John Deere 9rx Tractors Operator Manuals OMTR129376

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Fire Prevention
3.9 In Case of Fire
3.10 Avoid Static Electricity Risk When Refueling
3.11 Use Foldable ROPS and Seat Belt Properly
3.12 Stay Clear of Rotating Drivelines
3.13 Use Steps and Handholds Correctly
3.14 Read Operator?s Manuals for ISOBUS Controllers
3.15 Use Seat Belt Properly
3.16 Vibration
3.17 Operating the Tractor Safely
3.18 Avoid Backover Accidents
3.19 Limited Use in Forestry Operation
3.20 Operating the Loader Tractor Safely
3.21 Keep Riders Off Machine
3.22 Passenger Seat
3.23 Use Safety Lights and Devices
3.24 Towing Trailers/Implements Safely
3.25 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.26 Freeing a Mired Machine
3.27 Avoid Contact with Agricultural Chemicals
3.28 Handle Agricultural Chemicals Safely
3.29 Handling Batteries Safely
3.30 Avoid Heating Near Pressurized Fluid Lines
3.31 Remove Paint Before Welding or Heating
3.32 Handle Electronic Components and Brackets Safely
3.33 Practice Safe Maintenance
3.34 Avoid Hot Exhaust
3.35 Clean Exhaust Filter Safely
3.36 Work In Ventilated Area
3.37 Support Machine Properly
3.38 Prevent Machine Runaway
3.39 Park Machine Safely
3.40 Transport Tractor Safely
3.41 Service Cooling System Safely
3.42 Service Accumulator Systems Safely
3.43 Service Tires Safely
3.44 Service Front-Wheel Drive Tractor Safely
3.45 Tightening Wheel Retaining Bolts/Nuts
3.46 Avoid High-Pressure Fluids
3.47 Do Not Open High-Pressure Fuel System
3.48 Store Attachments Safely
3.49 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Passenger Seat
4.4 Hinge Area
4.5 Park Brake (Stored Energy)
4.6 Track Accumulators
4.7 Rear Hitch Remote Switch (If Equipped) [Ag] 4.8 Rear SCVs
5 Vehicle Overview
5.1 9RX Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Max Engine Speed
6.5 Engine Settings?Exhaust Filter System Overview
6.6 Engine Settings?AUTO Exhaust Filter Cleaning
6.7 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Parked Filter Cleaning
6.9 Engine Settings?Decelerator
6.10 Engine Settings?Advanced
6.11 Required Machine Stop Warning
6.12 Engine Fuel System and Power Rating
6.13 Battery Disconnect Switch
6.14 Start the Engine
6.15 Theft Deterrent Systems
6.16 Run the Engine
6.17 Stop the Engine
6.18 Restart Engine That Has Run Out of Fuel
6.19 Reduce Fuel Consumption
6.20 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?With Starting Aid
7.2 Change Starting Fluid Canister
7.3 Engine Coolant Heater Use
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
8.4 Restored Operation Option
9 Front Console
9.1 Front Console
9.2 Adjust Steering Wheel and Column
9.3 Operate Horn
9.4 Operate Wipers and Washers
9.5 Key Switch
9.6 Operate Turn Signals
9.7 Pedals
9.8 Operate Lights
9.9 Differential Lock Switch
10 Corner Post Display
10.1 Corner Post Display
11 CommandARM Controls
11.1 CommandARM
11.2 CommandARM Hitch Controls [Ag] 11.3 CommandARM SCV Control Levers
11.4 CommandARM PTO Control Levers [Ag] 11.5 CommandARM Climate, Radio, and Lighting Controls
11.6 CommandARM Controls?Left Side
11.7 CommandARM Secondary Brake Lever
11.8 CommandARM Navigation Bar
11.9 Adjust CommandARM Position
12 CommandCenter
12.1 Generation 4 Display
12.2 Rear Hitch or PTO Availability
12.3 Machine Settings Overview
12.4 Navigate Generation 4 CommandCenter
12.5 Compatible Universal Displays
12.6 Power Display On and Off
12.7 Change Pages and Values
12.8 Factory and Service ADVISOR Installed Onscreen Help
12.9 Radar Calibration
12.10 Slip Calibration
12.11 Steering Settings?Access
12.12 Steering Settings
12.13 Steering Settings?Steering Wheel Resistance
12.14 Controls Setup
12.15 Install Video Display Camera
13 Intelligent Total Equipment Control (iTEC)
13.1 CommandARM Control Functions
13.2 iTEC Station Description (EU 1322/2014)
13.3 CommandCenter Pages Descriptions and Functions
13.4 Status Area
13.5 All Sequence Page
13.6 Add New Sequence
13.7 Sequence Step Status
13.8 Edit or Remove Sequence
13.9 Sequence Sets Page
13.10 Perform Sequence
13.11 Recommendations (AutoLearn)
13.12 iTEC Functions?Efficiency Manager
14 Tractor-Implement Automation (TIA)
14.1 TIA?General Information
14.2 Activate TIA Equipment
14.3 Operate TIA
14.4 PTO Requirements [Ag] 14.5 SCV Requirements
14.6 PowerShift Transmission Requirements
14.7 AutoTrac Guidance Requirements
14.8 Rear Hitch Requirements [Ag] 15 Drivetrain
15.1 Drivetrain Overview
15.2 Differential Lock
15.3 Drivetrain Protection
16 Brakes
16.1 Trailer Brake System Settings?Access
16.2 Trailer Brake System Settings
16.3 Trailer Brake System Settings?Brake Gain
16.4 Trailer Brake System Settings?Pre-Brake Offset
16.5 Trailer Brake System Settings?Trailer Brake Test
16.6 Trailer Brake System Settings?Advanced
16.7 Brake Use
16.8 Hydraulic Trailer Brakes (If Equipped)
17 Transmission?General Information
17.1 Transmission Settings?Access Advanced
17.2 Transmission Settings?Advanced
17.3 Warm-Up Transmission-Hydraulic System
17.4 Backup Alarm
18 e18 PowerShift Transmission
18.1 Operate Transmission?e18
18.2 Shift Transmission?e18
18.3 e18 Set Speeds and Efficiency Manager
18.4 e18 Transmission Settings?Access
18.5 e18 Transmission Settings
18.6 e18 Transmission Settings?Mode
18.7 e18 Transmission Settings?Custom
18.8 e18 Transmission Settings?Droop
18.9 e18 Transmission Settings?ECO
18.10 e18 Transmission Settings?Max Speeds
19 PTO?General Information [Ag] 19.1 PTO Settings?Access
19.2 PTO Settings
19.3 PTO Settings?Advanced
19.4 PTO Settings?Engagement Rate
19.5 PTO Settings?Rear PTO Speed Limit
19.6 PTO Settings?PTO Out-of-Seat
19.7 Operating Instructions (EU 1322/2014)
19.8 Operate PTOs
19.9 External PTO Switches
19.10 Select Correct Engine Speed
20 Rear PTO [Ag] 20.1 Use PTO Shield (If Equipped)
20.2 Attach PTO-Driven Implement [Ag] 21 Rear Hitch [Ag] 21.1 Hitch Lift Capacities
21.2 Rear Hitch Settings?Access
21.3 Rear Hitch Settings
21.4 Rear Hitch Settings?Upper Limit
21.5 Rear Hitch Settings?Drop Rate
21.6 Rear Hitch Settings?Raise Rate
21.7 Rear Hitch Settings?Load Depth
21.8 Rear Hitch Settings?Slip Sensitivity
21.9 Rear Hitch Settings?Position
21.10 Rear Hitch Settings?Position Control
21.11 Rear Hitch Settings?Draft Control
21.12 Hitch Control Lever Adjustments
21.13 Hitch Depth Set Point
21.14 Float Operation
21.15 Rear Hitch Components
21.16 External Hitch Switches
21.17 Hitch Manual Lowering
21.18 Adjust Sway Blocks
21.19 Attach Implement to Quick-Hitch
21.20 Detach Implement from Quick-Hitch
21.21 Adjust Implement Level
21.22 Adjust Lateral Float
21.23 Hitch Conversion?Category 4/4N Convertible Quick-Hitch
21.24 Convert Category 4N/3 Convertible Quick-Hitch Lower Hooks
21.25 Convert Category 4N/3 Convertible Quick-Hitch Upper Hook
22 Drawbar
22.1 Drawbar Load Limitations [Ag] 22.2 Scraper Applications [Ag] 22.3 Scraper Applications [Scraper] 22.4 Calculate Static Vertical Drawbar Load
22.5 Calculate Vertical Drawbar Load Distance Behind Rear Axle
22.6 Adjust Drawbar [Ag] 22.7 Install Drawbar or Quick-Attach in Short Drawbar Support [Scraper] 22.8 Short Scraper Drawbar Conversion [Scraper] 22.9 Tow Cable [Scraper] 22.10 Install Clevis Assembly?Category 5 Drawbar [Ag] 22.11 Clevis Assembly Use [Ag] 22.12 Use Correct Drawbar Pin?Category 5 to 4 [Ag] 23 Hydraulics?General Information
23.1 Hydraulic System Overview
23.2 Hydraulic Option Connector
24 Selective Control Valves
24.1 SCV Settings?Access
24.2 SCV Settings
24.3 SCV Settings?Standard Mode
24.4 SCV Settings?Independent Mode
24.5 SCV Settings?Feature Mode
24.6 SCV Settings?Flow Adjustment
24.7 SCV Settings?Time Adjustment
24.8 SCV Settings?Advanced
24.9 SCV Settings?Activating Independent Mode
24.10 SCV Settings?Automation
24.11 SCV Settings?Assignment
24.12 SCV Settings?Flow Adjustment Sensitivity
24.13 SCV Settings?Flow Assist
24.14 SCV Control Lever Adjustments
24.15 Total SCV Flow
24.16 Flow Sharing
25 Hydraulic Connections
25.1 Connect/Disconnect Hydraulic Hoses
25.2 Implements Requiring Large Volumes of Hydraulic Oil
25.3 Using Load-Sensing Hydraulic System?Power-Beyond
25.4 Component Identification and Location [Ag] 25.5 Using Hydraulic Spray Pumps [Ag] 25.6 Implement Connection Example [Ag]: Closed Center Valve and Pump at High Pressure?Less Hitch
25.7 Implement Connection Example [Ag]: Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip
25.8 Implement Connection Example [Ag]: Planter with Vacuum Motor and Return Line to Motor Return?With Hitch and Implement Lift Assist
25.9 Implement Connection Example [Ag]: Pressure Control Valve Applications?Less Hitch (Grain Drills or Air Seeders with Constant Down-Pressure System)
25.10 Implement Connection Example?High-Flow Hydraulics [Ag]: Implement Control Valves?Less Hitch
25.11 Component Identification and Location [Scraper] 25.12 Scraper Hydraulic Hose Tips [Scraper] 25.13 Implement Connection Example [Scraper]: Pulling 1, 2, and 3 Scrapers
26 TouchSet Depth Control
26.1 TouchSet Depth Control Settings and Adjustments
26.2 Connect/Disconnect the Implement Position Connector
27 Laser Scraper Control [Ag] 27.1 Laser Scraper?Scrapers Equipped with Scraper Control Unit
28 Scraper Information [Scraper] 28.1 Scraper Operation Cycle
28.2 Weight Transfer Limits
28.3 Scraper/Tractor Attachment
28.4 Loading Techniques
28.5 Connect AutoLoad Harness
28.6 AutoLoad Settings?Access
28.7 AutoLoad Settings
28.8 AutoLoad Settings?Scraper Status
28.9 AutoLoad Settings?Initial Draft
28.10 AutoLoad Settings?Scraper Position
28.11 AutoLoad Settings?Average Draft
28.12 AutoLoad Settings?Advanced
28.13 AutoLoad Settings?Scraper Dimensions
29 Tracks?General Information
29.1 General Track Use Guidelines
29.2 Tracks Service
30 Seats
30.1 Adjust Air Seat
30.2 Operator Presence Sensor
30.3 Adjust Passenger Seat
31 Mirrors
31.1 Adjust Mirrors
32 Lights
32.1 Light Identification
32.2 Lights Settings?Access
32.3 Lights Settings
32.4 Lights Settings?Field Lights Presets
32.5 Lights Settings?Hood/Belt Line Lights
32.6 Lights Settings?Advanced
32.7 Hazard and Extremity Lights
32.8 Beacon Light
32.9 7-Pin Outlet
33 Accessories
33.1 Right-Hand Side Console
33.2 CommandARM Storage
33.3 Right-Hand Front Corner Post
33.4 Left-Hand Rear Corner Post
33.5 Right-Hand Rear Corner Post
33.6 Refrigerator and Cool/Storage Box
33.7 Sunshade
33.8 Storage Compartments
33.9 Monitor Bracket Mounts
33.10 Emergency Exit
33.11 Install Business Band/Citizens Band (CB) Antenna and/or Radio
33.12 Mount StarFire Receiver
33.13 Mount RTK (Real-Time Kinematic) Radio
33.14 Implement Connector
33.15 RS232 Serial Communication Connection
33.16 AutoLoad Harness Connector [Scraper] 33.17 Chain Box
34 HVAC
34.1 HVAC Settings?Access
34.2 HVAC Settings
34.3 HVAC Settings?Climate Control Automation
34.4 HVAC Settings?Set Temperature
34.5 HVAC Settings?Air Flow Mode
34.6 HVAC Settings?Fan Speed
34.7 HVAC Settings?Air Conditioning
35 Performance Ballasting
35.1 General Ballasting Information
35.2 General Guidelines
35.3 General Weight Split Guidelines
35.4 Ballast Options
35.5 Measure Slip
35.6 Quik-Tatch Weight Use
35.7 Idler Weight Use
35.8 Implement Guidelines
35.9 Calculate Tractor Ballast Package
35.10 Unballasted Tractor Weight Chart
36 Transport
36.1 Driving Tractor on Roads
36.2 Extended Road Transport
36.3 Towed Mass (EU 1322/2014)
36.4 Towed Loads and Transport with Ballast
36.5 Transport Rear Mounted Implements with Ballast
36.6 Safety Chains Use
36.7 Tow Points
36.8 Carrier Transport
36.9 Tow Mode?Engine Will Start
36.10 Tow Mode?Engine Will Not Start
36.11 Freeing a Mired Tractor
37 Fuel, Lubricants, and Coolant?General Information
37.1 Determine Tractor Engine Type
37.2 Minimizing the Effect of Cold Weather on Diesel Engines
37.3 Oil Filters
38 Fuel
38.1 Diesel Fuel
38.2 Supplemental Diesel Fuel Additives
38.3 Biodiesel Fuel
38.4 Lubricity of Diesel Fuel
38.5 Handling and Storing Diesel Fuel
38.6 Fill Fuel Tank
38.7 Testing Diesel Fuel
38.8 Fuel Filters
39 Diesel Exhaust Fluid (DEF)
39.1 Fill DEF Tank?Final Tier 4/Stage V Engine
39.2 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
39.3 Storing Diesel Exhaust Fluid (DEF)
39.4 Refilling Diesel Exhaust Fluid (DEF) Tank
39.5 Testing Diesel Exhaust Fluid (DEF)
39.6 Disposal of Diesel Exhaust Fluid (DEF)
40 Engine Oil
40.1 Diesel Engine Oil Service Interval for Operation at High Altitude
40.2 John Deere Break-In Plus Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
40.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
40.4 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
41 Engine Coolant
41.1 Diesel Engine Coolant (Engine with Wet Sleeve Cylinder Liners)
41.2 John Deere Cool-Gard II Coolant Extender
41.3 Operating in Warm Temperature Climates
41.4 Water Quality for Mixing with Coolant Concentrate
41.5 Testing Coolant Freeze Point
41.6 Disposing of Coolant
42 Other Lubricants
42.1 Transmission and Hydraulic Oil
42.2 Transmission and Hydraulic Oil Use
42.3 Multipurpose Extreme Pressure (EP) Grease
42.4 Lubricant Storage
42.5 Mixing of Lubricants
42.6 Alternative and Synthetic Lubricants
43 Service?General Information
43.1 Service Sections Overview
43.2 Service Tasks Performed As Required
43.3 Identify Tractor Engine Emissions Status
43.4 Open Hood
43.5 Open Hood (If Equipped)
43.6 Remove Engine Access Panel
43.7 Remove Front Engine Side Shield
43.8 Remove Rear Engine Side Shield
43.9 Remove Cab Rear Panel
43.10 Access Battery Compartment
43.11 Jack Up Tractor?Lifting Points and Support Stand Placement (EU 1322/2014)
43.12 Service and Connect STC (Snap-to-Connect) Fittings
43.13 High-Pressure Washer Use
43.14 Transmission Calibration
43.15 Abort Transmission Calibration
43.16 Do Not Modify Fuel System
43.17 Bleed Fuel System
43.18 Identify Zinc-Flake Coated Fasteners
43.19 Metric Bolt and Screw Torque Values
43.20 Unified Inch Bolt and Screw Torque Values
44 Service?Break-In (100 Hours or Less)
44.1 Perform Break-In Services
44.2 Perform Track Systems Break-In
45 Service?Record Charts
45.1 Service Record Chart Overview
45.2 Service Interval Chart
45.3 Service Record Chart
46 Service?Clean
46.1 Cleaning Diesel Exhaust Fluid (DEF) Tank
46.2 DEF Tank Filler Neck Filter
46.3 Tractor Exterior
46.4 Clean Display
46.5 Engine Cooling System
46.6 Dual Beam Radar Sensor
46.7 Optional Fuel Water Separator
46.8 Implement Connector
47 Service?Check
47.1 Engine Coolant Level
47.2 Engine Coolant Freeze Point
47.3 Water Separator
47.4 Engine and Exhaust Compartments
47.5 Air Conditioning System
47.6 Engine Water Pump Weep Hole
47.7 Fuel Tank Sump
47.8 Engine Oil Level
47.9 Hydraulic System Oil Level
47.10 Track Alignment
47.11 Track Tension
47.12 Track Wear and Trash Buildup
47.13 Undercarriage
47.14 Cab Suspension Bushings
47.15 Undercarriage Articulation Bumper Stops
47.16 Drive, Mid-Rollers, and Idler Wheels
47.17 Mid-Rollers and Idler Wheel Hub Oil Level
47.18 Drive Wheel Scraper Clearance
47.19 Secondary Brake
47.20 Transmission PARK System
47.21 Engine Air Intake System
47.22 Seat Belts
47.23 Engine Auxiliary Drive Belt and Drive Belt Tensioner
47.24 Engine Valve Clearance
47.25 Front Driveshaft Health (FDH) Sensor System
47.26 Drawbar Sensor Calibration [Scraper] 47.27 Drawbar Wear
47.28 Engine Brake
48 Service?Tighten
48.1 Mid-Roller, Drive, and Idler Wheel Fasteners
48.2 Drawbar Support Cap Screws
49 Service?Change
49.1 Engine Auxiliary Drive Belt
49.2 Engine Oil and Filter
49.3 Fuel Filters
49.4 Optional Fuel Water Separator Filter Element
49.5 Fuel Tank Vent Filters
49.6 Cab Filters
49.7 Engine Primary and Secondary Air Filters
49.8 SCV Pilot Valve Filter
49.9 Diesel Exhaust Fluid (DEF) Tank Vent Filter
49.10 Access Diesel Exhaust Fluid (DEF) In-Line Filter
49.11 Change Diesel Exhaust Fluid (DEF) In-Line Filter
49.12 Access Diesel Exhaust Fluid (DEF) Dosing Unit Filter
49.13 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
49.14 Hydraulic System Oil and Filters
49.15 Engine Coolant
49.16 Engine Crankshaft Damper
49.17 Front Drive Shaft U-Joints
50 Service?Lubricate
50.1 Heavy Duty Lift Link Pins (Optional)
50.2 Hinge Pins
50.3 Steering Pins
50.4 PTO Drive Shaft
50.5 Track Tension Cylinder
50.6 Heavy-Duty Gudgeon Bearings
50.7 Lower Drive Line Bearings
50.8 Rear Hitch
50.9 Lift Cylinders and Rockshaft
51 Service?Electrical
51.1 Service?Electrical Overview
51.2 Welding Near Electronic Control Units
51.3 Keep Electronic Control Unit Connectors Clean
51.4 Compressed Air Use
51.5 High-Pressure Washer Use
51.6 Disconnect Battery
51.7 Service Batteries and Connections
51.8 Load Center?Cab
51.9 Load Center?Front
51.10 Access Master Fuses
51.11 Access Implement Power Relay Module Relays
51.12 Handle Halogen Light Bulbs Safely
51.13 Change Halogen Bulbs
51.14 Change Front HID/LED Light Assembly
51.15 Adjust Front Grille Lights
51.16 Aim Headlights
51.17 Change Brake or Turn Signal Light Bulb
51.18 Change Cab Roof Light
51.19 Change Extremity Light?Cab
51.20 Change Cab Dome Light
52 Troubleshooting?Procedures
52.1 Troubleshooting Features
52.2 Electrical System
52.3 Engine
52.4 Hitch
52.5 Hydraulic System
52.6 Operator?s Station
52.7 Selective Control Valve (SCV)
52.8 Steering System
52.9 Tractor Operation
52.10 Transmission
53 Troubleshooting?Diagnostic Trouble Codes (DTC)
53.1 STOP, Service, and Information Alerts on CommandCenter
53.2 Access Diagnostic Trouble Codes
54 Service?Storage
54.1 Place Tractor in Storage
54.2 Remove Tractor from Storage
55 Specifications
55.1 Engine
55.2 Capacities
55.3 Fluorinated Greenhouse Gas
55.4 Hydraulic System
55.5 Transmission and Drivetrain
55.6 PTO [Ag], Hitch [Ag], and Drawbar
55.7 Electrical System
55.8 Integrated Technology
55.9 Overall Dimensions
55.10 Tractor Loads/Weights
55.11 Sound Level (EU 1322/2014)
55.12 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (EU 1322/2014)
55.13 Ground Speeds?e18 PowerShift Transmission
55.14 Required Emission-Related Information
55.15 Carbon Dioxide Emissions (CO?)
55.16 Third-Party Software Notifications and Licenses
56 Identification Numbers
56.1 Identification Plates
56.2 Product Identification Number
56.3 Engine Serial Number
56.4 Cab Serial Number
56.5 Transmission Serial Number
56.6 PTO Drop Box Serial Number [Ag] 56.7 PTO Clutch Serial Number [Ag] 56.8 Track Serial Numbers
56.9 Keep Proof of Ownership
56.10 Keep Machines Secure
57 Change of Ownership
57.1 Subsequent Ownership
58 Predelivery
58.1 Predelivery Checklist
58.2 Delivery Checklist and Certificate
59 Index
60 John Deere Service Literature Available
60.1 Technical Information
61 John Deere Service Keeps You On The Job
61.1 John Deere Parts
61.2 The Right Tools
61.3 Well-Trained Technicians
61.4 Prompt Service