John Deere 5090R, 5100R, 5115R, and 5125R (FT4) Tractor Operator Manual OMSU53451

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
2 General Information
2.1 Product View
2.2 Trademarks
2.3 Glossary of Terms
2.4 Regions and Country Versions
2.5 Machine Overview
3 Safety Precautions
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Replace Safety Signs
4.2 Operators Manual
4.3 Use Seat Belt Properly
4.4 Instructional Seat
4.5 Starter
4.6 PTO Shield
4.7 Tow Implement Properly
4.8 Front-End Loader
4.9 Engine Coolant Heater
5 Controls and Instruments
5.1 Front Console Controls
5.2 Foot Operated Controls
5.3 Right-Hand Controls
5.4 Corner Post Display and Navigation Pad
5.5 Key Pad
5.6 Transmission Controls
5.7 Multi-Function Lever/Mid-SCV Controls
5.8 Rear SCV Controls
5.9 Rear Hitch Controls
5.10 Rear PTO Controls
5.11 Engine Speed Control
5.12 Heat and Air Conditioning Controls
6 Engine Operation
6.1 Required Machine Stop Warning
6.2 Engine Menu
6.3 Engine Fuel System and Power Rating
6.4 Check Engine Indicators and Gauges
6.5 Operate Key Switch
6.6 Start Engine
6.7 Cold Weather Start
6.8 Run Engine
6.9 Engine Speeds and Operational Procedures
6.10 Stop Engine
6.11 Restart Engine That Has Run Out of Fuel
6.12 Engine Block Coolant Heater
6.13 FieldCruise?
6.14 Foot Throttle Pedal Lock
6.15 Intelligent Power Management
7 Air Intake, Fuel, Coolant, and Exhaust Operation
7.1 Aftertreatment Indicators Overview
7.2 Selective Catalytic Reduction (SCR) System Overview
7.3 US EPA Qualified Emergency Use ? SCR Derate Override Option
7.4 Fuel and Diesel Exhaust Fluid (DEF) Level Gauges
7.5 Fill Fuel Tank
7.6 Fill Diesel Exhaust Fluid (DEF) Tank
7.7 Reduce Fuel Consumption
7.8 Engine Menu
7.9 Exhaust Filter Cleaning Overview
8 Electrical and Lighting Operation
8.1 Light Switch
8.2 Headlights
8.3 Loader Lights
8.4 Bucket Lights
8.5 Tail and Brake Lights
8.6 Turn Signals
8.7 Warning Lights
8.8 Beacon Lights
8.9 Front Worklights
8.10 Side and Rear Worklights
8.11 Dome Light
8.12 Map Light
8.13 Right-Hand Console Light
8.14 Step Light
8.15 Horn
8.16 Backup Alarm
8.17 Front Wiper and Washer
8.18 Rear Wiper and Washer
8.19 Radio
8.20 Auxiliary Input and USB Port
8.21 Bluetooth? Microphone
8.22 Speakers
8.23 Radio Antenna
8.24 Satellite Module and Antenna
8.25 Implement Connector
8.26 Power Outlet
8.27 Convenience Outlets
8.28 Auxiliary Power Strip
8.29 ISO 11786 Connector
8.30 Service ADVISOR? Connector
8.31 Operator Presence
8.32 JDLink?
9 Displays, Software, and Electronics Operation
9.1 Corner Post Display
9.2 Primary Display
9.3 Information Display Navigation Controls
9.4 Basic Menu Navigation
9.5 Run Pages
9.6 Layout Manager Menu
9.7 Layout Manager Settings
9.8 Display Settings Menu
9.9 Display Settings
9.10 Work Monitor Menu
9.11 Work Monitor Operation
9.12 iTEC? Basic Menu
9.13 iTEC? Basic Operation
9.14 Maintenance Menu
9.15 Maintenance Counters and Intervals
10 Drivetrain Operation
10.1 Drivetrain Information
10.2 Off Level Operation
11 Transmission Operation
11.1 Transmission Menu
11.2 Transmission Settings
11.3 Transmission Indicators
11.4 Transmission Controls and Operation
11.5 Downhill Operation in Slippery Conditions
11.6 Adjust Set Speeds
11.7 Speed Matching
11.8 Efficiency Manager
11.9 ECO On-Off
11.10 AutoClutch?
11.11 Park Brake
11.12 16/16 Transmission Ground Speed Chart
11.13 16/16 Creeper Ground Speed Chart
11.14 32/16 Transmission Ground Speed Chart
11.15 Correction Factors for Other Tire Sizes
12 MFWD and Front Axle Operation
12.1 Mechanical Front Wheel Drive (MFWD)
13 Differential and Rear Axle Operation
13.1 Differential Lock
14 Power Take Off (PTO) Operation
14.1 Match Machine Power to Implement
14.2 PTO Guard
14.3 PTO Shield
14.4 PTO Drive Shaft Shield
14.5 Select PTO Drawbar Position
14.6 Exchangeable 540/1000 rpm PTO Shaft
14.7 Attach PTO Driven Implement
14.8 Select Correct PTO Speed
14.9 Operate Rear PTO
14.10 Operate Rear Remote PTO
14.11 PTO Alarm
15 Steering and Brake Operation
15.1 Service Brakes
15.2 Brake Operation with AutoClutch?
15.3 Autotrac? Universal Information
16 Hydraulics Operation
16.1 Warm Transmission-Hydraulic Oil
16.2 Closed Center Hydraulics
16.3 Open Center Hydraulics
17 Hitch and Drawbar Operation
17.1 Match Machine Power to Implement
17.2 Rear Hitch Controls
17.3 Rear Hitch Components
17.4 Operate Rear Hitch Controls
17.5 Operate Rear Hitch Fender Switch
17.6 Rear Hitch Menu
17.7 Load Depth Control
17.8 Implement Float
17.9 Upper Limit
17.10 Drop Rate
17.11 Raise Rate
17.12 Prepare Implement
17.13 Hitch Conversion – Category II to I
17.14 Position Center Link
17.15 Adjust Lateral Float
17.16 Hydraulic Center Link
17.17 Attach Implement to Rear Hitch
17.18 Level Hitch
17.19 Adjust Hitch Side Sway
17.20 Quick Coupler
17.21 Manually Raise/Lower Hitch
17.22 Front Hitch Components
17.23 Front Implement Connection
17.24 Front Hitch and Coupler Operation
17.25 Drawbar Settings
17.26 Clevis Drawbar
17.27 Drawn Implement Connection
18 Selective Control Valve Operation
18.1 SCV and Loader Menu
18.2 SCV and Loader Settings
18.3 Rear SCV Controls and Components
18.4 Mid-SCV Controls and Components
18.5 Front Hitch and SCV
18.6 Connect Hydraulic Hoses
18.7 Connect to Rear SCVs
18.8 Connect to Mid-SCVs
18.9 Correct Reversed Cylinder Response
18.10 Single-Acting Cylinders
18.11 Implements Requiring Large Volumes of Oil
18.12 Set SCV Detents
18.13 Operate Hydraulic Motor with Rear SCV
18.14 Operate Power-Beyond with Rear SCV
18.15 Operate Loader with Rear SCV
18.16 Adjust Flow Control
18.17 Power-Beyond
18.18 Case Drain
18.19 Motor Return
18.20 Fast Return to Sump
18.21 Mid-SCV Couplers
18.22 Rear SCV Oil Collection
19 Wheels and Tires Operation
19.1 Wheels and Tires Information
20 Ballasting
20.1 Ballasting Information
21 Additional Equipment
21.1 Tool Box
21.2 Front Loader
21.3 Lockable Fuel Fill Cap
21.4 Hood Latch
22 Operator Station Operation
22.1 Doors
22.2 Grab Handles
22.3 Windows
22.4 Window Shades
22.5 Mirrors
22.6 Air Suspension Seat
22.7 Instructional Seat
22.8 Steering Wheel and Column
22.9 Heat, Defrost, and Air Conditioning
22.10 Storage Drawer
22.11 General Storage
22.12 Field Office?
22.13 Monitor Mounts
22.14 Rear Window Cable Routing
22.15 Coat Hook
22.16 Ash Tray and Cigarette Lighter
22.17 Cab Suspension
23 Transport and Storage
23.1 Keep Machines Secure
23.2 Deliver Safely
23.3 Road Transportation
23.4 Towing Loads
23.5 Tow Machine
23.6 Release Park Brake for Towing
23.7 Front Tow Points
23.8 Rear Tow Points
23.9 Machine Storage
23.10 Remove Machine from Storage
24 Maintenance Intervals
24.1 Service Daily Before Start-Up
24.2 Service Interval Chart
25 Fuels, Lubricants, and Coolants
25.1 Alternative and Synthetic Lubricants
25.2 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
25.3 Operating in Warm Temperature Climates
25.4 John Deere COOL-GARD? II Coolant Extender
25.5 Water Quality for Mixing with Coolant Concentrate
25.6 Testing Coolant Freeze Point
25.7 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
25.8 Disposal of Diesel Exhaust Fluid (DEF)
25.9 Refilling Diesel Exhaust Fluid (DEF) Tank
25.10 Storing Diesel Exhaust Fluid (DEF)
25.11 Testing Diesel Exhaust Fluid (DEF)
25.12 Diesel Engine Oil Service Interval for Operation at High Altitude
25.13 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
25.14 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
25.15 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
25.16 Oil Filters
25.17 Fuel Filters
25.18 Diesel Fuel
25.19 Handling and Storing Diesel Fuel
25.20 Lubricity of Diesel Fuel
25.21 Testing Diesel Fuel
25.22 Biodiesel Fuel
25.23 Minimizing the Effect of Cold Weather on Diesel Engines
25.24 Supplemental Diesel Fuel Additives
25.25 Multipurpose Extreme Pressure (EP) Grease
25.26 Mixing of Lubricants
25.27 Lubricant Storage
25.28 Transmission, Steering, Brake, Hydraulic, and Gear Case Oil
25.29 Oilscan? and CoolScan?
26 As Required Maintenance
26.1 Service As Required
26.2 Paint and Finish Care
27 Controls and Instruments Maintenance
27.1 General Controls and Instruments Maintenance
28 Engine Maintenance
28.1 Break-In Service
28.2 Break-In Checks
28.3 Check Engine Oil Level
28.4 Change Engine Oil and Filter
28.5 Clean Open Crankcase Vent (OCV)
28.6 Change Open Crankcase Vent Filter (OCV)
28.7 Check Fan Belt Tensioner
28.8 Replace Fan Belt
28.9 Adjust Engine Valve Clearance
29 Air, Fuel, Coolant, and Exhaust Maintenance
29.1 Required Emission-Related Information
29.2 Recommended Dealer Performed Service
29.3 Check Engine and Exhaust Compartments for Debris
29.4 Clean Diesel Particulate Filter (DPF)
29.5 Changing Diesel Exhaust Fluid (DEF) Dosing Unit Filter
29.6 Cleaning Diesel Exhaust Fluid (DEF) Tank
29.7 Drain Diesel Exhaust Fluid (DEF) Tank
29.8 Service Air Cleaner Elements
29.9 Tighten Air Intake and Engine Cooling Hose Clamps
29.10 Clean Air Filter Dust Unloading Valve
29.11 Clean Grille Screens and Cooling Package
29.12 Do Not Modify Fuel System
29.13 Drain Water and Sediment from Fuel Filter
29.14 Bleed Fuel System
29.15 Replace Fuel Filters
29.16 Check Coolant Level
30 Electrical and Lighting Maintenance
30.1 Use Booster Battery or Charger
30.2 Battery Maintenance
30.3 Access and Replace Battery
30.4 Replace Fusible Link
30.5 Replace Fuses
30.6 Handle Halogen Light Bulbs Safely
30.7 Replace Halogen Headlight Bulb
30.8 Replace LED Headlight
30.9 Replace Loader Light Bulb
30.10 Replace Bucket Light
30.11 Replace Tail/Turn/Brake Light Bulb
30.12 Replace Warning Light Bulb
30.13 Replace Halogen Worklight Bulb
30.14 Replace LED Worklight
30.15 Replace Beacon Light Bulb
30.16 Replace Dome Light Bulb
30.17 Replace Right-Hand Console Light Bulb
30.18 Replace Map Light Bulb
30.19 Replace Step Light
31 Drive Train Maintenance
31.1 Drivetrain Information
32 Transmission Maintenance
32.1 Change Transmission-Hydraulic Oil and Filter
32.2 Check Neutral Start System
32.3 Check Transmission Park System
32.4 Replace Transmission Dampener
33 MFWD and Front Axle Maintenance
33.1 Check MFWD Axle for Oil Leaks
33.2 Check MFWD Axle Pivot Pin End Play
33.3 Lubricate MFWD Axle Trunnion
33.4 Change MFWD Axle Wheel Hub Oil
33.5 Change MFWD Axle Housing Oil
34 Differential and Rear Axle Maintenance
34.1 Lubricate Rear Axle Bearings
35 Power Take Off (PTO) Maintenance
35.1 Adjust PTO Speed Shift Lever
35.2 Lubricate Exchangeable 540/1000 rpm PTO Shaft
36 Steering and Brake Maintenance
36.1 Check Manual Brakes
37 Hydraulics Maintenance
37.1 Check Transmission-Hydraulic System Oil Level
37.2 Change Transmission-Hydraulic Oil and Filter (Closed Center)
37.3 Clean Transmission Suction Screen (Closed Center)
37.4 Change Transmission-Hydraulic Filter (Open Center)
37.5 Change Transmission-Hydraulic Oil and Filter (Open Center)
38 Hitch and Drawbar Maintenance
38.1 Lubricate Draft Sensing Shaft Seal
38.2 Lubricate Rear Hitch
38.3 Lubricate Front Hitch
38.4 Inspect Hitch and Drawbar for Excessive Wear
39 Selective Control Valve Maintenance
39.1 Adjust Mechanical SCV Cables
39.2 Empty Rear SCV Oil Collection Bottle
40 Wheels and Tires Maintenance
40.1 Inspect Tires
40.2 Adjust and Check Clearance
40.3 Check Tire Inflation Pressure
40.4 Tire Pressures
40.5 Tire Inflation Pressure Guidelines
40.6 Maximum Tire Pressures
40.7 Tire Sidewall Information
40.8 Use Correct Tire Combinations
40.9 Correct Tire Selection
40.10 Changing Tire Sizes
40.11 Select Front Tire Rolling Direction
40.12 Rear Wheel Tread Width Limitations
40.13 Set Tread?Two-Position MFWD Wheels
40.14 Set Tread?Multi-Position MFWD Wheels
40.15 Set Tread?Two-Position Rear Wheels
40.16 Set Tread?Multi-Position Rear Wheels
40.17 Tighten Wheel Bolts Correctly
40.18 Install Wheel Spacer
40.19 Tighten Wheel Bolts?MFWD Axle
40.20 Tighten Wheel Bolts?Rear Axle
40.21 Jacking Up Machine
40.22 Check Toe-In?MFWD Axle
40.23 Adjust Toe-In?MFWD Axle
40.24 Set Steering Stops
41 Ballasting Maintenance
41.1 General Ballast Information
41.2 Select Ballast Carefully
41.3 Implement Codes
41.4 Front-End Ballast
41.5 Rear Wheel Ballast
41.6 Control Power Hop – MFWD
41.7 Add Liquid Ballast to Tires
41.8 Remove Liquid Ballast from Tires
41.9 Measure Wheel Slip
42 Additional Equipment Maintenance
42.1 Front Loader Bracket Installation
42.2 Set Pivoting Fender Brackets
42.3 Set Fender Position
43 Operator Station Maintenance
43.1 Clean Cab Air Filters
43.2 Check Air Conditioning System
43.3 Replace Wiper Blade
43.4 Inspect Seat Belts
43.5 Keep Cab Protection System Installed Properly
43.6 Starfire? Receiver Mount
43.7 Clean Cab Suspension Components
44 Troubleshooting
44.1 Engine
44.2 Heat and Air Conditioning
44.3 Electrical
44.4 Transmission
44.5 Brakes
44.6 Hydraulics
44.7 Hitch
44.8 Selective Control Valves (SCV)
45 On-Board Diagnostics
45.1 STOP, Service, Information Alert Indicators, and Alarms
45.2 Diagnostics Menu
45.3 Trouble Codes
45.4 Addresses
45.5 CAN Bus
46 Specifications
46.1 Metric Bolt and Screw Torque Values
46.2 Unified Inch Bolt and Screw Torque Values
46.3 Fluid Capacities
46.4 Machine Dimensions
46.5 Machine Weight
46.6 Engine and PTO Power
46.7 Engine Specifications
46.8 Electrical Specifications
46.9 PTO Engine Speeds
46.10 Closed Center Hydraulic Specifications
46.11 Open Center Hydraulic Specifications
46.12 Rear Hitch Lift Capacities
46.13 Front Hitch Lift Capacities
46.14 Drawbar Capacities
46.15 Weight Distribution
46.16 Permissible Load
46.17 Ballast Capacities
46.18 Sound Level
47 Identification Numbers
47.1 Record Product Identification Number
47.2 Record Front Axle Serial Number
47.3 Record Engine Serial Number
47.4 Record Transmission Serial Number
47.5 Record Cab Serial Number
47.6 Keep Proof of Ownership
48 Certification and Warranty
48.1 ROPS Certificate
48.2 Limited Battery Warranty
48.3 Emissions Control System Certification Label
48.4 Carbon Dioxide Emissions (CO?)
48.5 CARB Non-road Emissions Control Warranty Statement?Compression Ignition
48.6 EPA Non-road Emissions Control Warranty Statement?Compression Ignition
49 Service Records
49.1 Daily or 10 Hour Service
49.2 Weekly or 50 Hour Service
49.3 First 100 Hour Service
49.4 Every 250 Hour Service
49.5 Every 500 Hour Service
49.6 Every 600 Hour Service
49.7 Every 1200 Hour Service
49.8 Every 1500 Hour Service
49.9 Annual Service
49.10 Every 3 Years or 3000 Hours Service
49.11 Every 5 Years or 4500 Hours Service
49.12 Every 6 Years or 6000 Hours Service
49.13 Change of Ownership
49.14 Change of Ownership
49.15 Change of Ownership
50 John Deere Service
50.1 Technical Information
50.2 John Deere Is At Your Service