Table of Content:
1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Fire Prevention
3.9 In Case of Fire
3.10 Avoid Static Electricity Risk When Refueling
3.11 Use Foldable ROPS and Seat Belt Properly
3.12 Stay Clear of Rotating Drivelines
3.13 Use Steps and Handholds Correctly
3.14 Read Operator?s Manuals for ISOBUS Controllers
3.15 Use Seat Belt Properly
3.16 Vibration
3.17 Operating the Tractor Safely
3.18 Avoid Backover Accidents
3.19 Limited Use in Forestry Operation
3.20 Operating the Loader Tractor Safely
3.21 Keep Riders Off Machine
3.22 Passenger Seat
3.23 Use Safety Lights and Devices
3.24 Towing Trailers/Implements Safely
3.25 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.26 Freeing a Mired Machine
3.27 Avoid Contact with Agricultural Chemicals
3.28 Handle Agricultural Chemicals Safely
3.29 Handling Batteries Safely
3.30 Avoid Heating Near Pressurized Fluid Lines
3.31 Remove Paint Before Welding or Heating
3.32 Handle Electronic Components and Brackets Safely
3.33 Practice Safe Maintenance
3.34 Avoid Hot Exhaust
3.35 Clean Exhaust Filter Safely
3.36 Work In Ventilated Area
3.37 Support Machine Properly
3.38 Prevent Machine Runaway
3.39 Park Machine Safely
3.40 Transport Tractor Safely
3.41 Service Cooling System Safely
3.42 Service Accumulator Systems Safely
3.43 Service Tires Safely
3.44 Service Front-Wheel Drive Tractor Safely
3.45 Tightening Wheel Retaining Bolts/Nuts
3.46 Avoid High-Pressure Fluids
3.47 Do Not Open High-Pressure Fuel System
3.48 Store Attachments Safely
3.49 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Passenger Seat
4.4 ILS? (If Equipped)
4.5 Front SCVs (If Equipped)
4.6 Front Hitch Remote Switch (If Equipped)
4.7 Rear SCVs
4.8 Pick-Up Hitch (If Equipped)
4.9 Rear Hitch Remote Switch (If Equipped)
5 Vehicle Overview
5.1 8R Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Engine Set Speed
6.5 Engine Settings?Max Engine Speed
6.6 Engine Settings?Exhaust Filter System Overview
6.7 Engine Settings?AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.9 Engine Settings?Parked Filter Cleaning
6.10 Required Machine Stop Warning
6.11 Engine Fuel System and Power Rating
6.12 Battery Disconnect Switch
6.13 Start the Engine
6.14 Theft Deterrent Systems
6.15 Run the Engine
6.16 Stop the Engine
6.17 Restart Engine That Has Run Out of Fuel
6.18 Reduce Fuel Consumption
6.19 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?Without Starting Aid
7.2 Cold Weather Starting?With Starting Aid
7.3 Change Starting Fluid Canister
7.4 Auxiliary Heaters Use
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
8.4 Restored Operation Option
9 Front Console
9.1 Front Console
9.2 Adjust Steering Wheel and Column
9.3 Operate Horn
9.4 Operate Wipers and Washers
9.5 Key Switch
9.6 Operate Turn Signals
9.7 Pedals
9.8 Operate Lights
10 Corner Post Display
10.1 Corner Post Display
11 CommandARM? Controls
11.1 CommandARM?
11.2 CommandARM? Hitch Controls
11.3 CommandARM? SCV Control Levers
11.4 CommandARM? PTO Control Levers
11.5 CommandARM? Climate, Radio, and Lighting Controls
11.6 Push-To-Talk (PTT)
11.7 CommandARM? Controls?Left Side
11.8 CommandARM? Secondary Brake Lever
11.9 CommandARM? Joystick
11.10 CommandARM? Navigation Bar
11.11 Adjust CommandARM? Position
12 CommandCenter?
12.1 Generation 4 Display
12.2 Machine Settings Overview
12.3 Automation Status Overview
12.4 Navigate Generation 4 CommandCenter?
12.5 Compatible Displays
12.6 Power Display On and Off
12.7 Change Pages and Values
12.8 Factory and Service ADVISOR? Installed Onscreen Help
12.9 Radar Calibration
12.10 Slip Calibration
12.11 Steering Settings?Access
12.12 Steering Settings
12.13 Steering Settings?ACS? 2 Variable Ratio Steering
12.14 Steering Settings?ACS? 2 Sensitivity
12.15 Steering Settings?Steering Wheel Resistance
12.16 Controls Setup
12.17 Automation Status
12.18 Install Video Display Camera
13 CommandCenter? Audio and Phone
13.1 External Sources
13.2 Select Audio Source with Generation 4 CommandCenter?
13.3 FM, MW, LW Home Page
13.4 USB Home Page
13.5 Bluetooth? Home Page
13.6 Auxiliary Home Page
13.7 Pair Bluetooth? Device to Generation 4 CommandCenter?
13.8 Manage Paired Bluetooth? Devices
13.9 Phone Operation
13.10 Contact List
13.11 Recent Calls
13.12 Clear Favorites and Call History
14 Intelligent Total Equipment Control (iTEC?)
14.1 CommandARM? Control Functions
14.2 iTEC? Station Description (Eu 1322/2014)
14.3 CommandCenter? Pages Descriptions and Functions
14.4 Status Area
14.5 All Sequence Page
14.6 Add New Sequence
14.7 Sequence Step Status
14.8 Edit or Remove Sequence
14.9 Sequence Sets Page
14.10 Perform Sequence
14.11 Recommendations (AutoLearn)
14.12 iTEC Functions?IVT?/AutoPowr? Transmission
14.13 iTEC? Functions?Efficiency Manager?
15 Tractor-Implement Automation (TIA)
15.1 Tractor-Implement Automation (TIA)
15.2 Activate Tractor-Implement Automation (TIA) Equipment
15.3 Tractor-Implement Automation (TIA) ? Status Page
15.4 Operate Tractor-Implement Automation (TIA)
15.5 PTO Requirements
15.6 SCV Requirements
15.7 IVT?/AutoPowr? Requirements
15.8 IVT?/AutoPowr? with CommandPRO? Joystick Requirements
15.9 PowerShift? Transmission Requirements
15.10 AutoTrac? Guidance Requirements
15.11 Rear Hitch Requirements
15.12 Drive Strategy Requirements
16 Drivetrain
16.1 Drivetrain Overview
16.2 Suspension Settings?Access
16.3 Suspension Settings
16.4 Suspension Settings?Manual
16.5 Operate Suspension
16.6 Differential Lock
16.7 Mechanical Front-Wheel Drive (MFWD)
17 Brakes
17.1 Trailer Brake System Settings?Access
17.2 Trailer Brake System Settings
17.3 Trailer Brake System Settings?Brake Gain
17.4 Trailer Brake System Settings?Pre-Brake Offset
17.5 Trailer Brake System Settings?Trailer Brake Test
17.6 Trailer Brake System Settings?Advanced
17.7 Brake Use
17.8 AutoClutch
17.9 Hydraulic Trailer Brakes (If Equipped)
17.10 Air Trailer Brakes (If Equipped)
18 Transmission – General Information
18.1 Transmission Settings?Access Advanced
18.2 Transmission Settings?Advanced
18.3 Transmission Top Speed Note
18.4 Warm-Up Transmission-Hydraulic System
18.5 Backup Alarm
19 16-Speed PowerShift? Transmission
19.1 Operate Transmission?16-Speed PowerShift?
19.2 Shift Transmission?16-Speed PowerShift?
19.3 16-Speed PowerShift? Transmission Settings?Access
19.4 16-Speed PowerShift? Transmission Settings
19.5 16-Speed PowerShift? Transmission Settings?Automatic PowerShift?
19.6 16-Speed PowerShift? Transmission Settings?APS Sensitivity
20 e23? Transmission
20.1 Operate Transmission?e23?
20.2 Shift Transmission?e23?
20.3 e23? Set Speeds and Efficiency Manager?
20.4 e23? Transmission Settings?Access
20.5 e23? Transmission Settings
20.6 e23? Transmission Settings?Mode
20.7 e23? Transmission Settings?Custom
20.8 e23? Transmission Settings?Droop
20.9 e23? Transmission Settings?ECO
20.10 e23? Transmission Settings?Max Speeds
21 IVT?-AutoPowr? Transmission
21.1 Operate Transmission?IVT?
21.2 Shift Transmission?IVT?
21.3 IVT? Set Speeds
21.4 IVT? Transmission Settings?Access
21.5 IVT? Transmission Settings
21.6 IVT? Transmission Settings?Mode
21.7 IVT? Transmission Settings?Pedal Mode
21.8 IVT? Transmission Settings?Custom
21.9 IVT? Transmission Settings?Droop
21.10 IVT? Transmission Settings?ECO
21.11 IVT? Transmission Settings?Max Speeds
22 IVT?/AutoPowr? Transmission with CommandPRO? Joystick
22.1 Operate Transmission?IVT? with CommandPRO? Joystick
22.2 Shift Transmission?IVT? with CommandPRO? Joystick
22.3 CommandPRO? Joystick
22.4 CommandPRO? Joystick?Acceleration/Deceleration Response
22.5 CommandPRO? Joystick?Enable Set Speeds
22.6 CommandPRO? Joystick?Adjust Travel Direction
22.7 CommandPRO? Joystick?Stopping
22.8 CommandPRO? Joystick?Operating on Hillsides
22.9 CommandPRO? Transmission Settings?Access
22.10 CommandPRO? Transmission Settings
22.11 CommandPRO? Transmission Settings?Mode
22.12 CommandPRO? Transmission Settings?Custom
22.13 CommandPRO? Transmission Settings?Droop
22.14 CommandPRO? Transmission Settings?Minimum Engine Speed
22.15 CommandPRO? Transmission Settings?Set Speeds
22.16 CommandPRO? Transmission Settings?Shuttle Shift Speeds
22.17 CommandPRO? Transmission Settings?Speed Limits
23 PTO, Hitch, and Drawbar
23.1 Attach PTO-Driven Implement
23.2 Hitch, SCV and PTO External Switches
24 PTO – General Information
24.1 PTO Settings?Access
24.2 PTO Settings
24.3 PTO Settings?Advanced
24.4 PTO Settings?Engagement Rate
24.5 PTO Settings?Rear PTO Cruise
24.6 PTO Settings?Auto Disengage
24.7 Operating Instructions (EU 1322-2014)
24.8 Operate PTOs
24.9 External PTO Switches
24.10 Select Correct Engine Speed
25 Front PTO
25.1 Change Optional PTO Shafts-Front
26 Rear PTO
26.1 Rear PTO Shield
26.2 Select Correct PTO Shaft
26.3 Change 540/1000 RPM PTO Stub Shafts
26.4 Change 1000/1000E RPM PTO Stub Shafts
27 Front Hitch
27.1 Front Hitch Settings?Access
27.2 Front Hitch Settings
27.3 Front Hitch Settings?Upper Limit
27.4 Front Hitch Settings?Drop Rate
27.5 Front Hitch Settings?Raise Rate
27.6 Front Hitch Settings?Position and Set Points
27.7 Front Hitch Use
27.8 Front Hitch Upper And Lower Locking Plates
27.9 Front Hitch?Stow or Extend Hitch Arms
28 Rear Hitch
28.1 Hitch Lift Capacities
28.2 Rear Hitch Settings?Access
28.3 Rear Hitch Settings
28.4 Rear Hitch Settings?Upper Limit
28.5 Rear Hitch Settings?Drop Rate
28.6 Rear Hitch Settings?Raise Rate
28.7 Rear Hitch Settings?Load Depth
28.8 Rear Hitch Settings?Slip Sensitivity
28.9 Rear Hitch Settings?Position
28.10 Rear Hitch Settings?Advanced
28.11 Rear Hitch Settings?Position Control
28.12 Rear Hitch Settings?Draft Control
28.13 Hitch Control Lever Adjustments
28.14 Hitch Depth Set Point
28.15 Wagon Hitch Lever
28.16 Float Operation
28.17 Rear Hitch Components
28.18 Remote Rear Hitch Switches
28.19 Draft Link Storage Position
28.20 Hitch Manual Lowering
28.21 Correct Center Link Position
28.22 Hydraulic Center Link (If Equipped)
28.23 Adjust Sway Blocks
28.24 Adjust Deluxe Stabilizers
28.25 Attaching Implement to Walterscheid Couplers
28.26 Detaching Implement from Walterscheid Couplers
28.27 Attach Implement to Quick-Hitch
28.28 Adjust Implement Level
28.29 Adjust Lateral Float
28.30 Detach Implement from Quick-Hitch
28.31 Converting Category 3-3N Convertible Quick-Hitch Lower Hooks
28.32 Converting Category 4N/3 Convertible Quick-Hitch Lower Hooks
28.33 Converting Category 4N-3 Convertible Quick-Hitch Upper Hooks
28.34 Operating Wagon Hitch
28.35 Operate Pick-Up Hitch
28.36 Change Pick-Up Hitch Coupler
28.37 3-in-1 Hitch System
29 Drawbar
29.1 Drawbar Load Limitations (2015/208-ANNEX XXXIV)
29.2 Scraper Applications
29.3 Calculate Static Vertical Drawbar Load
29.4 Calculate Vertical Drawbar Load Distance Behind Rear Axle
29.5 Adjust Drawbar Length, Height, and Side-to-Side
30 Hydraulics – General Information
30.1 Hydraulic System Overview
31 Selective Control Valves
31.1 SCV Settings?Access
31.2 SCV Settings
31.3 SCV Settings?Standard Mode
31.4 SCV Settings?Independent Mode
31.5 SCV Settings?Feature Mode
31.6 SCV Settings?Flow Adjustment
31.7 SCV Settings?Time Adjustment
31.8 SCV Settings?Advanced
31.9 SCV Settings?Activating Independent Mode
31.10 SCV Settings?Automation
31.11 SCV Settings?Assignment
31.12 SCV Settings?Flow Adjustment Sensitivity
31.13 SCV Control Lever Adjustments
31.14 Total SCV Flow
31.15 Operate SCVs with CommandARM? Joystick
31.16 CommandARM? Joystick?Layout and Joystick Lever Functions
31.17 Connect Front SCV?S (If Equipped)
32 Hydraulic Connections
32.1 Connect/Disconnect Hydraulic Hoses
32.2 Component Identification and Location
32.3 Using Load-Sensing Hydraulic System?Power-Beyond
32.4 Examples Using Load-Sensing Hydraulic System?Power-Beyond
32.5 Using Hydraulic Spray Pumps
32.6 Implement Connection Example 1?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)
32.7 Implement Connection Example 2?Motor Application Using Motor Case Drain
32.8 Implement Connection Example 3?Motor Application Using SCV Retract and Auxiliary Motor Return
32.9 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip
32.10 Implement Connection Example 5?Planter with Vacuum Motor, Return Line to Motor Return and Lift Assist
32.11 Implement Connection Example 6?Planter with Vacuum Motor and Return Line to Motor Return
32.12 Using Hydraulic Motor Return
32.13 Using Hydraulic Motor Case Drain
32.14 Using Implements Requiring Large Volumes of Oil
33 TouchSet? Depth Control
33.1 TouchSet? Depth Control Settings and Adjustments
33.2 Connect/Disconnect the Implement Position Connector
34 Laser Scraper Control
34.1 Laser Scraper?Scrapers Equipped with Scraper Control Unit
35 Wheels and Tires – General Information
35.1 Determine Tire Load Capacity
35.2 Change Tire Size
35.3 Select Tire Combinations
35.4 Tire Load Index
35.5 Tire Inflation Pressure Guidelines
36 Front Wheels and Tires
36.1 Recommended Pressures?Group 42
36.2 Recommended Pressures?Group 43
36.3 Recommended Pressures?Group 44
36.4 Adjust and Tighten – Front Wheel Bolts
36.5 Install 425 mm Dual Extensions (8R: 230, 250, 280, and 310)
36.6 Install 500 mm Dual Extensions – ILS? (8R: 340, 370, and 410)
36.7 Toe-In Check
36.8 Toe-In Adjustment – 1300 MFWD
36.9 Toe-In Adjustment – 1500 MFWD
36.10 Toe-In Adjustment – ILS?
37 Steering Stop, Fender, and Tread Settings
37.1 Tire, Steering Stop, and Fender Settings Table Explanation
37.2 Tire, Steering Stop, and Fender Settings?1300 MFWD
37.3 Tire, Steering Stop, and Fender Settings?1500 MFWD with Single Front Tires
37.4 Tire, Steering Stop, and Fender Settings?ILS? with Single Front Tires
37.5 Determine Mean Tread Spacing
37.6 Tire, Steering Stop, and Fender Settings?1500 MFWD and Dual Front Tires
37.7 Tire, Steering Stop, and Fender Settings?ILS? and Dual Front Tires
37.8 Determine Rim Type
37.9 Wheel Settings?8-Position
37.10 Wheel Setting?16-Position
37.11 Steering Stop Settings – MFWD
37.12 Steering Stop Settings – ILS?
37.13 Fender Settings – 1300 MFWD
37.14 Fender Settings – 1500 MFWD and ILS?
38 Rear Wheels and Tires
38.1 Recommended Pressures?Group 47
38.2 Recommended Pressures?Group 48
38.3 Recommended Pressures?Group 49
38.4 Use Wheel Tightening Stand
38.5 Use Wheel Torque Wrench Adapter
38.6 Rear Wheel, Tire, and Tread Guidelines
38.7 Minimum Tread Setting With Air Trailer Brakes And Inner Wheel Weights
38.8 Install Wheel to Cast Hub
38.9 Install Dual Wheel to Hub
38.10 Adjust and Tighten ? Inner Drive Wheels with Standard Hubs
38.11 Adjust and Tighten ? Dual Wheels with Standard Hubs
38.12 Adjust and Tighten ? 10-Bolt Heavy-Duty Hubs
38.13 Adjust and Tighten ? 12-Bolt Heavy-Duty Hubs
38.14 Tread Settings – Single Wheel
38.15 Wheel Settings – 16-Position
38.16 Tread Settings – Dual Wheel
38.17 Tread Settings – Triple Wheel
38.18 Clamp-on Dual Usage
39 Seats
39.1 Adjust Air Seat
39.2 Adjust ActiveSeat? II
39.3 Operator Presence Sensor
39.4 Adjust Passenger Seat
40 Mirrors
40.1 Adjust Mirrors
41 Steps
41.1 Left-Hand Steps
41.2 Right-Hand Service Steps
42 Lights
42.1 Light Identification
42.2 Lights Settings?Access
42.3 Lights Settings
42.4 Lights Settings?Field Lights Presets
42.5 Lights Settings?Hood/Belt Line Lights
42.6 Lights Settings?Advanced
42.7 Hazard and Extremity Lights
42.8 Adjust Extremity Warning Lights (900 Section Tires)
42.9 Beacon Light
42.10 7-Pin Outlet
43 Accessories
43.1 Right-Hand Side Console
43.2 CommandARM? Storage
43.3 Right-Hand Front Corner Post
43.4 Left-Hand Rear Corner Post
43.5 Right-Hand Rear Corner Post
43.6 Refrigerator and Cool/Storage Box
43.7 Sunshade
43.8 Storage Compartments
43.9 Monitor Bracket Mounts
43.10 Emergency Exit
43.11 Install Business Band/Citizens Band (CB) Antenna and/or Radio
43.12 Mount StarFire? Receiver
43.13 Mount RTK (Real-Time Kinematic) Radio
43.14 Implement Connector
43.15 RS232 Serial Communication Connection
44 HVAC
44.1 HVAC Settings?Access
44.2 HVAC Settings
44.3 HVAC Settings?Climate Control Automation
44.4 HVAC Settings?Set Temperature
44.5 HVAC Settings?Air Flow Mode
44.6 HVAC Settings?Fan Speed
44.7 HVAC Settings?Air Conditioning
45 Performance Ballasting
45.1 How to Calculate Permissible Towed Mass (EU 1322/2014)
45.2 How to Calculate Maximum Permissible Download on Trailer Hitch (EU 1322/2014)
45.3 Mechanical Towed Coupling Load Limitations (2015/208-ANNEX XXXIV)
45.4 General Ballasting Information
45.5 General Guidelines
45.6 General Weight Split Guidelines
45.7 Ballast Options
45.8 Measure Slip
45.9 Quik-Tatch? Weight Use
45.10 Rear Wheel Weight Use
45.11 Rear Wheel Weight Installation?Single Drive Wheel
45.12 Rear Wheel Weight Installation?Dual Drive Wheels
45.13 Controlling Power Hop-MFWD Tractors
45.14 Mounted Commodity Tank Use
45.15 Calculate Tractor Ballast Package
45.16 Unballasted Tractor Weight Chart
45.17 Implement and Tractor Codes
45.18 Liquid Ballast Use
46 Transport
46.1 Drive Tractor on Roads
46.2 Transport with Ballast
46.3 Towed Mass (EU 1322-2014)
46.4 Tow Loads
46.5 Tow Points
46.6 Tow Tractor
46.7 Tow Mode
46.8 Come Home Mode
46.9 Transporting on Flat-Bed Carrier
46.10 Tie Down on Transport Carrier
46.11 Freeing a Mired Tractor
47 Fuel, Lubricants, and Coolant – General Information
47.1 Determine Tractor Engine Type
47.2 Minimizing the Effect of Cold Weather on Diesel Engines
47.3 Oil Filters
48 Fuel
48.1 Diesel Fuel
48.2 Supplemental Diesel Fuel Additives
48.3 Biodiesel Fuel
48.4 Lubricity of Diesel Fuel
48.5 Handling and Storing Diesel Fuel
48.6 Fill Fuel Tank
48.7 Testing Diesel Fuel
48.8 Fuel Filters
49 Diesel Exhaust Fluid (DEF)
49.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
49.2 Storing Diesel Exhaust Fluid (DEF)
49.3 Refilling Diesel Exhaust Fluid (DEF) Tank
49.4 Fill DEF Tank – FT4/Stage V Engine
49.5 Testing Diesel Exhaust Fluid (DEF)
49.6 Disposal of Diesel Exhaust Fluid (DEF)
50 Engine Oil
50.1 Diesel Engine Oil Service Interval for Operation at High Altitude
50.2 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
50.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
50.4 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
51 Engine Coolant
51.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
51.2 John Deere COOL-GARD? II Coolant Extender
51.3 Operating in Warm Temperature Climates
51.4 Water Quality for Mixing with Coolant Concentrate
51.5 Testing Coolant Freeze Point
51.6 Disposing of Coolant
52 Other Lubricants
52.1 Gear Oil
52.2 Multipurpose Extreme Pressure (EP) Grease
52.3 MFWD Axle Housing Oil
52.4 Corn Head Grease
52.5 Lubricant Storage
52.6 Alternative and Synthetic Lubricants
52.7 Mixing of Lubricants
52.8 Transmission and Hydraulic Oil
52.9 PowerShift? Transmission Recalibration
53 Service – General Information
53.1 Do Not Modify Fuel System
53.2 Bleed Fuel System
53.3 Service Sections Overview
53.4 Service Tasks Performed As Required
53.5 Identify Tractor Engine Emissions Status
53.6 Open Hood
53.7 Remove Side Panels
53.8 Access Battery Compartment
53.9 Remove Cab Rear Panel
53.10 Jack Up Tractor – Lifting Points and Support Stand Placement (EU 1322/2014)
53.11 Service and Connect STC? (Snap-to-Connect) Fittings
53.12 High-Pressure Washer Use
53.13 Identify Zinc-Flake Coated Fasteners
53.14 Unified Inch Bolt and Screw Torque Values
53.15 Metric Bolt and Screw Torque Values
54 Service – Break-In (100 Hours or Less)
54.1 Perform Break-In Checks
55 Service – Record Charts
55.1 Service Record Chart Overview
55.2 Service Interval Chart
55.3 Service Record Chart
56 Service – Clean
56.1 Access DEF Tank Drain Plug
56.2 Cleaning Diesel Exhaust Fluid (DEF) Tank
56.3 Tractor Exterior
56.4 Air Intake Valve
56.5 Clean Display
56.6 Clean Seat
56.7 Engine Cooling System
56.8 Dual Beam Radar Sensor
56.9 MFWD Axle Breather Filter
56.10 Hydraulic Oil Suction Screen
56.11 ILS? Axle Internal Tie Rod Ball Joint Boots
57 Service – Check
57.1 Windshield Washer Fluid Level
57.2 Engine Coolant Level
57.3 Coolant Freeze Point
57.4 Water Separator
57.5 Optional Fuel Water Separator (If Equipped)
57.6 Engine and Exhaust Compartments
57.7 Air Conditioning System
57.8 Engine Water Pump Weep Hole – Final Tier 4/Stage V Engine
57.9 Fuel Tank Sump
57.10 MFWD Axle Housing Oil Level
57.11 MFWD Wheel Hub Oil Level
57.12 Engine Oil Level
57.13 Transmission-Hydraulic Oil Level
57.14 Tires
57.15 Mechanical Cab Suspension Components
57.16 Manually Operated Hitch
57.17 Remote Controlled Hitch
57.18 Tow Hitch (Piton Fix)
57.19 Ball-Type Tow Hitch
57.20 Pick-Up Hitch Tow-Hook
57.21 Drawbar Wear
57.22 Engine Air Intake System?Final Tier 4/Stage V Engine
57.23 Seat Belts
57.24 Auxiliary Drive Belt and Drive Belt Tensioner
57.25 ILS? Upper and Lower Rod and Head End Accumulator Charge Pressure
57.26 Engine Valve Clearance
57.27 Secondary Brake System
57.28 NEUTRAL Start System
57.29 Transmission PARK System
58 Service – Tighten
58.1 Wheel and Wheel Weight Bolts
58.2 Use Wheel Tightening Stand
58.3 Use Wheel Torque Wrench Adapter
58.4 Rear Wheel Weight Bolts
58.5 Front Wheel Bolts
58.6 Rear Drive Wheel to Cast Hub Bolts
58.7 Rear Steel Wheel to Hub Bolts
58.8 Rear Steel Wheels?Cast Hub Bolts
58.9 Rear Wheel Bolts?Heavy-duty Cast 10-Bolt Hubs
59 Service – Change
59.1 Engine Oil and Filter
59.2 Fuel Filters
59.3 Optional Fuel Water Separator Filter Element (If Equipped)
59.4 Cab Recirculation Air Filter
59.5 Cab Fresh Air Filter
59.6 Engine Primary and Secondary Air Filters
59.7 Fuel Tank Vent Filter
59.8 SCV Pilot Valve Filter
59.9 Chain Drive Oil
59.10 Auxiliary Drive Belt
59.11 Differential Oil
59.12 Drain 16-Speed Transmission
59.13 IVT?/AutoPowr? and e23?Transmissions-Hydraulic Oil
59.14 Drain ILS?
59.15 Transmission-Hydraulic Oil Filter
59.16 MFWD or ILS Wheel Hub Oil
59.17 MFWD Axle Housing Oil
59.18 Air Trailer Brake Air Dryer Filter
59.19 DEF Tank Vent Filter
59.20 Access In-Line DEF Filter
59.21 Change Diesel Exhaust Fluid (DEF) In-Line Filter
59.22 Access DEF Dosing Unit Filter
59.23 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
59.24 Transmission Torsional Damper
59.25 Engine Crankshaft Damper
59.26 Engine Coolant
60 Service – Lubricate
60.1 MFWD U-Joints
60.2 ILS? King Pins, Tie Rod Ends, Pivot Fittings, and Suspension Cylinders
60.3 ILS? Axle Internal Tie Rod Ball Joints
60.4 ILS? Inboard U-Joint
60.5 Rear Hitch
60.6 Deluxe Stabilizers
60.7 Front Hitch
60.8 Wagon Hitch
60.9 Pick-Up Hitch
60.10 MFWD Axle King Pins, Tie Rod Ends, Axle Pivot Fittings, and Steering Cylinders (1300 MFWD Axle)
60.11 MFWD Axle King Pins, Tie Rod Ends, Axle Pivot Fittings, and Steering Cylinders (1500 MFWD Axle)
60.12 Front PTO Drive Shaft
60.13 Draft Link Support Shaft Bushing
61 Service – Electrical
61.1 Service – Electrical Overview
61.2 Welding Near Electronic Control Units
61.3 Keep Electronic Control Unit Connectors Clean
61.4 Compressed Air Use
61.5 High-Pressure Washers Use
61.6 Disconnect Battery
61.7 Service Batteries and Connectors
61.8 Access Load Center Fuses
61.9 Access Front Load Center
61.10 Access Master Fuses
61.11 Access Implement Power Relay Module Fuses
61.12 Handle Halogen Light Bulbs Safely
61.13 Change Halogen Bulbs
61.14 Change Front LED Headlight Assembly
61.15 Aim Halogen High-Beam Headlights
61.16 Aim LED High Beam Headlights
61.17 Aim Headlights
61.18 Change Auxiliary Driving Light
61.19 Change Cab Roof Light
61.20 Change Rear Fender Light?Rear Indicator
61.21 Change Extremity Light?Cab
61.22 Change Cab Dome Light
62 Troubleshooting – Procedures
62.1 Perform Troubleshooting Process
62.2 Engine
62.3 Transmission
62.4 Hydraulic System
62.5 Hitch
62.6 Selective Control Valve (SCV)
62.7 TouchSet Depth Control
62.8 Electrical System
62.9 Operator Enclosure
62.10 Tractor Operation
62.11 ILS?
62.12 Steering System
63 Troubleshooting – Diagnostic Trouble Codes (DTC)
63.1 STOP, Service, and Information Alerts on CommandCenter?
63.2 Access Diagnostic Trouble Codes
64 Service – Storage
64.1 Place Tractor in Storage
64.2 Remove Tractor from Storage
65 Specifications
65.1 Engine
65.2 Capacities
65.3 Fluorinated Greenhouse Gas
65.4 Hydraulic System
65.5 Transmission and Power Train
65.6 Hitch, Drawbar, and PTO
65.7 Electrical System
65.8 Integrated Technology
65.9 Overall Dimensions
65.10 Loads and Weights
65.11 Sound Level
65.12 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (EU 1322/2014)
65.13 Ground Speeds?16-Speed PowerShift? Transmission
65.14 Ground Speeds?e23? Transmission
65.15 Ground Speeds?IVT?/AutoPowr? Transmission
65.16 Front Loader Installation?Front Loader Mounting Frames (EU 1322/2014)
65.17 Required Emission-Related Information
65.18 Carbon Dioxide Emissions (CO?)
66 Identification Numbers
66.1 Identification Plates
66.2 Product Identification Number (PIN)
66.3 Engine Serial Number
66.4 Cab Serial Number
66.5 Transmission Serial Number
66.6 Axle Serial Number
66.7 Keep Proof of Ownership
66.8 Keep Machines Secure
67 Change of Ownership
67.1 Subsequent Ownership
68 Predelivery
68.1 Predelivery Checklist
68.2 Delivery Checklist and Certificate
69 Index
70 John Deere Service Literature Available
70.1 Technical Information
71 John Deere Service Keeps You On The Job
71.1 John Deere Parts
71.2 The Right Tools
71.3 Well-Trained Technicians
71.4 Prompt Service
