John Deere 9rt Tractors Operator Manuals OMRE596860

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Fire Prevention
3.9 In Case of Fire
3.10 Avoid Static Electricity Risk When Refueling
3.11 Use Foldable ROPS and Seat Belt Properly
3.12 Stay Clear of Rotating Drivelines
3.13 Use Steps and Handholds Correctly
3.14 Read Operator?s Manuals for ISOBUS Controllers
3.15 Use Seat Belt Properly
3.16 Vibration
3.17 Operating the Tractor Safely
3.18 Avoid Backover Accidents
3.19 Limited Use in Forestry Operation
3.20 Operating the Loader Tractor Safely
3.21 Keep Riders Off Machine
3.22 Passenger Seat
3.23 Use Safety Lights and Devices
3.24 Towing Trailers/Implements Safely
3.25 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.26 Freeing a Mired Machine
3.27 Avoid Contact with Agricultural Chemicals
3.28 Handle Agricultural Chemicals Safely
3.29 Handling Batteries Safely
3.30 Avoid Heating Near Pressurized Fluid Lines
3.31 Remove Paint Before Welding or Heating
3.32 Handle Electronic Components and Brackets Safely
3.33 Practice Safe Maintenance
3.34 Avoid Hot Exhaust
3.35 Clean Exhaust Filter Safely
3.36 Work In Ventilated Area
3.37 Support Machine Properly
3.38 Prevent Machine Runaway
3.39 Park Machine Safely
3.40 Transport Tractor Safely
3.41 Service Cooling System Safely
3.42 Service Accumulator Systems Safely
3.43 Service Tires Safely
3.44 Service Front-Wheel Drive Tractor Safely
3.45 Tightening Wheel Retaining Bolts/Nuts
3.46 Avoid High-Pressure Fluids
3.47 Do Not Open High-Pressure Fuel System
3.48 Store Attachments Safely
3.49 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Passenger Seat
4.4 Rear Hitch Remote Switch (If Equipped) [Ag] 4.5 Park Brake (Stored Energy)
4.6 Track Accumulators
4.7 Rear SCVs?With Hitch [Ag] 4.8 Rear SCVs?Without Hitch with Standard Drawbar [Ag] 4.9 Rear SCVs?Without Hitch and with Wide-Swing Drawbar [Ag] 5 Vehicle Overview
5.1 9RT Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Max Engine Speed
6.5 Engine Settings?Exhaust Filter System Overview
6.6 Engine Settings?AUTO Exhaust Filter Cleaning
6.7 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Parked Filter Cleaning
6.9 Engine Settings?Decelerator
6.10 Engine Settings?Advanced
6.11 Required Machine Stop Warning
6.12 Engine Fuel System and Power Rating
6.13 Battery Disconnect Switch
6.14 Start the Engine
6.15 Theft Deterrent Systems
6.16 Run the Engine
6.17 Stop the Engine
6.18 Restart Engine That Has Run Out of Fuel
6.19 Reduce Fuel Consumption
6.20 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?With Starting Aid
7.2 Cold Weather Starting And Operation?Internal Starting Aid
7.3 Change Starting Fluid Canister
7.4 Engine Coolant Heater Use?13.5 L or 15 L Engines
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
8.4 Restored Operation Option
9 Controls and Instruments
9.1 Front Console
9.2 CommandARM? ISOBUS Shortcut Button (ISB)
9.3 Foot Decelerator
10 Corner Post Display
10.1 Corner Post Display
10.2 Information Indicators
10.3 Warning Indicators
10.4 Digital Indicators?Tachometer, Ground Speed, and Transmission
10.5 Gauges?Coolant Temperature, DEF Level, and Fuel Level
11 CommandARM? Controls
11.1 CommandARM? with Generation 4 CommandCenter? Display
11.2 CommandARM? Secondary Brake Lever (If Equipped)
11.3 CommandARM? Hitch Controls [Ag] 11.4 CommandARM? SCV Control Levers
11.5 CommandARM? Climate, Radio and Lighting Controls
11.6 CommandARM? PTO Control Lever [Ag] 11.7 CommandARM? Controls?Left Side
12 CommandCenter?
12.1 Generation 4 Display
12.2 Rear Hitch or PTO Availability
12.3 Machine Settings Overview
12.4 Automation Status Overview
12.5 Navigate Generation 4 CommandCenter?
12.6 Compatible Displays
12.7 Power Display On and Off
12.8 Change Pages and Values
12.9 Factory and Service ADVISOR? Installed Onscreen Help
12.10 Radar Calibration
12.11 Slip Calibration
12.12 Steering Settings?Access
12.13 Steering Settings
12.14 Steering Settings?Manual Steering Sensitivity
12.15 Controls Setup
12.16 Automation Status
12.17 Install Video Display Camera
13 CommandCenter? – Radio
13.1 External Sources
13.2 Select Audio Source with Generation 4 CommandCenter?
13.3 FM, MW, LW Home Page
13.4 Premium Radio USB Home Page
13.5 Premium Radio Bluetooth? Home Page
13.6 Auxiliary Home Page
13.7 Pair Bluetooth? Device to Generation 4 CommandCenter?
13.8 Manage Paired Bluetooth? Devices
13.9 Phone Operation
13.10 Contact List
13.11 Recent Calls
13.12 Clear Favorites and Call History
14 Intelligent Total Equipment Control (iTEC?)
14.1 CommandARM? Control Functions
14.2 iTEC? Station Description (Eu 1322/2014)
14.3 CommandCenter? Pages Descriptions and Functions
14.4 Status Area
14.5 All Sequence Page
14.6 Add New Sequence
14.7 Sequence Step Status
14.8 Edit or Remove Sequence
14.9 Sequence Sets Page
14.10 Perform Sequence
14.11 Recommendations (AutoLearn)
14.12 iTEC? Functions?Efficiency Manager?
15 Tractor-Implement Automation (TIA?)
15.1 Tractor-Implement Automation? (TIA?)
15.2 Activate Tractor-Implement Automation? Equipment
15.3 Tractor-Implement Automation? ? Status Page
15.4 Operate Tractor-Implement Automation?
15.5 PTO Requirements [Ag] 15.6 SCV Requirements
15.7 PowerShift? Transmission Requirements
15.8 AutoTrac? Guidance Requirements
15.9 Rear Hitch Requirements [Ag] 15.10 Drive Strategy Requirements
16 Drivetrain
16.1 Drivetrain Overview
16.2 Drivetrain Protection?9470RT, 9520RT and 9570RT
17 Brakes
17.1 Brake Use
17.2 Hydraulic Trailer Brakes (If Equipped)
17.3 Trailer Brake System Settings?Access
17.4 Trailer Brake System Settings
17.5 Trailer Brake System Settings?Brake Gain
17.6 Trailer Brake System Settings?Pre-Brake Offset
17.7 Trailer Brake System Settings?Trailer Brake Test
17.8 Trailer Brake System Settings?Advanced
17.9 Use Secondary Brake Lever
18 Transmission – General Information
18.1 Warm-Up Transmission-Hydraulic System
18.2 Backup Alarm
18.3 Access Transmission Advanced Settings
18.4 Transmission Advanced Settings
19 e18? PowerShift? Transmission
19.1 Operate Transmission?e18?
19.2 Shift Transmission?e18?
19.3 e18? Set Speeds and Efficiency Manager?
19.4 e18? Transmission Settings?Access
19.5 e18? Transmission Settings
19.6 e18? Transmission Settings?Mode
19.7 e18? Transmission Settings?Custom
19.8 e18? Transmission Settings?Droop
19.9 e18? Transmission Settings?ECO
19.10 e18? Transmission Settings?Max Speeds
20 PTO [Ag], Hitch [Ag], and Drawbar
20.1 Scraper Tractor Drawbar [Scraper] 20.2 Attach PTO-Driven Implement [Ag] 21 PTO – General Information [Ag] 21.1 PTO Settings?Access
21.2 PTO Settings
21.3 PTO Settings?Advanced
21.4 PTO Settings?Engagement Rate
21.5 PTO Settings?Rear PTO Cruise
21.6 PTO Settings?Auto Disengage
21.7 Operate PTOs
21.8 External PTO Switches (If Equipped)
22 Rear PTO [Ag] 22.1 Operating Instructions (EU 1322/2014)
22.2 Use PTO Master Shield (If Equipped)
22.3 PTO Engine Speed
23 Rear Hitch [Ag] 23.1 Hitch Lift Capacities
23.2 Rear Hitch Settings?Access
23.3 Rear Hitch Settings
23.4 Rear Hitch Settings?Upper Limit
23.5 Rear Hitch Settings?Drop Rate
23.6 Rear Hitch Settings?Raise Rate
23.7 Rear Hitch Settings?Load Depth
23.8 Rear Hitch Settings?Slip Sensitivity
23.9 Rear Hitch Settings?Position
23.10 Rear Hitch Settings?Position Control
23.11 Rear Hitch Settings?Draft Control
23.12 Hitch Control Lever Adjustments
23.13 Hitch Depth Set Point
23.14 Float Operation
23.15 Hitch Components
23.16 Hitch External Switches
23.17 Hitch Manual Lowering
23.18 Sway Blocks
23.19 Attaching Implement to Quick-Hitch
23.20 Adjusting Implement Level
23.21 Lateral Float
23.22 Detaching Implement From Quick-Hitch
23.23 Hitch Conversion?Category 4/4N/3 Convertible Quick-Hitch
23.24 Converting Category 4N/3 Convertible Quick-Hitch Lower Hooks
23.25 Converting Category 4N/3 Convertible Quick-Hitch Upper Hook
24 Drawbar [Ag] 24.1 Drawbar Load Limitations (Agricultural Tractors)
24.2 Using Correct Drawbar Pin?Category 5 to 4
24.3 Selecting Drawbar Position
24.4 Adjusting Wide Swing Drawbar (If Equipped)
24.5 Adjusting Drawbar Side-to-Side
24.6 Installing and Using Clevis Assembly
24.7 Category 5 Heavy-Duty Drawbar Load Limitations (If Equipped)
25 Drawbar [Scraper] 25.1 Drawbar Load Limitations (Scraper Tractors)
25.2 Scraper Applications
25.3 Calculate Static Vertical Drawbar Load
25.4 Calculate Vertical Drawbar Load Distance Behind Rear Axle
25.5 Install Drawbar or Quick-Attach in Short Drawbar Support
25.6 Short Scraper Drawbar Conversion
25.7 Tow Cable
26 Hydraulics – General Information
26.1 Hydraulic System Overview
27 Selective Control Valves
27.1 SCV Settings?Access
27.2 SCV Settings
27.3 SCV Settings?Standard Mode
27.4 SCV Settings?Independent Mode
27.5 SCV Settings?Feature Mode
27.6 SCV Settings?Flow Adjustment
27.7 SCV Settings?Time Adjustment
27.8 SCV Settings?Advanced
27.9 SCV Settings?Activating Independent Mode
27.10 SCV Settings?Automation
27.11 SCV Settings?Assignment
27.12 SCV Settings?Flow Adjustment Sensitivity
27.13 SCV Control Lever Adjustments
27.14 Total SCV Flow
27.15 Flow Sharing
27.16 Operate SCVs with CommandARM? Joystick
27.17 CommandARM? Joystick?Layout and Joystick Lever Functions
28 Hydraulic Connections
28.1 Connect/Disconnect Hydraulic Hoses
28.2 Implements Requiring Large Volumes of Hydraulic Oil
28.3 Using Load-Sensing Hydraulic System?Power-Beyond
28.4 Component Identification and Location [Ag] 28.5 Using Hydraulic Spray Pumps [Ag] 28.6 Implement Connection Example [Ag]: Closed Center Valve and Pump at High Pressure?Less Hitch
28.7 Implement Connection Example [Ag]: Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip
28.8 Implement Connection Example [Ag]: Planter with Vacuum Motor and Return Line to Motor Return?With Hitch and Implement Lift Assist
28.9 Implement Connection Example [Ag]: Pressure Control Valve Applications?Less Hitch (Grain Drills or Air Seeders with Constant Down-Pressure System)
28.10 Implement Connection Example?High-Flow Hydraulics [Ag]: Implement Control Valves?Less Hitch
28.11 Component Identification and Location [Scraper] 28.12 Scraper Hydraulic Hose Tips [Scraper] 28.13 Implement Connection Example [Scraper]: Pulling 1, 2, and 3 Scrapers
29 TouchSet? Depth Control
29.1 TouchSet? Depth Control Settings and Adjustments
29.2 Connect/Disconnect the Implement Position Connector
30 Laser Scraper Control [Ag] 30.1 Laser Scraper?for Scrapers Equipped with Scraper Control Unit
31 Scraper Information [Scraper] 31.1 Scraper Operation Cycle
31.2 Weight Transfer Limits
31.3 Scraper/Tractor Attachment
31.4 Loading Techniques
31.5 Connect AutoLoad? Harness
31.6 AutoLoad? Displays
31.7 Scraper Control Panel Reference
31.8 AutoLoad? Settings – Setting Auto Dimensions
31.9 Using AutoLoad?
31.10 Set Scraper ?Transport? Height
31.11 Set Scraper ?Ready? (Dump) Height
31.12 Set Scraper Ground ?Loading? Entering the Cut Height
31.13 AutoLoad? Operation
31.14 AutoLoad? Set Up Wizard
32 Tracks – General Information
32.1 General Track Use Guidelines
32.2 Tracks Service
33 Operator?s Station – General Information
33.1 Avoid Contact with Agricultural Chemicals
33.2 Clean Vehicle of Hazardous Pesticides
33.3 Keep Riders Off Machine
33.4 Keep Operator Station Window and Door Closed
33.5 Use Seat Belts
33.6 Use Emergency Exit
33.7 Monitor Bracket Mounts
34 Seat
34.1 Adjust ComfortCommand? Seat
34.2 Adjust Heated Leather Seat
34.3 Adjust CommandARM? Position
34.4 Use Passenger Seat
34.5 Operator Presence Sensor (If Equipped)
35 Steering Column
35.1 Adjust Steering Wheel and Column
35.2 Operate Horn
36 Mirrors
36.1 Manual Mirror
36.2 Electric Mirror
37 Wiper Washer
37.1 Operate Front Windshield Wiper and Washer
37.2 Operate Rear Wiper and Washer
37.3 Operate Right-Hand Wiper and Washer
38 Lights
38.1 Light Identification
38.2 Configurable Lights
38.3 Steering Column Light Controls
38.4 Exit Lights
38.5 Operate Turn Signals and High/Low Beam
38.6 Safety Lights and Devices
38.7 CommandARM? Light Buttons
38.8 Hazard Lights and Extremity Warning Lights
38.9 Rotary Beacon Light
38.10 7-Pin Outlet
39 Accessories
39.1 Pull-Down Sunshade
39.2 Install Business Band or Citizens Band (CB) Radio and Antenna
39.3 Auxiliary Power Strip Use
39.4 Accessory Electrical Outlet Use
39.5 Mount StarFire? Receiver
39.6 Connect Compatible Electronic Equipment
39.7 Configure Tractor for GPS or Radar
39.8 Refrigerator or Storage Space
39.9 Use Chain Box
39.10 Implement Connector
39.11 AutoLoad? Harness Connector [Scraper] 40 HVAC
40.1 HVAC Settings?Access
40.2 HVAC Settings
40.3 HVAC Settings?Climate Control Automation
40.4 HVAC Settings?Set Temperature
40.5 HVAC Settings?Air Flow Mode
40.6 HVAC Settings?Fan Speed
40.7 HVAC Settings?Air Conditioning
41 Performance Ballasting [Ag] 41.1 General Performance Guidelines
41.2 Ballasting for Tractive Performance
41.3 Ballast Recommendations
41.4 Determining Maximum Ballast
41.5 Ballasting Recommendations With Implements
41.6 Implement Guidelines
41.7 Installing Quik-Tatch? Front Weights (If Equipped)
41.8 Installing Quik-Tatch? Side Weights (If Equipped)
41.9 Idler Wheel Weights (If Equipped)
41.10 Wheel Weight Holding Wrench (JDG10958)
41.11 Measuring Track Slip (Manually)
41.12 Worksheet to Calculate Ballast Changes
42 Performance Ballasting [Scraper] 42.1 General Performance Guidelines
42.2 Ballasting for Tractive Performance
42.3 Ballast Recommendations
42.4 Determining Maximum Ballast
42.5 Ballasting Recommendations With Implements
42.6 Implement Guidelines
42.7 Installing Quik-Tatch? Front Weights (If Equipped)
42.8 Installing Quik-Tatch? Side Weights (If Equipped)
42.9 Idler Wheel Weights (If Equipped)
42.10 Wheel Weight Holding Wrench (JDG10958)
42.11 Measuring Track Slip (Manually)
42.12 Worksheet to Calculate Ballast Changes
43 Transport
43.1 Driving Tractor on Roads
43.2 Towed Mass ( EU 1322/2014)
43.3 Towing Loads and Transporting with Ballast
43.4 Transporting Rear Mounted Implements with Ballast
43.5 Use Safety Lights and Devices
43.6 Transport Towed Equipment at Safe Speeds
43.7 Safety Chain Use
43.8 Tow Mode?Engine Will Start
43.9 Tow Mode?Engine Will Not Start
43.10 Emergency Brake Steering
43.11 Carrier Transport
43.12 Freeing a Mired Tractor
44 Fuel, Lubricants, and Coolants – General Information
44.1 Determine Tractor Engine Type
44.2 Minimizing the Effect of Cold Weather on Diesel Engines
44.3 Oil Filters
45 Fuel
45.1 Diesel Fuel
45.2 Supplemental Diesel Fuel Additives
45.3 Biodiesel Fuel
45.4 Lubricity of Diesel Fuel
45.5 Handling and Storing Diesel Fuel
45.6 Avoid Static Electricity Risk When Refueling
45.7 Fill Fuel Tank
45.8 Testing Diesel Fuel
45.9 Fuel Filters
46 Diesel Exhaust Fluid (DEF)
46.1 Refilling Diesel Exhaust Fluid (DEF) Tank
46.2 Fill DEF Tank – FT4/Stage V Engine
46.3 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
46.4 Storing Diesel Exhaust Fluid (DEF)
46.5 Testing Diesel Exhaust Fluid (DEF)
46.6 Disposal of Diesel Exhaust Fluid (DEF)
47 Engine Oil
47.1 Diesel Engine Oil Service Interval for Operation at High Altitude
47.2 John Deere Break-In Plus? Engine Oil ? Final Tier 4/Stage V 13.5 L Engines
47.3 Break-In Engine Oil Use ? Final Tier 4/Stage V 15 L Engines
47.4 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
47.5 Engine Oil and Filter Service Intervals ? Final Tier 4/Stage V 13.5 L Engine
47.6 Engine Oil and Filter Service Intervals
48 Engine Coolant
48.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
48.2 John Deere COOL-GARD? II Coolant Extender
48.3 Operating in Warm Temperature Climates
48.4 Water Quality for Mixing with Coolant Concentrate
48.5 Testing Coolant Freeze Point
48.6 Disposing of Coolant
49 Other Lubricants
49.1 Transmission and Hydraulic Oil
49.2 Multipurpose Extreme Pressure (EP) Grease
49.3 Lubricant Storage
49.4 Mixing of Lubricants
49.5 Alternative and Synthetic Lubricants
50 Service – General Information
50.1 Service Sections Overview
50.2 Service Tasks Performed As Required
50.3 Identify Tractor Engine Emissions Status
50.4 Open Hood
50.5 Remove Engine Access Panel
50.6 Remove Front Engine Side Shield
50.7 Remove Rear Engine Side Shield
50.8 Jack Up Tractor – Lifting Points and Support Stand Placement (EU 1322/2014)
50.9 Service and Connect STC? (Snap-to-Connect) Fittings
50.10 Transmission Calibration
50.11 Abort Transmission Calibration
50.12 Do Not Modify Fuel System
50.13 Bleed Fuel System
50.14 Identify Zinc-Flake Coated Fasteners
50.15 Metric Bolt and Screw Torque Values
50.16 Unified Inch Bolt and Screw Torque Values
51 Break-In Service (100 Hours or Less)
51.1 Perform Break-In Services
51.2 Perform Track Systems Break-In
52 Service – Record Charts
52.1 Service Record Chart Overview
52.2 Service Interval Chart
52.3 Service Record Chart
53 Service – Clean
53.1 Cleaning Diesel Exhaust Fluid (DEF) Tank
53.2 DEF Tank Filler Neck Filter
53.3 Tractor Exterior
53.4 Clean Display
53.5 Engine Cooling System?13.5 L Engine
53.6 Engine Cooling System?15 L Engine
53.7 Dual Beam Radar Sensor
53.8 Optional Fuel Water Separator?13.5 L Engine
53.9 Aftertreatment Fuel Injector?15 L Engine
53.10 AirCushion? Suspension System Air Compressor Pump and Inlet Filter and Air Bags
54 Service – Check
54.1 Engine Coolant Level
54.2 Water Separator?15 L Engine
54.3 Tracks
54.4 Engine and Exhaust Compartments
54.5 Air Conditioning System
54.6 Engine Water Pump Weep Hole?13.5 L Engine
54.7 Engine Water Pump Seal?15 L Engine
54.8 Fuel Tank Sump
54.9 Engine Oil Level?13.5 L Engine
54.10 Engine Oil Level?15 L Engine
54.11 Transmission-Hydraulic Oil Level
54.12 Track Alignment
54.13 Track Tension
54.14 Drive and Idler Wheels and Mid-Rollers
54.15 Track Wear
54.16 Track Trash Buildup
54.17 Secondary Brake
54.18 NEUTRAL Start System
54.19 Transmission PARK System
54.20 AirCushion? Suspension System
54.21 AirCushion? Suspension System Walking Beam Bumper Stops
54.22 Engine Air Intake System?13.5 L Final Tier 4/Stage V Engine
54.23 Engine Air Intake System?15 L Engine
54.24 Engine Coolant Freeze Point
54.25 Seat Belts
54.26 Engine Auxiliary Drive Belt and Drive Belt Tensioner
54.27 Drive Wheel Hub Housing Oil Level
54.28 Mid-Rollers Oil Level
54.29 Idler Wheel Hub Oil Level
54.30 Engine Valve Clearance
54.31 Vari-Cool? Fan Drive and Belt?13.5L Final Tier 4/Stage V Engine
54.32 Drawbar Sensor Calibration
54.33 Drawbar Wear
55 Service – Tighten
55.1 Drive Wheel Nuts, Idler Wheel, and Mid-Roller Cap Screws
55.2 Drawbar Support Cap Screws
56 Service – Change
56.1 Vari-Cool? Fan Belt?13.5 L Final Tier 4/Stage V Engine
56.2 Auxiliary Drive Belt?13.5 L Engine
56.3 Engine Auxiliary Drive Belt?15 L Engine
56.4 Engine Water Pump Drive Belt?15 L Engine
56.5 Vari-Cool? Fan Drive Bearing and Retaining Capscrew?13.5L Final Tier 4/Stage V Engine
56.6 Engine Oil and Filter?13.5 L Engine
56.7 Engine Oil and Filter?15 L Engine
56.8 Fuel Filters?13.5 L Engine
56.9 Fuel Filters?15 L Engine
56.10 Optional Fuel Water Separator Filter Element?13.5 L Engine
56.11 Cab Recirculation Air Filter
56.12 Cab Fresh Air Filter
56.13 Walking Beam Bumper Stops
56.14 Engine Primary and Secondary Air Filters
56.15 Fuel Tank Vent Filters
56.16 SCV Pilot Valve Filter
56.17 DEF Tank Vent Filter
56.18 Access In-Line DEF Filter
56.19 Change Diesel Exhaust Fluid (DEF) In-Line Filter
56.20 Transmission-Hydraulic Oil and Filters
56.21 Engine Cooling System Radiator Cap?15 L Engine
56.22 Transmission Vent Filter
56.23 AirCushion? Suspension System Air Compressor Air Inlet Fitler
56.24 Engine Crankcase Breather Filter Element?15 L Engine
56.25 Transmission Drive Shaft Damper
56.26 Access DEF Dosing Unit Filter
56.27 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
56.28 Engine Coolant?13.5 L Engine
56.29 Engine Coolant?15 L Engine
56.30 Engine Crankshaft Damper?13.5 L Engine
56.31 Adjust Track Alignment
57 Service – Lubricate
57.1 Rear Hitch
57.2 Heavy Duty Lift Link Pins (Optional)
57.3 Lift Cylinders and Rockshaft
57.4 Track Tension Cylinder
57.5 Vari-Cool? Fan Drive?13.5 L Final Tier 4/Stage V Engine
58 Service – Electrical
58.1 Service – Electrical Overview
58.2 Welding Near Electronic Control Units
58.3 Keep Electronic Control Unit Connectors Clean
58.4 Compressed Air Use
58.5 High-Pressure Washer Use
58.6 Disconnect Battery
58.7 Handling Batteries Safely
58.8 Service Batteries and Connections?13.5 L Engine
58.9 Service Batteries and Connections?15 L Engine
58.10 Access Load Center Fuses
58.11 Access Master Fuse
58.12 Access Implement Power Relay Module Fuses
58.13 Handle Halogen Light Bulbs Safely
58.14 Change Front HID/LED Light Assembly
58.15 Change Front Grille Halogen Light Bulbs
58.16 Adjust Front Grille Lights
58.17 Adjust Headlights
58.18 Change Front, Side And Rear Cab Roof Light Bulb
58.19 Change Brake or Turn Signal Light Bulb
58.20 Change Dome Light Bulb
58.21 Change Extremity Warning Light Bulb
59 Troubleshooting – Procedures
59.1 Engine
59.2 Transmission/Hydraulics/Axle
59.3 Hydraulic System
59.4 Brakes
59.5 Hitch
59.6 Selective Control Valve (SCV)
59.7 Electrical System
59.8 Operator Enclosure
59.9 Steering System
60 Troubleshooting – Diagnostic Trouble Codes (DTC)
60.1 STOP, Service, and Information Alerts on CommandCenter?
60.2 Access Diagnostic Trouble Codes
61 Service – Storage
61.1 Place Tractor in Storage
61.2 Remove Tractor from Storage
62 Specifications
62.1 Engine: John Deere
62.2 Engine: QSX15 Cummins?
62.3 Capacities
62.4 Fluorinated Greenhouse Gas – 15 L Engine
62.5 Fluorinated Greenhouse Gas – 13.5 L Engine
62.6 Hydraulic
62.7 Transmission and Power Train
62.8 PTO [Ag], Hitch [Ag], and Drawbar
62.9 Electrical
62.10 Integrated Technology
62.11 Overall Dimensions
62.12 Loads and Weights (EU 1322/2014)
62.13 Sound Level (EU 1322/2014)
62.14 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (EU 1322/2014)
62.15 Ground Speeds?e18? PowerShift? Transmission
62.16 Limited Battery Warranty
62.17 Required Emission-Related Information
62.18 Carbon Dioxide Emissions (CO?)
63 Identification Numbers
63.1 Identification Plates
63.2 Product Identification Number
63.3 Engine Serial Number
63.4 Cab Serial Number
63.5 Transmission Serial Number
63.6 Axle Serial Number
63.7 PTO Clutch Serial Number [Ag] 63.8 PTO Dropbox Serial Number [Ag] 63.9 Track Serial Numbers
63.10 Keep Proof of Ownership
63.11 Keep Machines Secure
64 Change of Ownership
64.1 Subsequent Ownership
65 Predelivery
65.1 Predelivery Checklist
65.2 Delivery Checklist and Certificate
66 Index
67 John Deere Service Literature Available
67.1 Technical Information
68 John Deere Service Keeps You On The Job
68.1 John Deere Parts
68.2 The Right Tools
68.3 Well-Trained Technicians
68.4 Prompt Service