Table of Content:
1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Download Instructions
2 Glossary
2.1 Glossary
2.2 Trademarks
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Use the Seat Belt
4.2 Operate the Tractor Safely
4.3 Do Not Modify ROPS
4.4 Use of Instructional Seat (If Equipped)
4.5 Tow Trailer Safely (Not on Tractors up to 30 km/h)
4.6 Caution When Operating Front Loader (on Tractors with Mechanical Selective Control Valves)
4.7 Caution When Operating Front PTO
4.8 Caution When Operating Rear PTO
4.9 Pressure Accumulator (Front Hitch, for Tractors without Suspended Front-Wheel Drive Axle)
4.10 Pressure Accumulators (Suspended Front-Wheel Drive Axle, If Equipped)
4.11 Pressure Accumulator (Brake System)
4.12 Electrical Coolant Heater of Engine (If Equipped)
4.13 .
5 Vehicle Overview
5.1 Identification Views
5.2 Identification Views
6 Operator’s Manual ? General Information
6.1 General Information and Scope of Manual
6.2 How to Use This Manual
6.3 Comply with Operator’s Manuals of Implement Manufacturers
7 Operating the Engine
7.1 US EPA Qualified Emergency Use ? SCR Derate Override Option
7.2 Important Engine Information
7.3 Engines with Turbocharger
7.4 Engine Protection
7.5 Required Machine Stop Warning
7.6 Engine Menu
7.7 Check Engine Indicator Lights and Displays
7.8 Intelligent Power Management (Power Boost)
7.9 Starting the Engine
7.10 Engine Start with an Auxiliary Battery
7.11 Shutting Off the Engine
7.12 Battery Disconnect System (If Equipped)
7.13 Park the Tractor with PowrQuad?/AutoQuad? PLUS
7.14 Park the Tractor with CommandQuad? PLUS
7.15 Tow-Starting
7.16 Fill the Fuel Tank
7.17 Fill the DEF Tank
8 Cold-Weather Operation
8.1 Cold Start Aids
8.2 Coolant Heater
8.3 Connecting the Coolant Heater to a 230 V Power Grid
8.4 Ground Fault Circuit Interrupter (GFCI), 120 V
9 Aftertreatment
9.1 Exhaust Filter Cleaning, General Information
9.2 Required Machine Stop Warning
9.3 Aftertreatment Indicators Overview
9.4 Access the Engine Menu
9.5 Exhaust Filter Cleaning Overview
9.6 DEF (Diesel Exhaust Fluid) Level Gauge
9.7 Selective Catalytic Reduction (SCR) System Overview
10 Operator Controls
10.1 Vehicle Controls with PowrQuad? PLUS and AutoQuad? PLUS Transmissions
10.2 Vehicle Controls with CommandQuad? PLUS Transmission without CommandARM?
10.3 Vehicle Controls with CommandQuad? PLUS Transmission with CommandARM?
10.4 Controls in the Side Console, Overview
10.5 Key Switch
10.6 Come-Home Mode
10.7 Immobilizer
10.8 Creeper – Controls
10.9 PTO – Controls
10.10 Economy Front Hitch – Controls
10.11 Rear Hitch – Controls
10.12 Mechanical Selective Control Valves – Controls
10.13 Electronic Selective Control Valves – Controls
10.14 Mechanical Joystick (Factory Installed)
10.15 Mechanical Joystick (Retrofitted), R Series Loader for 6M Series Tractors (MY20-)
10.16 Electrical Joystick (Version 1)
10.17 Electrical Joystick (Version 2)
10.18 Front-Wheel Drive – Controls
10.19 Differential Lock – Controls
10.20 iTEC? Basic ? Intelligent Total Equipment Control – Controls
10.21 AutoTrac? – Controls
10.22 ISOBUS Button (ISB)
10.23 Heating, Ventilation and Air-Conditioning System – Controls
10.24 Radio A?Additional Phone Controls
11 Corner Post Display
11.1 Corner Post Display
11.2 Warning Indicators
11.3 Digital Indicators ? Revolution Counter, Ground Speed, Transmission, and Set Speed
11.4 Gauges – Coolant Temperature, DEF Level, and Fuel Level
11.5 Overview of All Menus
11.6 Basic Menu Navigation
11.7 Information Display, Run Pages
11.8 Display Settings, Menu
11.9 Display Settings, Brightness
11.10 Display Settings, Display Modes (Day/Night)
11.11 Display Settings, Language
11.12 Display Settings, Units
11.13 Display Settings, Numeric Format
11.14 Display Settings, Information on the Corner Post Display
11.15 Work Monitor, Menu
11.16 Work Monitor, Counters A and B
11.17 Work Monitor, Readings
11.18 Work Monitor, Implement Width
11.19 Work Monitor, Recording Trigger
11.20 Layout Manager, Settings
11.21 Set up Controls
12 CommandARM? Controls
12.1 CommandARM?, Controls (with CommandQuad? Plus)
13 Radio A?Operation
13.1 Radio A?Controls and Instruments
13.2 Radio A?Additional Phone Controls
13.3 Radio A?Microphone for Bluetooth Applications
13.4 Radio A?Connection of Memory Storage and Multimedia Appliances
13.5 FM, MW, LW and DAB/DAB+-Compliant Radio Antenna (Europe Only)
14 Radio B?Operation
14.1 Radio B?Identification Views and Features
14.2 Radio B?Controls and Instruments
14.3 Radio B?Connection of Memory Storage and Multimedia Appliances
14.4 FM, MW, LW and DAB/DAB+-Compliant Radio Antenna (Europe Only)
15 Guidance
15.1 AutoTrac? Guidance System (If Equipped)
15.2 AutoTrac? Guidance with GreenStar? Display
15.3 AutoTrac? Basic Guidance with Corner Post Display
15.4 Operate Guidance Systems Safely
15.5 Enable AutoTrac? Basic
15.6 Disable AutoTrac? Basic
15.7 AutoTrac? Resume Switch
15.8 Activate AutoTrac? Basic
15.9 Disengage AutoTrac? Basic
15.10 Reactivate AutoTrac? Basic on Next Pass
15.11 AutoTrac? Basic Menu
15.12 AutoTrac? Basic Map
15.13 AutoTrac? Status Pie
15.14 AutoTrac? Basic Track Setup
15.15 AutoTrac? Basic Tread Width
15.16 AutoTrac? Basic Shift Size
15.17 AutoTrac? Basic Vehicle
15.18 AutoTrac? Basic Tuning
15.19 StarFire? Correction Mode
15.20 AutoTrac? Basic TCM Calibration
15.21 StarFire? USB Drive
15.22 StarFire? GPS Status
15.23 AutoTrac? Basic Settings Locked
15.24 AutoTrac? Basic About
15.25 GPS Receiver Offset Values
15.26 AutoTrac? Universal Information
16 Intelligent Total Equipment Control (iTEC?)
16.1 iTEC? Basic, General Information
16.2 Basic Menu Navigation
16.3 iTEC? Basic, Menu
16.4 iTEC? Basic, Access Functions
16.5 iTEC? Basic, Settings
17 Drivetrain
17.1 Drive Systems – Overview
18 Front-Wheel Drive
18.1 Front-Wheel Drive, Control Elements and Indicator Lights
18.2 Front-Wheel Drive, Manual Engagement and Disengagement
18.3 Front-Wheel Drive, Automatic Engagement and Disengagement
18.4 Tractor Equipped With Front Suspension Option
19 Differential Lock
19.1 Differential Lock, Controls and Indicator Lights
19.2 Differential Lock, Manual Engaging/Disengaging
19.3 Differential Lock, Automatic Engaging/Disengaging
20 Brakes
20.1 Hydraulic Service Brakes
20.2 Single-Line Hydraulic Trailer Brake (If Equipped)
20.3 Socket for the Anti-Lock Brake System (ABS) of Trailer
20.4 Park the Tractor with PowrQuad?/AutoQuad? PLUS
20.5 Park the Tractor with CommandQuad? PLUS
21 Transmission – General Information
21.1 Reduce Fuel Consumption
21.2 Select Correct Ground Speed
21.3 Notes on Changing to a Different Size of Tire
21.4 Engage Creeper Transmission
21.5 Travel Speed Tables and SRI Values
21.6 Ground Speeds, PowrQuad? Plus Transmissions for 30 km/h (16/16), on 6155M Tractors – Tires with SRI 825 and 875
21.7 Ground Speeds, PowrQuad? Plus Transmissions for 30 km/h (16/16), on 6155M Tractors – Tires with SRI 925
21.8 Ground Speeds, PowrQuad? Plus Transmissions for 30 km/h (16/16), on 6155MH Tractors – Tires with SRI 875 and 925
21.9 Ground Speeds, PowrQuad? PLUS Transmission for 30 km/h (16/16), on 6175M and 6195M Tractors – Tires with SRI 875, 925 and 975
21.10 Ground Speeds, PowrQuad? PLUS and AutoQuad? PLUS Transmissions for 30 km/h (20/20), for 6155MH Tractor – Tires with SRI 875 and 925
21.11 Ground Speeds, PowrQuad? PLUS and AutoQuad? PLUS Transmissions for 40 km/h (20/20), for 6155M Tractor – Tires with SRI 825 and 875
21.12 Ground Speeds, PowrQuad? PLUS and AutoQuad? PLUS Transmissions for 40 km/h (20/20), on 6155M Tractors – Tires with SRI 925
21.13 Ground Speeds, PowrQuad? PLUS and AutoQuad? PLUS Transmissions for 40 km/h (20/20), on 6175M and 6195M Tractors – Tires with SRI 875, 925 and 975
21.14 Ground Speeds, CommandQuad? PLUS Transmission for 30 km/h (20/20), on 6155MH Tractors – Tires with SRI 875 and 925
21.15 Ground Speeds, CommandQuad? PLUS Transmission for 40 km/h (20/20), on 6155M Tractors – Tires with SRI 825, 875 and 925
21.16 Ground Speeds, CommandQuad? PLUS Transmission for 40 km/h (20/20), on 6175M and 6195M Tractors – Tires with SRI 875, 925 and 975
22 PowrQuad? PLUS Transmission
22.1 PowrQuad? PLUS Transmission, Controls
22.2 PowrQuad? PLUS Transmission, Park Lock
22.3 PowrQuad? PLUS Transmission, Reverse Drive Lever
22.4 PowrQuad? PLUS Transmission, Range-Shift Lever
22.5 PowrQuad? PLUS Transmission, Gearshift Buttons
22.6 PowrQuad? PLUS Transmission, Clutch Pedal and Clutch Button
22.7 PowrQuad? PLUS Transmission, Speed Control Pedal and Hand Throttle
22.8 PowrQuad? PLUS Transmission, Engine Set Speed
22.9 PowrQuad? PLUS Transmission, Cold-Weather Operation
22.10 PowrQuad? PLUS Transmission, Come-Home Mode
22.11 PowrQuad? PLUS Transmission, Menu
22.12 Symbols in the Transmission Menu
22.13 PowrQuad? PLUS Transmission, PowrReverser?
22.14 PowrQuad? PLUS Transmission, Reverse/Forward Ratio
22.15 PowrQuad? PLUS Transmission, Backup Alarm
23 AutoQuad? PLUS Transmission
23.1 AutoQuad? PLUS Transmission, Controls
23.2 AutoQuad? PLUS Transmission, Park Lock
23.3 AutoQuad? PLUS Transmission, Reverse Drive Lever
23.4 AutoQuad? PLUS Transmission, Range-Shift Lever
23.5 AutoQuad? PLUS Transmission, Gearshift Buttons
23.6 AutoQuad? PLUS Transmission, Clutch Pedal and Clutch Button
23.7 AutoQuad? PLUS Transmission, Automatic Gear Shifting
23.8 AutoQuad? PLUS Transmission, Speed Control Pedal and Hand Throttle
23.9 AutoQuad? PLUS Transmission, Engine Set Speed
23.10 AutoQuad? PLUS Transmission, Cold-Weather Operation
23.11 AutoQuad? PLUS Transmission, Come-Home Mode
23.12 AutoQuad? PLUS Transmission, Menu
23.13 Symbols in the Transmission Menu
23.14 AutoQuad? PLUS Transmission, Transmission Mode
23.15 AutoQuad? PLUS Transmission, PowrReverser?
23.16 AutoQuad? PLUS Transmission, Reverse/Forward Ratio
23.17 AutoQuad? PLUS Transmission, Backup Alarm
24 CommandQuad? PLUS Transmission
24.1 CommandQuad? PLUS Transmission, Controls without CommandARM?
24.2 CommandQuad? PLUS Transmission, Controls with CommandARM?
24.3 CommandQuad? PLUS Transmission, Control Lever of the Park Lock
24.4 CommandQuad? PLUS Transmission, Reverse Drive Lever
24.5 CommandQuad? PLUS Transmission, Range Shift Unit
24.6 CommandQuad? PLUS Transmission, Shift Lever
24.7 CommandQuad? PLUS Transmission, Set Maximum Ground Speed
24.8 CommandQuad? PLUS Transmission, Speed Control Pedal and Hand Throttle
24.9 CommandQuad? PLUS Transmission, Engine Set Speed
24.10 CommandQuad? PLUS Transmission, Select Start Gear
24.11 CommandQuad? PLUS Transmission, Brake Pedals and Clutch Pedal (AutoClutch Function)
24.12 CommandQuad? PLUS Transmission, Special Features when Maneuvering the Tractor
24.13 CommandQuad? PLUS Transmission, Adjust Driving Characteristics
24.14 CommandQuad? PLUS Transmission, Operating with Trailer on Hillsides in Slippery Conditions
24.15 CommandQuad? PLUS Transmission, Stopping and Parking the Tractor
24.16 CommandQuad? PLUS Transmission, Come-Home Mode
24.17 CommandQuad? PLUS Transmission, Tow the Tractor
24.18 CommandQuad? PLUS Transmission, Menu
24.19 Symbols in the Transmission Menu
24.20 CommandQuad? PLUS Transmission, Start Gears
24.21 CommandQuad? PLUS Transmission, PowrReverser?
24.22 CommandQuad? PLUS Transmission, Reverse/Forward Ratio
24.23 CommandQuad? PLUS Transmission, Minimum Speed
24.24 CommandQuad? PLUS Transmission, Load Anticipation
24.25 CommandQuad? PLUS Transmission, Droop with PTO OFF/ON
24.26 CommandQuad? PLUS Transmission, AutoClutch
24.27 CommandQuad? PLUS Transmission, Backup Alarm
25 PTO Shaft, Hitches, and Trailer Hitches
25.1 Hitch – Maximum Lifting Force
26 PTO Shaft – General Information
26.1 Front PTO?PTO Shield
26.2 Rear PTO?PTO Shield
26.3 None-Rotating PTO Guard
26.4 Operating Instructions
26.5 PTO Speeds
26.6 PTO Options
27 Front PTO
27.1 Front PTO
27.2 Engage and Disengage the Front PTO
27.3 Front PTO ? PTO Automatic Shutoff Function
28 Rear PTO
28.1 Rear PTO
28.2 Engage and Disengage the Rear PTO
28.3 Rear PTO – Select Standard Speed (Shiftable PTO)
28.4 Rear PTO – Remote Control and Function
28.5 Rear PTO – PTO Automatic Shutoff Function
28.6 Rear PTO?Change the PTO Stub Shaft
28.7 Rear PTO – Connect an Implement
29 Front Hitch
29.1 Economy Front Hitch – Controls
29.2 Economy Front Hitch
29.3 Front Hitch?Center Link
29.4 Front Hitch?Center Link Positions
29.5 Front Hitch?Hook-Type Center Link
30 Rear Hitch
30.1 Rear Hitch – Menu
30.2 Rear Hitch – Operation without CommandARM?
30.3 Rear Hitch – Operation with CommandARM?
30.4 Rear Hitch – Set the Depth Control Stop
30.5 Rear Hitch – Driving under Load with Mounted Implement
30.6 Rear Hitch – Hitch Dampening
30.7 Rear Hitch – Raise Height Limit
30.8 Rear Hitch – Adjust the Rate of Drop
30.9 Rear Hitch – Adjust the Raise Rate
30.10 Rear Hitch – Draft/Depth Control Adjustment
30.11 Rear Hitch – Use Draft Control
30.12 Rear Hitch – Float Position
30.13 Rear Hitch – Remote Control
30.14 Rear Hitch – Direct Actuation
30.15 Three-Point Hitch
30.16 Flat Steel Draft Links
30.17 Telescopic Draft Links
30.18 Quick-Coupling (Hook-Type) Draft Links
30.19 Attach Three-Point Hitch Mounted and Drawn Implements
30.20 Level the Implement
30.21 Center Link
30.22 Center Link Positions
30.23 Hook-Type Center Link
30.24 Hydraulic Center Link (If Equipped)
30.25 Adjust Lift Links
30.26 Lift Links – Adjust for Vertical Float
30.27 Sway Blocks, Category III/IIIN (if Equipped)
30.28 Stabilizer Bar (If Equipped)
30.29 Stabilizing System (If Equipped)
30.30 Draft Links?Adjust Spreading Dimension
30.31 Adjust Draft Links for Category III or IIIN (If Equipped)
30.32 Telescopic Draft Links?Convert Category III and IIIN (If Equipped)
31 Trailer Hitches
31.1 Trailer Hitches?Foreword
31.2 CAT II Drawbar
31.3 Proper Use of Drawbar
31.4 Lock the Hitch Pins
31.5 Lock the Height-Adjustable Trailer Hitch
31.6 Latch for Telescopic Draft Links
31.7 Hitch Jaw
31.8 Trailer Hitch with Piton-Fix or Ball-Type (Rigid)
31.9 Height-Adjustable Ball-Type Hitch (Version 1)
31.10 Height-Adjustable Ball-Type Hitch (Version 2)
31.11 Height-Adjustable Trailer Hitch
31.12 Remote Control for Trailer Hitch (If Equipped)
32 Hydraulic System
32.1 Selective Control Valves – Maximum Permissible Oil Withdrawal
32.2 Selective Control Valves – Oil Withdrawal with Hydrostatic Drive (with PFC Hydraulic System)
32.3 Using Large-Volume Hydraulic Cylinders
32.4 Additional Oil Reservoir (If Equipped)
33 Hydraulic Connections
33.1 Selective Control Valves – Fittings
33.2 Selective Control Valves – Connect Hydraulic Hoses
33.3 Selective Control Valves – Disconnect Hydraulic Hoses
33.4 Selective Control Valves – Connect or Disconnect Hydraulic Hoses at Front Hitch (If Equipped)
33.5 Hydraulic Connections for Implements and Hydraulic Motors
33.6 Connect Implements to Selective Control Valves
33.7 Adjustable Power Beyond Valve
34 Selective Control Valves (SCVs) – Controls
34.1 Selective Control Valves – Set Controls
34.2 Mechanical Selective Control Valves – Controls
34.3 Selective Control Valves, Mechanical – Control Lever
34.4 Selective Control Valves, Mechanical – Transport Lock
34.5 Selective Control Valves, Electronic – Controls
34.6 Selective Control Valves, Electronic – Control Lever
34.7 Selective Control Valves, Electronic – Neutral Position
34.8 Selective Control Valves, Electronic – Extend and Extend Click Position
34.9 Selective Control Valves, Electronic – Retract and Retract Click Position
34.10 Selective Control Valves, Electronic – Float Position (Detent)
35 Selective Control Valves (SCVs) – Settings
35.1 Selective Control Valves, Mechanical – Raise Rate
35.2 Selective Control Valves, Mechanical – Set Feature Mode
35.3 Selective Control Valves, Mechanical – Pressure Settings for Series 450
35.4 Selective Control Valves, Electronic – Menu
35.5 Selective Control Valves, Electronic – Adjust SCV Flow Rate and Flow Time
35.6 Selective Control Valves, Electronic – Loader Mode
35.7 Selective Control Valves, Electronic – Joystick Mode
35.8 Selective Control Valves, Electronic – Advanced Settings
35.9 Operator Presence Sensor – For North America, Australia, and New Zealand Only
36 Front Loader
36.1 Front Loader Mounting Frames for Loaders 620R/623R
36.2 Front Loader Mounting Frames for Loaders 640R/643R, 660R/663R, and 680R/683R
36.3 Front Loader?Hydraulic Quick Release (If Equipped)
36.4 Front Loader?Influence of Engine Speed on Lifting Function
36.5 Mechanical Joystick (Factory Installed)?Controls
36.6 Mechanical Joystick (Retrofitted), R Series Loader for 6M Series Tractors (MY20-)?Controls
36.7 Electrical Joystick?Identify the Version
36.8 Electrical Joystick (Version 1)?Controls
36.9 Electrical Joystick (Version 1)?Layout and Functions
36.10 Electrical Joystick (Version 1)?Lock Function (Transport Lock)
36.11 Electrical Joystick (Version 2)?Controls
36.12 Electrical Joystick (Version 2)?Hand-Presence Detection System
36.13 Electrical Joystick (Version 2)?Hand-Presence Detection System, Error Message
36.14 Electrical Joystick (Version 2)?Layout and Functions
36.15 Electrical Joystick (Version 2)?Available Presets
36.16 Electrical Joystick (Version 2)?Lock Function (Transport Lock)
37 Wheels and Tires
37.1 Tractor Models and Corresponding Axles?Overview, Tractors 6090M to 6210M (MY20- ) with Cab
37.2 Tires and Wheels?Foreword
37.3 General Wheel, Tire, and Tread Guidelines
37.4 Prevent Front Wheel or Fender Contact with Tractor Components
37.5 Change to a Different Tire Size
37.6 Changing the Tire Combination
37.7 Use of Dual Wheels (Easy-to-Attach)
37.8 Service Tires Safely
37.9 Change Wheels Safely
37.10 Wheel Exchange with Wheel Weights
37.11 Tire Combinations?Adjustable Front Axle (6155M)
37.12 Tire Combinations?Front-Wheel Drive Axle (6155M)
37.13 Tire Combinations?Front-Wheel Drive Axle (6155MH)
37.14 Tire Combinations?Front-Wheel Drive Axle (6175M and 6195M)
37.15 Tire Labeling?Ascertain the Load Capacity of Tires
37.16 Tire Load Index
37.17 Tire Pressures
37.18 Tire Inflation Pressure Guidelines
37.19 Select Tire Inflation Pressure
38 Front Wheels, Tires, and Tread Widths
38.1 Tires and Wheels?Foreword
38.2 Adjustable Front Axle?Check Toe-In
38.3 Adjustable Front Axle Type B?Adjust Toe-In
38.4 Adjustable Front Axle Type B?Tighten Axle Bolts and Wheels Bolts
38.5 Adjustable Front Axle Type B?Adjust the Wheel Treads
38.6 Adjustable Front Axle Type B?Tread Widths
38.7 Front Tires with Front-Wheel Drive
38.8 Front-Wheel Drive Axle?Toe-In Check and Adjustment
38.9 Front-Wheel Drive Axle?Check Toe-In (Conventional Method)
38.10 Front-Wheel Drive Axle?Check Toe-In Using a Laser Wheel-Measuring Tool
38.11 Front-Wheel Drive Axle?Adjust Toe-In
38.12 Instructions for Front-Wheel Tread Adjustment with Rims for 2, 8, and 16 Positions
38.13 Three-Piece Front Axle (Version 2)?Tread Widths for Front Wheels with Rims for 2 Positions (6155M)
38.14 Three-Piece Front Axle (Version 2)?Tread Widths for Front Wheels with Rims for 2 Positions (6175M and 6195M)
38.15 Three-Piece Front Axle (Version 2)?Tread Widths for Front Wheels with Rims for 8 Positions (6155M)
38.16 Three-Piece Front Axle (Version 2)?Tread Widths for Front Wheels with Rims for 8 Positions (6175M and 6195M)
38.17 Three-Piece Front Axle (Version 2)?Tread Widths for Front Wheels with Rims for 16 Positions (6155M)
38.18 Three-Piece Front Axle (Version 2)?Tread Widths for Front Wheels with Rims for 16 Positions (6155MH)
38.19 Three-Piece Front Axle (Version 2)?Tread Widths for Front Wheels with Rims for 16 Positions (6175M and 6195M)
39 Steering Stop and Fender ? Settings
39.1 Adjust Fenders
39.2 Three-Piece Front Axle (Version 2)?Identify Axle Type
39.3 Notes on Adjusting the Fenders
39.4 Three-Piece Front Axle (Version 2)?Notes on Adjusting the Steering Stop (750 and 755)
39.5 Three-Piece Front Axle (Version 2)?Adjust the Fixed Fenders and Steering Stop (750) Part 1
39.6 Three-Piece Front Axle (Version 2)?Adjust the Fixed Fenders and Steering Stop (750) Part 2
39.7 Three-Piece Front Axle (Version 2)?Adjust the Pivoting Fenders and Steering Stop (750) Part 1
39.8 Three-Piece Front Axle (Version 2)?Adjust the Pivoting Fenders and Steering Stop (750) Part 2
40 Rear Wheels, Tires, and Tread Widths
40.1 Tires and Wheels?Foreword
40.2 Instructions for Rear Wheel Tread Adjustment with Rims for 2, 8, and 16 Positions (Flanged Axle)
40.3 Tread Widths for Rear Wheels with Rims for 2 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6155M)
40.4 Tread Widths for Rear Wheels with Rims for 2 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6175M and 6195M)
40.5 Tread Widths for Rear Wheels with Rims for 2 Positions, Heavy-Duty Type?Flanged Axles, Bolt Circle Diameter 275 mm (6155M)
40.6 Tread Widths for Rear Wheels with Rims for 2 Positions, Heavy-Duty Type?Flanged Axles, Bolt Circle Diameter 275 mm (6175M and 6195M)
40.7 Tread Widths for Rear Wheels with Rims for 8 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6155M)
40.8 Tread Widths for Rear Wheels with Rims for 8 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6155MH)
40.9 Tread Widths for Rear Wheels with Rims for 8 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6175M and 6195M)
40.10 Tread Widths for Rear Wheels with Rims for 16 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6155M)
40.11 Tread Widths for Rear Wheels with Rims for 16 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6155MH)
40.12 Tread Widths for Rear Wheels with Rims for 16 Positions?Flanged Axles, Bolt Circle Diameter 275 mm (6175M and 6195M)
40.13 Steel Adjustable Wheels in Combination with Adjustable Rear Axles
40.14 Notes on Rear Wheels?Rack-and-Pinion Axles, Hub Diameter 86, 92, and 100 mm with Single Tapered Clamping Sleeves
40.15 Rack-and-Pinion Axles, Hub Diameter 86, 92, and 100 mm with Single Tapered Clamping Sleeves?Adjust Tread Widths for Cast Rear Wheels
40.16 Rack-and-Pinion Axles, Hub Diameter 86, 92, and 100 mm with Single Tapered Clamping Sleeves?Adjust Tread Widths for Steel Rear Wheels (with Adjusting Pinion)
40.17 Rack-and-Pinion Axles, Hub Diameter 86, 92, and 100 mm with Single Tapered Clamping Sleeves?Adjust Tread Widths for Steel Rear Wheels (without Adjusting Pinion)
40.18 Tread Widths for Rear Wheels with Rims for 2 Positions?Rack-and-Pinion Axles, Hub Diameter 92 mm (6155M)
40.19 Tread Widths for Rear Wheels with Rims for 2 Positions?Rack-and-Pinion Axles, Hub Diameter 92 mm (6175M and 6195M)
40.20 Tread Widths for Rear Wheels with Rims for 2 Positions, Heavy-Duty Type?Rack-and-Pinion Axles, Hub Diameter 92 mm (6155M)
40.21 Tread Widths for Rear Wheels with Rims for 2 Positions, Heavy-Duty Type?Rack-and-Pinion Axles, Hub Diameter 92 mm (6175M and 6195M)
41 Operator’s Cab
41.1 Avoid Contact with Agricultural Chemicals
41.2 Clean Vehicle of Hazardous Pesticides
41.3 Emergency Exits
41.4 Roll-Over Protective Structure
41.5 Falling Object Protective Structure (FOPS)
41.6 Use the Seat Belt
41.7 Tractors with Cab Suspension
42 Seat Adjustment
42.1 Seat Adjustment and Functions (6M Series)
42.2 CommandARM??Adjust Height
42.3 Instructional Seat for Training Purposes
43 Steering Column
43.1 Adjust the Steering Wheel
44 Mirrors
44.1 External Mirrors, Manually Adjustable
44.2 Adjust Interior Mirror
45 Access Steps
45.1 Access Steps and Handrails
45.2 Access Steps and Handrails (6155MH)
45.3 Remove and Install Left Access Step
45.4 Remove and Install Right Access Step
46 Wiper/Washer System
46.1 Wiper and Washer System
47 Heater/Ventilation/Air Conditioning (HVAC)
47.1 Heater/Ventilation/Air-Conditioning System (HVAC)
48 Lights
48.1 Overview of the Lights
48.2 Shift Lever for Turn Signal and Horn
48.3 Light Switch
48.4 Select Headlights
48.5 Select Worklights
48.6 Worklights of ISOBUS Implement
48.7 Switch On the Hazard Warning Lights
48.8 Beacon Light (Optional)
48.9 Dome Lights
48.10 Access-Step Light
48.11 Seven-Terminal Trailer Socket
49 Power Outlet Sockets
49.1 Socket for GreenStar? Display
49.2 Ethernet Socket for Universal Display (If Equipped)
49.3 3-Terminal Power Outlet Socket and Power Outlet Socket Strip (12 V, SAE)
49.4 12-V Power Outlet Socket/Cigarette Lighter
49.5 Signal Socket According to ISO Standard 11786
49.6 ISOBUS Socket in Cab
49.7 Diagnostic Connector (CAN Bus)
49.8 Radio A?Connection of Memory Storage and Multimedia Appliances
49.9 Radio B?Connection of Memory Storage and Multimedia Appliances
49.10 3-Terminal Power Outlet Socket (12 V, ECE), Front Hitch
49.11 ISOBUS Socket (ISB), Rear Hitch
49.12 Seven-Terminal Trailer Socket, Rear Hitch
49.13 Seven-Terminal Trailer Socket, Front Hitch
50 Accessories
50.1 Storage Tray
50.2 Controls for Hydraulic Quick Release and Worklights on Front Loader (If Equipped)
50.3 Turn Backup Alarm ON and OFF (Optional Equipment)
50.4 Install Additional Monitors
50.5 Open Rear Window and Side Windows
50.6 Rear Window – Cable Guides
50.7 Roof Hatch (If Equipped)
50.8 Pull-Down Sunshade
50.9 Lockable Tank Filler Cap
51 Performance Ballast
51.1 Ballasting Information and Guidelines for Tractors with Single Tires
51.2 General Guidelines for Tractor Weight Based on Engine Horsepower (according to EC Directive 97/68, using PS as Unit of Measurement)
51.3 Selection of Weights
51.4 Load on Rear Wheels
51.5 Measure Rear Wheel Slip
51.6 Fill Tires with Water
51.7 Drain Tires
51.8 Rear Wheel Ballast Weights (Standard Version)
51.9 Change Wheel Weights Safely (Type A)
51.10 Change Wheel Weights Safely (Type B)
51.11 Weight in Three-Point Hitch
51.12 Attach Pickup Weight to the Front Hitch
51.13 Attach the Pickup Weight to the Rear Hitch
51.14 Attach Pickup Weight to the Basic Weight
51.15 Install Front Weights
52 Transport
52.1 Transporting Tractor
52.2 Lashing the Tractor on a Transport Trailers
52.3 Wash Machine After Unloading
52.4 Driving on Public Roads
52.5 Towing Loads and Transporting with Ballast
52.6 Use Safety Chain
52.7 Freeing a Mired Machine
52.8 Tow the Tractor
52.9 CommandQuad? PLUS ? Towing the Tractor
53 Fuel, Lubricants, and Coolant
53.1 Oilscan? and CoolScan?
54 Diesel Fuel
54.1 Diesel Fuel
54.2 Handling and Storing Diesel Fuel
54.3 Lubricity of Diesel Fuel
54.4 Testing Diesel Fuel
54.5 Biodiesel Fuel
54.6 Minimizing the Effect of Cold Weather on Diesel Engines
54.7 Supplemental Diesel Fuel Additives
55 Diesel Exhaust Fluid
55.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
55.2 Refilling Diesel Exhaust Fluid (DEF) Tank
55.3 Storing Diesel Exhaust Fluid (DEF)
55.4 Testing Diesel Exhaust Fluid (DEF)
55.5 Disposal of Diesel Exhaust Fluid (DEF)
56 Engine Oil ? Only for Final Tier 4 Engines (6 Cylinder)
56.1 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
56.2 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
56.3 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
56.4 Diesel Engine Oil Service Interval for Operation at High Altitude
57 Engine Coolant
57.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
57.2 Operating in Warm Temperature Climates
57.3 Water Quality for Mixing with Coolant Concentrate
57.4 Testing Coolant Freeze Point
58 Other Lubricants
58.1 Transmission and Hydraulic Oil
58.2 Oil for Front-Wheel Drive Axle
58.3 Multipurpose Extreme Pressure (EP) Grease
58.4 Grease for Automated Lubrication Systems
58.5 Grease
58.6 Multipurpose Grease
58.7 Mixing of Lubricants
58.8 Lubricant Storage
58.9 Alternative and Synthetic Lubricants
59 Service ? General Information
59.1 Required Emission-Related Information
59.2 Safe Maintenance and Cleaning
59.3 Using High-Pressure Washers
59.4 Observe Service Intervals
59.5 Maintenance Intervals
59.6 Maintenance Menu
59.7 Raise the Hood
59.8 Open Service Doors
59.9 Bleed Air from Fuel System (6-Cylinder Engines)
59.10 Jack Up the Tractor, Lifting Points
59.11 General Instructions Regarding the Condition of the Tractor
59.12 Inspect/Replace Hydraulic Hoses
59.13 Important Instructions Regarding Alternator
59.14 Note on Wheels and Tires
59.15 Notes on, Before Initial Start-Up and Daily Service
59.16 Information on Engine Serial Number, Stage, and Aftertreatment
59.17 Instructions for Starting up the Air-Conditioning System
59.18 Unified Inch Bolt and Screw Torque Values
59.19 Metric Bolt and Screw Torque Values
60 Service Intervals ? Only Tractors with Final Tier 4 Engines (6 Cylinder)
60.1 GENERAL INFORMATION
60.2 Notes
60.3 Service Daily or Every 10 Operating Hours
60.4 Service (As Required, Annually, Every 2 and 3 Years) – Only on Tractors with 6-Cylinder Final Tier 4 Engines
60.5 Period