Table of Content:
1 Introduction
1.1 Foreword
1.2 Look For Supplemental Information
1.3 Trademarks
1.4 Traction Class
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Transport Towed Equipment at Safe Speeds
3.26 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.27 Freeing a Mired Machine
3.28 Avoid Contact with Agricultural Chemicals
3.29 Handle Agricultural Chemicals Safely
3.30 Handling Batteries Safely
3.31 Avoid Heating Near Pressurized Fluid Lines
3.32 Remove Paint Before Welding or Heating
3.33 Handle Electronic Components and Brackets Safely
3.34 Practice Safe Maintenance
3.35 Avoid Hot Exhaust
3.36 Clean Exhaust Filter Safely
3.37 Work In Ventilated Area
3.38 Support Machine Properly
3.39 Prevent Machine Runaway
3.40 Park Machine Safely
3.41 Transport Tractor Safely
3.42 Service Cooling System Safely
3.43 Service Accumulator Systems Safely
3.44 Service Tires Safely
3.45 Service Front-Wheel Drive Tractor Safely
3.46 Tightening Wheel Retaining Bolts/Nuts
3.47 Avoid High-Pressure Fluids
3.48 Do Not Open High-Pressure Fuel System
3.49 Store Attachments Safely
3.50 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 HydraCushion? Suspension Accumulators (If Equipped)
4.4 Hinge Area
4.5 Park Brake (Stored Energy)
4.6 Engine Cooling System (For China Only)
5 Vehicle Overview
5.1 9R Scraper Series Tractor
6 Operator?s Manual Use
6.1 Operator?s Manual Use
7 General Vehicle Description
7.1 9R Scraper Series Tractor
8 Engine Operation
8.1 Required Machine Stop Warning
8.2 Engine Fuel System and Power Rating
8.3 Battery Disconnect Switch
8.4 Start the Engine
8.5 Theft Deterrent Systems
8.6 Run the Engine
8.7 Stop the Engine
8.8 Restart Engine That Has Run Out of Fuel
8.9 Reduce Fuel Consumption
8.10 Use Battery Booster or Charger
9 Cold Weather Operation
9.1 Cold Weather Starting?With Starting Aid
9.2 Cold Weather Starting And Operation?Internal Starting Aid
9.3 Change Starting Fluid Canister
9.4 Engine Coolant Heater Use?13.5 L Engine
9.5 Engine Coolant Heater Use?15 L Engine
10 Emissions Equipment
10.1 Exhaust Filter System Overview?Final Tier 4/Stage IV Engine
10.2 Aftertreatment Indicators Overview
10.3 Selective Catalytic Reduction (SCR) System Overview
10.4 Qualified Emergency Use ? SCR Override Option
10.5 Auto Exhaust Filter Cleaning Mode?Final Tier 4/Stage IV Engine
10.6 Parked Exhaust Filter Cleaning?Final Tier 4/Stage IV Engine
10.7 Selective Catalytic Reduction (SCR) System?Final Tier 4/Stage IV Engine
10.8 Low Fuel or Low DEF Warning
10.9 Disconnect Battery?Final Tier 4/Stage IV Engine
11 Controls and Instruments
11.1 Front Console
11.2 CommandARM? ISOBUS Shortcut Button (ISB)
11.3 Foot Decelerator
12 Corner Post Display
12.1 Corner Post Display
12.2 Information Indicators
12.3 Digital Indicators?Tachometer, Ground Speed and Transmission
12.4 Gauges?Coolant Temperature, DEF Level and Fuel Level
13 CommandARM? Controls
13.1 CommandARM? with Generation 4 CommandCenter? Display
13.2 CommandARM? Secondary Brake Lever
13.3 CommandARM? SCV Control Levers
13.4 CommandARM? Climate, Radio and Lighting Controls
13.5 CommandARM? Left-Hand Side Controls
14 CommandCenter?
14.1 Onscreen Help
14.2 Generation 4 CommandCenter?
14.3 Generation 4 CommandCenter? Processor
14.4 Generation 4 CommandCenter? 4600 Processor Wi-Fi? Capabilities
14.5 Run Page Structure
14.6 Menu
14.7 Machine Settings Overview
14.8 Operating System Applications Overview
14.9 AMS Applications Overview
14.10 CommandCenter? Activations
14.11 Demo Activations
14.12 Automation Status Overview
14.13 Navigate Generation 4 CommandCenter?
14.14 Power Display On and Off
14.15 Navigate Run Pages on Main Page
14.16 Shortcut Buttons
14.17 Navigate to Display & Sound
14.18 Display and Sound
14.19 Brightness
14.20 Sound
14.21 Multiple Displays
14.22 Display Calibration
14.23 Navigate to Date & Time
14.24 Date and Time
14.25 Change Current Date
14.26 Change Current Time
14.27 Navigate to Language & Units
14.28 Language and Units
14.29 Language and Units Settings
14.30 Change Pages and Values
14.31 Status Center
14.32 Shortcut Softkeys
14.33 Navigate to Software Manager
14.34 Software Manager
14.35 Factory and Service ADVISOR? Installed Onscreen Help
14.36 Update Display Software
14.37 Activations
14.38 Service ADVISOR? Remote
14.39 Vehicle Reprogramming
14.40 Troubleshooting ? Reprogramming
14.41 System Recovery
14.42 Remote Display Access
14.43 Navigate to File Manager
14.44 File Manager
14.45 USB Drive
14.46 Capture Screen Shots
14.47 Navigate to Diagnostics Center
14.48 Diagnostics Center
14.49 Controller Diagnostics
14.50 Diagnostic Information
14.51 Hide Diagnostic Center
14.52 Diagnostic Trouble Codes
14.53 Display Hardware
14.54 CAN Bus Information
14.55 CAN Bus Values
14.56 Network
14.57 DataSync
14.58 Navigate to Users & Access
14.59 Users and Access
14.60 User Profiles
14.61 Access Groups
14.62 Navigate to Layout Manager
14.63 Layout Manager
14.64 Active Set
14.65 Shortcut Bar
14.66 All Run Pages
14.67 Add, Edit, or Duplicate Run Pages
14.68 Navigate to Fields
14.69 Fields and Boundaries
14.70 Field Boundaries
14.71 Manage Clients, Farms, and Fields
14.72 AutoTrac? Guidance
14.73 Navigate to Equipment Manager
14.74 Equipment Manager
14.75 Machine Profile
14.76 Implement Profile
14.77 Navigate to Machine Monitor
14.78 Machine Monitor
14.79 Navigate to Work Monitor
14.80 Work Monitor
14.81 Work Recording
14.82 Navigate to Maintenance & Calibrations
14.83 Maintenance and Calibrations
14.84 Calibrations
14.85 Radar Calibration
14.86 Wheel Slip Calibration
14.87 Service Intervals
14.88 Steering
14.89 Steering Settings
14.90 Controls Setup
14.91 Settings Manager
14.92 Automation Status
14.93 Read ISOBUS Controller?s Operator?s Manual
14.94 ISOBUS VT
14.95 StarFire? GPS Receiver
14.96 Use Video Display Capability Properly
14.97 Install Video Display Camera
14.98 Navigate to Video Application
14.99 Video
14.100 Video Triggers
15 Radio Operation
15.1 Radio Faceplate Features
15.2 Declaration of Conformity
15.3 Select Radio Receiver Wave Band
15.4 Mexico Bluetooth? Information
15.5 Russia Bluetooth? Certification
15.6 Set Clock
15.7 Reset Clock
15.8 Turn Confirmation Beep On/Off (BEEP)
15.9 Adjust Maximum Volume at Power-On (ONVOL)
15.10 Program Type (PTY)
15.11 Treble Reduction During Interference (HCUT)
15.12 Set Key Function (KEY PRG)
15.13 Traffic Information
15.14 External Sources (Premium Radio)
15.15 Select Radio Source with Generation 4 CommandCenter?
15.16 AM/FM Home Page
15.17 Premium Radio CD Home Page
15.18 Premium Radio USB Home Page
15.19 Premium Radio Bluetooth? Home Page
15.20 Auxiliary Home Page
15.21 Pair Bluetooth? Device to Generation 4 CommandCenter?
15.22 Manage Paired Bluetooth? Devices
15.23 Phone Operation
15.24 Phone Signal Strength and Battery Charge
15.25 Contact List
15.26 Recent Calls
15.27 Clear Favorites and Call History
16 AMS? Technology
16.1 Machine Sync
16.2 Mount StarFire? Receiver
16.3 Install GreenStar? System Components
16.4 Install Machine Communications Radio (MCR) Antenna
16.5 Connect AutoTrac? Assisted Steering System
17 Intelligent Total Equipment Control (iTEC?)
17.1 CommandARM? Control Functions
17.2 iTEC? Station Description
17.3 CommandCenter? Pages Descriptions and Functions
17.4 Status Area
17.5 All Sequence Page
17.6 Add New Sequence
17.7 Sequence Step Status
17.8 Edit or Remove Sequence
17.9 Sequence Sets Page
17.10 Perform Sequence
17.11 Recommendations (AutoLearn)
17.12 iTEC? Functions?Efficiency Manager?
18 Tractor-Implement Automation (TIA?)
18.1 Tractor-Implement Automation? (TIA?)
18.2 Activate Tractor-Implement Automation? Equipment
18.3 Tractor-Implement Automation? ? Status Page
18.4 Operate Tractor-Implement Automation?
18.5 SCV Requirements
18.6 Powershift Transmission Requirements
18.7 AutoTrac? Guidance Requirements
18.8 Drive Strategy Requirements
19 Drivetrain
19.1 Drivetrain Overview
19.2 HydraCushion? Front Axle Suspension
19.3 Drivetrain Protection?9520R Scraper, 9570R Scraper and 9620R Scraper
20 Differential Lock
20.1 Differential Lock
20.2 Change Differential Lock Disengagement Steering Angle
21 Brakes
21.1 Brake Use
21.2 Brake Warning Indicators
21.3 Hydraulic Trailer Brakes (If Equipped)
21.4 Trailer Brake Settings
21.5 Engine Brake ? 15 L Engine (If Equipped)
21.6 Use Secondary Brake Lever
21.7 Foot Decelerator
22 Transmission – General Information
22.1 Warm-Up Transmission-Hydraulic System
22.2 Activate and Set Maximum Set Speed
22.3 Use Maximum Set Speed with Different Transmission Modes
22.4 Backup Alarm
22.5 Come-Home Mode
23 e18? Powershift Transmission
23.1 Operate the e18? Powershift Transmission
23.2 Shift e18? Transmission
23.3 Avoid Tractor Overspeed
23.4 Set Start Gears
23.5 CommandCenter? Transmission Main Page
23.6 Efficiency Manager? on the e18? Transmission
23.7 Efficiency Manager? Custom Transmission Settings
24 Drawbar
24.1 Install Drawbar or Quick-Attach in Short Drawbar Support
24.2 Short Scraper Drawbar Conversion
24.3 Long Drawbar Support Load Limitations
24.4 Tow Cable (If Equipped)
25 Hydraulics – General Information
25.1 Hydraulic System Overview
26 Selective Control Valves
26.1 Configure SCV Modes
26.2 Configure SCV – Standard Mode
26.3 Activate Independent Mode
26.4 Configure SCV – Independent Mode
26.5 Configure SCV – Feature Mode
26.6 Total Rear SCV Flow
26.7 Six Position SCV Control Levers
26.8 SCV Control Lever?Neutral Position
26.9 SCV Control Lever?Extend and Retract Position
26.10 SCV Control Lever?Extend Detent and Retract Detent Position
26.11 SCV Control Lever?Float Position
26.12 Operator Presence Sensor
26.13 CommandARM? Joystick (If Equipped)
26.14 CommandARM? Joystick (If Equipped) – Custom Setup
26.15 CommandARM? Joystick (If Equipped) – Layout and Joystick Lever Functions
26.16 SCV and Joystick Flow Response Setting
27 Hydraulic Connections
27.1 Connecting Hydraulic Hoses?Rear of Tractor
27.2 Disconnecting Hydraulic Hoses?Rear of Tractor
27.3 High Flow Hydraulic Component Identification
27.4 Standard Hydraulic Component Identification
27.5 Using Load-Sensing Hydraulic System?Power-Beyond
27.6 Examples Using Load-Sensing Hydraulic System?Power-Beyond
27.7 Scraper Connection Example: Pulling 1, 2, and 3 Scrapers
27.8 Implements Requiring Large Volumes of Oil
27.9 Scraper Hydraulic Hose Tips
28 TouchSet? Depth Control
28.1 Attaching Implement and Control System
28.2 Reset Implement Connector
28.3 Using TouchSet? Depth Controls
29 Scraper Information
29.1 Scraper Operation Cycle
29.2 Weight Transfer Limits
29.3 Scraper/Tractor Attachment
29.4 Loading Techniques
29.5 Connect AutoLoad? Harness
29.6 AutoLoad? Displays
29.7 Scraper Control Panel Reference
29.8 AutoLoad? Settings – Setting Auto Dimensions
29.9 Using AutoLoad?
29.10 Set Scraper ?Transport? Height
29.11 Set Scraper ?Ready? (Dump) Height
29.12 Set Scraper Ground ?Loading? Entering the Cut Height
29.13 AutoLoad? Operation
29.14 AutoLoad? Set Up Wizard
30 Wheels and Tires – General Information
30.1 Service Tires Safely
30.2 Tire Group Sizes
30.3 Change Tire Size
30.4 Using Correct Tire Combinations
30.5 Tire Load Index
30.6 Tire Sidewall Information
30.7 Tire Inflation Pressure Guidelines
31 Wheels and Tires
31.1 Recommended Inflation Pressures?Flotation Logger
31.2 Recommended Inflation Pressures?Group 47
31.3 Recommended Inflation Pressures?Group 48
31.4 Observing Tread Width Limitations
31.5 Tread Widths
31.6 Installing Wheel Rim to Cast Wheel
31.7 Wheel Tightening Stand
31.8 Wheel Weight Holding Wrench
31.9 Use Wheel Torque Wrench Adapter
31.10 Adjust and Tighten Wheels ? Heavy-Duty Drive Wheels and Dual Hubs
31.11 Installing 76×50.00 B-32 Flotation Wheel and Tire Assembly
32 Steering Stop, Fender, and Tread Settings
32.1 Using Steering Stops
33 Operator?s Station – General Information
33.1 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (2010/52/EU)
33.2 Avoid Contact with Agricultural Chemicals
33.3 Clean Vehicle of Hazardous Pesticides
33.4 Keep Riders Off Machine
33.5 Keep Operator Station Window and Door Closed
33.6 Use Seat Belts
33.7 Use Emergency Exit
33.8 Monitor Bracket Mounts
34 Seat
34.1 Adjust ComfortCommand? Seat
34.2 Adjust Heated Leather Seat
34.3 Adjust ActiveSeat?
34.4 Adjust CommandARM? Position
34.5 Use Instructional Seat
34.6 Operator Presence Sensor
35 Steering Column
35.1 Adjust Steering Wheel and Column
35.2 Operate Horn
36 Mirrors
36.1 Manual Mirror
36.2 Electric Mirror
36.3 Telescoping Heated Electric Mirror
37 Wiper Washer
37.1 Operate Front Windshield Wiper and Washer
37.2 Operate Rear Wiper and Washer
37.3 Operate Right-Hand Wiper and Washer
38 Lights
38.1 Light Identification (Version A)
38.2 Light Identification (Version B)
38.3 Configurable Lights
38.4 Steering Column Light Controls (Version A)
38.5 Steering Column Light Controls (Version B)
38.6 Exit Lights
38.7 Operate Turn Signals and High/Low Beam
38.8 Safety Lights and Devices
38.9 CommandARM? Light Buttons
38.10 Hazard Lights and Extremity Warning Lights
38.11 Trailering Lights
38.12 Rotary Beacon Light
38.13 7-Pin Outlet (Equipped with Version A Lighting)
38.14 7-Pin Outlet (Equipped with Version B Lighting)
39 Accessories
39.1 Pull-Down Sunshade
39.2 Install Business Band or Citizens Band (CB) Radio and Antenna
39.3 Auxiliary Power Strip Use
39.4 Accessory Electrical Outlet Use
39.5 Connect Compatible Electronic Equipment
39.6 Configure Tractor for GPS or Radar
39.7 Refrigerator or Storage Space
39.8 Implement Connector Use
39.9 Use AutoLoad? Harness Connector
40 HVAC
40.1 Climate Controls
40.2 HVAC Settings?Generation 4 CommandCenter?
41 Performance Ballasting
41.1 General Performance Guidelines
41.2 Determining Maximum Ballast
41.3 Tire Sidewall Information
41.4 Ballasting for Engine Horsepower
41.5 Controlling Power Hop
41.6 Calculating Ballast?Without Dolly on Drawbar Hitch
41.7 Calculating Ballast?With Dolly – Wheel Scrapers or Drawn Tillage Implements
41.8 Recommended Ballast?Dual Radial Tires
41.9 Scraper Ballast Package with Duals
41.10 Recommended Ballast?76×50.00B32 and Logger Tires-Singles
41.11 Recommended Ballast?Scraper/Ag Combination Tractor With Radial Tires
41.12 Using Cast Hub Wheel Weights
41.13 Front Weight Frame
41.14 Implement and Scraper Size Guidelines
41.15 Measure Wheel Slip?Manually
41.16 Using Liquid Ballast
41.17 Worksheet to Calculate Ballast Changes
41.18 Unballasted Tractor Weight Chart (9470R and 9520R)
41.19 Unballasted Tractor Weight Chart (9570R and 9620R)
42 Transport
42.1 Driving Tractor on Roads
42.2 Towed Mass
42.3 Towed Loads and Transport with Ballast
42.4 Use Safety Lights and Devices
42.5 Transport Rear Mounted Implements with Ballast
42.6 Carrier Transport
42.7 Tie Down on Transport Carrier
42.8 Towing?Engine Will Start
42.9 Towing ? Axles on Ground?Engine Will Not Start
42.10 Freeing a Mired Tractor
43 Fuel, Lubricants, and Coolant – General Information
43.1 Determine Tractor Engine Type
43.2 Minimizing the Effect of Cold Weather on Diesel Engines
43.3 Oil Filters
44 Fuel
44.1 Diesel Fuel
44.2 Supplemental Diesel Fuel Additives
44.3 Lubricity of Diesel Fuel
44.4 Handling and Storing Diesel Fuel
44.5 Avoid Static Electricity Risk When Refueling
44.6 Fill Fuel Tank
44.7 BioDiesel Fuel
44.8 Testing Diesel Fuel
44.9 Fuel Filters
45 Diesel Exhaust Fluid (DEF)
45.1 Fill Diesel Exhaust Fluid (DEF) Tank – FT4/Stage IV Engines
45.2 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
45.3 Storing Diesel Exhaust Fluid (DEF)
45.4 Refilling Diesel Exhaust Fluid (DEF) Tank
45.5 Testing Diesel Exhaust Fluid (DEF)
45.6 Disposal of Diesel Exhaust Fluid (DEF)
46 Engine Oil
46.1 John Deere Break-In Plus? Engine Oil ? Final Tier 4 and Stage IV 13.5 L Engine
46.2 Break-In Engine Oil Use ? Final Tier 4 and Stage IV 15 L Engines
46.3 Diesel Engine Oil ? Tier 2 and Stage II
46.4 Engine Oil and Filter Service Intervals ? Tier 2 and Stage II Engines
46.5 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
46.6 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 13.5 L Engine
46.7 Engine Oil and Filter Service Intervals ? Final Tier 4 and Stage IV 15 L Engine
46.8 Diesel Engine Oil Service Interval for Operation at High Altitude
47 Engine Coolant
47.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
47.2 John Deere COOL-GARD? II Coolant Extender
47.3 Operating in Warm Temperature Climates
47.4 Water Quality for Mixing with Coolant Concentrate
47.5 Testing Coolant Freeze Point
47.6 Disposing of Coolant
48 Other Lubricants
48.1 Transmission and Hydraulic Oil
48.2 Multipurpose Extreme Pressure (EP) Grease
48.3 Mixing of Lubricants
48.4 Alternative and Synthetic Lubricants
48.5 Lubricant Storage
49 Service – General Information
49.1 Service Sections Overview
49.2 Service Tasks Performed As Required
49.3 Identify Tractor Engine Emissions Status
49.4 Open Hood
49.5 Jack Up Tractor – Lifting Points and Support Stand Placement
49.6 Service and Connect STC? (Snap-to-Connect) Fittings
49.7 High-Pressure Washer Use
49.8 Diesel Particulate Filter Service
49.9 Exhaust Filter / Diesel Particulate Filter Ash Handling and Disposal
49.10 Exhaust Filter Disposal
49.11 Transmission Calibration
49.12 Abort Transmission Calibration
49.13 Do Not Modify Fuel System
49.14 Do Not Open High-Pressure Fuel System
49.15 Bleed Fuel System
49.16 Identify Zinc-Flake Coated Fasteners
49.17 Metric Bolt and Screw Torque Values
49.18 Unified Inch Bolt and Screw Torque Values
50 Service – Predelivery Checklist
50.1 Predelivery Checklist
51 Service – Delivery Checklist and Certificate
51.1 Delivery Checklist and Certificate
52 Break-In Service (100 Hours or Less)
52.1 Perform Break-In Services
53 Service – Record Charts
53.1 Engine Oil and Filter Change
53.2 As Required Service
53.3 Annual Service
53.4 10 Hour or Daily Service
53.5 50 Hour Service
53.6 250 Hour Service
53.7 400 Hour Service
53.8 500 Hour Service
53.9 750 Hour Service
53.10 800 Hour Service
53.11 1000 Hour Service
53.12 1200 Hour Service
53.13 1250 Hour Service
53.14 1500 Hour Service
53.15 1600 Hour Service
53.16 1750 Hour Service
53.17 2000 Hour Service
53.18 2250 Hour Service
53.19 2400 Hour Service
53.20 2500 Hour Service
53.21 2750 Hour Service
53.22 2800 Hour Service
53.23 3000 Hour Service
53.24 3200 Hour Service
53.25 3250 Hour Service
53.26 3500 Hour Service
53.27 3600 Hour Service
53.28 3750 Hour Service
53.29 4000 Hour Service
53.30 4250 Hour Service
53.31 4400 Hour Service
53.32 4500 Hour Service
53.33 4750 Hour Service
53.34 4800 Hour Service
53.35 5000 Hour Service
53.36 5200 Hour Service
53.37 5250 Hour Service
53.38 5500 Hour Service
53.39 5600 Hour Service
53.40 5750 Hour Service
53.41 6000 Hour Service
53.42 Services – 6250 to 8800 Hours
53.43 9000 Hour Service
53.44 Services Beyond 9000 Hours
54 Service – Clean
54.1 Diesel Particulate Filter (DPF)?Final Tier 4/Stage IV Engine
54.2 Engine Cooling System?13.5 L Engine
54.3 Engine Cooling System?15 L Engine
54.4 DEF Tank
54.5 DEF Tank Filler Neck Filter
54.6 Clean Display
54.7 Dual Beam Radar Sensor
54.8 Optional Fuel Water Separator
54.9 Optional Fuel Water Separator Filter Element
54.10 Aftertreatment Fuel Injector?15 L Engine
55 Service – Check
55.1 Engine Coolant Level
55.2 Optional Fuel/Water Separator
55.3 Water Separator
55.4 Engine and Exhaust Compartments
55.5 Outer Exhaust Screens
55.6 Air Conditioning System
55.7 Engine Water Pump Weep Hole?13.5 L Engine
55.8 Engine Water Pump Seal?15 L Engine
55.9 Fuel Tank Sump
55.10 Engine Oil Level?13.5 L Engine
55.11 Engine Oil Level?15 L Engine
55.12 Transmission-Hydraulic Oil Level
55.13 Tires
55.14 Hydraulic Accumulator
55.15 Secondary Brake
55.16 NEUTRAL Start System
55.17 Transmission PARK System
55.18 Engine Air Intake System?13.5 L Tier 2/Stage II Engines
55.19 Engine Air Intake System?13.5 L Final Tier 4/Stage IV Engine
55.20 Engine Air Intake System?15 L Engine
55.21 Engine Coolant Freeze Point
55.22 Seat Belts
55.23 HydraCushion? Suspended Front Axle Accumulator Charge Pressure
55.24 Auxiliary Drive Belt and Drive Belt Tensioner
55.25 Axle End Play
55.26 Engine Valve Clearance
55.27 Vari-Cool? Fan Drive and Belt?13.5L Final Tier 4/Stage IV Engine
55.28 Front Driveshaft Health (FDH) Sensor System
56 Service – Tighten
56.1 Wheel and Wheel Weight Bolts
56.2 Use Wheel Tightening Stand
56.3 Use Wheel Torque Wrench Adapter
56.4 Scraper Drawbar Bolts
57 Service – Change
57.1 Replace Fan Belt?13.5 Tier 2 and Stage II Engine
57.2 Vari-Cool? Fan Belt?13.5 L Final Tier 4/Stage IV Engine
57.3 Vari-Cool? Fan Drive Bushings and Seals?13.5L Final Tier 4/Stage IV Engine
57.4 Auxiliary Drive Belt?9.0 L Engine
57.5 Auxiliary Drive Belt?13.5 L Engine
57.6 Auxiliary Drive Belt?15 L Engine
57.7 Engine Oil and Filter?13.5 L Engine
57.8 Engine Oil and Filter?15 L Engine
57.9 Fuel Filters?13.5 L Engine
57.10 Fuel Filters?15 L Engine
57.11 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (2010/52/EU)
57.12 Engine Primary and Secondary Air Filters
57.13 Cab Recirculation Air Filter
57.14 Cab Fresh Air Filter
57.15 Fuel Tank Vent Filters
57.16 SCV Pilot Valve Filter
57.17 Access DEF Dosing Unit Filter?Final Tier 4/Stage IV Engine
57.18 DEF Dosing Unit Filter?Final Tier 4/Stage IV Engine
57.19 DEF Tank Vent Filter?Final Tier 4/Stage IV Engine
57.20 DEF Header Filter?Final Tier 4/Stage IV Engine
57.21 Transmission-Hydraulic Oil and Filters
57.22 Engine Cooling System Radiator Cap?15 L Engine
57.23 Transmission-Hydraulic Vent Filter
57.24 Transmission Drive Shaft Damper
57.25 Engine Coolant?13.5 L Engine
57.26 Engine Coolant?15 L Engine
57.27 Engine Crankshaft Damper?13.5 L Engine
57.28 Engine Crankcase Breather Filter Element?15 L Engine
57.29 Front Drive Shaft U-Joints
58 Service – Lubricate
58.1 HydraCushion? Front Axle Suspension
58.2 Hinge Pins
58.3 Steering Pins
58.4 Telescoping Drive Shaft
58.5 Hydraulic Hose Support Bracket
58.6 Heavy-Duty Gudgeon Bearings
58.7 Lower Drive Line Bearings
58.8 Vari-Cool? Fan Drive?13.5 L Final Tier 4/Stage IV Engine
59 Service – Electrical
59.1 Service – Electrical Overview
59.2 Welding Near Electronic Control Units
59.3 Keep Electronic Control Unit Connectors Clean
59.4 Compressed Air Use
59.5 High-Pressure Washer Use
59.6 Disconnect Battery?Final Tier 4/Stage IV Engine
59.7 Handling Batteries Safely
59.8 Service Batteries and Connectors?13.5 L Engine
59.9 Service Batteries and Connectors?Tier 2 or Stage II or Interim Tier 4 or Stage III Engine
59.10 Service Batteries and Connectors?15 L Engine
59.11 Access Load Center Fuses
59.12 Access Master Fuses
59.13 Access Implement Power Relay Module Fuses
59.14 Handle Halogen Light Bulbs Safely
59.15 Change Front HID/LED Light Assembly
59.16 Change Front Grille Halogen Light Bulbs
59.17 Adjust Front Grille Lights
59.18 Adjust Headlights
59.19 Change Front, Side And Rear Cab Roof Light Bulb
59.20 Change Brake or Turn Signal Light Bulb
59.21 Change Dome Light Bulb
59.22 Change Extremity Warning Light Bulb
59.23 Change Trailering Light Bulb
60 Troubleshooting – Procedures
60.1 Engine
60.2 Transmission-Hydraulic-Axles
60.3 Brakes
60.4 Selective Control Valve (SCV)
60.5 Electrical System
60.6 Operator Enclosure
60.7 Premium Radio
61 Troubleshooting – Diagnostic Trouble Codes (DTC)
61.1 STOP and Service Alert Indicators
61.2 Information Indicator
61.3 Access Diagnostic Trouble Codes
62 Service – Storage
62.1 Place Tractor in Storage
62.2 Remove Tractor from Storage
62.3 Paint Finish Care
63 Specifications
63.1 Engine: John Deere
63.2 Engine: QSX15 Cummins?
63.3 Capacities
63.4 Hydraulics
63.5 Electrical
63.6 Transmission and Power Train
63.7 Drawbar
63.8 Overall Dimensions
63.9 Loads and Weights – (on Tractor 9470R Scraper)
63.10 Loads and Weights – (on Tractors 9520R Scraper, 9570R Scraper, and 9620R Scraper)
63.11 How to Calculate Permissible Mass
63.12 Sound Level
63.13 Other Equipment
63.14 Ground Speeds?e18? Powershift Transmission
63.15 Eurasian Economic Union
63.16 Machine Design Life
63.17 Required Emission-Related Information
63.18 Limited Battery Warranty
64 Identification Numbers
64.1 Identification Plates
64.2 Product Identification Number
64.3 Product Identification Number (China Only)
64.4 Engine Serial Number
64.5 Cab Serial Number
64.6 Transmission Serial Number
64.7 Keep Proof of Ownership
64.8 Keep Machines Secure
65 Change of Ownership
65.1 Subsequent Ownership
66 John Deere Service Literature Available
66.1 Technical Information
67 John Deere Service Keeps You On The Job
67.1 John Deere Parts
67.2 The Right Tools
67.3 Well-Trained Technicians
67.4 Prompt Service
