John Deere 8RX Tractor Operator Manual OMRE597223

Table of Content:

1 Introduction
1.1 Foreword
1.2 Emissions Performance and Tampering
1.3 Trademarks
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Use a Safety Chain
3.26 Transport Towed Equipment at Safe Speeds
3.27 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.28 Freeing a Mired Machine
3.29 Avoid Contact with Agricultural Chemicals
3.30 Handle Agricultural Chemicals Safely
3.31 Handling Batteries Safely
3.32 Avoid Heating Near Pressurized Fluid Lines
3.33 Remove Paint Before Welding or Heating
3.34 Handle Electronic Components and Brackets Safely
3.35 Practice Safe Maintenance
3.36 Avoid Hot Exhaust
3.37 Clean Exhaust Filter Safely
3.38 Work In Ventilated Area
3.39 Support Machine Properly
3.40 Prevent Machine Runaway
3.41 Park Machine Safely
3.42 Transport Tractor Safely
3.43 Service Cooling System Safely
3.44 Service Accumulator Systems Safely
3.45 Service Tires Safely
3.46 Service Front-Wheel Drive Tractor Safely
3.47 Tightening Wheel Retaining Bolts/Nuts
3.48 Avoid High-Pressure Fluids
3.49 Do Not Open High-Pressure Fuel System
3.50 Store Attachments Safely
3.51 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Transport, ROPS, and Seat Belt
4.3 Instructional Seat (If Equipped)
4.4 Track Accumulators
4.5 Trash Build-Up
4.6 Engine Block Heater (If Equipped)
4.7 Quick-Hitch (If Equipped)
4.8 Rear PTO Shield (If Equipped)
4.9 Rear PTO Shield (If Equipped)
5 Vehicle Overview
5.1 8RX Series Tractor
6 Engine Operation
6.1 Engine Settings?Access
6.2 Engine Settings
6.3 Engine Settings?Engine Power
6.4 Engine Settings?Engine Set Speed
6.5 Engine Settings?Max Engine Speed
6.6 Engine Settings?Exhaust Filter System Overview
6.7 Engine Settings?AUTO Exhaust Filter Cleaning
6.8 Engine Settings?Disable AUTO Exhaust Filter Cleaning
6.9 Engine Settings?Parked Filter Cleaning
6.10 Required Machine Stop Warning
6.11 Engine Fuel System and Power Rating
6.12 Battery Disconnect Switch
6.13 Start the Engine
6.14 Run the Engine
6.15 Stop the Engine
6.16 Restart Engine That Has Run Out of Fuel
6.17 Reduce Fuel Consumption
6.18 Battery Booster or Charger
7 Cold Weather Operation
7.1 Cold Weather Starting?Without Starting Aid
7.2 Cold Weather Starting?With Starting Aid
7.3 Change Starting Fluid Canister
7.4 Auxiliary Heaters Use
8 Emissions Equipment
8.1 Aftertreatment Indicators Overview
8.2 Selective Catalytic Reduction (SCR) System Overview
8.3 Diesel Particulate Filter (DPF) Service
9 Front Console
9.1 Front Console
9.2 Adjust Steering Wheel and Column
9.3 Operate Horn
9.4 Operate Wipers and Washers
9.5 Key Switch
9.6 Operate Turn Signals
9.7 Pedals
9.8 Operate Lights
10 Corner Post Display
10.1 Corner Post Display
11 CommandARM? Controls
11.1 CommandARM?
11.2 CommandARM? Hitch Controls
11.3 CommandARM? SCV Control Levers
11.4 CommandARM? PTO Control Levers
11.5 CommandARM? Climate, Radio, and Lighting Controls
11.6 Push-To-Talk (PTT)
11.7 CommandARM? Controls?Left Side
11.8 CommandARM? Joystick
11.9 CommandARM? Navigation Bar
11.10 Adjust CommandARM? Position
12 CommandCenter?
12.1 Generation 4 Display
12.2 Machine Settings Overview
12.3 Automation Status Overview
12.4 Navigate Generation 4 CommandCenter?
12.5 Compatible Displays
12.6 Power Display On and Off
12.7 Change Pages and Values
12.8 Factory and Service ADVISOR? Installed Onscreen Help
12.9 Radar Calibration
12.10 Slip Calibration
12.11 Controls Setup
12.12 Automation Status
12.13 Install Video Display Camera
13 CommandCenter? Audio and Phone
13.1 External Sources
13.2 Select Audio Source with Generation 4 CommandCenter?
13.3 AM, FM, Weather Channel Home Page
13.4 USB Home Page
13.5 Bluetooth? Home Page
13.6 Auxiliary Home Page
13.7 Pair Bluetooth? Device to Generation 4 CommandCenter?
13.8 Manage Paired Bluetooth? Devices
13.9 Phone Operation
13.10 Contact List
13.11 Recent Calls
13.12 Clear Favorites and Call History
14 Intelligent Total Equipment Control (iTEC?)
14.1 CommandARM? Control Functions
14.2 CommandCenter? Pages Descriptions and Functions
14.3 Status Area
14.4 All Sequence Page
14.5 Add New Sequence
14.6 Sequence Step Status
14.7 Edit or Remove Sequence
14.8 Sequence Sets Page
14.9 Perform Sequence
14.10 Recommendations (AutoLearn)
14.11 iTEC Functions?IVT?/AutoPowr? Transmission
14.12 iTEC? Functions?Efficiency Manager?
15 Tractor-Implement Automation (TIA)
15.1 Tractor-Implement Automation (TIA)
15.2 Activate Tractor-Implement Automation (TIA) Equipment
15.3 Tractor-Implement Automation (TIA) ? Status Page
15.4 Operate Tractor-Implement Automation (TIA)
15.5 PTO Requirements
15.6 SCV Requirements
15.7 IVT?/AutoPowr? Requirements
15.8 IVT?/AutoPowr? with CommandPRO? Joystick Requirements
15.9 PowerShift? Transmission Requirements
15.10 AutoTrac? Guidance Requirements
15.11 Rear Hitch Requirements
15.12 Drive Strategy Requirements
16 Drivetrain
16.1 Drivetrain Overview
16.2 Differential Lock
16.3 Mechanical Front-Wheel Drive (MFWD)
17 Brakes
17.1 Trailer Brake System Settings?Access
17.2 Trailer Brake System Settings
17.3 Trailer Brake System Settings?Brake Gain
17.4 Trailer Brake System Settings?Pre-Brake Offset
17.5 Trailer Brake System Settings?Trailer Brake Test
17.6 Trailer Brake System Settings?Advanced
17.7 Brake Use
17.8 AutoClutch
17.9 Hydraulic Trailer Brakes (If Equipped)
17.10 Air Trailer Brakes (If Equipped)
18 Transmission – General Information
18.1 Transmission Settings?Access Advanced
18.2 Transmission Settings?Advanced
18.3 Warm-Up Transmission-Hydraulic System
18.4 Backup Alarm
19 e23? Transmission
19.1 Operate Transmission?e23?
19.2 Shift Transmission?e23?
19.3 e23? Set Speeds and Efficiency Manager?
19.4 e23? Transmission Settings?Access
19.5 e23? Transmission Settings
19.6 e23? Transmission Settings?Mode
19.7 e23? Transmission Settings?Custom
19.8 e23? Transmission Settings?Droop
19.9 e23? Transmission Settings?ECO
19.10 e23? Transmission Settings?Max Speeds
20 IVT?-AutoPowr? Transmission
20.1 Operate Transmission?IVT?
20.2 Shift Transmission?IVT?
20.3 IVT? Set Speeds
20.4 IVT? Transmission Settings?Access
20.5 IVT? Transmission Settings
20.6 IVT? Transmission Settings?Mode
20.7 IVT? Transmission Settings?Pedal Mode
20.8 IVT? Transmission Settings?Custom
20.9 IVT? Transmission Settings?Droop
20.10 IVT? Transmission Settings?ECO
20.11 IVT? Transmission Settings?Max Speeds
21 IVT?/AutoPowr? Transmission with CommandPRO? Joystick
21.1 Operate Transmission?IVT? with CommandPRO? Joystick
21.2 Shift Transmission?IVT? with CommandPRO? Joystick
21.3 CommandPRO? Joystick
21.4 CommandPRO? Joystick?Acceleration/Deceleration Response
21.5 CommandPRO? Joystick?Enable Set Speeds
21.6 CommandPRO? Joystick?Adjust Travel Direction
21.7 CommandPRO? Joystick?Stopping
21.8 CommandPRO? Joystick?Operating on Hillsides
21.9 CommandPRO? Transmission Settings?Access
21.10 CommandPRO? Transmission Settings
21.11 CommandPRO? Transmission Settings?Mode
21.12 CommandPRO? Transmission Settings?Custom
21.13 CommandPRO? Transmission Settings?Droop
21.14 CommandPRO? Transmission Settings?Minimum Engine Speed
21.15 CommandPRO? Transmission Settings?Set Speeds
21.16 CommandPRO? Transmission Settings?Shuttle Shift Speeds
21.17 CommandPRO? Transmission Settings?Speed Limits
22 PTO, Hitch, and Drawbar
22.1 Attach PTO-Driven Implement
22.2 Hitch, SCV, and PTO External Switches
23 PTO – General Information
23.1 PTO Settings?Access
23.2 PTO Settings
23.3 PTO Settings?Advanced
23.4 PTO Settings?Engagement Rate
23.5 PTO Settings?Rear PTO Cruise
23.6 PTO Settings?Auto Disengage
23.7 Operate PTOs
23.8 External PTO Switches
23.9 Select Correct Engine Speed
24 Rear PTO
24.1 Rear PTO Shield
24.2 Select Correct PTO Shaft
24.3 Change 540/1000 RPM PTO Stub Shafts
24.4 Change 1000/1000E RPM PTO Stub Shafts
25 Rear Hitch
25.1 Hitch Lift Capacities
25.2 Rear Hitch Settings?Access
25.3 Rear Hitch Settings
25.4 Rear Hitch Settings?Upper Limit
25.5 Rear Hitch Settings?Drop Rate
25.6 Rear Hitch Settings?Raise Rate
25.7 Rear Hitch Settings?Load Depth
25.8 Rear Hitch Settings?Slip Sensitivity
25.9 Rear Hitch Settings?Position
25.10 Rear Hitch Settings?Advanced
25.11 Rear Hitch Settings?Position Control
25.12 Rear Hitch Settings?Draft Control
25.13 Hitch Control Lever Adjustments
25.14 Hitch Depth Set Point
25.15 Float Operation
25.16 Rear Hitch Components
25.17 Remote Rear Hitch Switches
25.18 Draft Link Storage Position
25.19 Hitch Manual Lowering
25.20 Correct Center Link Position
25.21 Hydraulic Center Link (If Equipped)
25.22 Adjust Sway Blocks
25.23 Attach Implement to Quick-Hitch
25.24 Adjust Implement Level
25.25 Adjust Lateral Float
25.26 Detach Implement from Quick-Hitch
25.27 Converting Category 4N/3 Convertible Quick-Hitch Lower Hooks
25.28 Converting Category 4N-3 Convertible Quick-Hitch Upper Hooks
25.29 3-in-1 Hitch System
25.30 Operating Wagon Hitch
26 Drawbar
26.1 Drawbar Load Limitations
26.2 Scraper Applications
26.3 Calculate Static Vertical Drawbar Load
26.4 Calculate Vertical Drawbar Load Distance Behind Rear Axle
26.5 Adjust Drawbar Length, Height, and Side-to-Side
27 Hydraulics – General Information
27.1 Hydraulic System Overview
28 Selective Control Valves
28.1 SCV Settings?Access
28.2 SCV Settings
28.3 SCV Settings?Standard Mode
28.4 SCV Settings?Independent Mode
28.5 SCV Settings?Feature Mode
28.6 SCV Settings?Flow Adjustment
28.7 SCV Settings?Time Adjustment
28.8 SCV Settings?Advanced
28.9 SCV Settings?Activating Independent Mode
28.10 SCV Settings?Automation
28.11 SCV Settings?Assignment
28.12 SCV Settings?Flow Adjustment Sensitivity
28.13 SCV Control Lever Adjustments
28.14 Total SCV Flow
28.15 Operate SCVs with CommandARM? Joystick
28.16 CommandARM? Joystick?Layout and Joystick Lever Functions
29 Hydraulic Connections
29.1 Connect/Disconnect Hydraulic Hoses
29.2 Component Identification and Location
29.3 Using Load-Sensing Hydraulic System?Power-Beyond
29.4 Examples Using Load-Sensing Hydraulic System?Power-Beyond
29.5 Using Hydraulic Spray Pumps
29.6 Implement Connection Example 1?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)
29.7 Implement Connection Example 2?Motor Application Using Motor Case Drain
29.8 Implement Connection Example 3?Motor Application Using SCV Retract and Auxiliary Motor Return
29.9 Implement Connection Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip
29.10 Implement Connection Example 5?Planter with Vacuum Motor, Return Line to Motor Return and Lift Assist
29.11 Implement Connection Example 6?Planter with Vacuum Motor and Return Line to Motor Return
29.12 Using Hydraulic Motor Return
29.13 Using Hydraulic Motor Case Drain
29.14 Using Implements Requiring Large Volumes of Oil
30 TouchSet? Depth Control
30.1 TouchSet? Depth Control Settings and Adjustments
30.2 Connect/Disconnect the Implement Position Connector
31 Laser Scraper Control
31.1 Laser Scraper?Scrapers Equipped with Scraper Control Unit
32 Tracks – General Information
32.1 General Track Use Guidelines
32.2 Tracks Service
32.3 Toe-In Check
32.4 Toe-In Adjustment – 1700 MFWD
33 Steering Stop, Fender, and Tread Settings
33.1 Steering Stop, Fender, and Tread Settings
34 Seats
34.1 Adjust Air Seat
34.2 Operator Presence Sensor
34.3 Adjust Instructional Seat
35 Mirrors
35.1 Adjust Mirrors
36 Steps
36.1 Left-Hand Steps
36.2 Right-Hand Service Steps
37 Lights
37.1 Light Identification
37.2 Lights Settings?Access
37.3 Lights Settings
37.4 Lights Settings?Field Lights Presets
37.5 Lights Settings?Hood/Belt Line Lights
37.6 Lights Settings?Advanced
37.7 Hazard and Extremity Lights
37.8 Beacon Light
37.9 7-Pin Outlet
38 Accessories
38.1 Right-Hand Side Console
38.2 CommandARM? Storage
38.3 Right-Hand Front Corner Post
38.4 Left-Hand Rear Corner Post
38.5 Right-Hand Rear Corner Post
38.6 Refrigerator and Cool/Storage Box
38.7 Sunshade
38.8 Storage Compartments
38.9 Monitor Bracket Mounts
38.10 Emergency Exit
38.11 Install Business Band/Citizens Band (CB) Antenna and/or Radio
38.12 Mount StarFire? Receiver
38.13 Mount RTK (Real-Time Kinematic) Radio
38.14 Implement Connector
38.15 RS232 Serial Communication Connection
39 HVAC
39.1 HVAC Settings?Access
39.2 HVAC Settings
39.3 HVAC Settings?Climate Control Automation
39.4 HVAC Settings?Set Temperature
39.5 HVAC Settings?Air Flow Mode
39.6 HVAC Settings?Fan Speed
39.7 HVAC Settings?Air Conditioning
40 Performance Ballasting
40.1 How to Calculate Maximum Permissible Download on Trailer Hitch
40.2 Mechanical Towed Coupling Load Limitations
40.3 General Ballasting Information
40.4 General Guidelines
40.5 General Weight Split Guidelines
40.6 Ballast Options
40.7 Measure Slip
40.8 Quik-Tatch? Weight Use
40.9 Mounted Commodity Tank Use
40.10 Calculate Tractor Ballast Package
40.11 Unballasted Tractor Weight Chart
40.12 Implement and Tractor Codes
41 Transport
41.1 Weight Chart
41.2 Drive Tractor on Roads
41.3 Road Transport
41.4 Transport with Ballast
41.5 Tow Loads
41.6 Tow Points
41.7 Tow Tractor
41.8 Tow Mode
41.9 Come Home Mode
41.10 Transporting on Flat-Bed Carrier
41.11 Tie-Down on Transport Carrier
41.12 Load Extended Axle Width Track Tractor
41.13 Freeing a Mired Tractor
42 Fuel, Lubricants, and Coolant – General Information
42.1 Determine Tractor Engine Type
42.2 Minimizing the Effect of Cold Weather on Diesel Engines
42.3 Oil Filters
43 Fuel
43.1 Diesel Fuel
43.2 Supplemental Diesel Fuel Additives
43.3 Biodiesel Fuel
43.4 Lubricity of Diesel Fuel
43.5 Handling and Storing Diesel Fuel
43.6 Fill Fuel Tank
43.7 Testing Diesel Fuel
43.8 Fuel Filters
44 Diesel Exhaust Fluid (DEF)
44.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
44.2 Storing Diesel Exhaust Fluid (DEF)
44.3 Refilling Diesel Exhaust Fluid (DEF) Tank
44.4 Fill DEF Tank – FT4/Stage V Engine
44.5 Testing Diesel Exhaust Fluid (DEF)
44.6 Disposal of Diesel Exhaust Fluid (DEF)
45 Engine Oil
45.1 Diesel Engine Oil Service Interval for Operation at High Altitude
45.2 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
45.3 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V
45.4 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
46 Engine Coolant
46.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
46.2 John Deere COOL-GARD? II Coolant Extender
46.3 Operating in Warm Temperature Climates
46.4 Water Quality for Mixing with Coolant Concentrate
46.5 Testing Coolant Freeze Point
46.6 Disposing of Coolant
47 Other Lubricants
47.1 Gear Oil
47.2 Multipurpose Extreme Pressure (EP) Grease
47.3 MFWD Axle Housing Oil
47.4 Corn Head Grease
47.5 Lubricant Storage
47.6 Alternative and Synthetic Lubricants
47.7 Mixing of Lubricants
47.8 Transmission and Hydraulic Oil
47.9 PowerShift? Transmission Recalibration
48 Service – General Information
48.1 Do Not Modify Fuel System
48.2 Bleed Fuel System
48.3 Service Sections Overview
48.4 Service Tasks Performed As Required
48.5 Identify Tractor Engine Emissions Status
48.6 Open Hood
48.7 Remove Side Panels
48.8 Access Battery Compartment
48.9 Remove Cab Rear Panel
48.10 Jack Up Tractor – Lifting Points and Support Stand Placement
48.11 Service and Connect STC? (Snap-to-Connect) Fittings
48.12 High-Pressure Washer Use
48.13 Identify Zinc-Flake Coated Fasteners
48.14 Unified Inch Bolt and Screw Torque Values
48.15 Metric Bolt and Screw Torque Values
49 Service – Break-In (100 Hours or Less)
49.1 Perform Break-In Checks
49.2 Perform Track Systems Break-In
50 Service – Record Charts
50.1 Service Record Chart Overview
50.2 Service Interval Chart
50.3 Service Record Chart
51 Service – Clean
51.1 Access DEF Tank Drain Plug
51.2 Cleaning Diesel Exhaust Fluid (DEF) Tank
51.3 Tractor Exterior
51.4 Air Intake Valve
51.5 Clean Display
51.6 Clean Seat
51.7 Engine Cooling System
51.8 Dual Beam Radar Sensor
51.9 MFWD Axle Breather Filter
51.10 Hydraulic Oil Suction Screen
52 Service – Check
52.1 Windshield Washer Fluid Level
52.2 Engine Coolant Level
52.3 Coolant Freeze Point
52.4 Water Separator
52.5 Optional Fuel Water Separator (If Equipped)
52.6 Engine and Exhaust Compartments
52.7 Air Conditioning System
52.8 Engine Water Pump Weep Hole – Final Tier 4/Stage V Engine
52.9 Fuel Tank Sump
52.10 MFWD Axle Housing Oil Level
52.11 MFWD Wheel Hub Oil Level
52.12 Engine Oil Level
52.13 Transmission-Hydraulic Oil Level
52.14 Track Alignment
52.15 Track Tension
52.16 Track Wear
52.17 Track Trash Buildup
52.18 Undercarriage Articulation Bumper Stops
52.19 Mid-Roller and Idler Wheels
52.20 Drive Sprocket Wheels
52.21 Mid-Rollers Oil Level
52.22 Idler Wheel Hub Oil Level
52.23 Drive Sprocket Wheel Scraper Clearance
52.24 Track Upper Rollers Oil Level
52.25 Track Upper Roller Scraper Clearance
52.26 Mechanical Cab Suspension Components
52.27 Engine Air Intake System?Final Tier 4/Stage V Engine
52.28 Seat Belts
52.29 Auxiliary Drive Belt and Drive Belt Tensioner
52.30 Engine Valve Clearance
52.31 NEUTRAL Start System
52.32 Transmission PARK System
53 Service – Tighten
53.1 Mid-Roller, Drive Sprocket Wheel, and Idler Wheel Fasteners
54 Service – Change
54.1 Engine Oil and Filter
54.2 Fuel Filters
54.3 Optional Fuel Water Separator Filter Element (If Equipped)
54.4 Cab Recirculation Air Filter
54.5 Cab Fresh Air Filter
54.6 Engine Primary and Secondary Air Filters
54.7 Fuel Tank Vent Filter
54.8 SCV Pilot Valve Filter
54.9 Auxiliary Drive Belt
54.10 Chain Drive Oil
54.11 Differential Oil
54.12 IVT?/AutoPowr? and e23?Transmissions-Hydraulic Oil
54.13 Transmission-Hydraulic Oil Filter
54.14 MFWD Wheel Hub Oil
54.15 MFWD Axle Housing Oil
54.16 Air Trailer Brake Air Dryer Filter
54.17 DEF Tank Vent Filter
54.18 Access In-Line DEF Filter
54.19 Change Diesel Exhaust Fluid (DEF) In-Line Filter
54.20 Access DEF Dosing Unit Filter
54.21 Change Diesel Exhaust Fluid (DEF) Dosing Unit Filter
54.22 Transmission Torsional Damper
54.23 Engine Crankshaft Damper
54.24 Engine Coolant
54.25 Remove and Install Track
55 Service – Lubricate
55.1 MFWD U-Joints
55.2 Rear Hitch
55.3 Deluxe Stabilizers
55.4 MFWD Axle King Pins, Tie Rod Ends, Axle Pivot Fittings, and Steering Cylinders (1700 MFWD Axle)
55.5 Draft Link Support Shaft Bushing
56 Service – Electrical
56.1 Service – Electrical Overview
56.2 Welding Near Electronic Control Units
56.3 Keep Electronic Control Unit Connectors Clean
56.4 Compressed Air Use
56.5 High-Pressure Washers Use
56.6 Disconnect Battery
56.7 Service Batteries and Connectors
56.8 Access Load Center Fuses
56.9 Access Front Load Center
56.10 Access Master Fuses
56.11 Access Implement Power Relay Module Fuses
56.12 Handle Halogen Light Bulbs Safely
56.13 Change Halogen Bulbs
56.14 Change Front LED Headlight Assembly
56.15 Aim Halogen Headlights
56.16 Aim Halogen Headlights
56.17 Aim LED Headlights
56.18 Aim Headlights
56.19 Change Auxiliary Driving Light
56.20 Change Wrap-Around Cab Light
56.21 Change Cab Roof Light
56.22 Change Rear Fender?Rear Indicator
56.23 Change Cab Dome Light
57 Troubleshooting – Procedures
57.1 Perform Troubleshooting Process
57.2 Engine
57.3 Transmission
57.4 Hydraulic System
57.5 Hitch
57.6 Selective Control Valve (SCV)
57.7 TouchSet Depth Control
57.8 Electrical System
57.9 Operator Enclosure
57.10 Steering System
58 Troubleshooting – Diagnostic Trouble Codes (DTC)
58.1 STOP, Service, and Information Alerts on CommandCenter?
58.2 Access Diagnostic Trouble Codes
59 Service – Storage
59.1 Place Tractor in Storage
59.2 Remove Tractor from Storage
60 Specifications
60.1 Engine
60.2 Capacities
60.3 Hydraulic System
60.4 Transmission and Power Train
60.5 Hitch, Drawbar, and PTO
60.6 Electrical System
60.7 Integrated Technology
60.8 Overall Dimensions
60.9 Ground Speeds?e23? Transmission
60.10 Ground Speeds?IVT?/AutoPowr? Transmission
60.11 Limited Battery Warranty
60.12 Emissions Control System Certification Label
60.13 EPA Non-road Emissions Control Warranty Statement?Compression Ignition
60.14 CARB Non-road Emissions Control Warranty Statement?Compression Ignition
60.15 Required Emission-Related Information
60.16 Carbon Dioxide Emissions (CO?)
61 Identification Numbers
61.1 Identification Plates
61.2 Product Identification Number (PIN)
61.3 Engine Serial Number
61.4 Cab Serial Number
61.5 Transmission Serial Number
61.6 Axle Serial Number
61.7 Keep Proof of Ownership
61.8 Keep Machines Secure
62 Change of Ownership
62.1 Subsequent Ownership
63 Predelivery
63.1 Predelivery Checklist
63.2 Delivery Checklist and Certificate
64 Index
65 John Deere Service Literature Available
65.1 Technical Information
66 John Deere Service Keeps You On The Job
66.1 John Deere Is At Your Service