Table of Content:
1 Introduction
1.1 Foreword
2 General Information
2.1 Product View
2.2 Trademarks
2.3 Glossary of Terms
2.4 Regions and Country Versions
2.5 Machine Overview
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Fire Prevention
3.9 In Case of Fire
3.10 Avoid Static Electricity Risk When Refueling
3.11 Use Foldable ROPS and Seat Belt Properly
3.12 Stay Clear of Rotating Drivelines
3.13 Use Steps and Handholds Correctly
3.14 Read Operator?s Manuals for ISOBUS Controllers
3.15 Use Seat Belt Properly
3.16 Vibration
3.17 Operating the Tractor Safely
3.18 Avoid Backover Accidents
3.19 Limited Use in Forestry Operation
3.20 Operating the Loader Tractor Safely
3.21 Keep Riders Off Machine
3.22 Passenger Seat
3.23 Use Safety Lights and Devices
3.24 Towing Trailers/Implements Safely
3.25 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.26 Freeing a Mired Machine
3.27 Avoid Contact with Agricultural Chemicals
3.28 Handle Agricultural Chemicals Safely
3.29 Handling Batteries Safely
3.30 Avoid Heating Near Pressurized Fluid Lines
3.31 Remove Paint Before Welding or Heating
3.32 Handle Electronic Components and Brackets Safely
3.33 Practice Safe Maintenance
3.34 Avoid Hot Exhaust
3.35 Clean Exhaust Filter Safely
3.36 Work In Ventilated Area
3.37 Support Machine Properly
3.38 Prevent Machine Runaway
3.39 Park Machine Safely
3.40 Transport Tractor Safely
3.41 Service Cooling System Safely
3.42 Service Accumulator Systems Safely
3.43 Service Tires Safely
3.44 Service Front-Wheel Drive Tractor Safely
3.45 Tightening Wheel Retaining Bolts/Nuts
3.46 Avoid High-Pressure Fluids
3.47 Do Not Open High-Pressure Fuel System
3.48 Store Attachments Safely
3.49 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Replace Safety Signs
4.2 Caution Label
4.3 Caution Label
4.4 Caution Label
4.5 Caution Label?Cab Tractors
4.6 Caution Label
4.7 Caution Label
4.8 Caution Label
4.9 Caution Label?Cab Tractors
4.10 Caution Label?Cab Tractors
5 Controls and Instruments
5.1 Front Console Controls
5.2 Foot Operated Controls
5.3 Right-Hand Console Controls
5.4 Left-Hand Console Controls
5.5 Fender Controls
5.6 HVAC Controls
5.7 Instrument Panel
5.8 Information Display and Display Mode Switch
5.9 Information Display
6 Engine Operation
6.1 Using Key Switch
6.2 Using Throttle
6.3 Using eThrottle?If Equipped
6.4 Starting the Engine?Hydrostatic Transmission
6.5 Starting the Engine?PowrReverser Transmission
6.6 Stopping Machine
7 Air Intake, Fuel, Coolant, and Exhaust Operation
7.1 Using Fuel Shutoff Valve
7.2 Filling Fuel Tank
7.3 Exhaust Filter System Overview?If Equipped
8 Electrical and Lighting Operation
8.1 Using Lights and Turn Signals
8.2 Using Display Mode Switch
8.3 Using Dome Light?Cab
8.4 Using Power Port Outlet
9 Drivetrain Operation
9.1 Drive Machine?Hydrostatic Transmission
9.2 Driving Machine?PowrReverser Transmission
10 Transmission Operation
10.1 Operating Hydrostatic Transmission
10.2 Operating PowrReverser Transmission
10.3 Using Cruise Control?If Equipped
10.4 Using LoadMatch?(4049M, 4066M)
10.5 Using LoadMatch?(4049R, 4066R)
10.6 Using SpeedMatch?If Equipped
10.7 Using MotionMatch?(4049M, 4066M)
10.8 Using MotionMatch?(4049R, 4066R)
11 MFWD and Front Axle Operation
11.1 Using Mechanical Front Wheel Drive (MFWD)
12 Differential and Rear Axle Operation
12.1 Using Differential Lock (Traction Assist)
13 Power Take Off (PTO) Operation
13.1 Stay Clear of Rotating Drivelines
13.2 Using the Power Take-Off (PTO) Safely
13.3 Using Rear PTO Switch
13.4 Using the Two Speed Rear PTO?If Equipped
14 Steering and Brake Operation
14.1 Use Brake Pedals
14.2 Use Park Brake
14.3 Adjusting Tilt Steering Wheel?If Equipped
15 Hydraulics Operation
15.1 Warm Hydraulic System Oil
15.2 Hydraulics Information
16 Hitch and Drawbar Operation
16.1 Operate Attachments
16.2 Using Hitch Assist?Cab Tractors
16.3 Using Drawbar Hitch
16.4 Use 3-Point Hitch
16.5 Use Rockshaft Control Lever?Open Operator Station
16.6 Use Rate-of-Drop?Open Operator Station
16.7 Operate Rear EH Hitch Controls?Cab Tractors
16.8 Operate Rear EH Hitch Fender Switch?Cab Tractors
16.9 Manually Lower EH Hitch?Cab Tractors
16.10 Level Hitch
16.11 Adjust Hitch Side Sway
16.12 Installing A-Frame?If Equipped
16.13 Using Front 3-Point Hitch?If Equipped
16.14 Removing and Installing Implements on Front Hitch?If Equipped
16.15 Using Front Hitch Lift Arms?Category 1 and 1N?If Equipped
16.16 Using Torsion Tube?Category 1 and 1N?If Equipped
16.17 Using Heavy Duty Push Bar?Category 1 and 1N?If Equipped
16.18 Using Variable Clutch Engagement Setting with Front Hitch Installed
16.19 Using Loader with Front Hitch?If Equipped
17 Selective Control Valve Operation
17.1 Connecting Implement Hydraulic Hoses?Mechanical SCV
17.2 Using Dual Selective Control Valve Lever?If Equipped
17.3 Using Third Selective Control Valve (SCV) Outlet?If Equipped
17.4 Using Power Beyond Outlet?If Equipped
17.5 Using Fourth and Fifth Rear Outlet Selective Control Valve (SCV)?If Equipped
17.6 Using Diverter Rear Outlets?If Equipped
17.7 EH Selective Control Valve (SCV) Coupling Mode
17.8 Use EH Selective Control Valve (SCV) Joystick
17.9 Use Third EH SCV Outlet
18 Wheels and Tires Operation
18.1 Tire Combinations
19 Ballast
19.1 Selecting Ballast
19.2 Ballast Machine
19.3 Implement Codes
19.4 Use Optional Rear Cast Iron Wheel Weights
19.5 Use Optional Rear Ballast Box
19.6 Use Liquid Weight in Tires
19.7 Use Optional Front Weights
20 Additional Equipment Operation
20.1 Additional Equipment Operation
21 Operator Station Operation
21.1 Entering and Exiting Machine
21.2 Adjusting Seat
21.3 Using Seat Belt
21.4 Roll Over Protection Structure (ROPS)
21.5 Using Horn
21.6 HVAC Temperature Control?Cab
21.7 Using Windshield Wiper and Washer?Cab
21.8 Defrost Windshield and Side Glass?Cab
21.9 Using Rear Window?Cab
21.10 Using Radio?Cab
21.11 Using Toolbox?If Equipped
22 Transport and Storage
22.1 Transport Machine on Trailer
22.2 Transporting Machine
22.3 Pushing or Towing Machine
22.4 Towing Loads
22.5 Store Safety
22.6 Prepare Machine for Storage
22.7 Prepare Fuel and Engine For Storage
22.8 Remove Machine from Storage
22.9 Battery Isolation / Disconnect
22.10 Placing Front Hitch Lift Arms in Storage Position?Category 1 and 1N?If Equipped
23 Maintenance Intervals
23.1 Service Your Machine
23.2 Maintenance Interval Chart?Daily to Every 400 Hours
23.3 Maintenance Interval Chart?Every 400 Hours or Annually to Every 6000 Hours
23.4 Test Safety Systems
23.5 Testing Rear PTO Switch
23.6 Testing the Seat Switch
23.7 Avoid Damage to Plastic and Painted Surfaces
23.8 Clean Plastic Surfaces
23.9 Clean and Repair Metal Surfaces
24 Fuel, Lubricants, and Coolant
24.1 Diesel Fuel
24.2 Handling and Storing Diesel Fuel
24.3 Testing Diesel Fuel
24.4 Minimizing the Effect of Cold Weather on Diesel Engines
24.5 Alternative and Synthetic Lubricants
24.6 Engine Oil
24.7 Diesel Engine Coolant
24.8 Operating in Warm Temperature Climates
24.9 Additional Information About Diesel Engine Coolants and John Deere COOL-GARD? II Coolant Extender
24.10 Testing Diesel Engine Coolant
24.11 Testing Coolant Freeze Point
24.12 Transmission and Hydraulic Oil
24.13 Front Axle and MFWD Oil
24.14 Grease
25 Maintenance?As Required
25.1 Service?As Required
26 Controls and Instruments Maintenance
26.1 Controls and Instruments Maintenance
27 Engine Maintenance
27.1 Required Emission-Related Information
27.2 Emissions Performance and Tampering
27.3 Carbon Dioxide Emissions (CO?)
27.4 Daily Startup Procedure
27.5 Avoid Fumes
27.6 Checking Engine Oil Level
27.7 Changing Engine Oil and Filter
27.8 Clean Dust Unloading Valve
27.9 Servicing the Alternator Belt
27.10 Servicing the Air Conditioner Belt?Cab
27.11 Clean Front Grille Screens
27.12 Checking Engine Oil Level
27.13 Changing Engine Oil and Filter
27.14 Cleaning Front and Side Grille Screens
27.15 Clean Engine Compartment
28 Air, Fuel, Coolant and Exhaust Maintenance
28.1 Servicing Air Filter Elements
28.2 Checking Air Filter Intake Hose
28.3 Exhaust Filter Maintenance and Service
28.4 Automatic (AUTO) Exhaust Filter Cleaning?If Equipped
28.5 Disabled Exhaust Filter Cleaning?If Equipped
28.6 Parked Exhaust Filter Cleaning?If Equipped
28.7 Service Exhaust Filter Cleaning?If Equipped
28.8 Checking and Cleaning Fuel Filter Sediment Bowl and Replacing Filter
28.9 Fuel Injection Pump
28.10 Fuel Injection Nozzles
28.11 Service Cooling System Safely
28.12 Servicing Cooling System
28.13 Checking Radiator Hoses and Clamps
28.14 Cleaning Cooling Fins
28.15 Fluorinated Greenhouse Gas
29 Electrical and Lighting Maintenance
29.1 Service Electrical
29.2 Service the Battery Safely
29.3 Check Battery Electrolyte Level
29.4 Removing and Installing Battery
29.5 Clean Battery and Terminals
29.6 Use Booster Battery
29.7 Replacing Headlight Bulb
29.8 Replacing Light Bulbs?Open Operator Station
29.9 Replacing Light Bulbs?Cab
29.10 Replacing Relays and Fuses
30 Drivetrain Maintenance
30.1 Drivetrain Maintenance
31 Transmission Maintenance
31.1 Checking Transmission Oil Level
31.2 Changing Transmission Oil and Hydraulic Suction Oil Filter
32 MFWD and Front Axle Maintenance
32.1 Checking Front Axle Oil Level
32.2 Changing Front Axle Oil
32.3 Adjusting Front Axle Thrust Bolt Torque
32.4 Lubricating Axle Trunnion
33 Differential and Rear Axle Maintenance
33.1 Rear Axle
34 Power Take Off (PTO) Maintenance
34.1 PTO Maintenance
35 Steering and Brake Maintenance
35.1 Check and Adjust Toe-In
36 Hydraulics Maintenance
36.1 Hydraulic Maintenance
37 Hitch and Drawbar Maintenance
37.1 Lubricating 3-Point Hitch
37.2 Lubricate Front Hitch
37.3 Check Front Hitch Gear Case Oil
38 Selective Control Valve Maintenance
38.1 Check Selective Control Valve
39 Wheels and Tires Maintenance
39.1 Checking Wheel Bolts and Hardware
39.2 Removing and Installing Wheels
39.3 Check Tire Pressure
39.4 Tire Inflation Pressure Chart
39.5 Select Front Tire Rolling Direction
39.6 Changing Wheel Spacing and Tread Width
39.7 Lifting Points for Jacking up the Tractor
40 Ballasting Maintenance
40.1 Match Ballast to Work Load
41 Additional Equipment Maintenance
41.1 Additional Equipment Maintenance
42 Operator Station Maintenance
42.1 Raising and Lowering Hood
42.2 Side Panel Removal and Installation
42.3 Hood Cowl Removal and Installation
42.4 Cleaning Hood Vents
42.5 Inspect ROPS for Loose Hardware
42.6 Servicing Air Conditioner
42.7 Cleaning Cab Air Filter
42.8 Checking Cab Roll-Over Protection System Installation
43 Troubleshooting
43.1 Engine
43.2 Electrical System
43.3 Heater and Air Conditioning System
43.4 Machine
43.5 Brakes
43.6 Steering
44 On Board Diagnostics
44.1 Service Alert and Information Display
44.2 On Board Diagnostic Display
44.3 On-Board Diagnostic (OBD) Tool
44.4 Diagnostic Trouble Code (DTC)
44.5 Come Home Mode
45 Specifications
45.1 Engine
45.2 Drivetrain Specifications
45.3 Hydraulic System Specifications
45.4 Electrical System Specifications
45.5 Fluid Capacities
45.6 Ground Speeds
45.7 Dimensions
45.8 Sound Level
45.9 Seat Vibration
45.10 Height From Ground
45.11 Ground Clearance
45.12 Track Width
45.13 Turning Radius
45.14 Machine Weight
45.15 3-Point Hitch Specification
45.16 Coupling Devices
45.17 How to Calculate Maximum Permissible Download on Trailer Hitch
45.18 How to Calculate Permissible Mass
45.19 Unified Inch Bolt and Screw Torque Values
45.20 Metric Bolt and Screw Torque Values
46 Identification Numbers
46.1 Product Identification Information
46.2 Record Identification Numbers
47 Certification and Warranty
47.1 Warranty
48 Service Records
48.1 Every 10 Hour Service
48.2 Every 50 Hour Service
48.3 Every 100 Hour Service
48.4 Every 200 Hour Service or Annually
48.5 Every 400 Hour Service
48.6 Every 600 Hour Service
48.7 Annually
48.8 Every 1000 Hour Service
48.9 Every 2000 Hour Service or Every Two Years
48.10 Every 6000 Hour Service or Every Six Years
48.11 Change of Ownership
48.12 Change of Ownership
48.13 Change of Ownership
49 John Deere Service
49.1 John Deere Is At Your Service
49.2 Technical Information
