menu
12.8 Machine Settings Overview
12.9 Operating System Applications Overview
12.10 AMS Applications Overview
12.11 CommandCenter? Activations
12.12 Demo Activations
12.13 Automation Status Overview
12.14 Navigate Generation 4 CommandCenter?
12.15 Power Display On and Off
12.16 Navigate Run Pages on Main Page
12.17 Shortcut Buttons
12.18 Display and Sound
12.19 Brightness
12.20 Sound
12.21 Multiple Displays
12.22 Display Calibration
12.23 Date and Time
12.24 Change Current Date
12.25 Change Current Time
12.26 Language and Units
12.27 Language and Units Settings
12.28 Change Pages and Values
12.29 Status Center
12.30 Shortcut Softkeys
12.31 Software Manager
12.32 Factory and Service ADVISOR? Installed Onscreen Help
12.33 Update Display Software
12.34 Activations
12.35 Service ADVISOR? Remote
12.36 Vehicle Reprogramming
12.37 Troubleshooting ? Reprogramming
12.38 System Recovery
12.39 Remote Display Access
12.40 File Manager
12.41 USB Drive
12.42 Capture Screen Shots
12.43 Diagnostics Center
12.44 Controller Diagnostics
12.45 Diagnostic Information
12.46 Hide Diagnostic Center
12.47 Diagnostic Trouble Codes
12.48 Display Hardware
12.49 CAN Bus Information
12.50 CAN Bus Values
12.51 Network
12.52 DataSync
12.53 Users and Access
12.54 User Profiles
12.55 Access Groups
12.56 Layout Manager
12.57 Active Set
12.58 Shortcut Bar
12.59 All Run Pages
12.60 Add, Edit, or Duplicate Run Pages
12.61 Fields and Boundaries
12.62 Field Boundaries
12.63 Manage Clients, Farms, and Fields
12.64 AutoTrac? Guidance
12.65 Equipment Manager
12.66 Machine Profile
12.67 Implement Profile
12.68 Machine Monitor
12.69 Work Monitor
12.70 Work Recording
12.71 Maintenance and Calibrations
12.72 Calibrations
12.73 Radar Calibration
12.74 Slip Calibration
12.75 Service Intervals
12.76 Steering
12.77 Steering Settings
12.78 Controls Setup
12.79 Settings Manager
12.80 Automation Status
12.81 ISOBUS VT
12.82 StarFire? GPS Receiver
12.83 Install Video Display Camera
12.84 Video
12.85 Video Triggers
13 CommandCenter? – Radio
13.1 External Sources
13.2 Select Radio Source with Generation 4 CommandCenter?
13.3 FM, MW, LW Home Page
13.4 Premium Radio USB Home Page
13.5 Premium Radio Bluetooth? Home Page
13.6 Auxiliary Home Page
13.7 Pair Bluetooth? Device to Generation 4 CommandCenter?
13.8 Manage Paired Bluetooth? Devices
13.9 Phone Operation
13.10 Contact List
13.11 Recent Calls
13.12 Clear Favorites and Call History
14 Intelligent Total Equipment Control (iTEC?)
14.1 CommandARM? Control Functions
14.2 iTEC? Station Description (Eu 1322/2014)
14.3 CommandCenter? Pages Descriptions and Functions
14.4 Status Area
14.5 All Sequence Page
14.6 Add New Sequence
14.7 Sequence Step Status
14.8 Edit or Remove Sequence
14.9 Sequence Sets Page
14.10 Perform Sequence
14.11 Recommendations (AutoLearn)
14.12 iTEC? Functions?Efficiency Manager?
15 Tractor-Implement Automation? (TIA?)
15.1 Tractor-Implement Automation? (TIA?)
15.2 Activate Tractor-Implement Automation? Equipment
15.3 Tractor-Implement Automation? ? Status Page
15.4 Operate Tractor-Implement Automation?
15.5 PTO Requirements [Ag] 15.6 SCV Requirements
15.7 Powershift Transmission Requirements
15.8 AutoTrac? Guidance Requirements
15.9 Rear Hitch Requirements [Ag] 15.10 Drive Strategy Requirements
16 Drivetrain
16.1 Drivetrain Overview
16.2 Differential Lock
16.3 Change Differential Lock Disengagement Steering Angle
16.4 Operate HydraCushion? Front Axle Suspension
16.5 Drivetrain Protection
17 Brakes
17.1 Brake Use
17.2 Hydraulic Trailer Brakes (If Equipped)
17.3 Trailer Brake Settings
17.4 Engine Brake ? 15 L Engine (If Equipped)
17.5 Use Secondary Brake Lever
17.6 Foot Decelerator
18 Transmission – General Information
18.1 Warm-Up Transmission-Hydraulic System
18.2 Activate and Set Maximum Set Speed
18.3 Use Maximum Set Speed with Different Transmission Modes
18.4 Back Up Alarm
18.5 Back Up Alarm Setting
19 e18? Powershift Transmission
19.1 Operate the e18? Powershift Transmission
19.2 Shift e18? Transmission
19.3 Avoid Tractor Overspeed
19.4 Set Start Gears
19.5 CommandCenter? Transmission Main Page
19.6 Efficiency Manager? on the e18? Transmission
19.7 Efficiency Manager? on e18? Transmission in Manual Mode
19.8 e18? Custom Mode Settings
20 PTO [Ag], Hitch [Ag], and Drawbar
20.1 Scraper Tractor Drawbar [Scraper] 20.2 Attach PTO-Driven Implement [Ag] 21 PTO – General Information [Ag] 21.1 Stay Clear of Rotating Drivelines
21.2 PTO Settings?Access
21.3 PTO Settings
21.4 PTO Settings?Advanced
21.5 PTO Settings?Engagement Rate
21.6 PTO Settings?Rear PTO Cruise
21.7 PTO Settings?Auto Disengage
21.8 Operate PTOs
21.9 External PTO Switches (If Equipped)
22 Rear PTO [Ag] 22.1 Operating Instructions (EU 1322/2014)
22.2 Use PTO Master Shield (If Equipped)
22.3 PTO Engine Speed
23 Rear Hitch [Ag] 23.1 Hitch Capacities (EU 1322/2014)
23.2 Rear Hitch Settings?Access
23.3 Rear Hitch Settings
23.4 Rear Hitch Settings?Upper Limit
23.5 Rear Hitch Settings?Drop Rate
23.6 Rear Hitch Settings?Raise Rate
23.7 Rear Hitch Settings?Load Depth
23.8 Rear Hitch Settings?Slip Sensitivity
23.9 Rear Hitch Settings?Position
23.10 Rear Hitch Settings?Position Control
23.11 Rear Hitch Settings?Draft Control
23.12 Hitch Control Lever Adjustments
23.13 Hitch Depth Set Point
23.14 Float Operation
23.15 Hitch Components
23.16 Hitch External Switches
23.17 Hitch Manual Lowering
23.18 Sway Blocks
23.19 Attaching Implement to Quick-Hitch
23.20 Adjusting Implement Level
23.21 Lateral Float
23.22 Detaching Implement From Quick-Hitch
23.23 Hitch Conversion?Category 4/4N/3 Convertible Quick-Hitch
23.24 Converting Category 4N/3 Convertible Quick-Hitch Lower Hooks
23.25 Converting Category 4N/3 Convertible Quick-Hitch Upper Hook
24 Drawbar [Ag] 24.1 Drawbar Load Limitations
24.2 Non-John Deere Scrapers Drawbar Load Limits
24.3 Category 4 Heavy Duty Drawbar Reinforcement Kit Load Limitations
24.4 Category 5 Heavy Duty Drawbar Support Load Limitations
24.5 Selecting Drawbar Position
24.6 Adjusting Drawbar Side-to-Side
24.7 Install Clevis Assembly ? Category 4 Drawbar
24.8 Clevis Assembly Use ? Category 4 Drawbar
24.9 Install Clevis Assembly ? Category 5 Drawbar
24.10 Clevis Assembly Use ? Category 5 Drawbar
24.11 Use Correct Drawbar Pin ? Category 5 to 4
25 Drawbar [Scraper] 25.1 Install Drawbar or Quick-Attach in Short Drawbar Support
25.2 Short Scraper Drawbar Conversion
25.3 Long Drawbar Support Load Limitations
25.4 Tow Cable
26 Hydraulics – General Information
26.1 Hydraulic System Overview
27 Selective Control Valves
27.1 Configure SCV Modes
27.2 Configure SCV – Standard Mode
27.3 Activate Independent Mode
27.4 Configure SCV – Independent Mode
27.5 Configure SCV – Feature Mode
27.6 Flow Sharing
27.7 Total Rear SCV Flow
27.8 Six-Position SCV Control Levers
27.9 SCV Control Lever?Neutral Position
27.10 SCV Control Lever?Extend and Retract Position
27.11 SCV Control Lever?Extend Detent and Retract Detent Position
27.12 SCV Control Lever?Float Position
27.13 Operator Presence Sensor
27.14 Operate SCVs with CommandARM? Joystick (If Equipped)
27.15 CommandARM? Joystick (If Equipped) – Custom Setup
27.16 CommandARM? Joystick (If Equipped) – Layout and Joystick Lever Functions
27.17 SCV Lever and Joystick Flow Response Setting
27.18 SCV Flow Sharing Setting
28 Hydraulic Connections
28.1 Connecting Hydraulic Hoses?Rear of Tractor
28.2 Disconnecting Hydraulic Hoses?Rear of Tractor
28.3 Standard Hydraulic Component Identification [AG] 28.4 High Flow Hydraulic Component Identification [AG] 28.5 High Flow Hydraulic Component Identification [Scraper] 28.6 Using Load-Sensing Hydraulic System?Power-Beyond
28.7 Examples Using Load-Sensing Hydraulic System?Power-Beyond
28.8 Using Hydraulic Spray Pumps [AG] 28.9 Implement Connection Example 1?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)?Less Hitch?Standard Hydraulics [AG] 28.10 Implement Connection Example 2?Motor Application Using Motor Case Drain?Less Hitch?Standard Hydraulics [AG] 28.11 Implement Connection Example 3?Closed Center Valve, Pump at High Pressure?Less Hitch?Standard Hydraulics [AG] 28.12 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip?Less Hitch?Standard Hydraulics [AG] 28.13 Implement Connection Example 5?Planter with Vacuum Motor and Return Line to Motor Return?With Hitch?With Lift Assist?Standard Hydraulics [AG] 28.14 Implement Connection Example 6?Planter with Vacuum Motor and Return Line to Motor Return?With Hitch?Implement Lift Assist?Standard Hydraulics [AG] 28.15 Connecting Implements to High Flow Hydraulic SCV’s [AG] 28.16 Connecting Implements to Air Seeder Special High-Flow Hydraulic SCVs [AG] 28.17 Implement Connection Example 1?Implement Control Valves?Less Hitch?High Flow Hydraulics [AG] 28.18 Implement Connection Example 2?Motor Application Using Motor Case Drain?Less Hitch?Standard Hydraulics [AG] 28.19 Implement Connection Example 3?Closed Center Valve, Pump at High Pressure?Less Hitch?High Flow Hydraulics [AG] 28.20 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip?With Hitch?High Flow Hydraulics [AG] 28.21 Scraper Connection Example: Pulling 1, 2, and 3 Scrapers [Scraper] 28.22 Implements Requiring Large Volumes of Oil
28.23 Scraper Hydraulic Hose Tips [Scraper] 29 TouchSet? Depth Control
29.1 Attaching Implement and Control System
29.2 Reset Implement Connector
29.3 Set TouchSet? Depth Controls
29.4 Use TouchSet? Depth Controls
30 Laser Scraper Control [Ag] 30.1 Laser Scraper?for Scrapers Equipped with Scraper Control Unit
31 Scraper Information [Scraper] 31.1 Scraper Operation Cycle
31.2 Weight Transfer Limits
31.3 Scraper/Tractor Attachment
31.4 Loading Techniques
31.5 Connect AutoLoad? Harness
31.6 AutoLoad? Displays
31.7 Scraper Control Panel Reference
31.8 AutoLoad? Settings – Setting Auto Dimensions
31.9 Using AutoLoad?
31.10 Set Scraper ?Transport? Height
31.11 Set Scraper ?Ready? (Dump) Height
31.12 Set Scraper Ground ?Loading? Entering the Cut Height
31.13 AutoLoad? Operation
31.14 AutoLoad? Set Up Wizard
32 Wheels and Tires – General Information
32.1 Service Tires Safely
32.2 Tire Group Sizes
32.3 Change Tire Size
32.4 Using Correct Tire Combinations
32.5 Tire Load Index
32.6 Tire Sidewall Information [TBD] 32.7 Tire Inflation Pressure Guidelines
33 Wheels and Tires
33.1 Observe Tread Width Limitations
33.2 Tread Widths
33.3 Using Dual Tires
33.4 Triple Wheels [Ag] 33.5 Triple Wheels (Heavy Duty Wheel Hubs)
33.6 Install Wheel Rim to Cast Wheel
33.7 Use Wheel Tightening Stand
33.8 Wheel Weight Holding Wrench?JDG10958
33.9 Use Wheel Torque Wrench Adapter
33.10 Adjust and Tighten?Standard Drive Wheel and Standard Dual Hubs [Ag] 33.11 Adjust and Tighten?Heavy-Duty Drive Wheels
33.12 Adjust and Tighten?Heavy-Duty Dual Wheel Hubs
33.13 Install 76×50.00 B-32 Flotation Wheel and Tire Assembly [Scraper] 33.14 Recommended Inflation Pressures?Group 47
33.15 Recommended Inflation Pressures?Group 48
33.16 Recommended Inflation Pressures?Flotation Logger [Scraper] 34 Steering Stop and Tread Settings
34.1 Using Steering Stops
35 Operator?s Station – General Information
35.1 Avoid Contact with Agricultural Chemicals
35.2 Clean Vehicle of Hazardous Pesticides
35.3 Keep Riders Off Machine
35.4 Keep Operator Station Window and Door Closed
35.5 Use Seat Belts
35.6 Use Emergency Exit
35.7 Monitor Bracket Mounts
36 Seat
36.1 Adjust ComfortCommand? Seat
36.2 Adjust Heated Leather Seat
36.3 Adjust ActiveSeat?
36.4 Adjust CommandARM? Position
36.5 Use Passenger Seat
36.6 Operator Presence Sensor (If Equipped)
37 Steering Column
37.1 Adjust Steering Wheel and Column
37.2 Operate Horn
38 Mirrors
38.1 Manual Mirror
38.2 Electric Mirror
38.3 Telescoping Heated Electric Mirror
39 Wiper Washer
39.1 Operate Front Windshield Wiper and Washer
39.2 Operate Rear Wiper and Washer
39.3 Operate Right-Hand Wiper and Washer
40 Lights
40.1 Light Identification
40.2 Configurable Lights
40.3 Steering Column Light Controls
40.4 Exit Lights
40.5 Operate Turn Signals and High/Low Beam
40.6 Safety Lights and Devices
40.7 CommandARM? Light Buttons
40.8 Hazard Lights and Extremity Warning Lights
40.9 Rotary Beacon Light
40.10 7-Pin Outlet
41 Accessories
41.1 Pull-Down Sunshade
41.2 Install Business Band or Citizens Band (CB) Radio and Antenna
41.3 Auxiliary Power Strip Use
41.4 Accessory Electrical Outlet Use
41.5 Mount StarFire? Receiver
41.6 Connect Compatible Electronic Equipment
41.7 Configure Tractor for GPS or Radar
41.8 Refrigerator or Storage Space
41.9 Implement Connector Use
41.10 Use AutoLoad? Harness Connector [Scraper] 42 HVAC
42.1 HVAC Settings?Access
42.2 HVAC Settings
42.3 HVAC Settings?Climate Control Automation
42.4 HVAC Settings?Set Temperature
42.5 HVAC Settings?Air Flow Mode
42.6 HVAC Settings?Fan Speed
42.7 HVAC Settings?Air Conditioning
43 Performance Ballasting [Ag] 43.1 General Performance Guidelines
43.2 Determining Maximum Ballast
43.3 Tire Sidewall Information [TBD] 43.4 Ballasting for Engine Horsepower
43.5 Control Power Hop
43.6 Calculating Ballast
43.7 Rear Wheel Weight Use
43.8 Front Weight Frame
43.9 Rear Weight Frame
43.10 Implement Guidelines
43.11 Measuring Wheel Slip (Manually)
43.12 Using Liquid Ballast
43.13 Worksheet to Calculate Ballast Changes
43.14 Unballasted Tractor Weight Chart (9370R and 9420R)
43.15 Unballasted Tractor Weight Chart (9470R and 9520R)
43.16 Unballasted Tractor Weight Chart (9570R and 9620R)
44 Performance Ballasting [Scraper] 44.1 General Performance Guidelines
44.2 Determining Maximum Ballast
44.3 Tire Sidewall Information [TBD] 44.4 Ballasting for Engine Horsepower
44.5 Controlling Power Hop
44.6 Calculating Ballast?Without Dolly on Drawbar Hitch
44.7 Calculating Ballast?With Dolly – Wheel Scrapers or Drawn Tillage Implements
44.8 Recommended Ballast?Dual Radial Tires
44.9 Scraper Ballast Package with Duals
44.10 Recommended Ballast?Scraper/Ag Combination Tractor With Radial Tires
44.11 Using Cast Hub Wheel Weights
44.12 Front Weight Frame
44.13 Implement and Scraper Size Guidelines
44.14 Measure Wheel Slip?Manually
44.15 Using Liquid Ballast
44.16 Worksheet to Calculate Ballast Changes
44.17 Unballasted Tractor Weight Chart (9470R and 9520R)
44.18 Unballasted Tractor Weight Chart (9570R and 9620R)
45 Transport
45.1 Driving Tractor on Roads
45.2 Towed Mass (EU 1322/2014)
45.3 Towed Loads and Transport with Ballast
45.4 Use Safety Lights and Devices
45.5 Transport Rear Mounted Implements with Ballast
45.6 Safety Chain Use
45.7 Carrier Transport
45.8 Tie Down on Transport Carrier
45.9 Tow Mode?Engine Will Start
45.10 Tow Mode?Engine Will Not Start
45.11 Come Home Mode
45.12 Freeing a Mired Tractor
46 Fuel, Lubricants, and Coolant – General Information
46.1 Determine Tractor Engine Type
46.2 Minimizing the Effect of Cold Weather on Diesel Engines
46.3 Oil Filters
47 Fuel
47.1 Diesel Fuel
47.2 Supplemental Diesel Fuel Additives
47.3 Biodiesel Fuel
47.4 Lubricity of Diesel Fuel
47.5 Handling and Storing Diesel Fuel
47.6 Avoid Static Electricity Risk When Refueling
47.7 Fill Fuel Tank
47.8 Testing Diesel Fuel
47.9 Fuel Filters
48 Diesel Exhaust Fluid (DEF)
48.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
48.2 Storing Diesel Exhaust Fluid (DEF)
48.3 Refilling Diesel Exhaust Fluid (DEF) Tank
48.4 Fill DEF Tank – FT4/Stage V Engine
48.5 Testing Diesel Exhaust Fluid (DEF)
48.6 Disposal of Diesel Exhaust Fluid (DEF)
49 Engine Oil
49.1 Diesel Engine Oil Service Interval for Operation at High Altitude
49.2 John Deere Break-In Plus? Engine Oil ? Final Tier 4/Stage V 9.0 L [Ag] and 13.5 L Engine
49.3 Break-In Engine Oil Use ? Final Tier 4/Stage V 15 L Engines
49.4 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
49.5 Engine Oil and Filter Service Intervals ? Final Tier 4/Stage V – 9.0 L [Ag] and 13.5 L Engines
49.6 Engine Oil and Filter Service Intervals
50 Engine Coolant
50.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
50.2 John Deere COOL-GARD? II Coolant Extender
50.3 Operating in Warm Temperature Climates
50.4 Water Quality for Mixing with Coolant Concentrate
50.5 Testing Coolant Freeze Point
50.6 Disposing of Coolant
51 Other Lubricants
51.1 Transmission and Hydraulic Oil
51.2 Multipurpose Extreme Pressure (EP) Grease
51.3 Lubricant Storage
51.4 Mixing of Lubricants
51.5 Alternative and Synthetic Lubricants
52 Service – General Information
52.1 Service Sections Overview
52.2 Service Tasks Performed As Required
52.3 Identify Tractor Engine Emissions Status
52.4 Single or Double Reduction Axle Identification
52.5 Open Hood
52.6 Remove Engine Access Panel
52.7 Remove Front Engine Side Shield
52.8 Remove Rear Engine Side Shield
52.9 Jack Up Tractor – Lifting Points and Support Stand Placement (EU 1322/2014)
52.10 Service and Connect STC? (Snap-to-Connect) Fittings
52.11 Diesel Particulate Filter Service
52.12 Exhaust Filter / Diesel Particulate Filter Ash Handling and Disposal
52.13 Exhaust Filter Disposal
52.14 Transmission Calibration
52.15 Abort Transmission Calibration
52.16 Do Not Modify Fuel System
52.17 Do Not Open High-Pressure Fuel System
52.18 Bleed Fuel System
52.19 Identify Zinc-Flake Coated Fasteners
52.20 Metric Bolt and Screw Torque Values
52.21 Unified Inch Bolt and Screw Torque Values
53 Break-In Service (100 Hours or Less)
53.1 Perform Break-In Services
54 Service – Record Charts
54.1 Engine Oil and Filter Change
54.2 As Required Service
54.3 Annual Service
54.4 10 Hour or Daily Service
54.5 50 Hour Service
54.6 250 Hour Service
54.7 400 Hour Service
54.8 500 Hour Service
54.9 750 Hour Service
54.10 800 Hour Service
54.11 1000 Hour Service
54.12 1200 Hour Service
54.13 1250 Hour Service
54.14 1500 Hour Service
54.15 1600 Hour Service
54.16 1750 Hour Service
54.17 2000 Hour Service
54.18 2250 Hour Service
54.19 2400 Hour Service
54.20 2500 Hour Service
54.21 2750 Hour Service
54.22 2800 Hour Service
54.23 3000 Hour Service
54.24 3200 Hour Service
54.25 3250 Hour Service
54.26 3500 Hour Service
54.27 3600 Hour Service
54.28 3750 Hour Service
54.29 4000 Hour Service
54.30 4250 Hour Service
54.31 4400 Hour Service
54.32 4500 Hour Service
54.33 4750 Hour Service
54.34 4800 Hour Service
54.35 5000 Hour Service
54.36 5200 Hour Service
54.37 5250 Hour Service
54.38 5500 Hour Service
54.39 5600 Hour Service
54.40 5750 Hour Service
54.41 6000 Hour Service
54.42 Services – 6250 to 8800 Hours
54.43 9000 Hour Service
54.44 Services Beyond 9000 Hours
55 Service – Clean
55.1 Tractor Exterior
55.2 Diesel Particulate Filter (DPF)?Final Tier 4/Stage V Engine
55.3 Exhaust Filter/Diesel Particulate Filter (DPF) Ash Handling and Disposal
55.4 Exhaust Filter Disposal
55.5 Engine Cooling System?9.0 or 13.5 L Engine
55.6 Engine Cooling System?15 L Engine
55.7 Cleaning Diesel Exhaust Fluid (DEF) Tank
55.8 DEF Tank Filler Neck Filter
55.9 Clean Display
55.10 Dual Beam Radar Sensor
55.11 Aftertreatment Fuel Injector?15 L Engine
55.12 Optional Fuel Water Separator
55.13 Tractor Exterior
56 Service – Check
56.1 Vari-Cool? Fan Drive and Belt?9.0 L Final Tier 4/Stage V Engine
56.2 Vari-Cool? Fan Drive and Belt?13.5L Final Tier 4/Stage V Engine
56.3 Engine Coolant Level
56.4 Optional Fuel/Water Separator
56.5 Water Separator
56.6 Engine and Exhaust Compartments
56.7 Outer Exhaust Screens
56.8 Air Conditioning System
56.9 Engine Water Pump Weep Hole?9.0 L Engine
56.10 Engine Water Pump Weep Hole?13.5 L Engine
56.11 Engine Water Pump Seal?15 L Engine
56.12 Fuel Tank Sump
56.13 Engine Oil Level?9.0 L Engine
56.14 Engine Oil Level?13.5 L Engine
56.15 Engine Oil Level?15 L Engine
56.16 Transmission-Hydraulic Oil Level
56.17 Tires
56.18 Secondary Brake
56.19 NEUTRAL Start System
56.20 Transmission PARK System
56.21 Engine Air Intake System?9.0 L Final Tier 4/Stage V Engine
56.22 Engine Air Intake System?13.5 L Final Tier 4/Stage V Engine
56.23 Engine Air Intake System?15 L Engine
56.24 Engine Coolant Freeze Point
56.25 Seat Belts
56.26 HydraCushion? Suspended Front Axle Accumulator Charge Pressure
56.27 Engine Auxiliary Drive Belt and Drive Belt Tensioner
56.28 Axle End Play
56.29 Engine Valve Clearance
56.30 Front Driveshaft Health (FDH) Sensor System
56.31 Drawbar Sensor Calibration
57 Service – Tighten
57.1 Wheel and Wheel Weight Bolts
57.2 Use Wheel Tightening Stand
57.3 Use Wheel Torque Wrench Adapter
57.4 Drawbar Support and Cap Screws
58 Service – Change
58.1 Vari-Cool? Fan Belt?9.0 L Final Tier 4/Stage V Engine
58.2 Vari-Cool? Fan Belt?13.5 L Final Tier 4/Stage V Engine
58.3 Vari-Cool? Fan Drive Bushings, Seals, and Wear Pads?9.0 L Final Tier 4/Stage V Engine
58.4 Vari-Cool? Fan Drive Bushings and Seals?13.5L Final Tier 4/Stage V Engine
58.5 Vari-Cool? Fan Drive Bearing and Retaining Capscrew?13.5L Final Tier 4/Stage V Engine
58.6 Engine Auxiliary Drive Belt?9.0 L or 13.5 L Engine
58.7 Engine Auxiliary Drive Belt?15 L Engine
58.8 Engine Water Pump Drive Belt?15 L Engine
58.9 Engine Oil and Filter?9.0 L Engine
58.10 Engine Oil and Filter?13.5 L Engine
58.11 Engine Oil and Filter?15 L Engine
58.12 Fuel Filters?9.0 L Engine
58.13 Fuel Filters?13.5 L Engine
58.14 Fuel Filters?15 L Engine
58.15 Optional Fuel Water Separator Filter Element
58.16 Cab Recirculation Air Filter
58.17 Cab Fresh Air Filter
58.18 Engine Primary and Secondary Air Filters
58.19 Fuel Tank Vent Filters
58.20 SCV Pilot Valve Filter
58.21 DEF Tank Vent Filter?Final Tier 4/Stage V Engine
58.22 In-Line DEF Filter
58.23 Transmission-Hydraulic Oil and Filters
58.24 Engine Cooling System Radiator Cap?15 L Engine
58.25 Transmission-Hydraulic Vent Filter
58.26 Access DEF Dosing Unit Filter?Final Tier 4/Stage V Engine
58.27 DEF Dosing Unit Filter?Final Tier 4/Stage V Engine
58.28 Transmission Drive Shaft Damper
58.29 Engine Coolant?9.0L Engine
58.30 Engine Coolant?13.5 L Engine
58.31 Engine Coolant?15 L Engine
58.32 Engine Crankshaft Damper?9.0 L or 13.5 L Engine
58.33 Engine Crankcase Breather Filter Element?15 L Engine
58.34 Front Drive Shaft U-Joints
59 Service – Lubricate
59.1 Heavy Duty Lift Link Pins (Optional)
59.2 Hinge Pins
59.3 Steering Pins
59.4 Telescoping Drive Shaft
59.5 PTO Drive Shaft
59.6 Heavy-Duty Gudgeon Bearings
59.7 Lower Drive Line Bearings
59.8 Rear Hitch
59.9 Lift Cylinders and Rockshaft
59.10 Vari-Cool? Fan Drive?9.0 L Final Tier 4/Stage V Engine
59.11 Vari-Cool? Fan Drive?13.5 L Final Tier 4/Stage V Engine
59.12 HydraCushion? Front Axle Suspension
59.13 Rear Hitch Draft Sensor?9370R, 9420R, or 9470R Tractor
60 Service – Electrical
60.1 Service – Electrical Overview
60.2 Welding Near Electronic Control Units
60.3 Keep Electronic Control Unit Connectors Clean
60.4 Compressed Air Use
60.5 High-Pressure Washer Use
60.6 Disconnect Battery
60.7 Handling Batteries Safely
60.8 Service Batteries and Connections
60.9 Access Load Center Fuses
60.10 Access Master Fuses
60.11 Access Implement Power Relay Module Fuses
60.12 Handle Halogen Light Bulbs Safely
60.13 Change Front HID/LED Light Assembly
60.14 Change Front Grille Halogen Light Bulbs
60.15 Adjust Front Grille Lights
60.16 Adjust Headlights
60.17 Change Front, Side And Rear Cab Roof Light Bulb
60.18 Change Brake or Turn Signal Light Bulb
60.19 Change Dome Light Bulb
60.20 Change Extremity Warning Light Bulb
61 Troubleshooting – Procedures
61.1 Engine
61.2 Transmission-Hydraulic-Axles
61.3 Hydraulic System
61.4 Brakes
61.5 Hitch
61.6 Selective Control Valve (SCV)
61.7 Electrical System
61.8 Operator Enclosure
62 Troubleshooting – Diagnostic Trouble Codes (DTC)
62.1 STOP, Service, and Information Alerts on CommandCenter?
62.2 Access Diagnostic Trouble Codes
63 Service – Storage
63.1 Place Tractor in Storage
63.2 Remove Tractor from Storage
64 Specifications
64.1 Engine: John Deere
64.2 Engine: QSX15 Cummins?
64.3 Capacities
64.4 Fluorinated Greenhouse Gas ? 9 L / 13.5 L Engine
64.5 Fluorinated Greenhouse Gas?15 L Engine
64.6 Hydraulics
64.7 Transmission and Power Train
64.8 PTO [Ag], Hitch [Ag], and Drawbar
64.9 Electrical
64.10 Integrated Technology
64.11 Overall Dimensions
64.12 Loads and Weights (EU 1322/2014) [Ag] 64.13 Loads and Weights (EU 1322/2014) [Scraper] 64.14 How to Calculate Permissible Mass (EU 1322/2014)
64.15 Sound Level (EU 1322/2014)
64.16 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (EU 1322/2014)
64.17 Ground Speeds?e18? Powershift Transmission
64.18 Limited Battery Warranty
64.19 Required Emission-Related Information
64.20 Carbon Dioxide Emissions (CO?)
65 Identification Numbers
65.1 Identification Plates
65.2 Product Identification Number
65.3 Engine Serial Number
65.4 Cab Serial Number
65.5 Transmission Serial Number
65.6 PTO Dropbox Serial Number [Ag] 65.7 PTO Clutch Serial Number [Ag] 65.8 Keep Proof of Ownership
65.9 Keep Machines Secure
66 Change of Ownership
66.1 Subsequent Ownership
67 Predelivery
67.1 Predelivery Checklist
67.2 Delivery Checklist and Certificate
68 John Deere Service Literature Available
68.1 Technical Information
69 John Deere Service Keeps You On The Job
69.1 John Deere Parts
69.2 The Right Tools
69.3 Well-Trained Technicians
69.4 Prompt Service