Table of Content:
1 Introduction
1.1 Foreword
2 Glossary
2.1 Glossary
2.2 Trademarks
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Decals
4.1 Replace Safety Signs
4.2 Riders (Open Operator Station)
4.3 Use Seat Belt Properly (Cab)
4.4 Avoid Crushing, Use Seat Belt Properly (Open Operator Station)
4.5 Operate Tractor Safely (Cab)
4.6 Operate Tractor Safely (Open Operator Station)
4.7 Starter Motor (Cab)
4.8 Starter Motor (Open Operator Station)
4.9 Towing Loads Safely (Cab)
4.10 Towing Loads Safely (Open Operator Station)
4.11 Do Not Modify ROPS (Cab)
4.12 Do Not Modify ROPS (Open Operator Station)
4.13 Caution When Operating The Front Loader (Cab)
4.14 Caution When Operating The Front Loader (Open Operator Station)
4.15 Caution When Operating Rear PTO
4.16 Accumulator ? Front Hitch
5 Vehicle Overview
5.1 Product Identification View
6 Operator’s Manual – General Information
6.1 Scope of This Manual
6.2 Operator Manual Usage Information
6.3 Comply with Operator’s Manuals of Implement Manufacturers
6.4 Operator Training Required
7 Operating the Engine
7.1 Engines with Turbocharger
7.2 Neutral Start Switch
7.3 Starting the Engine
7.4 Start with a Booster Battery
7.5 Start the Engine with a Slave Battery
7.6 Stop the Engine
7.7 Restart a Stalled Engine
7.8 Change Engine Speeds
7.9 Fill DEF Tank (Diesel Exhaust Fluid)
8 Cold Weather Operation
8.1 Cold-Weather Operation
9 Aftertreatment Equipment (DOC/DPF)
9.1 Exhaust Filter Cleaning, General Information
9.2 Aftertreatment General Warning (Tractor with DPF System)
9.3 Access the DPF Menu on the Digital Display
9.4 DPF Soot Load, General Information
9.5 Manual Regeneration, General Information
9.6 DPF Soot Load
10 Aftertreatment Equipment (DOC/SCR)
10.1 DEF Warning Messages
10.2 DEF Level Warning
10.3 Poor DEF Quality Warning
10.4 SCR System Failures/Tampering Warning
10.5 Aftertreatment General Warning (Tractor with SCR System)
10.6 Aftertreatment General Warning (Tractor without SCR System)
11 Controls
11.1 Vehicle Controls (5GV, 5GN) (Cab)
11.2 Vehicle Controls (5GV, 5GN) (Open Operator Station)
11.3 Vehicle Controls (5GL)
11.4 Vehicle Controls
12 Instrument Panel
12.1 Instruments and Indicator Lights
12.2 Observe Instruments After Starting the Engine
12.3 Engine Oil Pressure Indicator Light
12.4 Alternator Indicator Light
12.5 Air Cleaner Indicator Light
12.6 Transmission Oil Filter Indicator Light
12.7 Coolant Temperature Gauge
12.8 Observe Fuel Level
12.9 Warm Up the Engine
12.10 Avoid Idling the Engine
12.11 Observe Engine Work and Idle Speeds
13 Digital Display
13.1 Digital Display – User Interface
13.2 User Menu
13.3 Digital Display – Initial Setup (Matching with Tractor)
14 Drive Train
14.1 Drive System – Overview
15 Front-Wheel Drive
15.1 Operate Front-Wheel Drive
16 Differential Lock
16.1 Use Differential Lock
17 Brakes
17.1 Stop the Tractor
17.2 Use Brakes
17.3 Park the Tractor
17.4 Parking Brake
17.5 Chock Block
18 Transmission – General Information
18.1 Reduce Fuel Consumption
18.2 Travel Speeds
19 PowrReverser? Transmission
19.1 Shifting Transmission
19.2 Electro-hydraulic Hi-Lo (24/12 – Speed Transmission) (If Equipped)
19.3 Operate Transmission Shift Levers
19.4 Select a Gear
19.5 Cruise Control
19.6 Manually Adjusting the Engine Speed Memory MEM1
20 Mechanical Transmission
20.1 Shifting Transmission
20.2 Operate Transmission Shift Levers
20.3 Select a Gear
21 PTO Shaft and Hitch
21.1 Maximum Lifting Force
22 Rear PTO
22.1 PTO Guard
22.2 Operating Instructions
22.3 Attaching PTO-Driven Implement
22.4 Operating the Rear PTO (Mechanical Version) (5GV, 5GN)
22.5 Operating the Rear PTO (Electro-hydraulic Version) (5GV, 5GN, 5GL)
22.6 Selecting PTO Speeds
22.7 Drawbar
23 Rear Hitch
23.1 Three-Point Hitch Components
23.2 Match Tractor Power to Implement
23.3 Hitch Control Levers
23.4 Use the Hitch Position Control
23.5 Use the Draft Control
23.6 Position Control Lever Stop
23.7 Adjust the Rate-of-Drop
23.8 Prepare the Implement
23.9 Converting Category II Hitch to Category IN or Category I
23.10 Positioning Draft Link Ends
23.11 Quick-Coupling (Hook-Type) Draft Links
23.12 Attaching Implements
23.13 Attach Implements to 3-Point Hitch
23.14 Adjust Sway Blocks
23.15 Position the Center Link
23.16 Level the Hitch
23.17 Adjust Hitch Control Lever Friction
24 Hydraulic System
24.1 Maximum Permissible Oil Withdrawal
25 Hydraulic Connections
25.1 Use Correct Hose Tips
25.2 Connecting and Disconnecting Cylinder Hoses
25.3 Connect Hose Under Pressure
25.4 Neutral Position
25.5 Retracting and Extending Cylinder
25.6 Return to Sump
26 Selective Control Valves – Controls
26.1 Selective Control Valve (SCV) Levers
26.2 Control Lever and Coupler Identification
26.3 Operating the SCV Control Levers
26.4 Double/Single Acting SCVs Conversion
26.5 Flow Divider Valve
27 Wheels and Tires
27.1 Service Tires Safely
27.2 Changing Wheels Safely
27.3 Check Implement-to-Tire Clearance
27.4 Tire Pressures
27.5 Mounting Tires
27.6 Tire Combinations
28 Front Wheels, Tires, and Tread Widths
28.1 Tighten Wheel Bolts
28.2 Adjusting Front Axle Tread Width
28.3 Check Toe-In
28.4 Adjust Toe-In
28.5 Tread Adjustment (without Front-Wheel Drive) (5GV, 5GN)
28.6 Tread Adjustment (with Front-Wheel Drive) (5GV, 5GN)
29 Steering Stop and Fender ? Settings
29.1 Steering Angle Adjustment
29.2 Direction of Tire Rotation
30 Rear Wheels, Tires, and Tread Widths
30.1 Observe Rear Wheel Tread Width Limitations
30.2 Tread Adjustment – Rear Wheels (5GV, 5GN)
31 Operator’s Station and Cab
31.1 Emergency Exits
31.2 Roll-Over Protective Structure
31.3 Operating Roll-Over Protective Structure
32 Seat Adjustment
32.1 Seat Adjustment
33 Mirrors
33.1 Mirrors (Open Operator Station)
34 Heater / Ventilation / Air Conditioning (HVAC)
34.1 Heater and Air Conditioning System Controls
34.2 Operator’s Cab Switches
35 Lights
35.1 Total View – Lights (Cab) (5GV, 5GN)
35.2 Total View – Lights (2-Post ROPS) (5GV, 5GN)
35.3 Total View – Lights (2-Post ROPS) (5GL)
35.4 Light Switch and Horn Switch
35.5 Light Switch and Turn Signal Switch
35.6 Low Beam and High Beam Indicator Light
35.7 Wake up Mode
35.8 Front Clearance Lights, Turn Signal Lights, and Tail Lights
35.9 Turn Signal Lights
35.10 Hazard Warning Light Switch (Amber Warning Light Switch)
35.11 Worklight Switches (Open Operator Station)
35.12 Worklight Switches (Cab)
35.13 Beacon Light (Optional)
35.14 H4 Farm Headlights (Optional)
35.15 Dome Light
36 Power Outlet Sockets
36.1 Seven-Terminal Trailer Socket
37 Accessories
37.1 Sun Visor
37.2 Tool Box
38 Performance Ballast
38.1 Select Ballast
38.2 Ballast Limitations
38.3 Measuring Rear Wheel Slip
38.4 Installing Front Weights
38.5 Ballasting Front Wheel Drive Tractors
38.6 With Weight in 3-Point Hitch
38.7 Rear Wheel Weights
38.8 Front Weights
39 Transport
39.1 Transporting the Tractor
39.2 Towing Tractor
39.3 Tow the Tractor
39.4 Driving Tractor on Public Roads
40 Fuel, Lubricants, Hydraulic Oil and Coolant
40.1 Oilscan? and CoolScan?
41 Diesel Fuel
41.1 Diesel Fuel
41.2 Handling and Storing Diesel Fuel
41.3 Lubricity of Diesel Fuel
41.4 Testing Diesel Fuel
41.5 Biodiesel Fuel
41.6 Minimizing the Effect of Cold Weather on Diesel Engines
42 Engine Oil
42.1 John Deere Break-In Plus? Engine Oil
42.2 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
42.3 Engine Oil and Filter Service Intervals
43 Engine Coolant
43.1 Diesel Engine Coolant
43.2 Operating in Warm Temperature Climates
43.3 Water Quality for Mixing with Coolant Concentrate
43.4 Testing Diesel Engine Coolant
43.5 Supplemental Coolant Additives
44 Other Lubricants
44.1 Transmission and Hydraulic Oil
44.2 Front-Wheel Drive Axle Oil
44.3 Grease for Automated Lubrication Systems
44.4 Mixing of Lubricants
44.5 Lubricant Storage
44.6 Alternative and Synthetic Lubricants
45 Service ? General Information
45.1 Safe Maintenance and Cleaning
45.2 Using High-Pressure Washers
45.3 Avoid High-Pressure Fluids
45.4 Storing Fuel
45.5 Ultra Low Sulfur Fuel
45.6 When Performing Services
45.7 Lubrication and Periodic Service
45.8 Oil Service Message Reset (5075 Model)
45.9 Use Correct Lubricant
45.10 Other Service Jobs
45.11 Oil Vapor Recirculation System Maintenance
45.12 Turbo Compressor Maintenance
45.13 Overhaul Injection Pump
45.14 Fuel Filters
45.15 Tire Pressures
45.16 Inspect All Tires
45.17 Service Tractor Safely
45.18 Air Intake System Components
45.19 Fuel System Components
45.20 Engine Cooling System Components
45.21 Air-Conditioning System
45.22 Open Hood (Version 1)
45.23 Open Hood (Version 2)
45.24 Jack Up the Tractor – Lifting Points
45.25 Metric Bolt and Screw Torque Values
45.26 Unified Inch Bolt and Screw Torque Values
46 Service Intervals
46.1 Information
46.2 Service (Daily / Every 10, 50, 250, 500, and 750 Hours)
46.3 Service (Every 1000, 1250, 1500, 3000 Hours and Annually Services)
46.4 Information on Changing Engine Oil
46.5 Engine Oil and Filter Change
46.6 Engine Oil and Filter Change
46.7 Engine Oil and Filter Change
46.8 Engine Oil and Filter Change
46.9 Engine Oil and Filter Change
46.10 Engine Air Cleaner and Cab Air Filters, Service
46.11 Engine Air Cleaner and Cab Air Filters, Service
46.12 Activated Carbon Filters in Cab, Service (If Equipped)
46.13 Activated Carbon Filters in Cab, Service (If Equipped)
46.14 Activated Carbon Filters in Cab, Service (If Equipped)
46.15 Activated Carbon Filters in Cab, Service (If Equipped)
46.16 Cooling System, Service
46.17 Cooling System, Service
46.18 Yearly Service
46.19 Yearly Service
46.20 50 Hour Service
46.21 250 Hour Service
46.22 500 Hour Service
46.23 750 Hour Service
46.24 1000 Hour Service
46.25 1250 Hour Service
46.26 1500 Hour Service
46.27 1750 Hour Service
46.28 2000 Hour Service
46.29 2250 Hour Service
46.30 2500 Hour Service
46.31 2750 Hour Service
46.32 3000 Hour Service
46.33 3250 Hour Service
46.34 3500 Hour Service
46.35 3750 Hour Service
46.36 4000 Hour Service
46.37 4250 Hour Service
46.38 4500 Hour Service
46.39 4750 Hour Service
46.40 5000 Hour Service
46.41 5250 Hour Service
46.42 5500 Hour Service
46.43 5750 Hour Service
46.44 6000 Hour Service
46.45 Information About Further Services
46.46 Record for Further Services
47 Service ? Cleaning
47.1 Cleaning the Dust Unloading Valve
47.2 Clean Radiator and Oil Cooler
47.3 Radiators, Cleaning
47.4 Clean Air-Conditioning System Condenser
47.5 Service Air Cleaner at Regular Intervals
47.6 Clean Cab Air Filters
47.7 Clean Vehicle of Hazardous Pesticides
48 Service ? Electrical System
48.1 Observe Electrical Service Precautions
48.2 Battery Cut-off Switch (If Equipped)
48.3 Battery
48.4 Bulb Replacement ? Safety Instructions
48.5 Checking on Lights
48.6 Adjusting the Headlights
48.7 Replace Headlight Bulbs
48.8 Replace Clearance, Brake, Turn Signal Light Bulbs and SMV Lights
48.9 Replace Rear Working Light Bulb
48.10 Check Charge State of the Battery
48.11 Starting Motor
48.12 Fuse Box
48.13 Fuse Check
48.14 Main Fuses and Relays (5GV, 5GN)
48.15 Fuse Box (Cab) (If Equipped) (5GV, 5GN)
48.16 Relays (Cab) (5GV, 5GN)
48.17 Main Fuses and Relays (5GL)
48.18 Engine Fuses and Relays (5GV, 5GN)
48.19 Engine Fuses and Relays (5GL)
48.20 Main Power Supply Fuses and Additional Relays (5GL)
48.21 Fuse and Relay Box (Mechanical Transmission) (5GV, 5GN)
48.22 Fuse and Relay Box (PowrReverser? Transmission) (5GV, 5GN)
49 Maintenance ? Checking Hardware Torques
49.1 Tighten Wheel Bolts
49.2 After the First 4 and 8 Hours of Operation
49.3 Mounting Bolts of Operator’s Cab / Open Station and ROPS
50 Service ? Checks
50.1 Check Torque of Wheel and Rim Bolts
50.2 Check Engine Oil Level
50.3 Check the Fuel Filter
50.4 Check Coolant Level
50.5 Check Transmission/Hydraulic System Oil Level
50.6 Check Brake System Oil Level
50.7 Check Brake Operation
50.8 Check Oil Levels in Front-Wheel Drive Axle
50.9 Check Oil Levels in Front-Wheel Drive (Final Drive) Axle
50.10 Check Neutral Start System ? 24/12 Transmission
50.11 Check Neutral Start System ? 12/12 Transmission
50.12 Check Belt Wear and Belt Tension
50.13 Check Torque of Drawbar Attaching Screws
50.14 Check Clutch Pedal Free Travel
50.15 Check Hoses and Hose Clamps
50.16 Check Components of Drawbar and Trailer Hitches
50.17 Check Engine Idle Speeds
50.18 Check and Lubricate Front Axle Pivot Pin
50.19 Check the Seat Belt
50.20 Check Condition of Diesel Engine Coolant
50.21 Radiator Pressure Cap Check
50.22 Inspect Hydraulic Hoses
50.23 Inspect Alternator
51 Service ? Change
51.1 Change Engine Oil
51.2 Change Engine Oil and Replace Oil Filter
51.3 Changing Oil in Front-Wheel Drive Axle
51.4 Change Oil in Front-Wheel Drive Axle Housing
51.5 Change Oil in Front-Wheel Drive Final Drives
51.6 Change Brake System Oil
51.7 Change Engine Coolant
51.8 Change Cooling System Coolant
51.9 Replace Transmission Hydraulic Oil and Suction Strainer
51.10 Replace Transmission/Hydraulic Oil Filter Cartridge (First and Second Pump)
51.11 Replace Cab Air Filters
51.12 Replace Diesel Particulate Filter
51.13 Replace Alternator Drive Belt
51.14 Replace Water Pump
51.15 Replace Fuel Filter
51.16 Replace and Clean Engine Air Filter
51.17 Drain Water and Sediment from Fuel Filter
51.18 Drain Water and Sediment from Fuel Tank
51.19 Replace Transmission/Hydraulic Oil Filter Cartridge (Third Pump)
51.20 Drain Sediment from DEF (Diesel Exhaust Fluid) Tank
51.21 Replace the Supply Module Filter
51.22 Replace DOC SCR Filters
51.23 Adjust PTO Clutch Linkage
52 Service ? Lubrication
52.1 Lubricate Front-Wheel Drive Axle
52.2 Lubricate Front Axle King Pins
52.3 Lubricate 3-Point Hitch
52.4 Lubricate Hub Bearings (Tractors Without Front-Wheel Drive)
52.5 Lubricate Draft Links
52.6 Lubricate Rear Axle Bearings
52.7 Lubricate
53 Troubleshooting
53.1 Diagnostic Trouble Codes – Operator Information
53.2 Engine Troubleshooting
53.3 Transmission Troubleshooting
53.4 Brakes Troubleshooting
53.5 Rockshaft and Quick-Coupler 3-Point Hitch Troubleshooting
53.6 Remote Hydraulic Cylinders Troubleshooting
53.7 Electrical System Troubleshooting
54 Storage
54.1 Storage for Long Period
54.2 Remove Tractor from Storage
55 Specifications
55.1 Engine
55.2 JD After Treatment System
55.3 DPF Soot Load
55.4 Transmission
55.5 Hydraulic System
55.6 Electrical System
55.7 Fuel System
55.8 Capacities
55.9 Sound Level
55.10 Brakes
55.11 Three-Point Hitch
55.12 Loads and Weights
55.13 Towable Loads
55.14 Shipping Weights
55.15 Maximum Permissible Axle Loads and Total Weights
55.16 Maximum Permissible Axle Load in Relation to Tires (Normal Operation)
55.17 Load Capacity of Tires with Front Loader
55.18 Dimensions (Cab) (5GV, 5GN)
55.19 Dimensions (ROPS) (5GV, 5GN)
55.20 Dimensions (Open Operator Station) (5GL)
55.21 Safety Note Regarding the Subsequent Installation of Electrical and Electronic Appliances and/or Components
55.22 How to Calculate Maximum Permissible Download on Trailer Hitch
55.23 How to Calculate Permissible Mass
55.24 Vibration
55.25 Safety Note Regarding the Subsequent Installation of Electrical and Electronic Appliances and/or Components
55.26 Limited Battery Warranty
55.27 FPT ? EPA Non-road Emissions Control Warranty Statement?Compression Ignition
55.28 FPT ? CARB Non-road Emissions Control Warranty Statement?Compression Ignition
55.29 Emissions Control System Certification Label
56 Serial Numbers
56.1 Identification Plates
56.2 Product Identification Number
56.3 Engine Serial Number
56.4 Transmission Serial Number
56.5 Front Axle Serial Number
57 Change of Ownership
57.1 List of Owners
58 Service ? Predelivery Inspection
58.1 Service Procedure
58.2 Copy for Dealer
58.3 Copy for Owner
59 John Deere Service Keeps You On the Job
59.1 John Deere Parts
59.2 The Right Tools
59.3 Well-Trained Technicians
59.4 Prompt Service