Table of Content:
1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Fire Prevention
3.9 In Case of Fire
3.10 Avoid Static Electricity Risk When Refueling
3.11 Use Foldable ROPS and Seat Belt Properly
3.12 Stay Clear of Rotating Drivelines
3.13 Use Steps and Handholds Correctly
3.14 Read Operator?s Manuals for ISOBUS Controllers
3.15 Use Seat Belt Properly
3.16 Vibration
3.17 Operating the Tractor Safely
3.18 Avoid Backover Accidents
3.19 Limited Use in Forestry Operation
3.20 Operating the Loader Tractor Safely
3.21 Keep Riders Off Machine
3.22 Passenger Seat
3.23 Use Safety Lights and Devices
3.24 Towing Trailers/Implements Safely
3.25 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.26 Freeing a Mired Machine
3.27 Avoid Contact with Agricultural Chemicals
3.28 Handle Agricultural Chemicals Safely
3.29 Handling Batteries Safely
3.30 Avoid Heating Near Pressurized Fluid Lines
3.31 Remove Paint Before Welding or Heating
3.32 Handle Electronic Components and Brackets Safely
3.33 Practice Safe Maintenance
3.34 Avoid Hot Exhaust
3.35 Clean Exhaust Filter Safely
3.36 Work In Ventilated Area
3.37 Support Machine Properly
3.38 Prevent Machine Runaway
3.39 Park Machine Safely
3.40 Transport Tractor Safely
3.41 Service Cooling System Safely
3.42 Service Accumulator Systems Safely
3.43 Service Tires Safely
3.44 Service Front-Wheel Drive Tractor Safely
3.45 Tightening Wheel Retaining Bolts/Nuts
3.46 Avoid High-Pressure Fluids
3.47 Do Not Open High-Pressure Fuel System
3.48 Store Attachments Safely
3.49 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Passenger Seat
4.4 ILS? (If Equipped)
4.5 Front SCVs (If Equipped)
4.6 Front Hitch Remote Switch (If Equipped)
4.7 Rear SCVs
4.8 Pick-Up Hitch (If Equipped)
4.9 Rear Hitch Remote Switch (If Equipped)
5 Vehicle Overview
5.1 8R Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Intelligent Power Management (IPM)
6.5 Engine Settings?Engine Set Speed
6.6 Engine Settings?Max Engine Speed
6.7 Engine Settings?Exhaust Filter System Overview
6.8 Engine Settings?AUTO Exhaust Filter Cleaning
6.9 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.10 Engine Settings?Parked Filter Cleaning
6.11 Required Machine Stop Warning
6.12 Engine Fuel System and Power Rating
6.13 Battery Disconnect Switch
6.14 Start the Engine
6.15 Theft Deterrent Systems
6.16 Run the Engine
6.17 Stop the Engine
6.18 Restart Engine That Has Run Out of Fuel
6.19 Reduce Fuel Consumption
6.20 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?Without Starting Aid
7.2 Cold Weather Starting?With Starting Aid
7.3 Change Starting Fluid Canister
7.4 Auxiliary Heaters Use
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
8.4 Restored Operation Option
9 Front Console
9.1 Front Console
9.2 Adjust Steering Wheel and Column
9.3 Operate Horn
9.4 Operate Wipers and Washers
9.5 Key Switch
9.6 Operate Turn Signals
9.7 Pedals
9.8 Operate Lights
10 Corner Post Display
10.1 Corner Post Display
11 CommandARM? Controls
11.1 CommandARM?
11.2 CommandARM? Hitch Controls
11.3 CommandARM? SCV Control Levers
11.4 CommandARM? PTO Control Levers
11.5 CommandARM? Climate, Radio, and Lighting Controls
11.6 Push-To-Talk (PTT)
11.7 CommandARM? Controls?Left Side
11.8 CommandARM? Secondary Brake Lever
11.9 CommandARM? Joystick
11.10 CommandARM? Navigation Bar
11.11 Adjust CommandARM? Position
12 CommandCenter?
12.1 Generation 4 Display
12.2 Machine Settings Overview
12.3 Navigate Generation 4 CommandCenter?
12.4 Compatible Universal Displays
12.5 Power Display On and Off
12.6 Change Pages and Values
12.7 Factory and Service ADVISOR? Installed Onscreen Help
12.8 Radar Calibration
12.9 Slip Calibration
12.10 Steering Settings?Access
12.11 Steering Settings
12.12 Steering Settings?ACS? 2 Variable Ratio Steering
12.13 Steering Settings?ACS? 2 Sensitivity
12.14 Steering Settings?Steering Wheel Resistance
12.15 Controls Setup
12.16 Install Video Display Camera
13 Intelligent Total Equipment Control (iTEC?)
13.1 CommandARM? Control Functions
13.2 iTEC? Station Description (EU 1322/2014)
13.3 CommandCenter? Pages Descriptions and Functions
13.4 Status Area
13.5 All Sequence Page
13.6 Add New Sequence
13.7 Sequence Step Status
13.8 Edit or Remove Sequence
13.9 Sequence Sets Page
13.10 Perform Sequence
13.11 Recommendations (AutoLearn)
13.12 iTEC Functions?IVT?/AutoPowr? Transmission
13.13 iTEC? Functions?Efficiency Manager?
14 Tractor-Implement Management (TIM)/Tractor-Implement Automation (TIA)
14.1 TIM/TIA?General Information
14.2 Activate TIM/TIA Equipment
14.3 Operate TIM/TIA
14.4 PTO Requirements
14.5 SCV Requirements
14.6 IVT?/AutoPowr? Requirements
14.7 IVT?/AutoPowr? with CommandPRO? Joystick Requirements
14.8 PowerShift? Transmission Requirements
14.9 AutoTrac? Guidance Requirements
14.10 Rear Hitch Requirements
15 Drivetrain
15.1 Drivetrain Overview
15.2 Suspension Settings?Access
15.3 Suspension Settings
15.4 Suspension Settings?Manual
15.5 Operate Suspension
15.6 Differential Lock
15.7 Mechanical Front-Wheel Drive (MFWD)
16 Brakes
16.1 Trailer Brake System Settings?Access
16.2 Trailer Brake System Settings
16.3 Trailer Brake System Settings?Brake Gain
16.4 Trailer Brake System Settings?Pre-Brake Offset
16.5 Trailer Brake System Settings?Trailer Brake Test
16.6 Trailer Brake System Settings?Advanced
16.7 Brake Use
16.8 AutoClutch
16.9 Hydraulic Trailer Brakes (If Equipped)
16.10 Air Trailer Brakes (If Equipped)
17 Transmission?General Information
17.1 Transmission Settings?Access Advanced
17.2 Transmission Settings?Advanced
17.3 Transmission Top Speed Note
17.4 Warm-Up Transmission-Hydraulic System
17.5 Backup Alarm
18 16-Speed PowerShift? Transmission
18.1 Operate Transmission?16-Speed PowerShift?
18.2 Shift Transmission?16-Speed PowerShift?
18.3 16-Speed PowerShift? Transmission Settings?Access
18.4 16-Speed PowerShift? Transmission Settings
18.5 16-Speed PowerShift? Transmission Settings?Automatic PowerShift?
18.6 16-Speed PowerShift? Transmission Settings?APS Sensitivity
19 e23? Transmission
19.1 Operate Transmission?e23?
19.2 Shift Transmission?e23?
19.3 e23? Set Speeds and Efficiency Manager?
19.4 e23? Transmission Settings?Access
19.5 e23? Transmission Settings
19.6 e23? Transmission Settings?Mode
19.7 e23? Transmission Settings?Custom
19.8 e23? Transmission Settings?Droop
19.9 e23? Transmission Settings?ECO
19.10 e23? Transmission Settings?Max Speeds
20 IVT?-AutoPowr? Transmission
20.1 Operate Transmission?IVT?
20.2 Shift Transmission?IVT?
20.3 IVT? Set Speeds
20.4 IVT? Transmission Settings?Access
20.5 IVT? Transmission Settings
20.6 IVT? Transmission Settings?Mode
20.7 IVT? Transmission Settings?Pedal Mode
20.8 IVT? Transmission Settings?Custom
20.9 IVT? Transmission Settings?Droop
20.10 IVT? Transmission Settings?ECO
20.11 IVT? Transmission Settings?Max Speeds
21 IVT?-AutoPowr? Transmission with CommandPRO? Joystick
21.1 Operate Transmission?IVT? with CommandPRO? Joystick
21.2 Shift Transmission?IVT? with CommandPRO? Joystick
21.3 CommandPRO? Joystick
21.4 CommandPRO? Joystick?Acceleration/Deceleration Response
21.5 CommandPRO? Joystick?Enable Set Speeds
21.6 CommandPRO? Joystick?Adjust Travel Direction
21.7 CommandPRO? Joystick?Stopping
21.8 CommandPRO? Joystick?Operating on Hillsides
21.9 CommandPRO? Transmission Settings?Access
21.10 CommandPRO? Transmission Settings
21.11 CommandPRO? Transmission Settings?Mode
21.12 CommandPRO? Transmission Settings?Custom
21.13 CommandPRO? Transmission Settings?Droop
21.14 CommandPRO? Transmission Settings?Minimum Engine Speed
21.15 CommandPRO? Transmission Settings?Set Speeds
21.16 CommandPRO? Transmission Settings?Shuttle Shift Speeds
21.17 CommandPRO? Transmission Settings?Speed Limits
22 PTO, Hitch, and Drawbar
22.1 Attach PTO-Driven Implement
23 PTO?General Information
23.1 PTO Settings?Access
23.2 PTO Settings
23.3 PTO Settings?Advanced
23.4 PTO Settings?Engagement Rate
23.5 PTO Settings?Rear PTO Cruise
23.6 PTO Settings?Auto Disengage
23.7 Operating Instructions (EU 1322-2014)
23.8 Operate PTOs
23.9 External PTO Switches
23.10 Select Correct Engine Speed
24 Front PTO
24.1 Change Optional PTO Shafts?Front
25 Rear PTO
25.1 Rear PTO Shield
25.2 Select Correct PTO Shaft
25.3 Change 540/1000 RPM PTO Stub Shafts
25.4 Change 1000/1000E RPM PTO Stub Shafts
26 Front Hitch
26.1 Front Hitch Settings?Access
26.2 Front Hitch Settings
26.3 Front Hitch Settings?Upper Limit
26.4 Front Hitch Settings?Drop Rate
26.5 Front Hitch Settings?Raise Rate
26.6 Front Hitch Settings?Position and Set Points
26.7 Front Hitch Use
26.8 Front Hitch Upper And Lower Locking Plates
26.9 Front Hitch?Stow or Extend Hitch Arms
27 Rear Hitch
27.1 Hitch Lift Capacities
27.2 Rear Hitch Settings?Access
27.3 Rear Hitch Settings
27.4 Rear Hitch Settings?Upper Limit
27.5 Rear Hitch Settings?Drop Rate
27.6 Rear Hitch Settings?Raise Rate
27.7 Rear Hitch Settings?Load Depth
27.8 Rear Hitch Settings?Slip Sensitivity
27.9 Rear Hitch Settings?Position
27.10 Rear Hitch Settings?Advanced
27.11 Rear Hitch Settings?Position Control
27.12 Rear Hitch Settings?Draft Control
27.13 Hitch Control Lever Adjustments
27.14 Hitch Depth Set Point
27.15 Wagon Hitch Lever
27.16 Float Operation
27.17 Rear Hitch Components
27.18 External Hitch Switches
27.19 Draft Link Storage Position
27.20 Hitch Manual Lowering
27.21 Adjust Sway Blocks
27.22 Adjust Deluxe Stabilizers
27.23 Attach Implement to Walterscheid Couplers
27.24 Detach Implement from Walterscheid Couplers
27.25 Attach Implement to Quick-Hitch
27.26 Adjust Implement Level
27.27 Adjust Lateral Float
27.28 Detach Implement from Quick-Hitch
27.29 Convert Category 3/3N Convertible Quick-Hitch Lower Hooks
27.30 Convert Category 4N/3 Convertible Quick-Hitch Lower Hooks
27.31 Convert Category 4N/3 Convertible Quick-Hitch Upper Hooks
27.32 Operate Wagon Hitch
27.33 Operate Pick-Up Hitch
27.34 Change Pick-Up Hitch Coupler
27.35 3-in-1 Hitch System
28 Drawbar
28.1 Drawbar Load Limitations (2015/208-ANNEX XXXIV)
28.2 Scraper Applications
28.3 Calculate Static Vertical Drawbar Load
28.4 Calculate Vertical Drawbar Load Distance Behind Rear Axle
28.5 Adjust Drawbar Length, Height, and Side-to-Side
29 Hydraulics?General Information
29.1 Hydraulic System Overview
30 Selective Control Valves
30.1 SCV Settings?Access
30.2 SCV Settings
30.3 SCV Settings?Standard Mode
30.4 SCV Settings?Independent Mode
30.5 SCV Settings?Feature Mode
30.6 SCV Settings?Flow Adjustment
30.7 SCV Settings?Time Adjustment
30.8 SCV Settings?Advanced
30.9 SCV Settings?Activating Independent Mode
30.10 SCV Settings?Automation
30.11 SCV Settings?Assignment
30.12 SCV Settings?Flow Adjustment Sensitivity
30.13 SCV Control Lever Adjustments
30.14 External SCV Switches
30.15 Total SCV Flow
30.16 Operate SCVs with CommandARM? Joystick
30.17 CommandARM? Joystick?Layout and Joystick Lever Functions
31 Hydraulic Connections
31.1 Connect/Disconnect Hydraulic Hoses
31.2 Component Identification and Location
31.3 Using Load-Sensing Hydraulic System?Power-Beyond
31.4 Examples Using Load-Sensing Hydraulic System?Power-Beyond
31.5 Using Hydraulic Spray Pumps
31.6 Implement Connection Example 1?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)
31.7 Implement Connection Example 2?Motor Application Using Motor Case Drain
31.8 Implement Connection Example 3?Motor Application Using SCV Retract and Auxiliary Motor Return
31.9 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip
31.10 Implement Connection Example 5?Planter with Vacuum Motor, Return Line to Motor Return and Lift Assist
31.11 Implement Connection Example 6?Planter with Vacuum Motor and Return Line to Motor Return
31.12 Using Hydraulic Motor Return
31.13 Using Hydraulic Motor Case Drain
31.14 Using Implements Requiring Large Volumes of Oil
32 TouchSet? Depth Control
32.1 TouchSet? Depth Control Settings and Adjustments
32.2 Connect/Disconnect the Implement Position Connector
33 Laser Scraper Control
33.1 Laser Scraper?Scrapers Equipped with Scraper Control Unit
34 Wheels and Tires?General Information
34.1 Determine Tire Load Capacity
34.2 Change Tire Size
34.3 Select Tire Combinations
34.4 Tire Load Index
34.5 Tire Inflation Pressure Guidelines
34.6 Replace Tires
35 Front Wheels and Tires
35.1 Recommended Pressures?Group 42
35.2 Recommended Pressures?Group 43
35.3 Recommended Pressures?Group 44
35.4 Adjust and Tighten?Front Wheel Bolts
35.5 Install 425 mm Dual Extensions
35.6 Install 500 mm Dual Extensions?ILS?
35.7 Toe-In Check
35.8 Toe-In Adjustment?1300 MFWD
35.9 Toe-In Adjustment?1500 MFWD
35.10 Toe-In Adjustment?ILS?
36 Steering Stop, Fender, and Tread Settings
36.1 Tire, Steering Stop, and Fender Settings Table Explanation
36.2 Tire, Steering Stop, and Fender Settings?1300 MFWD
36.3 Tire, Steering Stop, and Fender Settings?1500 MFWD with Single Front Tires
36.4 Tire, Steering Stop, and Fender Settings?ILS? with Single Front Tires
36.5 Determine Mean Tread Spacing
36.6 Tire, Steering Stop, and Fender Settings?1500 MFWD and Dual Front Tires
36.7 Tire, Steering Stop, and Fender Settings?ILS? and Dual Front Tires
36.8 Tire, Steering Stop, and Fender Settings?ILS? with John Deere CTIS
36.9 Determine Rim Type
36.10 Wheel Settings?8-Position
36.11 Wheel Setting?16-Position
36.12 Steering Stop Settings?MFWD
36.13 Steering Stop Settings?ILS?
36.14 Fender Settings?1300 MFWD
36.15 Fender Settings?1500 MFWD and ILS?
37 Rear Wheels and Tires
37.1 Recommended Pressures?Group 47
37.2 Recommended Pressures?Group 48
37.3 Recommended Pressures?Group 48?Continued
37.4 Recommended Pressures?Group 49
37.5 Rear Wheel, Tire, and Tread Guidelines
37.6 Minimum Tread Setting with Air Trailer Brakes and Inner Wheel Weights
37.7 Install Wheel to Cast Hub
37.8 Install Dual Wheel to Hub
37.9 Adjust and Tighten?Inner Drive Wheels with Standard Hubs
37.10 Adjust and Tighten?Dual Wheels with Standard Hubs
37.11 Adjust and Tighten?10-Bolt Heavy-Duty Hubs
37.12 Adjust and Tighten?12-Bolt Heavy-Duty Hubs
37.13 Tread Settings?Single Wheel
37.14 Wheel Settings?16-Position
37.15 Tread Settings?Dual Wheel
37.16 Tread Settings?Triple Wheel
37.17 Tread Settings?Single Wheel with John Deere CTIS
37.18 Tread Settings?Dual Wheel with John Deere CTIS
37.19 Clamp-on Dual Usage
38 John Deere CTIS
38.1 John Deere CTIS Settings?Access
38.2 John Deere CTIS Settings
38.3 John Deere CTIS Settings?Status
38.4 John Deere CTIS Settings?Pressure Targets Mode
38.5 John Deere CTIS Settings?Current Pressures
38.6 John Deere CTIS Settings?Advanced
38.7 John Deere CTIS Component Location
38.8 Connecting/Disconnecting John Deere CTIS Hoses
38.9 Isolating Tires During Failure
38.10 Operation While Land-Leveling
38.11 Auxiliary Connections
38.12 Offboarding Air
38.13 Onboarding Air
39 Seats
39.1 Adjust Air Seat
39.2 Adjust ActiveSeat? II
39.3 Operator Presence Sensor
39.4 Adjust Passenger Seat
40 Mirrors
40.1 Adjust Mirrors
41 Steps
41.1 Left-Hand Steps
41.2 Right-Hand Service Steps
42 Lights
42.1 Light Identification
42.2 Lights Settings?Access
42.3 Lights Settings
42.4 Lights Settings?Field Lights Presets
42.5 Lights Settings?Hood/Belt Line Lights
42.6 Lights Settings?Advanced
42.7 Hazard and Extremity Lights
42.8 Adjust Extremity Warning Lights (900 Section Tires)
42.9 Beacon Light
42.10 7-Pin Outlet
43 Accessories
43.1 Right-Hand Side Console
43.2 CommandARM? Storage
43.3 Right-Hand Front Corner Post
43.4 Left-Hand Rear Corner Post
43.5 Right-Hand Rear Corner Post
43.6 Refrigerator and Cool/Storage Box
43.7 Sunshade
43.8 Storage Compartments
43.9 Monitor Bracket Mounts
43.10 Emergency Exit
43.11 Install Business Band/Citizens Band (CB) Antenna and/or Radio
43.12 Mount StarFire? Receiver
43.13 Mount RTK (Real-Time Kinematic) Radio
43.14 Implement Connector
43.15 RS232 Serial Communication Connection
44 HVAC
44.1 HVAC Settings?Access
44.2 HVAC Settings
44.3 HVAC Settings?Climate Control Automation
44.4 HVAC Settings?Set Temperature
44.5 HVAC Settings?Air Flow Mode
44.6 HVAC Settings?Fan Speed
44.7 HVAC Settings?Air Conditioning
45 Performance Ballasting
45.1 How to Calculate Permissible Towed Mass (EU 1322/2014)
45.2 How to Calculate Maximum Permissible Download on Trailer Hitch (EU 1322/2014)
45.3 Mechanical Towed Coupling Load Limitations (2015/208-ANNEX XXXIV)
45.4 General Ballasting Information
45.5 General Guidelines
45.6 General Weight Split Guidelines
45.7 Ballast Options
45.8 Measure Slip
45.9 Quik-Tatch? Weight Use
45.10 Rear Wheel Weight Use
45.11 Rear Wheel Weight Installation?Single Drive Wheel
45.12 Rear Wheel Weight Installation?Dual Drive Wheels
45.13 Controlling Power Hop-MFWD Tractors
45.14 Mounted Commodity Tank Use
45.15 Calculate Tractor Ballast Package
45.16 Unballasted Tractor Weight Chart
45.17 Implement and Tractor Codes
45.18 Liquid Ballast Use
46 Transport
46.1 Drive Tractor on Roads
46.2 Transport with Ballast
46.3 Towed Mass (EU 1322-2014)
46.4 Tow Loads
46.5 Tow Points
46.6 Tow Tractor
46.7 Tow Mode
46.8 Come Home Mode
46.9 Transport on Flat-Bed Carrier
46.10 Tie Down on Transport Carrier
46.11 Freeing a Mired Tractor
47 Fuel, Lubricants, and Coolant?General Information
47.1 Determine Tractor Engine Type
47.2 Minimizing the Effect of Cold Weather on Diesel Engines
47.3 Oil Filters
48 Fuel
48.1 Diesel Fuel
48.2 Supplemental Diesel Fuel Additives
48.3 Biodiesel Fuel
48.4 Lubricity of Diesel Fuel
48.5 Handling and Storing Diesel Fuel
48.6 Fill Fuel Tank
48.7 Testing Diesel Fuel
48.8 Fuel Filters
49 Diesel Exhaust Fluid (DEF)
49.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
49.2 Storing Diesel Exhaust Fluid (DEF)
49.3 Refilling Diesel Exhaust Fluid (DEF) Tank
49.4 Fill DEF Tank?FT4/Stage V Engine
49.5 Testing Diesel Exhaust Fluid (DEF)
49.6 Disposal of Diesel Exhaust Fluid (DEF)
50 Engine Oil
50.1 Diesel Engine Oil Service Interval for Operation at High Altitude
50.2 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
50.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
50.4 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
51 Engine Coolant
51.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
51.2 John Deere COOL-GARD? II Coolant Extender
51.3 Operating in Warm Temperature Climates
51.4 Water Quality for Mixing with Coolant Concentrate
51.5 Testing Coolant Freeze Point
51.6 Disposing of Coolant
52 Other Lubricants
52.1 Gear Oil
52.2 Multipurpose Extreme Pressure (EP) Grease
52.3 MFWD Axle Housing Oil
52.4 Corn Head Grease
52.5 Lubricant Storage
52.6 Alternative and Synthetic Lubricants
52.7 Mixing of Lubricants
52.8 Transmission and Hydraulic Oil
52.9 PowerShift? Transmission Recalibration
53 Service?General Information
53.1 Do Not Modify Fuel System
53.2 Bleed Fuel System
53.3 Service Sections Overview
53.4 Service Tasks Performed As Required
53.5 Identify Tractor Engine Emissions Status
53.6 Open Hood
53.7 Remove Side Panels
53.8 Access Battery Compartment
53.9 Remove Cab Rear Panel
53.10 Jack Up Tractor?Lifting Points and Support Stand Placement (EU 1322/2014)
53.11 Service and Connect STC? (Snap-to-Connect) Fittings
53.12 High-Pressure Washer Use
53.13 Identify Zinc-Flake Coated Fasteners
53.14 Unified Inch Bolt and Screw Torque Values
53.15 Metric Bolt and Screw Torque Values
54 Service?Break-In (100 Hours or Less)
54.1 Perform Break-In Checks
55 Service?Record Charts
55.1 Service Record Chart Overview
55.2 Service Interval Chart
55.3 Service Record Chart
56 Service?Clean
56.1 Access DEF Tank Drain Plug
56.2 Cleaning Diesel Exhaust Fluid (DEF) Tank
56.3 Tractor Exterior
56.4 Air Intake Valve
56.5 Clean Display
56.6 Clean Seat
56.7 Engine Cooling System
56.8 Dual Beam Radar Sensor
56.9 MFWD Axle Vent Breather
56.10 Hydraulic Oil Suction Screen
56.11 ILS? Axle Internal Tie Rod Ball Joint Boots
56.12 Implement Connector
57 Service?Check
57.1 Windshield Washer Fluid Level
57.2 Engine Coolant Level
57.3 Coolant Freeze Point
57.4 Water Separator
57.5 Engine and Exhaust Compartments
57.6 Air Conditioning System
57.7 Engine Water Pump Weep Hole
57.8 Fuel Tank Sump
57.9 MFWD Axle Housing Oil Level
57.10 MFWD Wheel Hub Oil Level
57.11 Engine Oil Level
57.12 Hydraulic System Oil Level
57.13 Tires
57.14 Mechanical Cab Suspension Components
57.15 Manually Operated Hitch
57.16 Remote Controlled Hitch
57.17 Tow Hitch (Piton Fix)
57.18 Ball-Type Tow Hitch
57.19 Pick-Up Hitch Tow-Hook
57.20 Engine Air Intake System
57.21 Seat Belts
57.22 Auxiliary Drive Belt and Drive Belt Tensioner
57.23 ILS? Upper and Lower Rod and Head End Accumulator Charge Pressure
57.24 Engine Valve Clearance
57.25 Secondary Brake System
57.26 Transmission PARK System
58 Service?Tighten
58.1 Wheel and Wheel Weight Bolts
58.2 Use Wheel Tightening Stand
58.3 Use Wheel Torque Wrench Adapter
58.4 Rear Wheel Weight Bolts
58.5 Front Wheel Bolts
58.6 Rear Drive Wheel to Cast Hub Bolts
58.7 Rear Steel Wheel to Hub Bolts
58.8 Rear Steel Wheels?Cast Hub Bolts
58.9 Rear Wheel Bolts?Heavy-Duty Cast 10-Bolt Hubs
59 Service?Change
59.1 Change Hydraulic Oil and Filters
59.2 Engine Oil and Filter
59.3 Fuel Filters
59.4 Optional Fuel Water Separator Filter Element (If Equipped)
59.5 Cab Filters
59.6 Engine Primary and Secondary Air Filters
59.7 Fuel Tank Vent Filter
59.8 SCV Pilot Valve Filter
59.9 Fan Chain Drive Housing Oil
59.10 Auxiliary Drive Belt
59.11 Differential Oil
59.12 Drain 16-Speed PowerShift? Transmission
59.13 IVT?/AutoPowr? and e23?Transmissions-Hydraulic Oil
59.14 Drain ILS?
59.15 Hydraulic Oil Filters
59.16 MFWD or ILS Wheel Hub Oil
59.17 MFWD Axle Housing Oil
59.18 Onboarding Air Coalescing Filter (If Equipped)
59.19 Air Dryer Filter
59.20 DEF Tank Vent Filter
59.21 Access In-Line DEF Filter
59.22 Change Diesel Exhaust Fluid (DEF) In-Line Filter
59.23 Access DEF Dosing Unit Filter
59.24 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
59.25 Transmission Torsional Damper
59.26 Engine Crankshaft Damper
59.27 Engine Coolant
60 Service?Lubricate
60.1 Front Axle Fittings (MFWD)
60.2 Front Axle Fittings (ILS?)
60.3 Rear Hitch
60.4 Deluxe Stabilizers
60.5 Front Hitch
60.6 Wagon Hitch
60.7 Pick-Up Hitch
60.8 Front PTO Drive Shaft
60.9 Draft Link Support Shaft Bushing
61 Service?Electrical
61.1 Service?Electrical Overview
61.2 Welding Near Electronic Control Units
61.3 Keep Electronic Control Unit Connectors Clean
61.4 Compressed Air Use
61.5 High-Pressure Washers Use
61.6 Disconnect Battery
61.7 Service Batteries and Connectors
61.8 Access Load Center Fuses
61.9 Access Front Load Center
61.10 Access Master Fuses
61.11 Access Implement Power Relay Module Relays
61.12 Handle Halogen Light Bulbs Safely
61.13 Change Halogen Bulbs
61.14 Change Front LED Headlight Assembly
61.15 Aim Halogen High-Beam Headlights
61.16 Aim LED High Beam Headlights
61.17 Aim Headlights
61.18 Change Auxiliary Driving Light
61.19 Change Cab Roof Light
61.20 Change Rear Fender Light?Rear Indicator
61.21 Change Extremity Light?Cab
61.22 Change Cab Dome Light
62 Troubleshooting?Procedures
62.1 Troubleshooting Features
62.2 Electrical System
62.3 Engine
62.4 Hitch
62.5 Hydraulic System
62.6 ILS?
62.7 Operator Enclosure
62.8 Selective Control Valve (SCV)
62.9 Steering System
62.10 Tractor Operation
62.11 Transmission
63 Troubleshooting?Diagnostic Trouble Codes (DTC)
63.1 STOP, Service, and Information Alerts on CommandCenter?
63.2 Access Diagnostic Trouble Codes
64 Service?Storage
64.1 Place Tractor in Storage
64.2 Remove Tractor from Storage
65 Specifications
65.1 Engine
65.2 Capacities
65.3 Fluorinated Greenhouse Gas
65.4 Hydraulic System
65.5 Transmission and Power Train
65.6 Hitch, Drawbar, and PTO
65.7 Electrical System
65.8 Integrated Technology
65.9 Overall Dimensions
65.10 Loads and Weights
65.11 Sound Level
65.12 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (EU 1322/2014)
65.13 Ground Speeds?16-Speed PowerShift? Transmission
65.14 Ground Speeds?e23? Transmission
65.15 Ground Speeds?IVT?/AutoPowr? Transmission
65.16 Front Loader Installation?Front Loader Mounting Frames (EU 1322/2014)
65.17 Required Emission-Related Information
65.18 Carbon Dioxide Emissions (CO?)
65.19 Third-Party Software Notifications and Licenses
66 Identification Numbers
66.1 Identification Plates
66.2 Product Identification Number (PIN)
66.3 Engine Serial Number
66.4 Cab Serial Number
66.5 Transmission Serial Number
66.6 Axle Serial Number
66.7 Keep Proof of Ownership
66.8 Keep Machines Secure
67 Change of Ownership
67.1 Subsequent Ownership
68 Predelivery
68.1 Predelivery Checklist
68.2 Delivery Checklist and Certificate
69 Index
70 John Deere Service Literature Available
70.1 Technical Information
71 John Deere Service Keeps You On The Job
71.1 John Deere Parts
71.2 The Right Tools
71.3 Well-Trained Technicians
71.4 Prompt Service
