John Deere 7r Tractors Operator Manuals OMTA28704

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Transport, ROPS, and Seat Belt
4.3 Instructional Seat (If Equipped)
4.4 Engine Block Heater (If Equipped)
4.5 Triple Link Suspension Plus (TLS Plus) (If Equipped)
4.6 Front PTO (If Equipped)
4.7 Quick-Hitch (If Equipped)
4.8 Rear PTO Shield (If Equipped)
4.9 Rear PTO Shield (If Equipped)
5 Vehicle Overview
5.1 7R Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Engine Set Speed
6.5 Engine Settings?Max Engine Speed
6.6 Engine Settings?Exhaust Filter System Overview
6.7 Engine Settings?AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.9 Engine Settings?Parked Filter Cleaning
6.10 Required Machine Stop Warning
6.11 Engine Fuel System and Power Rating
6.12 Battery Disconnect Switch
6.13 Start the Engine
6.14 Run the Engine
6.15 Stop the Engine
6.16 Restart Engine That Has Run Out of Fuel
6.17 Reduce Fuel Consumption
6.18 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?With Glow Plug Starting Aid (6.8 L Engine)
7.2 Cold Weather Starting?Without Starting Aid (9.0 L Engine)
7.3 Cold Weather Starting?With Starting Aid (9.0 L Engine)
7.4 Change Starting Fluid Canister
7.5 Auxiliary Heaters Use
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
9 Front Console
9.1 Front Console
9.2 Adjust Steering Wheel and Column
9.3 Operate Horn
9.4 Operate Wipers and Washers
9.5 Key Switch
9.6 Operate Turn Signals
9.7 Pedals
9.8 Operate Lights
10 Corner Post Display
10.1 Corner Post Display
11 CommandARM Controls
11.1 CommandARM
11.2 CommandARM Hitch Controls
11.3 CommandARM SCV Control Levers
11.4 CommandARM PTO Control Levers
11.5 CommandARM Climate, Radio, and Lighting Controls
11.6 CommandARM Controls?Left Side
11.7 CommandARM Joystick
11.8 CommandARM Navigation Bar
11.9 Adjust CommandARM Position
12 CommandCenter
12.1 Generation 4 Display
12.2 Machine Settings Overview
12.3 Navigate Generation 4 CommandCenter
12.4 Compatible Universal Displays
12.5 Power Display On and Off
12.6 Change Pages and Values
12.7 Factory and Service ADVISOR Installed Onscreen Help
12.8 Radar Calibration
12.9 Slip Calibration
12.10 Steering Settings?Access
12.11 Steering Settings
12.12 Steering Settings?ACS 2 Variable Ratio Steering
12.13 Steering Settings?ACS 2 Sensitivity
12.14 Steering Settings?Steering Wheel Resistance
12.15 Steering Settings?Reactive Steering
12.16 Controls Setup
12.17 Install Video Display Camera
13 Intelligent Total Equipment Control (iTEC)
13.1 CommandARM Control Functions
13.2 CommandCenter Pages Descriptions and Functions
13.3 Status Area
13.4 All Sequence Page
13.5 Add New Sequence
13.6 Sequence Step Status
13.7 Edit or Remove Sequence
13.8 Sequence Sets Page
13.9 Perform Sequence
13.10 Recommendations (AutoLearn)
13.11 iTEC Functions?IVT/AutoPowr and EVT/eAutoPowr Transmissions
13.12 iTEC Functions?Efficiency Manager
14 Tractor-Implement Automation (TIA)
14.1 TIA?General Information
14.2 Activate TIA Equipment
14.3 Operate TIA
14.4 PTO Requirements
14.5 SCV Requirements
14.6 IVT/AutoPowr and EVT/eAutoPowr Requirements
14.7 IVT/AutoPowr and EVT/eAutoPowr with CommandPRO Joystick Requirements
14.8 PowerShift Transmission Requirements
14.9 AutoTrac Guidance Requirements
14.10 Rear Hitch Requirements
15 Drivetrain
15.1 Drivetrain Overview
15.2 Suspension Settings?Access
15.3 Suspension Settings
15.4 Suspension Settings?Manual
15.5 Operate Suspension
15.6 Differential Lock
15.7 Mechanical Front-Wheel Drive (MFWD)
15.8 Large Square Baler (LSB) Ride Control
16 Brakes
16.1 Trailer Brake System Settings?Access
16.2 Trailer Brake System Settings
16.3 Trailer Brake System Settings?Brake Gain
16.4 Trailer Brake System Settings?Pre-Brake Offset
16.5 Trailer Brake System Settings?Trailer Brake Test
16.6 Trailer Brake System Settings?Advanced
16.7 Brake Use
16.8 AutoClutch
16.9 Hydraulic Trailer Brakes
16.10 Air Trailer Brakes
17 Transmission?General Information
17.1 Transmission Settings?Access Advanced
17.2 Transmission Settings?Advanced
17.3 Transmission Top Speed Note
17.4 Warm-Up Transmission-Hydraulic System
17.5 Backup Alarm
18 e23 Transmission
18.1 Operate Transmission?e23
18.2 Shift Transmission?e23
18.3 e23 Set Speeds and Efficiency Manager
18.4 e23 Transmission Settings?Access
18.5 e23 Transmission Settings
18.6 e23 Transmission Settings?Mode
18.7 e23 Transmission Settings?Custom
18.8 e23 Transmission Settings?Droop
18.9 e23 Transmission Settings?ECO
18.10 e23 Transmission Settings?Max Speeds
19 IVT/AutoPowr Transmission
19.1 Operate Transmission?IVT
19.2 Shift Transmission?IVT
19.3 IVT Set Speeds
19.4 IVT Transmission Settings?Access
19.5 IVT Transmission Settings
19.6 IVT Transmission Settings?Mode
19.7 IVT Transmission Settings?Pedal Mode
19.8 IVT Transmission Settings?Custom
19.9 IVT Transmission Settings?Droop
19.10 IVT Transmission Settings?ECO
19.11 IVT Transmission Settings?Max Speeds
20 IVT/AutoPowr Transmission with CommandPRO Joystick
20.1 Operate Transmission?IVT with CommandPRO Joystick
20.2 Shift Transmission?IVT with CommandPRO Joystick
20.3 CommandPRO Joystick
20.4 CommandPRO Joystick Guide
20.5 CommandPRO Joystick?Acceleration/Deceleration Response
20.6 CommandPRO Joystick?Enable Set Speeds
20.7 CommandPRO Joystick?Adjust Travel Direction
20.8 CommandPRO Joystick?Stopping
20.9 CommandPRO Joystick?Operating on Hillsides
20.10 CommandPRO Transmission Settings?Access
20.11 CommandPRO Transmission Settings
20.12 CommandPRO Transmission Settings?Mode
20.13 CommandPRO Transmission Settings?Custom
20.14 CommandPRO Transmission Settings?Droop
20.15 CommandPRO Transmission Settings?Minimum Engine Speed
20.16 CommandPRO Transmission Settings?Set Speeds
20.17 CommandPRO Transmission Settings?Shuttle Shift Speeds
20.18 CommandPRO Transmission Settings?Speed Limits
21 PTO?General Information
21.1 PTO Settings?Access
21.2 PTO Settings
21.3 PTO Settings?Advanced
21.4 PTO Settings?Engagement Rate
21.5 PTO Settings?Rear PTO Speed Limit
21.6 PTO Settings?PTO Out-of-Seat
21.7 Operate PTOs
21.8 External PTO Switches
21.9 Select Correct Engine Speed
22 Front PTO
22.1 Front PTO Disconnect
22.2 PTO Cold-Weather Operation
22.3 Change Optional Front PTO Shafts
22.4 Attach PTO-Driven Implement?Front
23 Rear PTO
23.1 Rear PTO Shield?Type 3 PTO
23.2 Operate Shiftable 3-Speed Rear PTO (If Equipped)
23.3 Operate Shiftable 2-Speed Rear PTO (If Equipped)
23.4 Change PTO Stub Shaft (If Equipped)
23.5 Attach PTO-Driven Implement?Rear
24 Front Hitch
24.1 Hitch Lift Capacities?Front
24.2 Front Hitch Settings?Access
24.3 Front Hitch Settings
24.4 Front Hitch Settings?Upper Limit
24.5 Front Hitch Settings?Drop Rate
24.6 Front Hitch Settings?Raise Rate
24.7 Front Hitch Settings?Position and Set Points
24.8 Front Hitch Use
25 Rear Hitch
25.1 Hitch Lift Capacities?Rear
25.2 Rear Hitch Settings?Access
25.3 Rear Hitch Settings
25.4 Rear Hitch Settings?Upper Limit
25.5 Rear Hitch Settings?Drop Rate
25.6 Rear Hitch Settings?Raise Rate
25.7 Rear Hitch Settings?Load Depth
25.8 Rear Hitch Settings?Slip Sensitivity
25.9 Rear Hitch Settings?Position
25.10 Rear Hitch Settings?Advanced
25.11 Rear Hitch Settings?Position Control
25.12 Rear Hitch Settings?Draft Control
25.13 Hitch Control Lever Adjustments
25.14 Hitch Depth Set Point
25.15 Float Operation
25.16 Rear Hitch Components
25.17 External Hitch Switches
25.18 Hitch Manual Lowering
25.19 Adjust Sway Blocks
25.20 Adjust Deluxe Stabilizers
25.21 Attach Implement to Quick-Hitch
25.22 Adjust Implement Level
25.23 Adjust Lateral Float
25.24 Detach Implement from Quick-Hitch
25.25 Convert Category 3/3N Convertible Quick-Hitch Lower Hooks
25.26 3-in-1 Hitch System
26 Drawbar
26.1 Drawbar Load Limitations
26.2 Adjust Drawbar
26.3 Install and Use Clevis Assembly?Category 3 Drawbar
26.4 Install and Use Clevis Assembly?Category 4 Drawbar
26.5 Install and Use Clevis Assembly?High Vertical Load Drawbar Support
27 Hydraulics?General Information
27.1 Hydraulic System Overview
27.2 Hydraulic Option Connector
28 Selective Control Valves
28.1 SCV Settings?Access
28.2 SCV Settings
28.3 SCV Settings?Standard Mode
28.4 SCV Settings?Independent Mode
28.5 SCV Settings?Feature Mode
28.6 SCV Settings?Flow Adjustment
28.7 SCV Settings?Time Adjustment
28.8 SCV Settings?Advanced
28.9 SCV Settings?Activating Independent Mode
28.10 SCV Settings?Automation
28.11 SCV Settings?Assignment
28.12 SCV Settings?Flow Adjustment Sensitivity
28.13 SCV Control Lever Adjustments
28.14 External SCV Switches
28.15 Total SCV Flow
28.16 Operate SCVs with CommandARM Joystick
28.17 CommandARM Joystick?Layout and Joystick Lever Functions
29 Hydraulic Connections
29.1 Connect/Disconnect Hydraulic Hoses
29.2 Component Identification and Location?Rear SCVs
29.3 Component Identification and Location?Mid-Mount or Front SCVs
29.4 Use Load-Sense Hydraulic System (Power Beyond)
29.5 Examples Using Load-Sensing Hydraulic System?Power-Beyond
29.6 Implement Connections?Active Down Pressure
29.7 Implement Connections?Vacuum Motors with Power Beyond and Motor Case Drain
29.8 Implement Connections?Hydraulic Motor with Motor Return
29.9 Implement Connections?Vacuum Motor with Motor Return Tip
29.10 Implement Connections?Hitch Auxiliary Raise in Parallel with Hitch Valve
29.11 Implement Connections?Hitch Auxiliary Raise in Parallel with SCV
29.12 Hydraulic Motor Return and Case Drain Kits
29.13 Hitch Auxiliary Raise Kit
29.14 Using Implements Requiring Large Volumes of Oil
30 TouchSet Depth Control
30.1 TouchSet Depth Control Settings and Adjustments
30.2 Connect/Disconnect the Implement Position Connector
31 Laser Scraper Control
31.1 Laser Scraper?Scrapers Equipped with Scraper Control Unit
32 Wheels and Tires?General Information
32.1 Determine Tire Load Capacity
32.2 Change Tire Size
32.3 Select Tire Combinations
32.4 Tire Load Index
32.5 Tire Inflation Pressure Guidelines
32.6 Clamp-On Dual Usage
33 Front Wheels and Tires
33.1 Recommended Pressures?Group 42
33.2 Recommended Pressures?Group 43
33.3 Recommended Pressures?Group 44
33.4 Adjust and Tighten?Front Wheel Bolts
33.5 Toe-In Check
34 Steering Stop, Fender, and Tread Settings
34.1 Tire, Steering Stop, and Fender Settings Table Explanation
34.2 Tire, Steering Stop, and Fender Settings?1300 MFWD Axle
34.3 Tire, Steering Stop, and Fender Settings?TLS Plus Axle
34.4 Determine Rim Type
34.5 Wheel Settings?8-Position
34.6 Wheel Setting?16-Position
34.7 Set Steering Stops
34.8 Fender Settings
35 Rear Wheels and Tires
35.1 Recommended Pressures?Group 47
35.2 Recommended Pressures?Group 48
35.3 Recommended Pressures?Group 48?Continued
35.4 Recommended Pressures?Group 49
35.5 16-Position Rear Wheel Settings
35.6 Rear Wheel, Tire, and Tread Guidelines
35.7 Minimum Tread Setting with Air Trailer Brakes and Inner Wheel Weights
35.8 Use Wheel Tightening Stand
35.9 Install Rear Drive Wheel to Cast Hub
35.10 Install Rear Steel Wheel to Hub
35.11 Adjust and Tighten Rear Steel Wheels with Cast Hubs
35.12 Adjust and Tighten Rear Wheels?10-Bolt Heavy-Duty Hubs
35.13 Adjust and Tighten Rear Wheels?12-Bolt Heavy-Duty Hubs
35.14 Single Wheel Tread Settings
35.15 Dual Wheel Tread Settings
35.16 Dual Wheel Row Crop Settings and Dual Hub Extensions
36 Seats
36.1 Adjust Air Seat
36.2 Adjust ActiveSeat II
36.3 Operator Presence Sensor
36.4 Adjust Instructional Seat
37 Mirrors
37.1 Adjust Mirrors
38 Steps
38.1 Left-Hand Steps
38.2 Right-Hand Service Steps
39 Lights
39.1 Light Identification
39.2 Lights Settings?Access
39.3 Lights Settings
39.4 Lights Settings?Field Lights Presets
39.5 Lights Settings?Hood/Belt Line Lights
39.6 Lights Settings?Advanced
39.7 Hazard and Extremity Lights
39.8 Beacon Light
39.9 7-Pin Outlet
40 Accessories
40.1 Right-Hand Side Console
40.2 CommandARM Storage
40.3 Right-Hand Front Corner Post
40.4 Left-Hand Rear Corner Post
40.5 Right-Hand Rear Corner Post
40.6 Refrigerator and Cool/Storage Box
40.7 Sunshade
40.8 Storage Compartments
40.9 Monitor Bracket Mounts
40.10 Emergency Exit
40.11 Install Business Band/Citizens Band (CB) Antenna and/or Radio
40.12 Mount StarFire Receiver
40.13 Mount RTK (Real-Time Kinematic) Radio
40.14 Implement Connector
40.15 RS232 Serial Communication Connection
41 HVAC
41.1 HVAC Settings?Access
41.2 HVAC Settings
41.3 HVAC Settings?Climate Control Automation
41.4 HVAC Settings?Set Temperature
41.5 HVAC Settings?Air Flow Mode
41.6 HVAC Settings?Fan Speed
41.7 HVAC Settings?Air Conditioning
42 Performance Ballasting
42.1 How to Calculate Maximum Permissible Download on Trailer Hitch
42.2 Mechanical Towed Coupling Load Limitations
42.3 General Ballasting Information
42.4 General Guidelines
42.5 General Weight Split Guidelines
42.6 Ballast Options
42.7 Measure Slip
42.8 Ballast Suggestions for Specific Types of Implements used with MFWD Tractors
42.9 Quik-Tatch Weight Use
42.10 Rear Wheel Weight Use
42.11 Rear Wheel Weight Installation?Flanged Axles
42.12 Rear Wheel Weight Installation?Single Cast Drive Wheel
42.13 Rear Wheel Weight Installation?Dual Drive Wheels
42.14 Controlling Power Hop-MFWD Tractors Without TLS Plus Front Axle
42.15 Calculate Tractor Ballast Package
42.16 Add Rear Ballast For Front Loader
42.17 Ballast Suggestions?Hitch-Mounted Implements
42.18 Unballasted Tractor Weight Charts
42.19 Implement and Tractor Codes
42.20 Liquid Ballast Use
43 Transport
43.1 Drive Tractor on Roads
43.2 Transport with Ballast
43.3 Tow Loads
43.4 Use Safety Chain
43.5 Tow Tractor
43.6 Tow Mode
43.7 Come Home Mode
43.8 Transport on Carrier
43.9 Freeing a Mired Tractor
44 Fuel, Lubricants, and Coolant?General Information
44.1 Determine Tractor Engine Type
44.2 Minimizing the Effect of Cold Weather on Diesel Engines
44.3 Oil Filters
45 Fuel
45.1 Diesel Fuel
45.2 Supplemental Diesel Fuel Additives
45.3 Biodiesel Fuel
45.4 Lubricity of Diesel Fuel
45.5 Handling and Storing Diesel Fuel
45.6 Fill Fuel Tank
45.7 Testing Diesel Fuel
45.8 Fuel Filters
46 Diesel Exhaust Fluid (DEF)
46.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
46.2 Storing Diesel Exhaust Fluid (DEF)
46.3 Refilling Diesel Exhaust Fluid (DEF) Tank
46.4 Fill DEF Tank?FT4/Stage V Engine
46.5 Testing Diesel Exhaust Fluid (DEF)
46.6 Disposal of Diesel Exhaust Fluid (DEF)
47 Engine Oil
47.1 Diesel Engine Oil Service Interval for Operation at High Altitude
47.2 John Deere Break-In Plus Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
47.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
47.4 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
48 Engine Coolant
48.1 Diesel Engine Coolant (Engine with Wet Sleeve Cylinder Liners)
48.2 John Deere Cool-Gard II Coolant Extender
48.3 Operating in Warm Temperature Climates
48.4 Water Quality for Mixing with Coolant Concentrate
48.5 Testing Coolant Freeze Point
48.6 Disposing of Coolant
49 Other Lubricants
49.1 Lubricant Storage
49.2 Alternative and Synthetic Lubricants
49.3 Mixing of Lubricants
49.4 Transmission and Hydraulic Oil
49.5 Use Correct Viscosity Front PTO Oil in Cold Weather
49.6 Transmission Recalibration
49.7 Gear Oil
49.8 Multipurpose Extreme Pressure (EP) Grease
50 Service?General Information
50.1 Service Sections Overview
50.2 Service Tasks Performed As Required
50.3 Identify Tractor Engine Emissions Status
50.4 Open Hood
50.5 Remove Engine Access Panel
50.6 Remove Engine Side Shields
50.7 Remove Radiator Shields
50.8 Remove Battery Compartment Cover
50.9 Remove Cab Rear Panel
50.10 Jack Up Tractor?Lifting Points and Support Stand Placement
50.11 Service and Connect STC (Snap-to-Connect) Fittings
50.12 High-Pressure Washer Use
50.13 Do Not Modify Fuel System
50.14 Do Not Open High-Pressure Fuel System
50.15 Bleed Fuel System
50.16 Identify Zinc-Flake Coated Fasteners
50.17 Metric Bolt and Screw Torque Values
50.18 Unified Inch Bolt and Screw Torque Values
51 Service?Break-In (100 Hours or Less)
51.1 Perform Break-In Checks
52 Service?Record Charts
52.1 Service Record Chart Overview
52.2 Service Interval Chart
52.3 Service Record Chart
53 Service?Clean
53.1 Access DEF Tank Drain Plug
53.2 Cleaning Diesel Exhaust Fluid (DEF) Tank
53.3 Tractor Exterior
53.4 Clean Display
53.5 Clean Seat
53.6 Engine Cooling System
53.7 Dual Beam Radar Sensor
53.8 MFWD or TLS Plus Axle Vent Breather
53.9 Implement Connector
54 Service?Check
54.1 Windshield Washer Fluid Level
54.2 Engine Coolant Level
54.3 Engine Coolant Freeze Point
54.4 Water Separator
54.5 Engine Air Filter Precleaner System
54.6 Primary and Secondary Engine Air Filters
54.7 Engine and Exhaust Compartments
54.8 Air Conditioning System
54.9 Engine Water Pump Weep Hole
54.10 Fuel Tank Sump
54.11 MFWD or TLS Plus Axle Housing Oil Level
54.12 Wheel Hub Oil Level
54.13 mk_767
54.14 Engine Oil Level
54.15 Hydraulic System Oil Level
54.16 Mechanical Cab Suspension Components
54.17 Front PTO Housing Oil Level
54.18 Engine Air Intake System?6.8 L Engine
54.19 Engine Air Intake System?9.0 L Engine
54.20 Tires
54.21 TLS Plus Accumulator Charge Pressure
54.22 Seat Belts
54.23 Fan Belt Tensioner and Fan Belt
54.24 Engine Valve Clearance
54.25 Transmission PARK System
55 Service?Tighten
55.1 Wheel and Wheel Weight Bolts
55.2 Use Wheel Tightening Stand
55.3 Use Wheel Torque Wrench Adapter
55.4 Rear Wheel Weight Bolts
55.5 Front Wheel Bolts
55.6 Rear Drive Wheel to Cast Hub Bolts
55.7 Rear Steel Wheel to Hub Bolts
55.8 Rear Steel Wheels?Cast Hub Bolts
55.9 Rear Wheel Bolts?Heavy-Duty Cast 10-Bolt Hubs
55.10 Rear Wheel Bolts?Heavy-Duty 12-Bolt Hubs
56 Service?Change
56.1 Engine Primary and Secondary Air Filters
56.2 Fan Belt
56.3 Engine Oil and Filter?6.8 L Engine
56.4 Engine Oil and Filter?9.0 L Engine
56.5 Fuel Filters
56.6 Optional Fuel Water Separator Filter Element (If Equipped)
56.7 Cab Filters
56.8 Hydraulic Oil and Filters
56.9 Wheel Hub Oil
56.10 MFWD or TLS Plus Axle Housing Oil
56.11 Front PTO Housing Oil and Filter
56.12 Crankcase Ventilation Filter?6.8 L Engine
56.13 Fuel Tank Vent Filter
56.14 SCV Pilot Valve Filter
56.15 Trailer Air Brake Dryer Filter
56.16 DEF Tank Vent Filter
56.17 Access In-Line DEF Filter
56.18 Change Diesel Exhaust Fluid (DEF) In-Line Filter
56.19 Access DEF Dosing Unit Filter
56.20 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
56.21 Transmission Torsional Damper
56.22 Engine Crankshaft Damper?9.0 L Engine
56.23 Engine Coolant
57 Service?Lubricate
57.1 Rear Hitch
57.2 Front Hitch
57.3 Deluxe Stabilizers
57.4 Trailer Hitch
57.5 Lubricate Front Axle Fittings (MFWD or TLS?)
57.6 Draft Link Support Shaft Bushing
58 Service?Electrical
58.1 Service?Electrical Overview
58.2 Welding Near Electronic Control Units
58.3 Keep Electronic Control Unit Connectors Clean
58.4 Compressed Air Use
58.5 High-Pressure Washers Use
58.6 Disconnect Battery
58.7 Service Batteries and Connections
58.8 Load Center?Cab
58.9 Load Center?Front
58.10 Access Master Fuses
58.11 Access Implement Power Relay Module Fuses
58.12 Handle Halogen Light Bulbs Safely
58.13 Change Front LED Light Assembly
58.14 Change Halogen Bulbs
58.15 Adjust Front Grille Lights
58.16 Change Front/Rear Belt Line Work Lights
58.17 Adjust Headlights
58.18 Change Auxiliary Driving Light
58.19 Change Wrap-Around Cab Light
58.20 Change Roof Work Lights
58.21 Change Extremity Arm Light
58.22 Change Cab Dome Light
59 Troubleshooting?Procedures
59.1 Troubleshooting Features
59.2 Electrical System
59.3 Engine
59.4 Hitch
59.5 Hydraulic System
59.6 Operator?s Station
59.7 Selective Control Valve (SCV)
59.8 Steering System
59.9 Tractor Operation
59.10 Transmission
60 Troubleshooting?Diagnostic Trouble Codes (DTC)
60.1 STOP, Service, and Information Alerts on CommandCenter
60.2 Access Diagnostic Trouble Codes
61 Service?Storage
61.1 Place Tractor in Storage
61.2 Remove Tractor from Storage
62 Specifications
62.1 Engine
62.2 Capacities
62.3 Hydraulic System
62.4 Transmission and Drivetrain
62.5 Hitch, Drawbar, and PTO
62.6 Electrical System
62.7 Integrated Technology
62.8 Overall Dimensions
62.9 Tractor Loads/Weights
62.10 Ground Speeds?e23 Transmission
62.11 Ground Speeds?IVT/AutoPowr Transmission
62.12 Limited Battery Warranty
62.13 Emissions Control System Certification Label
62.14 EPA Non-road Emissions Control Warranty Statement?Compression Ignition
62.15 CARB Non-road Emissions Control Warranty Statement?Compression Ignition
62.16 Required Emission-Related Information
62.17 Carbon Dioxide Emissions (CO?)
62.18 Third-Party Software Notifications and Licenses
63 Identification Numbers
63.1 Identification Plates
63.2 Product Identification Number (PIN)
63.3 Engine Serial Number
63.4 Cab Serial Number
63.5 Transmission Serial Number
63.6 Axle Serial Number
63.7 Keep Proof of Ownership
63.8 Keep Machines Secure
64 Change of Ownership
64.1 Subsequent Ownership
65 Predelivery
65.1 Predelivery Checklist
65.2 Delivery Checklist and Certificate
66 Index
67 John Deere Service Literature Available
67.1 Technical Information
68 John Deere Service Keeps You On The Job
68.1 John Deere Is At Your Service