Table of Content:
1 Introduction
1.1 Foreword
2 Glossary
2.1 Glossary
2.2 Trademarks
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Decals
4.1 Replace Safety Signs
4.2 Riders (Open Operator Station)
4.3 Use Seat Belt Properly (Cab)
4.4 Avoid Crushing, Use Seat Belt Properly (Open Operator Station)
4.5 Operate Tractor Safely (Cab)
4.6 Operate Tractor Safely (Open Operator Station)
4.7 Starter Motor (Cab)
4.8 Starter Motor (Open Operator Station)
4.9 Towing Loads Safely (Cab)
4.10 Towing Loads Safely (Open Operator Station)
4.11 Do Not Modify ROPS (Cab)
4.12 Do Not Modify ROPS (Open Operator Station)
4.13 Caution When Operating The Front Loader (Cab)
4.14 Caution When Operating The Front Loader (Open Operator Station)
4.15 Caution When Operating Rear PTO
5 Vehicle Overview
5.1 Product Identification View
6 Operator’s Manual – General Information
6.1 Scope of This Manual
6.2 Operator Manual Usage Information
6.3 Comply with Operator’s Manuals of Implement Manufacturers
6.4 Operator Training Required
7 Operating the Engine
7.1 Engines with Turbocharger
7.2 Neutral Start Switch
7.3 Starting the Engine
7.4 Start with a Booster Battery
7.5 Start the Engine with a Slave Battery
7.6 Stop the Engine
7.7 Restart a Stalled Engine
7.8 Change Engine Speeds
7.9 Fill DEF Tank (Diesel Exhaust Fluid)
8 Cold Weather Operation
8.1 Cold-Weather Operation
9 Aftertreatment Equipment (DOC/DPF)
9.1 Exhaust Filter Cleaning, General Information
9.2 Aftertreatment General Warning (Tractor with DPF System)
9.3 Access the DPF Menu on the Digital Display
9.4 DPF Soot Load, General Information
9.5 Manual Regeneration, General Information
9.6 DPF Soot Load
10 Aftertreatment Equipment (DOC/SCR)
10.1 DEF Warning Messages
10.2 DEF Level Warning
10.3 Poor DEF Quality Warning
10.4 SCR System Failures/Tampering Warning
10.5 Aftertreatment General Warning (Tractor with SCR System)
10.6 Aftertreatment General Warning (Tractor without SCR System)
11 Controls
11.1 Vehicle Controls (5GV, 5GN) (Cab)
11.2 Vehicle Controls (5GV, 5GN) (Open Operator Station)
11.3 Vehicle Controls (5GL)
11.4 Vehicle Controls
12 Instrument Panel
12.1 Instruments and Indicator Lights
12.2 Observe Instruments After Starting the Engine
12.3 Engine Oil Pressure Indicator Light
12.4 Alternator Indicator Light
12.5 Air Cleaner Indicator Light
12.6 Transmission Oil Filter Indicator Light
12.7 Coolant Temperature Gauge
12.8 Observe Fuel Level
12.9 Warm Up the Engine
12.10 Avoid Idling the Engine
12.11 Observe Engine Work and Idle Speeds
13 Digital Display
13.1 Digital Display – User Interface
13.2 User Menu
13.3 Digital Display – Initial Setup (Matching with Tractor)
13.4 Oil Service Message Reset
14 Drive Train
14.1 Drive System – Overview
15 Front-Wheel Drive
15.1 Operate Front-Wheel Drive
16 Differential Lock
16.1 Use Differential Lock
17 Brakes
17.1 Stop the Tractor
17.2 Use Brakes
17.3 Park the Tractor
17.4 Parking Brake
17.5 Chock Block
18 Transmission – General Information
18.1 Reduce Fuel Consumption
18.2 Travel Speeds
19 PowrReverser Transmission
19.1 Shifting Transmission
19.2 Operate Transmission Shift Levers
19.3 Select a Gear
19.4 Cruise Control
19.5 Manually Adjusting the Engine Speed Memory MEM1
20 Mechanical Transmission
20.1 Shifting Transmission
20.2 Operate Transmission Shift Levers
20.3 Select a Gear
21 PTO Shaft and Hitch
21.1 Maximum Lifting Force
22 Front PTO
22.1 Front PTO
23 Rear PTO
23.1 PTO Guard
23.2 Operating Instructions
23.3 Attaching PTO-Driven Implement
23.4 Operating the Rear PTO (Mechanical Version)
23.5 Operating the Rear PTO (Electrohydraulic Version)
23.6 Selecting PTO Speeds
23.7 Drawbar
24 Rear Hitch
24.1 Three-Point Hitch Components
24.2 Match Tractor Power to Implement
24.3 Hitch Control Levers
24.4 Use the Hitch Position Control
24.5 Use the Draft Control
24.6 Position Control Lever Stop
24.7 Adjust the Rate-of-Drop
24.8 Prepare the Implement
24.9 Converting Category II Hitch to Category IN or Category I
24.10 Positioning Draft Link Ends
24.11 Quick-Coupling (Hook-Type) Draft Links
24.12 Attaching Implements
24.13 Attach Implements to 3-Point Hitch
24.14 Adjust Sway Blocks
24.15 Position the Center Link
24.16 Level the Hitch
24.17 Adjust Hitch Control Lever Friction
25 Hydraulic System
25.1 Maximum Permissible Oil Withdrawal
26 Hydraulic Connections
26.1 Use Correct Hose Tips
26.2 Connecting and Disconnecting Cylinder Hoses
26.3 Connect Hose Under Pressure
26.4 Neutral Position
26.5 Retracting and Extending Cylinder
26.6 Return to Sump
27 Selective Control Valves – Controls
27.1 Selective Control Valve (SCV) Levers
27.2 Control Lever and Coupler Identification
27.3 Operating the SCV Control Levers
27.4 Double/Single Acting SCVs Conversion
27.5 Flow Divider Valve
28 Wheels and Tires
28.1 Service Tires Safely
28.2 Changing Wheels Safely
28.3 Check Implement-to-Tire Clearance
28.4 Tire Pressures
28.5 Mounting Tires
28.6 Tire Combinations
29 Front Wheels, Tires, and Tread Widths
29.1 Tighten Wheel Bolts
29.2 Adjusting Front Axle Tread Width
29.3 Check Toe-In
29.4 Adjust Toe-In
29.5 Tread Adjustment (without Front-Wheel Drive) (5GV, 5GN)
29.6 Tread Adjustment (with Front-Wheel Drive) (5GV, 5GN)
30 Steering Stop and Fender ? Settings
30.1 Steering Angle Adjustment
30.2 Direction of Tire Rotation
31 Rear Wheels, Tires, and Tread Widths
31.1 Observe Rear Wheel Tread Width Limitations
31.2 Tread Adjustment – Rear Wheels (5GV, 5GN)
32 Operator’s Station and Cab
32.1 Emergency Exits
32.2 Roll-Over Protective Structure
32.3 Operating Roll-Over Protective Structure
33 Seat Adjustment
33.1 Seat Adjustment
34 Mirrors
34.1 Mirrors (Open Operator Station)
35 Heater / Ventilation / Air Conditioning (HVAC)
35.1 Heater and Air Conditioning System Controls
35.2 Operator’s Cab Switches
36 Lights
36.1 Total View – Lights (Cab) (5GV, 5GN)
36.2 Total View – Lights (2-Post ROPS) (5GV, 5GN)
36.3 Total View – Lights (2-Post ROPS) (5GL)
36.4 Light Switch and Horn Switch
36.5 Light Switch and Turn Signal Switch
36.6 Low Beam and High Beam Indicator Light
36.7 Wake up Mode
36.8 Front Clearance Lights, Turn Signal Lights, and Tail Lights
36.9 Turn Signal Lights
36.10 Hazard Warning Light Switch (Amber Warning Light Switch)
36.11 Worklight Switches (Open Operator Station)
36.12 Worklight Switches (Cab)
36.13 Beacon Light (Optional)
36.14 H4 Farm Headlights (Optional)
36.15 Dome Light
37 Power Outlet Sockets
37.1 Seven-Terminal Trailer Socket
38 Accessories
38.1 Sun Visor
38.2 Tool Box
39 Performance Ballast
39.1 Select Ballast
39.2 Ballast Limitations
39.3 Measuring Rear Wheel Slip
39.4 Installing Front Weights
39.5 Ballasting Front Wheel Drive Tractors
39.6 With Weight in 3-Point Hitch
39.7 Rear Wheel Weights
39.8 Front Weights
40 Transport
40.1 Transporting the Tractor
40.2 Towing Tractor
40.3 Tow the Tractor
40.4 Driving Tractor on Public Roads
41 Fuel, Lubricants, Hydraulic Oil and Coolant
41.1 Oilscan? and CoolScan?
42 Diesel Fuel
42.1 Diesel Fuel
42.2 Handling and Storing Diesel Fuel
42.3 Lubricity of Diesel Fuel
42.4 Testing Diesel Fuel
42.5 Biodiesel Fuel
42.6 Minimizing the Effect of Cold Weather on Diesel Engines
43 Engine Oil
43.1 John Deere Break-In Plus? Engine Oil
43.2 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
43.3 Engine Oil and Filter Service Intervals
44 Engine Coolant
44.1 Diesel Engine Coolant
44.2 Operating in Warm Temperature Climates
44.3 Water Quality for Mixing with Coolant Concentrate
44.4 Testing Diesel Engine Coolant
44.5 Supplemental Coolant Additives
45 Other Lubricants
45.1 Transmission and Hydraulic Oil
45.2 Front-Wheel Drive Axle Oil
45.3 Grease for Automated Lubrication Systems
45.4 Mixing of Lubricants
45.5 Lubricant Storage
45.6 Alternative and Synthetic Lubricants
46 Service ? General Information
46.1 Safe Maintenance and Cleaning
46.2 Using High-Pressure Washers
46.3 Avoid High-Pressure Fluids
46.4 Storing Fuel
46.5 Ultra Low Sulfur Fuel
46.6 When Performing Services
46.7 Lubrication and Periodic Service
46.8 Oil Service Message Reset (5075 Model)
46.9 Use Correct Lubricant
46.10 Other Service Jobs
46.11 Oil Vapor Recirculation System Maintenance
46.12 Turbo Compressor Maintenance
46.13 Overhaul Injection Pump
46.14 Fuel Filters
46.15 Tire Pressures
46.16 Inspect All Tires
46.17 Service Tractor Safely
46.18 Air Intake System Components
46.19 Fuel System Components
46.20 Engine Cooling System Components
46.21 Air-Conditioning System
46.22 Open Hood (Version 1)
46.23 Open Hood (Version 2)
46.24 Jack Up the Tractor – Lifting Points
46.25 Metric Bolt and Screw Torque Values
46.26 Unified Inch Bolt and Screw Torque Values
47 Service Intervals
47.1 Information
47.2 Service (Daily / Every 10, 50, 250, 500, and 750 Hours)
47.3 Service (Every 1000, 1250, 1500, 3000 Hours and Annually Services)
47.4 Information on Changing Engine Oil
47.5 Engine Oil and Filter Change
47.6 Engine Oil and Filter Change
47.7 Engine Oil and Filter Change
47.8 Engine Oil and Filter Change
47.9 Engine Oil and Filter Change
47.10 Engine Air Cleaner and Cab Air Filters, Service
47.11 Engine Air Cleaner and Cab Air Filters, Service
47.12 Activated Carbon Filters in Cab, Service (If Equipped)
47.13 Activated Carbon Filters in Cab, Service (If Equipped)
47.14 Activated Carbon Filters in Cab, Service (If Equipped)
47.15 Activated Carbon Filters in Cab, Service (If Equipped)
47.16 Cooling System, Service
47.17 Cooling System, Service
47.18 Yearly Service
47.19 Yearly Service
47.20 50 Hour Service
47.21 250 Hour Service
47.22 500 Hour Service
47.23 750 Hour Service
47.24 1000 Hour Service
47.25 1250 Hour Service
47.26 1500 Hour Service
47.27 1750 Hour Service
47.28 2000 Hour Service
47.29 2250 Hour Service
47.30 2500 Hour Service
47.31 2750 Hour Service
47.32 3000 Hour Service
47.33 3250 Hour Service
47.34 3500 Hour Service
47.35 3750 Hour Service
47.36 4000 Hour Service
47.37 4250 Hour Service
47.38 4500 Hour Service
47.39 4750 Hour Service
47.40 5000 Hour Service
47.41 5250 Hour Service
47.42 5500 Hour Service
47.43 5750 Hour Service
47.44 6000 Hour Service
47.45 Information About Further Services
47.46 Record for Further Services
48 Service ? Cleaning
48.1 Cleaning the Dust Unloading Valve
48.2 Clean Radiator and Oil Cooler
48.3 Radiators, Cleaning
48.4 Clean Air-Conditioning System Condenser
48.5 Service Air Cleaner at Regular Intervals
48.6 Clean Cab Air Filters
48.7 Clean Vehicle of Hazardous Pesticides
49 Service ? Electrical System
49.1 Observe Electrical Service Precautions
49.2 Battery Cut-off Switch (If Equipped)
49.3 Battery
49.4 Bulb Replacement ? Safety Instructions
49.5 Checking on Lights
49.6 Adjusting the Head Lights
49.7 Replace Head Light Bulbs
49.8 Replace Clearance, Brake, Turn Signal Light Bulbs and SMV Lights
49.9 Replace Rear Working Light Bulb
49.10 Checking of the charge state of the battery
49.11 Starting Motor
49.12 Fuse Box
49.13 Fuse Check
49.14 Main Fuses and Relays (5GV, 5GN)
49.15 Fuse Box (Cab) (If Equipped) (5GV, 5GN)
49.16 Relays (Cab) (5GV, 5GN)
49.17 Main Fuses and Relays (5GL)
49.18 Engine Fuses and Relays (5GV, 5GN)
49.19 Engine Fuses and Relays (5GL)
49.20 Main Power Supply Fuses and Additional Relays (5GL)
49.21 Fuse and Relay Box (Mechanical Transmission) (5GV, 5GN)
49.22 Fuse and Relay Box (PowrReverser Transmission) (5GV, 5GN)
50 Maintenance ? Checking Hardware Torques
50.1 Tighten Wheel Bolts
50.2 After the First 4 and 8 Hours of Operation
50.3 Mounting Bolts of Operator’s Cab / Open Station and ROPS
51 Service ? Checks
51.1 Check Torque of Wheel and Rim Bolts
51.2 Check Engine Oil Level
51.3 Check the Fuel Filter
51.4 Check Coolant Level
51.5 Check Transmission/Hydraulic System Oil Level
51.6 Check Brake System Oil Level
51.7 Check Brake Operation
51.8 Check Oil Levels in Front-Wheel Drive Axle
51.9 Check Neutral Start System ? 24/12 Transmission
51.10 Check Neutral Start System ? 12/12 Transmission
51.11 Check Belt Wear and Belt Tension
51.12 Check Torque of Drawbar Attaching Screws
51.13 Check Clutch Pedal Free Travel
51.14 Check Hoses and Hose Clamps
51.15 Check Components of Drawbar and Trailer Hitches
51.16 Check Engine Idle Speeds
51.17 Check and Lubricate Front Axle Pivot Pin
51.18 Check the Seat Belt (If Equipped)
51.19 Check Condition of Diesel Engine Coolant
51.20 Radiator Pressure Cap Check
51.21 Inspect Hydraulic Hoses
51.22 Inspect Alternator
52 Service ? Change
52.1 Change Engine Oil
52.2 Change Engine Oil and Replace Oil Filter
52.3 Changing Oil in Front-Wheel Drive Axle
52.4 Change Oil in Front-Wheel Drive Axle Housing
52.5 Change Oil in Front-Wheel Drive Final Drives
52.6 Change Brake System Oil
52.7 Change Engine Coolant
52.8 Change Cooling System Coolant
52.9 Replace Transmission Hydraulic Oil and Filters/Screen
52.10 Replace Transmission/Hydraulic Oil Filter Cartridge (First and Second Pump) (5GL)
52.11 Replace Cab Air Filters
52.12 Replace Diesel Particulate Filter
52.13 Replace Alternator Drive Belt
52.14 Replace Water Pump
52.15 Replace Fuel Filter
52.16 Replace and Clean Engine Air Filter
52.17 Drain Water and Sediment from Fuel Filter
52.18 Drain Water and Sediment from Fuel Tank
52.19 Replace Transmission/Hydraulic Oil Filter Cartridge (Third Pump) (5GL)
52.20 Drain Sediment from DEF (Diesel Exhaust Fluid) Tank
52.21 Replace the Supply Module Filter
52.22 Replace DOC SCR Filters
52.23 Adjust PTO Clutch Linkage
53 Service ? Lubrication
53.1 Lubricate Front-Wheel Drive Axle
53.2 Lubricate Front Axle King Pins
53.3 Lubricate 3-Point Hitch
53.4 Lubricate Hub Bearings (Tractors Without Front-Wheel Drive)
53.5 Lubricate Draft Links
53.6 Lubricate Rear Axle Bearings
53.7 Lubricate
54 Troubleshooting
54.1 Diagnostic Trouble Codes – Operator Information
54.2 Engine Troubleshooting
54.3 Transmission Troubleshooting
54.4 Brakes Troubleshooting
54.5 Rockshaft and Quick-Coupler 3-Point Hitch Troubleshooting
54.6 Remote Hydraulic Cylinders Troubleshooting
54.7 Electrical System Troubleshooting
55 Storage
55.1 Storage for Long Period
55.2 Remove Tractor from Storage
56 Specifications
56.1 Engine
56.2 JD After Treatment System
56.3 DPF Soot Load
56.4 Transmission
56.5 Hydraulic System
56.6 Electrical System
56.7 Fuel System
56.8 Capacities
56.9 Sound Level
56.10 Brakes
56.11 Three-Point Hitch
56.12 Loads and Weights
56.13 Towable Loads
56.14 Shipping Weights
56.15 Maximum Permissible Axle Loads and Total Weights
56.16 Maximum Permissible Axle Load in Relation to Tires (Normal Operation)
56.17 Load Capacity of Tires with Front Loader
56.18 Dimensions (Cab) (5GV, 5GN)
56.19 Dimensions (ROPS) (5GV, 5GN)
56.20 Dimensions (Open Operator Station) (5GL)
56.21 Safety Note Regarding the Subsequent Installation of Electrical and Electronic Appliances and/or Components
56.22 How to Calculate Maximum Permissible Download on Trailer Hitch
56.23 How to Calculate Permissible Mass
56.24 Vibration
56.25 Safety Note Regarding the Subsequent Installation of Electrical and Electronic Appliances and/or Components
56.26 Limited Battery Warranty
56.27 FPT ? EPA Non-road Emissions Control Warranty Statement?Compression Ignition
56.28 FPT ? CARB Non-road Emissions Control Warranty Statement?Compression Ignition
56.29 Emissions Control System Certification Label
57 Serial Numbers
57.1 Identification Plates
57.2 Product Identification Number
57.3 Engine Serial Number
57.4 Transmission Serial Number
57.5 Front Axle Serial Number
58 Change of Ownership
58.1 List of Owners
59 Service ? Predelivery Inspection
59.1 Service Procedure
59.2 Copy for Dealer
59.3 Copy for Owner
60 John Deere Service Keeps You On the Job
60.1 John Deere Parts
60.2 The Right Tools
60.3 Well-Trained Technicians
60.4 Prompt Service
