John Deere 9R Tractor Operator Manual OMRE592495

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Look For Supplemental Information
1.4 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator?s Manual
4.2 Instructional Seat (If Equipped)
4.3 Seat Belt
4.4 Starter
4.5 Engine Block Heater?9.0 L Engine [Ag] 4.6 Engine Block Heater?13.5 L Engine
4.7 Engine Block Heater?15 L Engine
4.8 HydraCushion? Suspension Accumulators (If Equipped)
4.9 Rear PTO Shield (If Equipped) [Ag] 4.10 Quick-Hitch (If Equipped) [Ag] 4.11 Hinge Area
4.12 Park Brake (Stored Energy)
4.13 Rotating Driveline (If Equipped) [Ag] 5 Vehicle Overview
5.1 9R Series Tractor
6 Operator?s Manual Use
6.1 Operator?s Manual Use
7 General Vehicle Description
7.1 9R Series Tractor
8 Engine Operation
8.1 Required Machine Stop Warning
8.2 Engine Fuel System and Power Rating
8.3 Battery Disconnect Switch
8.4 Start the Engine
8.5 Run the Engine
8.6 Stop the Engine
8.7 Restart Engine That Has Run Out of Fuel
8.8 Reduce Fuel Consumption
8.9 Use Battery Booster or Charger
9 Cold Weather Operation
9.1 Cold Weather Starting?With Starting Aid
9.2 Cold Weather Starting And Operation?Internal Starting Aid
9.3 Change Starting Fluid Canister
9.4 Engine Coolant Heater Use?9.0 L Engine [Ag] 9.5 Engine Coolant Heater Use?13.5 L or 15 L Engines
10 Emissions Equipment
10.1 Exhaust Filter System Overview?Final Tier 4/Stage V Engine
10.2 Aftertreatment Indicators Overview
10.3 Selective Catalytic Reduction (SCR) System Overview
10.4 Auto Exhaust Filter Cleaning Mode?Final Tier 4/Stage V Engine
10.5 Parked Exhaust Filter Cleaning?Final Tier 4/Stage V Engine
10.6 Selective Catalytic Reduction (SCR) System?Final Tier 4/Stage V Engine
10.7 Low Fuel or Low DEF Warning
10.8 Disconnect Battery?Final Tier 4/Stage V Engine
11 Controls and Instruments
11.1 Front Console
11.2 CommandARM? ISOBUS Shortcut Button (ISB)
11.3 Foot Decelerator
12 Corner Post Display
12.1 Corner Post Display
12.2 Information Indicators
12.3 Digital Indicators?Tachometer, Ground Speed and Transmission
12.4 Gauges?Coolant Temperature, DEF Level and Fuel Level
13 CommandARM? Controls
13.1 CommandARM? with Generation 4 CommandCenter? Display
13.2 CommandARM? Hitch Controls [Ag] 13.3 CommandARM? SCV Control Levers
13.4 CommandARM? Climate, Radio and Lighting Controls
13.5 CommandARM? PTO Control Lever [Ag] 13.6 CommandARM? Left-Hand Side Controls
14 CommandCenter?
14.1 Rear Hitch or PTO Availability
14.2 Onscreen Help
14.3 Generation 4 CommandCenter?
14.4 Generation 4 CommandCenter? Processor
14.5 Generation 4 CommandCenter? 4600 Processor Wi-Fi? Capabilities
14.6 Federal Communications Commission and Industry Canada Notification
14.7 Run Page Structure
14.8 Menu
14.9 Machine Settings Overview
14.10 Operating System Applications Overview
14.11 AMS Applications Overview
14.12 CommandCenter? Activations
14.13 Demo Activations
14.14 Automation Status Overview
14.15 Navigate Generation 4 CommandCenter?
14.16 Power Display On and Off
14.17 Navigate Run Pages on Main Page
14.18 Shortcut Buttons
14.19 Display and Sound
14.20 Brightness
14.21 Sound
14.22 Multiple Displays
14.23 Display Calibration
14.24 Date and Time
14.25 Change Current Date
14.26 Change Current Time
14.27 Language and Units
14.28 Language and Units Settings
14.29 Change Pages and Values
14.30 Status Center
14.31 Shortcut Softkeys
14.32 Software Manager
14.33 Factory and Service ADVISOR? Installed Onscreen Help
14.34 Update Display Software
14.35 Activations
14.36 Service ADVISOR? Remote
14.37 Vehicle Reprogramming
14.38 Troubleshooting ? Reprogramming
14.39 System Recovery
14.40 Remote Display Access
14.41 File Manager
14.42 USB Drive
14.43 Capture Screen Shots
14.44 Diagnostics Center
14.45 Controller Diagnostics
14.46 Diagnostic Information
14.47 Hide Diagnostic Center
14.48 Diagnostic Trouble Codes
14.49 Display Hardware
14.50 CAN Bus Information
14.51 CAN Bus Values
14.52 Network
14.53 DataSync
14.54 Users and Access
14.55 User Profiles
14.56 Access Groups
14.57 Layout Manager
14.58 Active Set
14.59 Shortcut Bar
14.60 All Run Pages
14.61 Add, Edit, or Duplicate Run Pages
14.62 Fields and Boundaries
14.63 Field Boundaries
14.64 Manage Clients, Farms, and Fields
14.65 AutoTrac? Guidance
14.66 Equipment Manager
14.67 Machine Profile
14.68 Implement Profile
14.69 Machine Monitor
14.70 Work Monitor
14.71 Work Recording
14.72 Maintenance and Calibrations
14.73 Calibrations
14.74 Radar Calibration
14.75 Wheel Slip Calibration
14.76 Service Intervals
14.77 Steering
14.78 Steering Settings
14.79 Controls Setup
14.80 Settings Manager
14.81 Automation Status
14.82 Read ISOBUS Controller?s Operator?s Manual
14.83 ISOBUS VT
14.84 StarFire? GPS Receiver
14.85 Use Video Display Capability Properly
14.86 Install Video Display Camera
14.87 Video
14.88 Video Triggers
15 Radio Operation
15.1 Radio Faceplate Features
15.2 Select Radio Receiver Wave Band
15.3 Federal Communications Commission (FCC) Bluetooth? Information
15.4 Set Clock
15.5 Reset Clock
15.6 Turn Confirmation Beep On/Off (BEEP)
15.7 Adjust Maximum Volume at Power-On (ONVOL)
15.8 Program Type (PTY)
15.9 Treble Reduction During Interference (HCUT)
15.10 Set Key Function (KEY PRG)
15.11 SiriusXM? Radio?General Information
15.12 Display XM Serial Number
15.13 External Sources
15.14 Select Radio Source with Generation 4 CommandCenter?
15.15 AM, FM, Weather Channel Home Page
15.16 Premium Radio XM Home Page
15.17 Premium Radio USB Home Page
15.18 Premium Radio Bluetooth? Home Page (If Equipped)
15.19 Auxiliary Home Page
15.20 Pair Bluetooth? Device to Generation 4 CommandCenter?
15.21 Manage Paired Bluetooth? Devices
15.22 Phone Operation
15.23 Phone Signal Strength and Battery Charge
15.24 Contact List
15.25 Recent Calls
15.26 Clear Favorites and Call History
16 AMS? Technology
16.1 Machine Sync
16.2 Mount StarFire? Receiver
16.3 Install GreenStar? System Components
16.4 Install Machine Communications Radio (MCR) Antenna (If Equipped)
16.5 Connect AutoTrac? Assisted Steering System
17 Intelligent Total Equipment Control (iTEC?)
17.1 CommandARM? Control Functions
17.2 CommandCenter? Pages Descriptions and Functions
17.3 Status Area
17.4 All Sequence Page
17.5 Add New Sequence
17.6 Sequence Step Status
17.7 Edit or Remove Sequence
17.8 Sequence Sets Page
17.9 Perform Sequence
17.10 Recommendations (AutoLearn)
17.11 iTEC? Functions?Efficiency Manager?
18 Tractor-Implement Automation? (TIA?)
18.1 Tractor-Implement Automation? (TIA?)
18.2 Activate Tractor-Implement Automation? Equipment
18.3 Tractor-Implement Automation? ? Status Page
18.4 Operate Tractor-Implement Automation?
18.5 PTO Requirements [Ag] 18.6 SCV Requirements
18.7 Powershift Transmission Requirements
18.8 AutoTrac? Guidance Requirements
18.9 Rear Hitch Requirements [Ag] 18.10 Drive Strategy Requirements
19 Drivetrain
19.1 Drivetrain Overview
19.2 Operate HydraCushion? Front Axle Suspension
19.3 Drivetrain Protection
20 Differential Lock
20.1 Differential Lock
20.2 Change Differential Lock Disengagement Steering Angle
21 Brakes
21.1 Brake Use
21.2 Brake Warning Indicators
21.3 Hydraulic Trailer Brakes (If Equipped)
21.4 Trailer Brake Settings
21.5 Engine Brake ? 15 L Engine (If Equipped)
21.6 Foot Decelerator
22 Transmission – General Information
22.1 Warm-Up Transmission-Hydraulic System
22.2 Activate and Set Maximum Set Speed
22.3 Use Maximum Set Speed with Different Transmission Modes
22.4 Backup Alarm
22.5 Come-Home Mode
23 e18? Powershift Transmission
23.1 Operate the e18? Powershift Transmission
23.2 Shift e18? Transmission
23.3 Avoid Tractor Overspeed
23.4 Set Start Gears
23.5 CommandCenter? Transmission Main Page
23.6 Efficiency Manager? on the e18? Transmission
23.7 Efficiency Manager? on e18? Transmission in Manual Mode
23.8 e18? Custom Mode Settings
24 PTO [Ag], Hitch [Ag], and Drawbar
24.1 Scraper Tractor Drawbar [Scraper] 24.2 Attach PTO-Driven Implement [Ag] 25 PTO – General Information [Ag] 25.1 Stay Clear of Rotating Drivelines
26 Rear PTO [Ag] 26.1 Use PTO Master Shield (If Equipped)
26.2 PTO Engine Speed
26.3 Operate PTO
26.4 PTO Engagement Rate
27 Rear Hitch [Ag] 27.1 Rear Hitch
27.2 Hitch Control Lever
27.3 Rear Hitch Lock
27.4 Adjust Load/Depth Control (Draft Response)
27.5 Position Control Use
27.6 Draft Control Use
27.7 Adjust Rear Hitch Upper Limit
27.8 Adjust Rear Hitch Drop Rate
27.9 Adjust Rear Hitch Raise Rate
27.10 Adjust Slip Sensitivity
27.11 Float Operation
27.12 Hitch Components
27.13 Hitch External Switches
27.14 Hitch Manual Lowering
27.15 Sway Blocks
27.16 Attaching Implement to Quick-Hitch
27.17 Adjusting Implement Level
27.18 Lateral Float
27.19 Detaching Implement From Quick-Hitch
27.20 Hitch Conversion?Category 4/4N/3 Convertible Quick-Hitch
27.21 Converting Category 4N/3 Convertible Quick-Hitch Lower Hooks
27.22 Converting Category 4N/3 Convertible Quick-Hitch Upper Hook
28 Drawbar [Ag] 28.1 Drawbar Load Limitations
28.2 Category 4 Heavy Duty Drawbar Reinforcement Kit Load Limitations
28.3 Category 5 Heavy Duty Drawbar Support Load Limitations
28.4 Selecting Drawbar Position
28.5 Adjusting Drawbar Side-to-Side
28.6 Install Clevis Assembly ? Category 4 Drawbar
28.7 Clevis Assembly Use ? Category 4 Drawbar
28.8 Install Clevis Assembly ? Category 5 Drawbar
28.9 Clevis Assembly Use ? Category 5 Drawbar
28.10 Use Correct Drawbar Pin ? Category 5 to 4
29 Drawbar [Scraper] 29.1 Install Drawbar or Quick-Attach in Short Drawbar Support
29.2 Short Scraper Drawbar Conversion
29.3 Long Drawbar Support Load Limitations
29.4 Tow Cable (If Equipped)
30 Hydraulics – General Information
30.1 Hydraulic System Overview
31 Selective Control Valves
31.1 Configure SCV Modes
31.2 Configure SCV – Standard Mode
31.3 Activate Independent Mode
31.4 Configure SCV – Independent Mode
31.5 Configure SCV – Feature Mode
31.6 Flow Sharing
31.7 Total Rear SCV Flow
31.8 Six-Position SCV Control Levers
31.9 SCV Control Lever?Neutral Position
31.10 SCV Control Lever?Extend and Retract Position
31.11 SCV Control Lever?Extend Detent and Retract Detent Position
31.12 SCV Control Lever?Float Position
31.13 Operator Presence Sensor
31.14 CommandARM? Joystick (If Equipped)
31.15 CommandARM? Joystick (If Equipped) – Custom Setup
31.16 CommandARM? Joystick (If Equipped) – Layout and Joystick Lever Functions
31.17 SCV and Joystick Flow Response Setting
31.18 SCV Flow Sharing Setting
32 Hydraulic Connections
32.1 Connecting Hydraulic Hoses?Rear of Tractor
32.2 Disconnecting Hydraulic Hoses?Rear of Tractor
32.3 Standard Hydraulic Component Identification [AG] 32.4 Standard Hydraulic Component Identification [Scraper] 32.5 High Flow Hydraulic Component Identification [AG] 32.6 High Flow Hydraulic Component Identification [Scraper] 32.7 Using Load-Sensing Hydraulic System?Power-Beyond
32.8 Examples Using Load-Sensing Hydraulic System?Power-Beyond
32.9 Using Hydraulic Spray Pumps [AG] 32.10 Implement Connection Example 1?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)?Less Hitch?Standard Hydraulics [AG] 32.11 Implement Connection Example 2?Motor Application Using Motor Case Drain?Less Hitch?Standard Hydraulics [AG] 32.12 Implement Connection Example 3?Closed Center Valve, Pump at High Pressure?Less Hitch?Standard Hydraulics [AG] 32.13 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip?Less Hitch?Standard Hydraulics [AG] 32.14 Implement Connection Example 5?Planter with Vacuum Motor and Return Line to Motor Return?With Hitch?With Lift Assist?Standard Hydraulics [AG] 32.15 Implement Connection Example 6?Planter with Vacuum Motor and Return Line to Motor Return?With Hitch?Implement Lift Assist?Standard Hydraulics [AG] 32.16 Connecting Implements to High Flow Hydraulic SCV’s [AG] 32.17 Connecting Implements to Air Seeder Special High Flow Hydraulic SCV’s [AG] 32.18 Implement Connection Example 1?Implement Control Valves?Less Hitch?High Flow Hydraulics [AG] 32.19 Implement Connection Example 2?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)?Less Hitch?High Flow Hydraulics [AG] 32.20 Implement Connection Example 3?Closed Center Valve, Pump at High Pressure?Less Hitch?High Flow Hydraulics [AG] 32.21 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip?With Hitch?High Flow Hydraulics [AG] 32.22 Scraper Connection Example: Pulling 1, 2, and 3 Scrapers [Scraper] 32.23 Implements Requiring Large Volumes of Oil
32.24 Scraper Hydraulic Hose Tips [Scraper] 33 TouchSet? Depth Control
33.1 Attaching Implement and Control System
33.2 Reset Implement Connector
33.3 Set TouchSet? Depth Controls
33.4 Use TouchSet? Depth Controls
34 Laser Scraper Control [Ag] 34.1 Laser Scraper?for Scrapers Equipped with Scraper Control Unit
35 Scraper Information [Scraper] 35.1 Scraper Operation Cycle
35.2 Weight Transfer Limits
35.3 Scraper/Tractor Attachment
35.4 Loading Techniques
35.5 Connect AutoLoad? Harness
35.6 AutoLoad? Displays
35.7 Scraper Control Panel Reference
35.8 AutoLoad? Settings – Setting Auto Dimensions
35.9 Using AutoLoad?
35.10 Set Scraper ?Transport? Height
35.11 Set Scraper ?Ready? (Dump) Height
35.12 Set Scraper Ground ?Loading? Entering the Cut Height
35.13 AutoLoad? Operation
35.14 AutoLoad? Set Up Wizard
36 Wheels and Tires – General Information
36.1 Service Tires Safely
36.2 Tire Group Sizes
36.3 Change Tire Size
36.4 Using Correct Tire Combinations
36.5 Tire Load Index
36.6 Tire Sidewall Information
36.7 Tire Inflation Pressure Guidelines
37 Wheels and Tires
37.1 Observe Tread Width Limitations
37.2 Tread Widths
37.3 Dual Tire Use
37.4 Triple Wheels [Ag] 37.5 Triple Wheels (Heavy Duty Wheel Hubs)
37.6 Install Wheel Rim to Cast Wheel
37.7 Use Wheel Tightening Stand
37.8 Wheel Weight Holding Wrench?JDG10958
37.9 Use Wheel Torque Wrench Adapter
37.10 Adjust and Tighten?Standard Drive Wheel and Standard Dual Hubs [Ag] 37.11 Adjust and Tighten?Heavy-Duty Drive Wheels
37.12 Adjust and Tighten?Heavy-Duty Dual Wheel Hubs
37.13 Install 76×50.00 B-32 Flotation Wheel and Tire Assembly [Scraper] 37.14 Recommended Inflation Pressures?Group 47
37.15 Recommended Inflation Pressures?Group 48
37.16 Recommended Inflation Pressures?Flotation Logger [Scraper] 38 Steering Stop and Tread Settings
38.1 Using Steering Stops
39 Operator?s Station – General Information
39.1 Avoid Contact with Agricultural Chemicals
39.2 Clean Vehicle of Hazardous Pesticides
39.3 Keep Riders Off Machine
39.4 Keep Operator Station Window and Door Closed
39.5 Use Seat Belts
39.6 Use Emergency Exit
39.7 Monitor Bracket Mounts
40 Seat
40.1 Adjust ComfortCommand? Seat
40.2 Adjust Heated Leather Seat
40.3 Adjust ActiveSeat?
40.4 Adjust CommandARM? Position
40.5 Use Instructional Seat
40.6 Operator Presence Sensor (If Equipped)
41 Steering Column
41.1 Adjust Steering Wheel and Column
41.2 Operate Horn
42 Mirrors
42.1 Manual Mirror
42.2 Electric Mirror
42.3 Telescoping Heated Electric Mirror
43 Wiper Washer
43.1 Operate Front Windshield Wiper and Washer
43.2 Operate Rear Wiper and Washer
43.3 Operate Right-Hand Wiper and Washer
44 Lights
44.1 Light Identification
44.2 Configurable Lights
44.3 Steering Column Light Controls
44.4 Exit Lights
44.5 Operate Turn Signals and High/Low Beam
44.6 Safety Lights and Devices
44.7 CommandARM? Light Buttons
44.8 Hazard Lights and Extremity Warning Lights
44.9 Rotary Beacon Light
44.10 7-Pin Outlet
45 Accessories
45.1 Pull-Down Sunshade
45.2 Install Business Band or Citizens Band (CB) Radio and Antenna
45.3 Auxiliary Power Strip Use
45.4 Accessory Electrical Outlet Use
45.5 Connect Compatible Electronic Equipment
45.6 Configure Tractor for GPS or Radar
45.7 Refrigerator or Storage Space
45.8 Implement Connector Use
45.9 Use AutoLoad? Harness Connector [Scraper] 46 HVAC
46.1 Climate Controls
46.2 HVAC Settings?Generation 4 CommandCenter?
47 Performance Ballasting [Ag] 47.1 General Performance Guidelines
47.2 Determining Maximum Ballast
47.3 Tire Sidewall Information
47.4 Ballasting for Engine Horsepower
47.5 Control Power Hop
47.6 Rear Wheel Weight Use
47.7 Front Weight Frame
47.8 Rear Weight Frame
47.9 Implement Guidelines
47.10 Measuring Wheel Slip (Manually)
47.11 Using Liquid Ballast
47.12 Worksheet to Calculate Ballast Changes
47.13 Unballasted Tractor Weight Chart (9370R and 9420R)
47.14 Unballasted Tractor Weight Chart (9470R and 9520R)
47.15 Unballasted Tractor Weight Chart (9570R and 9620R)
48 Performance Ballasting [Scraper] 48.1 General Performance Guidelines
48.2 Determining Maximum Ballast
48.3 Tire Sidewall Information
48.4 Ballasting for Engine Horsepower
48.5 Controlling Power Hop
48.6 Calculating Ballast?Without Dolly on Drawbar Hitch
48.7 Calculating Ballast?With Dolly – Wheel Scrapers or Drawn Tillage Implements
48.8 Recommended Ballast?76×50.00B32 and Logger Tires-Singles
48.9 Recommended Ballast?Dual Radial Tires
48.10 Scraper Ballast Package with Duals
48.11 Recommended Ballast?Scraper/Ag Combination Tractor With Radial Tires
48.12 Using Cast Hub Wheel Weights
48.13 Front Weight Frame
48.14 Implement and Scraper Size Guidelines
48.15 Measure Wheel Slip?Manually
48.16 Using Liquid Ballast
48.17 Worksheet to Calculate Ballast Changes
48.18 Unballasted Tractor Weight Chart (9470R and 9520R)
48.19 Unballasted Tractor Weight Chart (9570R and 9620R)
49 Transport
49.1 Driving Tractor on Roads
49.2 Towed Loads and Transport with Ballast
49.3 Use Safety Lights and Devices
49.4 Transport Rear Mounted Implements with Ballast
49.5 Safety Chain Use
49.6 Carrier Transport
49.7 Tie Down on Transport Carrier
49.8 Towing?Engine Will Start
49.9 Towing?All Wheels on Ground?Engine Will Not Start
49.10 Freeing a Mired Tractor
50 Fuel, Lubricants, and Coolant – General Information
50.1 Determine Tractor Engine Type
50.2 Minimizing the Effect of Cold Weather on Diesel Engines
50.3 Oil Filters
51 Fuel
51.1 Diesel Fuel
51.2 Supplemental Diesel Fuel Additives
51.3 Biodiesel Fuel
51.4 Lubricity of Diesel Fuel
51.5 Handling and Storing Diesel Fuel
51.6 Avoid Static Electricity Risk When Refueling
51.7 Fill Fuel Tank
51.8 Testing Diesel Fuel
51.9 Fuel Filters
52 Diesel Exhaust Fluid (DEF)
52.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
52.2 Storing Diesel Exhaust Fluid (DEF)
52.3 Refilling Diesel Exhaust Fluid (DEF) Tank
52.4 Fill DEF Tank – FT4/Stage V Engine
52.5 Testing Diesel Exhaust Fluid (DEF)
52.6 Disposal of Diesel Exhaust Fluid (DEF)
53 Engine Oil
53.1 Diesel Engine Oil Service Interval for Operation at High Altitude
53.2 John Deere Break-In Plus? Engine Oil ? Final Tier 4/Stage V 9.0 L [Ag] and 13.5 L Engine
53.3 Break-In Engine Oil Use ? Final Tier 4/Stage V 15 L Engines
53.4 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
53.5 Engine Oil and Filter Service Intervals ? Final Tier 4/Stage V – 9.0 L [Ag] and 13.5 L Engines
53.6 Engine Oil and Filter Service Intervals ? Final Tier 4/Stage V 15 L Engine
54 Engine Coolant
54.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
54.2 John Deere COOL-GARD? II Coolant Extender
54.3 Operating in Warm Temperature Climates
54.4 Water Quality for Mixing with Coolant Concentrate
54.5 Testing Coolant Freeze Point
54.6 Disposing of Coolant
55 Other Lubricants
55.1 Transmission and Hydraulic Oil
55.2 Multipurpose Extreme Pressure (EP) Grease
55.3 Lubricant Storage
55.4 Mixing of Lubricants
55.5 Alternative and Synthetic Lubricants
56 Service – General Information
56.1 Service Sections Overview
56.2 Service Tasks Performed As Required
56.3 Identify Tractor Engine Emissions Status
56.4 Single or Double Reduction Axle Identification
56.5 Open Hood
56.6 Remove Engine Access Panel
56.7 Remove Front Engine Side Shield
56.8 Remove Rear Engine Side Shield
56.9 Jack Up Tractor – Lifting Points and Support Stand Placement (2010-52-EU)
56.10 Service and Connect STC? (Snap-to-Connect) Fittings
56.11 High-Pressure Washer Use
56.12 Diesel Particulate Filter Service
56.13 Exhaust Filter / Diesel Particulate Filter Ash Handling and Disposal
56.14 Exhaust Filter Disposal
56.15 Transmission Calibration
56.16 Abort Transmission Calibration
56.17 Do Not Modify Fuel System
56.18 Do Not Open High-Pressure Fuel System
56.19 Bleed Fuel System
56.20 Identify Zinc-Flake Coated Fasteners
56.21 Metric Bolt and Screw Torque Values
56.22 Unified Inch Bolt and Screw Torque Values
57 Break-In Service (100 Hours or Less)
57.1 Perform Break-In Services
58 Service – Record Charts
58.1 Engine Oil and Filter Change
58.2 As Required Service
58.3 Annual Service
58.4 10 Hour or Daily Service
58.5 50 Hour Service
58.6 250 Hour Service
58.7 400 Hour Service
58.8 500 Hour Service
58.9 750 Hour Service
58.10 800 Hour Service
58.11 1000 Hour Service
58.12 1200 Hour Service
58.13 1250 Hour Service
58.14 1500 Hour Service
58.15 1600 Hour Service
58.16 1750 Hour Service
58.17 2000 Hour Service
58.18 2250 Hour Service
58.19 2400 Hour Service
58.20 2500 Hour Service
58.21 2750 Hour Service
58.22 2800 Hour Service
58.23 3000 Hour Service
58.24 3200 Hour Service
58.25 3250 Hour Service
58.26 3500 Hour Service
58.27 3600 Hour Service
58.28 3750 Hour Service
58.29 4000 Hour Service
58.30 4250 Hour Service
58.31 4400 Hour Service
58.32 4500 Hour Service
58.33 4750 Hour Service
58.34 4800 Hour Service
58.35 5000 Hour Service
58.36 5200 Hour Service
58.37 5250 Hour Service
58.38 5500 Hour Service
58.39 5600 Hour Service
58.40 5750 Hour Service
58.41 6000 Hour Service
58.42 Services – 6250 to 8800 Hours
58.43 9000 Hour Service
58.44 Services Beyond 9000 Hours
59 Service – Clean
59.1 Diesel Particulate Filter (DPF)?Final Tier 4/Stage V Engine
59.2 Exhaust Filter/Diesel Particulate Filter (DPF) Ash Handling and Disposal
59.3 Exhaust Filter Disposal
59.4 Engine Cooling System?9.0 or 13.5 L Engine
59.5 Engine Cooling System?15 L Engine
59.6 Cleaning Diesel Exhaust Fluid (DEF) Tank
59.7 DEF Tank Filler Neck Filter
59.8 Clean Display
59.9 Dual Beam Radar Sensor
59.10 Optional Fuel Water Separator
59.11 Optional Fuel Water Separator Filter Element
59.12 Aftertreatment Fuel Injector?15 L Engine
60 Service – Check
60.1 Engine Coolant Level
60.2 Engine Coolant Freeze Point
60.3 Optional Fuel/Water Separator
60.4 Water Separator
60.5 Engine and Exhaust Compartments
60.6 Outer Exhaust Screens
60.7 Air Conditioning System
60.8 Engine Water Pump Weep Hole?9.0 L Engine
60.9 Engine Water Pump Weep Hole?13.5 L Engine
60.10 Engine Water Pump Seal?15 L Engine
60.11 Fuel Tank Sump
60.12 Engine Oil Level?9.0 L Engine
60.13 Engine Oil Level?13.5 L Engine
60.14 Engine Oil Level?15 L Engine
60.15 Transmission-Hydraulic Oil Level
60.16 Tires
60.17 NEUTRAL Start System
60.18 Transmission PARK System
60.19 Engine Air Intake System?9.0 L Final Tier 4/Stage V Engine
60.20 Engine Air Intake System?13.5 L Final Tier 4/Stage V Engine
60.21 Engine Air Intake System?15 L Engine
60.22 Seat Belts
60.23 HydraCushion? Suspended Front Axle Accumulator Charge Pressure
60.24 Engine Auxiliary Drive Belt and Drive Belt Tensioner
60.25 Axle End Play
60.26 Engine Valve Clearance
60.27 Vari-Cool? Fan Drive and Belt?9.0 L Final Tier 4/Stage V Engine
60.28 Vari-Cool? Fan Drive and Belt?13.5L Final Tier 4/Stage V Engine
60.29 Front Driveshaft Health (FDH) Sensor System
61 Service – Tighten
61.1 Wheel and Wheel Weight Bolts
61.2 Use Wheel Tightening Stand
61.3 Use Wheel Torque Wrench Adapter
61.4 Drawbar Support and Cap Screws
62 Service – Change
62.1 Vari-Cool? Fan Belt?9.0 L Final Tier 4/Stage V Engine
62.2 Vari-Cool? Fan Belt?13.5 L Final Tier 4/Stage V Engine
62.3 Vari-Cool? Fan Drive Bushings, Seals, and Wear Pads
62.4 Vari-Cool? Fan Drive Bushings and Seals?13.5L Final Tier 4/Stage V Engine
62.5 Engine Auxiliary Drive Belt?9.0 L or 13.5 L Engine
62.6 Engine Auxiliary Drive Belt?15 L Engine
62.7 Engine Water Pump Drive Belt?15 L Engine
62.8 Engine Oil and Filter?9.0 L Engine
62.9 Engine Oil and Filter?13.5 L Engine
62.10 Engine Oil and Filter?15 L Engine
62.11 Fuel Filters?9.0 L Engine
62.12 Fuel Filters?13.5 L Engine
62.13 Fuel Filters?15 L Engine
62.14 Cab Recirculation Air Filter
62.15 Cab Fresh Air Filter
62.16 Engine Primary and Secondary Air Filters
62.17 Fuel Tank Vent Filters
62.18 SCV Pilot Valve Filter
62.19 DEF Tank Vent Filter?Final Tier 4/Stage V Engine
62.20 In-Line DEF Filter
62.21 Transmission-Hydraulic Oil and Filters
62.22 Engine Cooling System Radiator Cap?15 L Engine
62.23 Transmission-Hydraulic Vent Filter
62.24 Access DEF Dosing Unit Filter?Final Tier 4/Stage V Engine
62.25 DEF Dosing Unit Filter?Final Tier 4/Stage V Engine
62.26 Engine Crankcase Breather Filter Element?15 L Engine
62.27 Transmission Drive Shaft Damper
62.28 Engine Coolant?9.0L Engine
62.29 Engine Coolant?13.5 L Engine
62.30 Engine Coolant?15 L Engine
62.31 Engine Crankshaft Damper?9.0 L or 13.5 L Engine
62.32 Front Drive Shaft U-Joints
63 Service – Lubricate
63.1 Heavy Duty Lift Link Pins (Optional)
63.2 Hinge Pins
63.3 Steering Pins
63.4 Telescoping Drive Shaft
63.5 PTO Drive Shaft
63.6 Heavy-Duty Gudgeon Bearings
63.7 Lower Drive Line Bearings
63.8 Rear Hitch
63.9 Lift Cylinders and Rockshaft
63.10 Vari-Cool? Fan Drive?9.0 L Final Tier 4/Stage V Engine
63.11 Vari-Cool? Fan Drive?13.5 L Final Tier 4/Stage V Engine
63.12 HydraCushion? Front Axle Suspension
63.13 Rear Hitch Draft Sensor?9370R, 9420R, or 9470R Tractor
64 Service – Electrical
64.1 Service – Electrical Overview
64.2 Welding Near Electronic Control Units
64.3 Keep Electronic Control Unit Connectors Clean
64.4 Compressed Air Use
64.5 High-Pressure Washer Use
64.6 Disconnect Battery
64.7 Handling Batteries Safely
64.8 Service Batteries and Connections
64.9 Access Load Center Fuses
64.10 Access Master Fuses
64.11 Access Implement Power Relay Module Fuses
64.12 Handle Halogen Light Bulbs Safely
64.13 Change Front HID/LED Light Assembly
64.14 Change Front Grille Halogen Light Bulbs
64.15 Adjust Front Grille Lights
64.16 Adjust Headlights
64.17 Change Front, Side And Rear Cab Roof Light Bulb
64.18 Change Brake or Turn Signal Light Bulb
64.19 Change Dome Light Bulb
64.20 Change Extremity Warning Light Bulb
65 Troubleshooting – Procedures
65.1 Engine
65.2 Transmission-Hydraulic-Axles
65.3 Hydraulic System
65.4 Brakes
65.5 Hitch
65.6 Selective Control Valve (SCV)
65.7 Electrical System
65.8 Operator Enclosure
65.9 Premium Radio
66 Troubleshooting – Diagnostic Trouble Codes (DTC)
66.1 STOP and Service Alert Indicators
66.2 Information Indicator
66.3 Access Diagnostic Trouble Codes
67 Service – Storage
67.1 Place Tractor in Storage
67.2 Remove Tractor from Storage
67.3 Paint Finish Care
68 Specifications
68.1 Engine: John Deere
68.2 Engine: QSX15 Cummins?
68.3 Capacities
68.4 Hydraulics
68.5 Transmission and Power Train
68.6 PTO [Ag], Hitch [Ag], and Drawbar
68.7 Electrical
68.8 Other Equipment
68.9 Overall Dimensions
68.10 Ground Speeds?e18? Powershift Transmission
68.11 Agricultural Heavy-Duty Land Leveling Package [Ag] 68.12 Emissions Control System Certification Label
68.13 EPA Non-road Emissions Control Warranty Statement?Compression Ignition
68.14 CARB Non-road Emissions Control Warranty Statement?Compression Ignition
68.15 Required Emission-Related Information
68.16 Cummins? ? CARB Non-road Emissions Control Warranty Statement
68.17 Cummins? ? EPA Non-Road Emissions Control Warranty Statement
68.18 Limited Battery Warranty
68.19 Carbon Dioxide Emissions (CO?)
69 Identification Numbers
69.1 Identification Plates
69.2 Product Identification Number
69.3 Engine Serial Number
69.4 Cab Serial Number
69.5 Transmission Serial Number
69.6 PTO Dropbox Serial Number [Ag] 69.7 PTO Clutch Serial Number [Ag] 69.8 Keep Proof of Ownership
69.9 Keep Machines Secure
70 Change of Ownership
70.1 Subsequent Ownership
71 Predelivery
71.1 Predelivery Checklist
71.2 Delivery Checklist and Certificate
72 John Deere Servic