John Deere 7R Tractor Operator Manual OMTA22619

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Transport, ROPS, and Seat Belt
4.3 Instructional Seat (If Equipped)
4.4 Engine Block Heater (If Equipped)
4.5 Triple Link Suspension Plus (TLS? Plus) (If Equipped)
4.6 Front PTO (If Equipped)
4.7 Quick-Hitch (If Equipped)
4.8 Rear PTO Shield (If Equipped)
4.9 Rear PTO Shield (If Equipped)
5 Vehicle Overview
5.1 7R Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Engine Set Speed
6.5 Engine Settings?Max Engine Speed
6.6 Engine Settings?Exhaust Filter System Overview
6.7 Engine Settings?AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.9 Engine Settings?Parked Filter Cleaning
6.10 Required Machine Stop Warning
6.11 Engine Fuel System and Power Rating
6.12 Battery Disconnect Switch
6.13 Start the Engine
6.14 Run the Engine
6.15 Stop the Engine
6.16 Restart Engine That Has Run Out of Fuel
6.17 Reduce Fuel Consumption
6.18 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?With Glow Plug Starting Aid (6.8 L Engine)
7.2 Cold Weather Starting?Without Starting Aid (9.0 L Engine)
7.3 Cold Weather Starting?With Starting Aid (9.0 L Engine)
7.4 Change Starting Fluid Canister
7.5 Auxiliary Heaters Use
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
9 Front Console
9.1 Front Console
9.2 Adjust Steering Wheel and Column
9.3 Operate Horn
9.4 Operate Wipers and Washers
9.5 Key Switch
9.6 Operate Turn Signals
9.7 Pedals
9.8 Operate Lights
10 Corner Post Display
10.1 Corner Post Display
11 CommandARM? Controls
11.1 CommandARM?
11.2 CommandARM? Hitch Controls
11.3 CommandARM? SCV Control Levers
11.4 CommandARM? PTO Control Levers
11.5 CommandARM? Climate, Radio, and Lighting Controls
11.6 Push-To-Talk (PTT)
11.7 CommandARM? Controls?Left Side
11.8 CommandARM? Joystick
11.9 CommandARM? Navigation Bar
11.10 Adjust CommandARM? Position
12 CommandCenter?
12.1 Generation 4 Display
12.2 Machine Settings Overview
12.3 Navigate Generation 4 CommandCenter?
12.4 Compatible Universal Displays
12.5 Power Display On and Off
12.6 Change Pages and Values
12.7 Factory and Service ADVISOR? Installed Onscreen Help
12.8 Radar Calibration
12.9 Slip Calibration
12.10 Steering Settings?Access
12.11 Steering Settings
12.12 Steering Settings?ACS? 2 Variable Ratio Steering
12.13 Steering Settings?ACS? 2 Sensitivity
12.14 Steering Settings?Steering Wheel Resistance
12.15 Controls Setup
12.16 Install Video Display Camera
13 Intelligent Total Equipment Control (iTEC?)
13.1 CommandARM? Control Functions
13.2 CommandCenter? Pages Descriptions and Functions
13.3 Status Area
13.4 All Sequence Page
13.5 Add New Sequence
13.6 Sequence Step Status
13.7 Edit or Remove Sequence
13.8 Sequence Sets Page
13.9 Perform Sequence
13.10 Recommendations (AutoLearn)
13.11 iTEC Functions?IVT?/AutoPowr? Transmission
13.12 iTEC? Functions?Efficiency Manager?
14 Tractor-Implement Automation (TIA)
14.1 TIA?General Information
14.2 Activate TIA Equipment
14.3 Operate TIA
14.4 PTO Requirements
14.5 SCV Requirements
14.6 IVT?/AutoPowr? Requirements
14.7 IVT?/AutoPowr? with CommandPRO? Joystick Requirements
14.8 PowerShift? Transmission Requirements
14.9 AutoTrac? Guidance Requirements
14.10 Rear Hitch Requirements
15 Drivetrain
15.1 Drivetrain Overview
15.2 Suspension Settings?Access
15.3 Suspension Settings
15.4 Suspension Settings?Manual
15.5 Operate Suspension
15.6 Differential Lock
15.7 Mechanical Front-Wheel Drive (MFWD)
15.8 Large Square Baler (LSB) Ride Control
16 Brakes
16.1 Trailer Brake System Settings?Access
16.2 Trailer Brake System Settings
16.3 Trailer Brake System Settings?Brake Gain
16.4 Trailer Brake System Settings?Pre-Brake Offset
16.5 Trailer Brake System Settings?Trailer Brake Test
16.6 Trailer Brake System Settings?Advanced
16.7 Brake Use
16.8 AutoClutch
16.9 Hydraulic Trailer Brakes
16.10 Air Trailer Brakes
17 Transmission?General Information
17.1 Transmission Settings?Access Advanced
17.2 Transmission Settings?Advanced
17.3 Transmission Top Speed Note
17.4 Warm-Up Transmission-Hydraulic System
17.5 Backup Alarm
18 e23? Transmission
18.1 Operate Transmission?e23?
18.2 Shift Transmission?e23?
18.3 e23? Set Speeds and Efficiency Manager?
18.4 e23? Transmission Settings?Access
18.5 e23? Transmission Settings
18.6 e23? Transmission Settings?Mode
18.7 e23? Transmission Settings?Custom
18.8 e23? Transmission Settings?Droop
18.9 e23? Transmission Settings?ECO
18.10 e23? Transmission Settings?Max Speeds
19 IVT?/AutoPowr? Transmission
19.1 Operate Transmission?IVT?
19.2 Shift Transmission?IVT?
19.3 IVT? Set Speeds
19.4 IVT? Transmission Settings?Access
19.5 IVT? Transmission Settings
19.6 IVT? Transmission Settings?Mode
19.7 IVT? Transmission Settings?Pedal Mode
19.8 IVT? Transmission Settings?Custom
19.9 IVT? Transmission Settings?Droop
19.10 IVT? Transmission Settings?ECO
19.11 IVT? Transmission Settings?Max Speeds
20 IVT?/AutoPowr? Transmission with CommandPRO? Joystick
20.1 Operate Transmission?IVT? with CommandPRO? Joystick
20.2 Shift Transmission?IVT? with CommandPRO? Joystick
20.3 CommandPRO? Joystick
20.4 CommandPRO? Joystick?Acceleration/Deceleration Response
20.5 CommandPRO? Joystick?Enable Set Speeds
20.6 CommandPRO? Joystick?Adjust Travel Direction
20.7 CommandPRO? Joystick?Stopping
20.8 CommandPRO? Joystick?Operating on Hillsides
20.9 CommandPRO? Transmission Settings?Access
20.10 CommandPRO? Transmission Settings
20.11 CommandPRO? Transmission Settings?Mode
20.12 CommandPRO? Transmission Settings?Custom
20.13 CommandPRO? Transmission Settings?Droop
20.14 CommandPRO? Transmission Settings?Minimum Engine Speed
20.15 CommandPRO? Transmission Settings?Set Speeds
20.16 CommandPRO? Transmission Settings?Shuttle Shift Speeds
20.17 CommandPRO? Transmission Settings?Speed Limits
21 PTO, Hitch, and Drawbar
21.1 Attach PTO-Driven Implement?Front
21.2 Attach PTO-Driven Implement?Rear
22 PTO?General Information
22.1 PTO Settings?Access
22.2 PTO Settings
22.3 PTO Settings?Advanced
22.4 PTO Settings?Engagement Rate
22.5 PTO Settings?Rear PTO Cruise
22.6 PTO Settings?Auto Disengage
22.7 Operate PTOs
22.8 External PTO Switches
22.9 Select Correct Engine Speed
23 Front PTO
23.1 Front PTO Disconnect
23.2 PTO Cold Weather Operation
23.3 Change Optional Front PTO Shafts
24 Rear PTO
24.1 Rear PTO Shield?Type 3 PTO
24.2 Operate Shiftable 3-Speed Rear PTO (If Equipped)
24.3 Operate Shiftable 2-Speed Rear PTO (If Equipped)
24.4 Change PTO Stub Shaft (If Equipped)
25 Front Hitch
25.1 Front Hitch Settings?Access
25.2 Front Hitch Settings
25.3 Front Hitch Settings?Upper Limit
25.4 Front Hitch Settings?Drop Rate
25.5 Front Hitch Settings?Raise Rate
25.6 Front Hitch Settings?Position and Set Points
25.7 Front Hitch Use
26 Rear Hitch
26.1 Rear Hitch Settings?Access
26.2 Rear Hitch Settings
26.3 Rear Hitch Settings?Upper Limit
26.4 Rear Hitch Settings?Drop Rate
26.5 Rear Hitch Settings?Raise Rate
26.6 Rear Hitch Settings?Load Depth
26.7 Rear Hitch Settings?Slip Sensitivity
26.8 Rear Hitch Settings?Position
26.9 Rear Hitch Settings?Advanced
26.10 Rear Hitch Settings?Position Control
26.11 Rear Hitch Settings?Draft Control
26.12 Hitch Control Lever Adjustments
26.13 Hitch Depth Set Point
26.14 Float Operation
26.15 Rear Hitch Components
26.16 External Hitch Switches
26.17 Hitch Manual Lowering
26.18 Adjust Sway Blocks
26.19 Adjust Deluxe Stabilizers
26.20 Attach Implement to Quick-Hitch
26.21 Adjust Implement Level
26.22 Adjust Lateral Float
26.23 Detach Implement from Quick-Hitch
26.24 Convert Category 3/3N Convertible Quick-Hitch Lower Hooks
26.25 3-in-1 Hitch System
27 Drawbar
27.1 Drawbar Load Limitations
27.2 Adjust Drawbar Position
27.3 Install and Use Clevis Assembly?Cat 3 Drawbar
27.4 Install and Use Clevis Assembly?High Vertical Load Drawbar Support
28 Hydraulics?General Information
28.1 Hydraulic System Overview
29 Selective Control Valves
29.1 SCV Settings?Access
29.2 SCV Settings
29.3 SCV Settings?Standard Mode
29.4 SCV Settings?Independent Mode
29.5 SCV Settings?Feature Mode
29.6 SCV Settings?Flow Adjustment
29.7 SCV Settings?Time Adjustment
29.8 SCV Settings?Advanced
29.9 SCV Settings?Activating Independent Mode
29.10 SCV Settings?Automation
29.11 SCV Settings?Assignment
29.12 SCV Settings?Flow Adjustment Sensitivity
29.13 SCV Control Lever Adjustments
29.14 External SCV Switches
29.15 Total SCV Flow
29.16 Operate SCVs with CommandARM? Joystick
29.17 CommandARM? Joystick?Layout and Joystick Lever Functions
30 Hydraulic Connections
30.1 Connect/Disconnect Hydraulic Hoses
30.2 Component Identification and Location?Rear SCVs
30.3 Component Identification and Location?Mid-Mount or Front SCVs
30.4 Use Load-Sense Hydraulic System (Power Beyond)
30.5 Examples Using Load-Sensing Hydraulic System?Power-Beyond
30.6 Implement Connections?Active Down Pressure
30.7 Implement Connections?Vacuum Motors with Power Beyond and Motor Case Drain
30.8 Implement Connections?Hydraulic Motor with Motor Return
30.9 Implement Connections?Vacuum Motor with Motor Return Tip
30.10 Implement Connections?Hitch Auxiliary Raise in Parallel with Hitch Valve
30.11 Implement Connections?Hitch Auxiliary Raise in Parallel with SCV
30.12 Hydraulic Motor Return and Case Drain Kits
30.13 Hitch Auxiliary Raise Kit
30.14 Using Implements Requiring Large Volumes of Oil
31 TouchSet? Depth Control
31.1 TouchSet? Depth Control Settings and Adjustments
31.2 Connect/Disconnect the Implement Position Connector
32 Laser Scraper Control
32.1 Laser Scraper?Scrapers Equipped with Scraper Control Unit
33 Wheels and Tires?General Information
33.1 Determine Tire Load Capacity
33.2 Change Tire Size
33.3 Select Tire Combinations
33.4 Tire Load Index
33.5 Tire Inflation Pressure Guidelines
34 Front Wheels and Tires
34.1 Recommended Pressures?Group 42
34.2 Recommended Pressures?Group 43
34.3 Recommended Pressures?Group 44
34.4 Adjust and Tighten?Front Wheel Bolts
34.5 Toe-In Check
35 Steering Stop, Fender, and Tread Settings
35.1 Tire, Steering Stop, and Fender Settings Table Explanation
35.2 Tire, Steering Stop, and Fender Settings?1150/1300 MFWD Axles
35.3 Tire, Steering Stop, and Fender Settings?TLS? Plus Axle
35.4 Determine Rim Type
35.5 Wheel Settings?8-Position
35.6 Wheel Setting?16-Position
35.7 Set Steering Stops
35.8 Fender Settings
36 Rear Wheels and Tires
36.1 Recommended Pressures?Group 47
36.2 Recommended Pressures?Group 48
36.3 Recommended Pressures?Group 48?Continued
36.4 Recommended Pressures?Group 49
36.5 16-Position Rear Wheel Settings
36.6 Rear Wheel, Tire, and Tread Guidelines
36.7 Minimum Tread Setting with Air Trailer Brakes and Inner Wheel Weights
36.8 Use Wheel Tightening Stand
36.9 Install Rear Drive Wheel to Cast Hub
36.10 Install Rear Steel Wheel to Hub
36.11 Adjust and Tighten Rear Steel Wheels with Cast Hubs
36.12 Adjust and Tighten Rear Wheels?10-Bolt Heavy-Duty Hubs
36.13 Adjust and Tighten Rear Wheels?12-Bolt Heavy-Duty Hubs
36.14 Single Wheel Tread Settings
36.15 Dual Wheel Tread Settings
36.16 Dual Wheel Row Crop Settings and Dual Hub Extensions
36.17 Clamp-on Dual Usage
37 Seats
37.1 Adjust Air Seat
37.2 Adjust ActiveSeat? II
37.3 Operator Presence Sensor
37.4 Adjust Instructional Seat
38 Mirrors
38.1 Adjust Mirrors
39 Steps
39.1 Position Left-Hand Steps
39.2 Right-Hand Service Steps
40 Lights
40.1 Light Identification
40.2 Lights Settings?Access
40.3 Lights Settings
40.4 Lights Settings?Field Lights Presets
40.5 Lights Settings?Hood/Belt Line Lights
40.6 Lights Settings?Advanced
40.7 Hazard and Extremity Lights
40.8 Beacon Light
40.9 7-Pin Outlet
41 Accessories
41.1 Right-Hand Side Console
41.2 CommandARM? Storage
41.3 Right-Hand Front Corner Post
41.4 Left-Hand Rear Corner Post
41.5 Right-Hand Rear Corner Post
41.6 Refrigerator and Cool/Storage Box
41.7 Sunshade
41.8 Storage Compartments
41.9 Monitor Bracket Mounts
41.10 Emergency Exit
41.11 Install Business Band/Citizens Band (CB) Antenna and/or Radio
41.12 Mount StarFire? Receiver
41.13 Mount RTK (Real-Time Kinematic) Radio
41.14 Implement Connector
41.15 RS232 Serial Communication Connection
42 HVAC
42.1 HVAC Settings?Access
42.2 HVAC Settings
42.3 HVAC Settings?Climate Control Automation
42.4 HVAC Settings?Set Temperature
42.5 HVAC Settings?Air Flow Mode
42.6 HVAC Settings?Fan Speed
42.7 HVAC Settings?Air Conditioning
43 Performance Ballasting
43.1 How to Calculate Maximum Permissible Download on Trailer Hitch
43.2 Mechanical Towed Coupling Load Limitations
43.3 General Ballasting Information
43.4 General Guidelines
43.5 General Weight Split Guidelines
43.6 Ballast Options
43.7 Measure Slip
43.8 Ballast Suggestions for Specific Types of Implements used with MFWD Tractors
43.9 Quik-Tatch? Weight Use
43.10 Rear Wheel Weight Use
43.11 Rear Wheel Weight Installation?Flanged Axles
43.12 Rear Wheel Weight Installation?Single Cast Drive Wheel
43.13 Rear Wheel Weight Installation?Dual Drive Wheels
43.14 Controlling Power Hop-MFWD Tractors Without TLS? Plus Front Axle
43.15 Calculate Tractor Ballast Package
43.16 Add Rear Ballast For Front Loader
43.17 Ballast Suggestions?Hitch-Mounted Implements
43.18 Unballasted Tractor Weight Charts (7R: 210, 230, 250, and 270)
43.19 Unballasted Tractor Weight Charts (7R: 290, 310, 330, and 350)
43.20 Implement and Tractor Codes
43.21 Liquid Ballast Use
44 Transport
44.1 Drive Tractor on Roads
44.2 Transport with Ballast
44.3 Tow Loads
44.4 Use Safety Chain
44.5 Tow Tractor
44.6 Tow Mode
44.7 Come Home Mode
44.8 Transport on Carrier
44.9 Freeing a Mired Tractor
45 Fuel, Lubricants, and Coolant?General Information
45.1 Determine Tractor Engine Type
45.2 Minimizing the Effect of Cold Weather on Diesel Engines
45.3 Oil Filters
46 Fuel
46.1 Diesel Fuel
46.2 Supplemental Diesel Fuel Additives
46.3 Biodiesel Fuel
46.4 Lubricity of Diesel Fuel
46.5 Handling and Storing Diesel Fuel
46.6 Fill Fuel Tank
46.7 Testing Diesel Fuel
46.8 Fuel Filters
47 Diesel Exhaust Fluid (DEF)
47.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
47.2 Storing Diesel Exhaust Fluid (DEF)
47.3 Refilling Diesel Exhaust Fluid (DEF) Tank
47.4 Fill DEF Tank?FT4/Stage V Engine
47.5 Testing Diesel Exhaust Fluid (DEF)
47.6 Disposal of Diesel Exhaust Fluid (DEF)
48 Engine Oil
48.1 Diesel Engine Oil Service Interval for Operation at High Altitude
48.2 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
48.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
48.4 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
49 Engine Coolant
49.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
49.2 John Deere COOL-GARD? II Coolant Extender
49.3 Operating in Warm Temperature Climates
49.4 Water Quality for Mixing with Coolant Concentrate
49.5 Testing Coolant Freeze Point
49.6 Disposing of Coolant
50 Other Lubricants
50.1 Lubricant Storage
50.2 Alternative and Synthetic Lubricants
50.3 Mixing of Lubricants
50.4 Transmission and Hydraulic Oil
50.5 Use Correct Viscosity Front PTO Oil in Cold Weather
50.6 Transmission Recalibration
50.7 Gear Oil
50.8 Multipurpose Extreme Pressure (EP) Grease
51 Service?General Information
51.1 Service Sections Overview
51.2 Service Tasks Performed As Required
51.3 Identify Tractor Engine Emissions Status
51.4 Open Hood
51.5 Remove Engine Access Panel
51.6 Remove Engine Side Shields
51.7 Remove Radiator Shields
51.8 Remove Battery Compartment Cover
51.9 Remove Cab Rear Panel
51.10 Jack Up Tractor?Lifting Points and Support Stand Placement
51.11 Service and Connect STC? (Snap-to-Connect) Fittings
51.12 High-Pressure Washer Use
51.13 Do Not Modify Fuel System
51.14 Do Not Open High-Pressure Fuel System
51.15 Bleed Fuel System
51.16 Identify Zinc-Flake Coated Fasteners
51.17 Metric Bolt and Screw Torque Values
51.18 Unified Inch Bolt and Screw Torque Values
52 Service?Break-In (100 Hours or Less)
52.1 Perform Break-In Checks
53 Service?Record Charts
53.1 Service Record Chart Overview
53.2 Service Interval Chart
53.3 Service Record Chart
54 Service?Clean
54.1 Access DEF Tank Drain Plug
54.2 Cleaning Diesel Exhaust Fluid (DEF) Tank
54.3 Tractor Exterior
54.4 Clean Display
54.5 Clean Seat
54.6 Engine Cooling System
54.7 Dual Beam Radar Sensor
54.8 MFWD or TLS? Plus Axle Vent Filter
54.9 Implement Connector
55 Service?Check
55.1 Windshield Washer Fluid Level
55.2 Engine Coolant Level
55.3 Engine Coolant Freeze Point
55.4 Water Separator
55.5 Optional Fuel Water Separator (If Equipped)
55.6 Engine Air Filter Precleaner System
55.7 Primary and Secondary Engine Air Filters
55.8 Engine and Exhaust Compartments
55.9 Air Conditioning System
55.10 Engine Water Pump Weep Hole
55.11 Fuel Tank Sump
55.12 MFWD or TLS? Plus Axle Housing Oil Level
55.13 MFWD or TLS? Plus Wheel Hub Oil Level
55.14 Engine Oil Level
55.15 Transmission-Hydraulic Oil Level
55.16 Mechanical Cab Suspension Components
55.17 Front PTO Housing Oil Level
55.18 Engine Air Intake System?6.8 L Engine
55.19 Engine Air Intake System?9.0 L Engine
55.20 Tires
55.21 TLS? Plus Accumulator Charge Pressure
55.22 Handling Batteries Safely
55.23 Seat Belts
55.24 Fan Belt Tensioner and Fan Belt
55.25 Engine Valve Clearance
55.26 Transmission PARK System
56 Service?Tighten
56.1 Wheel and Wheel Weight Bolts
56.2 Use Wheel Tightening Stand
56.3 Use Wheel Torque Wrench Adapter
56.4 Rear Wheel Weight Bolts
56.5 Front Wheel Bolts
56.6 Rear Drive Wheel to Cast Hub Bolts
56.7 Rear Steel Wheel to Hub Bolts
56.8 Rear Steel Wheels?Cast Hub Bolts
56.9 Rear Wheel Bolts?Heavy-Duty Cast 10-Bolt Hubs
56.10 Rear Wheel Bolts?Heavy-Duty 12-Bolt Hubs
57 Service?Change
57.1 Engine Primary and Secondary Air Filters
57.2 Fan Belt
57.3 Engine Oil and Filter?6.8 L Engine
57.4 Engine Oil and Filter?9.0 L Engine
57.5 Fuel Filters
57.6 Optional Fuel Water Separator Filter Element (If Equipped)
57.7 Cab Filters
57.8 Cab Fresh Air Filter
57.9 Transmission-Hydraulic Oil and Filter
57.10 MFWD or TLS? Plus Wheel Hub Oil
57.11 MFWD or TLS? Plus Axle Housing Oil
57.12 Front PTO Housing Oil and Filter
57.13 Crankcase Ventilation Filter?6.8 L Engine
57.14 Fuel Tank Vent Filter
57.15 SCV Pilot Valve Filter
57.16 Trailer Air Brake Dryer Filter
57.17 DEF Tank Vent Filter
57.18 Access In-Line DEF Filter
57.19 Change Diesel Exhaust Fluid (DEF) In-Line Filter
57.20 Access DEF Dosing Unit Filter
57.21 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
57.22 Replace Transmission Drive Shaft Damper
57.23 Engine Crankshaft Damper
57.24 Engine Coolant
58 Service?Lubricate
58.1 Rear Hitch
58.2 Front Hitch
58.3 Deluxe Stabilizers
58.4 Wagon Hitch
58.5 MFWD or TLS? Plus Kingpins, Tie Rod Ends, Steering Cylinder, Axle Pivot, and Panhard Rod
58.6 MFWD or TLS? Plus U-Joints
58.7 Draft Link Support Shaft Bushing
59 Service?Electrical
59.1 Service?Electrical Overview
59.2 Welding Near Electronic Control Units
59.3 Keep Electronic Control Unit Connectors Clean
59.4 Compressed Air Use
59.5 High-Pressure Washers Use
59.6 Disconnect Battery
59.7 Service Batteries and Connections
59.8 Access Load Center Fuses
59.9 Access Front Load Center
59.10 Access Master Fuses
59.11 Access Implement Power Relay Module Fuses
59.12 Handle Halogen Light Bulbs Safely
59.13 Change Front LED Light Assembly
59.14 Change Halogen Bulbs
59.15 Adjust Front Grille Lights
59.16 Change Front/Rear Belt Line Work Lights
59.17 Adjust Headlights
59.18 Change Auxiliary Driving Light
59.19 Change Wrap-Around Cab Light
59.20 Change Roof Work Lights
59.21 Change Extremity Arm Light
59.22 Change Cab Dome Light
60 Troubleshooting?Procedures
60.1 Engine
60.2 Transmission
60.3 Hydraulic System
60.4 Hitch
60.5 Selective Control Valve (SCV)
60.6 TouchSet? Depth Control
60.7 Electrical System
60.8 Operator Enclosure
60.9 Tractor Operation
60.10 Steering System
61 Troubleshooting?Diagnostic Trouble Codes (DTC)
61.1 STOP, Service, and Information Alerts on CommandCenter?
61.2 Access Diagnostic Trouble Codes
62 Service?Storage
62.1 Place Tractor in Storage
62.2 Remove Tractor from Storage
63 Specifications
63.1 Engine
63.2 Capacities
63.3 Hydraulic
63.4 Transmission and Drive Train
63.5 Hitch, Drawbar, and PTO
63.6 Electrical System
63.7 Integrated Technology
63.8 Overall Dimensions
63.9 Tractor Load/Weights
63.10 Ground Speeds?e23? Transmission
63.11 Ground Speeds?IVT?/AutoPowr? Transmission
63.12 Limited Battery Warranty
63.13 Emissions Control System Certification Label
63.14 EPA Non-road Emissions Control Warranty Statement?Compression Ignition
63.15 CARB Non-road Emissions Control Warranty Statement?Compression Ignition
63.16 Required Emission-Related Information
63.17 Carbon Dioxide Emissions (CO?)
63.18 Third-Party Software Notifications and Licenses
64 Identification Numbers
64.1 Identification Plates
64.2 Product Identification Number (PIN)
64.3 Engine Serial Number
64.4 Cab Serial Number
64.5 Transmission Serial Number
64.6 Axle Serial Number
64.7 Keep Proof of Ownership
64.8 Keep Machines Secure
65 Change of Ownership
65.1 Subsequent Ownership
66 Predelivery
66.1 Predelivery Checklist
66.2 Delivery Checklist and Certificate
67 Index
68 John Deere Service Literature Available
68.1 Technical Information
69 John Deere Service Keeps You On The Job
69.1 John Deere Is At Your Service