John Deere 8r Tractors Operator Manuals OMRE591486

Table of Content:

1 Introduction
1.1 Foreword
1.2 Look For Supplemental Information
1.3 Trademarks
1.4 Traction Class
2 Glossary
2.1 Glossary of Terms
3 Safety
3.1 Recognize Safety Information
3.2 Understand Signal Words
3.3 Follow Safety Instructions
3.4 Prepare for Emergencies
3.5 Wear Protective Clothing
3.6 Protect Against Noise
3.7 Handle Fuel Safely?Avoid Fires
3.8 Handle Starting Fluid Safely
3.9 Fire Prevention
3.10 In Case of Fire
3.11 Avoid Static Electricity Risk When Refueling
3.12 Keep ROPS Installed Properly
3.13 Use Foldable ROPS and Seat Belt Properly
3.14 Stay Clear of Rotating Drivelines
3.15 Use Steps and Handholds Correctly
3.16 Read Operator?s Manuals for ISOBUS Controllers
3.17 Use Seat Belt Properly
3.18 Operating the Tractor Safely
3.19 Avoid Backover Accidents
3.20 Limited Use in Forestry Operation
3.21 Operating the Loader Tractor Safely
3.22 Keep Riders Off Machine
3.23 Instructional Seat
3.24 Use Safety Lights and Devices
3.25 Transport Towed Equipment at Safe Speeds
3.26 Use Caution on Slopes, Uneven Terrain, and Rough Ground
3.27 Freeing a Mired Machine
3.28 Avoid Contact with Agricultural Chemicals
3.29 Handle Agricultural Chemicals Safely
3.30 Handling Batteries Safely
3.31 Avoid Heating Near Pressurized Fluid Lines
3.32 Remove Paint Before Welding or Heating
3.33 Handle Electronic Components and Brackets Safely
3.34 Practice Safe Maintenance
3.35 Avoid Hot Exhaust
3.36 Clean Exhaust Filter Safely
3.37 Work In Ventilated Area
3.38 Support Machine Properly
3.39 Prevent Machine Runaway
3.40 Park Machine Safely
3.41 Transport Tractor Safely
3.42 Service Cooling System Safely
3.43 Service Accumulator Systems Safely
3.44 Service Tires Safely
3.45 Service Front-Wheel Drive Tractor Safely
3.46 Tightening Wheel Retaining Bolts/Nuts
3.47 Avoid High-Pressure Fluids
3.48 Do Not Open High-Pressure Fuel System
3.49 Store Attachments Safely
3.50 Decommissioning ? Proper Recycling and Disposal of Fluids and Components
4 Safety Signs
4.1 Operator’s Manual
4.2 Seat Belt
4.3 Cab Suspension (If Equipped)
4.4 Front Hitch (If Equipped for China Only)
4.5 Pick-Up Hitch (If Equipped)
4.6 ILS? (If Equipped)
4.7 Brake Accumulator (If Equipped)
4.8 Front PTO (If Equipped for China Only)
4.9 Rear Hitch (If Equipped for China Only) and PTO (If Equipped for China Only)
4.10 Engine Cooling System (For China Only)
5 Vehicle Overview
5.1 8R Series Tractor
6 Operator?s Manual Use
6.1 Operator?s Manual Use
7 General Vehicle Description
7.1 8R Series Tractor
8 Engine Operation
8.1 Required Machine Stop Warning
8.2 Engine Fuel System and Power Rating
8.3 Battery Disconnect Switch (If Equipped)
8.4 Start the Engine
8.5 Theft Deterrent Systems
8.6 Run the Engine
8.7 Stop the Engine
8.8 Restart Engine That Has Run Out of Fuel
8.9 Reduce Fuel Consumption
8.10 Use Battery Booster or Charger
9 Cold Weather Operation
9.1 Cold Weather Starting?Without Starting Aid
9.2 Cold Weather Starting?With Starting Aid
9.3 Change Starting Fluid Canister
9.4 Auxiliary Heaters Use
10 Emissions Equipment
10.1 Exhaust Filter System Overview?Final Tier 4/Stage IV Engine
10.2 Aftertreatment Indicators Overview
10.3 Selective Catalytic Reduction (SCR) System Overview
10.4 Qualified Emergency Use ? SCR Override Option
10.5 Auto Exhaust Filter Cleaning Mode?Final Tier 4/Stage IV Engine
10.6 Parked Exhaust Filter Cleaning?Final Tier 4/Stage IV Engine
10.7 Selective Catalytic Reduction (SCR) System?Final Tier 4/Stage IV Engine
10.8 Low Fuel or Low DEF Warning
10.9 Disconnect Battery?Final Tier 4/Stage IV Engine
11 Controls and Instruments
11.1 Front Console
11.2 CommandARM? ISOBUS Shortcut Button (ISB)
11.3 Foot Throttle
12 Corner Post Display
12.1 Corner Post Display
12.2 Information Indicators
12.3 Digital Indicators?Tachometer, Ground Speed, Transmission, and Set Speed
12.4 Gauges?Coolant Temperature, DEF Level and Fuel Level
13 CommandARM? Controls
13.1 CommandARM? with Generation 4 CommandCenter? Display
13.2 CommandARM? Secondary Brake Lever
13.3 Rear and Front Hitch Controls
13.4 SCV Control Levers
13.5 CommandARM? Climate, Radio and Lighting Controls
13.6 CommandARM? PTO Control Levers
13.7 Left-Hand Side Controls
14 CommandCenter?
14.1 Onscreen Help
14.2 Generation 4 CommandCenter?
14.3 Generation 4 CommandCenter? Processor
14.4 Generation 4 CommandCenter? 4600 Processor Wi-Fi? Capabilities
14.5 Run Page Structure
14.6 Menu
14.7 Machine Settings Overview
14.8 Operating System Applications Overview
14.9 AMS Applications Overview
14.10 CommandCenter? Activations
14.11 Demo Activations
14.12 Automation Status Overview
14.13 Navigate Generation 4 CommandCenter?
14.14 Power Display On and Off
14.15 Navigate Run Pages on Main Page
14.16 Shortcut Buttons
14.17 Navigate to Display & Sound
14.18 Display and Sound
14.19 Brightness
14.20 Sound
14.21 Multiple Displays
14.22 Display Calibration
14.23 Navigate to Date & Time
14.24 Date and Time
14.25 Change Current Date
14.26 Change Current Time
14.27 Navigate to Language & Units
14.28 Language and Units
14.29 Language and Units Settings
14.30 Change Pages and Values
14.31 Status Center
14.32 Shortcut Softkeys
14.33 Navigate to Software Manager
14.34 Software Manager
14.35 Factory and Service ADVISOR? Installed Onscreen Help
14.36 Update Display Software
14.37 Activations
14.38 Service ADVISOR? Remote
14.39 Vehicle Reprogramming
14.40 Troubleshooting ? Reprogramming
14.41 System Recovery
14.42 Remote Display Access
14.43 Navigate to File Manager
14.44 File Manager
14.45 USB Drive
14.46 Capture Screen Shots
14.47 Navigate to Diagnostics Center
14.48 Diagnostics Center
14.49 Controller Diagnostics
14.50 Diagnostic Information
14.51 Hide Diagnostic Center
14.52 Diagnostic Trouble Codes
14.53 Display Hardware
14.54 CAN Bus Information
14.55 CAN Bus Values
14.56 Network
14.57 DataSync
14.58 Navigate to Users & Access
14.59 Users and Access
14.60 User Profiles
14.61 Access Groups
14.62 Navigate to Layout Manager
14.63 Layout Manager
14.64 Active Set
14.65 Shortcut Bar
14.66 All Run Pages
14.67 Add, Edit, or Duplicate Run Pages
14.68 Navigate to Fields
14.69 Fields and Boundaries
14.70 Field Boundaries
14.71 Manage Clients, Farms, and Fields
14.72 AutoTrac? Guidance
14.73 Navigate to Equipment Manager
14.74 Equipment Manager
14.75 Machine Profile
14.76 Implement Profile
14.77 Navigate to Machine Monitor
14.78 Machine Monitor
14.79 Navigate to Work Monitor
14.80 Work Monitor
14.81 Work Recording
14.82 Navigate to Maintenance & Calibrations
14.83 Maintenance and Calibrations
14.84 Calibrations
14.85 Radar Calibration
14.86 Wheel Slip Calibration
14.87 Service Intervals
14.88 Service Checks
14.89 Steering
14.90 Steering Settings
14.91 Controls Setup
14.92 Settings Manager
14.93 Automation Status
14.94 Read ISOBUS Controller?s Operator?s Manual
14.95 ISOBUS VT
14.96 StarFire? GPS Receiver
14.97 Use Video Display Capability Properly
14.98 Install Video Display Camera
14.99 Navigate to Video Application
14.100 Video
14.101 Video Triggers
15 Radio Operation
15.1 Radio Faceplate Features
15.2 Declaration of Conformity
15.3 Select Radio Receiver Wave Band
15.4 Mexico Bluetooth? Information
15.5 Russia Bluetooth? Certification
15.6 Set Clock
15.7 Reset Clock
15.8 Turn Confirmation Beep On/Off (BEEP)
15.9 Adjust Maximum Volume at Power-On (ONVOL)
15.10 Program Type (PTY)
15.11 Treble Reduction During Interference (HCUT)
15.12 Set Key Function (KEY PRG)
15.13 Traffic Information
15.14 External Sources (Premium Radio)
15.15 Select Radio Source with Generation 4 CommandCenter?
15.16 AM/FM Home Page
15.17 Premium Radio CD Home Page
15.18 Premium Radio USB Home Page
15.19 Premium Radio Bluetooth? Home Page
15.20 Auxiliary Home Page
15.21 Pair Bluetooth? Device to Generation 4 CommandCenter?
15.22 Manage Paired Bluetooth? Devices
15.23 Phone Operation
15.24 Phone Signal Strength and Battery Charge
15.25 Contact List
15.26 Recent Calls
15.27 Clear Favorites and Call History
16 AMS? Technology
16.1 Machine Sync
16.2 Mount StarFire? Receiver
16.3 Install GreenStar? System Components
16.4 Install Machine Communications Radio (MCR) Antenna
16.5 Connect AutoTrac? Assisted Steering System
17 Intelligent Total Equipment Control (iTEC?)
17.1 CommandARM? Control Functions
17.2 iTEC? Station Description
17.3 CommandCenter? Pages Descriptions and Functions
17.4 Status Area
17.5 All Sequence Page
17.6 Add New Sequence
17.7 Sequence Step Status
17.8 Edit or Remove Sequence
17.9 Sequence Sets Page
17.10 Perform Sequence
17.11 Recommendations (AutoLearn)
17.12 iTEC Functions?IVT?/AutoPowr? Transmission
17.13 iTEC? Functions?Efficiency Manager? Powershift Transmission
18 Tractor-Implement Automation? (TIA?)
18.1 Tractor-Implement Automation? (TIA?)
18.2 Activate Tractor-Implement Automation? Equipment
18.3 Tractor-Implement Automation? ? Status Page
18.4 Operate Tractor-Implement Automation?
18.5 PTO Requirements
18.6 SCV Requirements
18.7 IVT?/AutoPowr? Requirements
18.8 Powershift Transmission Requirements
18.9 AutoTrac? Guidance Requirements
18.10 Rear Hitch Requirements
18.11 Drive Strategy Requirements
19 Drivetrain
19.1 Drivetrain Overview
19.2 Operate ILS? and Cab Suspension (If Equipped)
20 Mechanical Front-Wheel Drive (MFWD)
20.1 Mechanical Front-Wheel Drive (MFWD)
20.2 Change Mechanical Front-Wheel Drive (MFWD) Disengagement Steering Angle
21 Differential Lock
21.1 Differential Lock
21.2 Change Differential Lock Disengagement Steering Angle
22 Brakes
22.1 Brake Use
22.2 Use Secondary Brake Lever (If Equipped)
22.3 Brake Warning Indicators
22.4 Hydraulic Trailer Brakes (If Equipped)
22.5 Air Trailer Brakes (If Equipped)
22.6 Trailer Brake Settings
22.7 Use AutoClutch (If Equipped)
23 Transmission – General Information
23.1 Transmission Top Speed Note
23.2 Warm-Up Transmission-Hydraulic System
23.3 Foot Pedal Mode (If Equipped)
23.4 Activate and Set Maximum Set Speed
23.5 Use Maximum Set Speed with Different Transmission Modes
23.6 Intelligent Power Management
23.7 Backup Alarm
23.8 Come Home Mode
24 16 Speed Powershift Transmission
24.1 Operate 16-Speed Powershift Transmission
24.2 Shift Transmission
24.3 Set Startup Gear and RPM Droop
24.4 Operate Automatic Powershift (APS)
25 e23? Transmission
25.1 Operate e23? Transmission with Right-Hand Reverser
25.2 Shift e23? Transmission with Right-Hand Reverser
25.3 Operate e23? Transmission with Left-Hand Reverser
25.4 Shift e23? Transmission with Left-Hand Reverser
25.5 Set Startup Gears
25.6 Stop and Park Tractor
25.7 CommandCenter? Transmission Main Page
25.8 Efficiency Manager? on the e23? Transmission
25.9 Efficiency Manager? on e23? Transmission in Manual Mode
25.10 e23? Custom Mode Settings
26 IVT?-AutoPowr? Transmission
26.1 Controls Identification
26.2 Left-hand and Right-hand Reverser Shift Patterns
26.3 Operate the Transmission
26.4 Adjust Set Speeds
26.5 Set Speeds?Guidelines and Examples
26.6 IVT?/AutoPowr? Modes and Set Maximum Speed
26.7 IVT?/AutoPowr? Custom Mode Settings
26.8 Adjust Reverse/Forward Set Speed Ratio
26.9 Put Tractor in Motion
26.10 Use Creeper Mode
26.11 Stop and Park Tractor
26.12 Downhill Operation in Slippery Conditions
27 PTO, Hitch, and Drawbar
27.1 Attach PTO-Driven Implement
27.2 Hitch, SCV and PTO External Switches
28 PTO – General Information
28.1 Stay Clear of Rotating Drivelines
28.2 Operating Instructions
28.3 Select PTO Cruise Speed
28.4 Fine Adjust PTO Cruise Speeds
29 Front PTO
29.1 Operate Front PTO
29.2 Remote Front PTO Switch
29.3 Change Optional PTO Shafts-Front
29.4 PTO Engagement Rate
30 Rear PTO
30.1 PTO Shield Use
30.2 Use Correct Engine Speed
30.3 Operate Rear PTO
30.4 Remote Rear PTO Switch
30.5 Use Correct PTO Shaft
30.6 Change 540/1000 RPM PTO Stub Shafts
30.7 Change 1000/1000E RPM PTO Stub Shafts
31 Front Hitch
31.1 Front Hitch Use
31.2 Front Hitch Single Acting Mode And Position & Set Points
31.3 Front Hitch Upper And Lower Locking Plates
31.4 Front Hitch?Stow or Extend Hitch Arms
31.5 Adjust Front Hitch Drop Rate
31.6 Adjust Front Hitch Raise Rate
32 Rear Hitch
32.1 Hitch Capacities
32.2 Rear Hitch
32.3 Hitch Control Lever
32.4 Lock and Damping
32.5 Adjust Load/Depth Control (Draft Response)
32.6 Using Position Control
32.7 Using Draft Control
32.8 Adjust Upper Limit
32.9 Adjust Drop Rate
32.10 Adjust Raise Rate
32.11 Slip Sensitivity
32.12 Float Operation
32.13 Rear Hitch Components
32.14 Remote Rear Hitch Switches
32.15 Hitch Manual Lowering
32.16 Correct Center Link Position
32.17 Hydraulic Center Link (If Equipped)
32.18 Adjust Sway Blocks
32.19 Adjust Deluxe Stabilizers
32.20 Attaching Implement to Walterscheid Couplers
32.21 Detaching Implement from Walterscheid Couplers
32.22 Attach Implement to Quick Coupler
32.23 Adjust Implement Level
32.24 Adjust Lateral Float
32.25 Detach Implement from Quick Coupler
32.26 Hitch Conversion?Convertible Quick Coupler
32.27 Converting Category 4 Convertible Quick Coupler Lower Hooks
32.28 Converting Category 3/4 Convertible Quick Coupler Upper Hooks
32.29 Operating Wagon Hitch
32.30 Operate Pick-Up Hitch
32.31 Change Pick-Up Hitch Coupler
32.32 3-in-1 Hitch System
33 Drawbar
33.1 Drawbar Load Limitations
33.2 Adjust Drawbar Length, Height, and Side-to-Side
33.3 Clevis Assembly Installation and Use
34 Hydraulics – General Information
34.1 Hydraulic System Overview
35 Selective Control Valves
35.1 Connect Front SCV?S (If Equipped)
35.2 Configure SCV Modes
35.3 Configure SCV – Standard Mode
35.4 Activate Independent Mode
35.5 Configure SCV – Independent Mode
35.6 Configure SCV – Feature Mode
35.7 Total Rear SCV Flow
35.8 Six Position SCV Control Levers
35.9 SCV Control Lever?Neutral Position
35.10 SCV Control Lever?Extend and Retract Position
35.11 SCV Control Lever?Extend Detent and Retract Detent Position
35.12 SCV Control Lever?Float Position
35.13 Operator Presence Sensor
35.14 Hitch, SCV and PTO External Switches
35.15 Operate SCVs With CommandARM? Joystick (If Equipped)
35.16 CommandARM? Joystick (If Equipped) – Custom Setup
35.17 CommandARM? Joystick (If Equipped) – Layout and Joystick Lever Functions
35.18 SCV and Joystick Flow Response Setting
36 Hydraulic Connections
36.1 Connecting Hydraulic Hoses?Rear of Tractor
36.2 Disconnect Rear Hydraulic Hoses
36.3 Hydraulic Component Identification
36.4 Using Load-Sensing Hydraulic System?Power-Beyond
36.5 Examples Using Load-Sensing Hydraulic System?Power-Beyond
36.6 Using Hydraulic Spray Pumps
36.7 Implement Connection, Example 1?Pressure Control Valve Applications (Grain Drills or Air Seeders with Constant Down-Pressure System)
36.8 Implement Connection, Example 2?Motor Application Using Motor Case Drain
36.9 Implement Connection, Example 3?Motor Application Using SCV Retract and Auxiliary Motor Return
36.10 Implement Connection, Example 4?Planter with Vacuum Motor and Return Line to SCV Using Motor Return Tip
36.11 Implement Connection, Example 5?Planter with Vacuum Motor, Return Line to Motor Return and Lift Assist
36.12 Implement Connection, Example 6?Planter with Vacuum Motor and Return Line to Motor Return
36.13 Using Hydraulic Motor Return
36.14 Using Hydraulic Motor Case Drain
36.15 Using Implements Requiring Large Volumes of Oil
37 TouchSet? Depth Control
37.1 Attaching Implement and Control System
37.2 Reset Implement Connector
37.3 Set TouchSet? Depth Controls
37.4 Use TouchSet? Depth Controls
38 Laser Scraper Control
38.1 Laser Scraper?for Scrapers Equipped with Scraper Control Unit
39 Wheels and Tires – General Information
39.1 Service Tires Safely
39.2 Determine Tire Load Capacity
39.3 Change Tire Size
39.4 Select Tire Combinations
39.5 Tire Load Index
39.6 Tire Sidewall Information
39.7 Tire Inflation Pressure Guidelines
40 Front Wheels and Tires
40.1 Recommended Pressures?Group 42
40.2 Recommended Pressures?Group 43
40.3 Recommended Pressures?Group 44
40.4 Adjust and Tighten – Front Wheel Bolts
40.5 Install 425 mm Dual Extensions (8225R, 8245R, 8270R, 8295R, and 8320R only)
40.6 Install 500 mm Dual Extensions – ILS?
40.7 Toe-In Check
40.8 Toe-In Adjustment – 1300 MFWD
40.9 Toe-In Adjustment – 1500 MFWD
40.10 Toe-In Adjustment – ILS?
41 Steering Stop, Fender, and Tread Settings
41.1 Steering Stop Settings – MFWD
41.2 Steering Stop Settings – ILS?
41.3 Fender Settings – 1300 MFWD
41.4 Fender Settings – 1500 MFWD and ILS?
41.5 Determine Rim Type
41.6 Wheel Settings?8-Position
41.7 Wheel Setting?16-Position
41.8 Tire, Steering Stop, and Fender Settings Table Explanation
41.9 Tire, Steering Stop, and Fender Settings – 1300 MFWD
41.10 Tire, Steering Stop, and Fender Settings – 1500 MFWD with Single Front Tires
41.11 Tire, Steering Stop, and Fender Settings – ILS? with Single Front Tires
41.12 Determine Mean Tread Spacing
41.13 Tire, Steering Stop, and Fender Settings – 1500 MFWD and Dual Front Tires
41.14 Tire, Steering Stop, and Fender Settings – ILS?and Dual Front Tires
42 Rear Wheels and Tires
42.1 Recommended Pressures?Group 47
42.2 Recommended Pressures?Group 48
42.3 Recommended Pressures?Group 49
42.4 Use Wheel Tightening Stand
42.5 Use Wheel Torque Wrench Adapter
42.6 Rear Wheel, Tire, and Tread Guidelines
42.7 Minimum Tread Setting With Air Trailer Brakes And Inner Wheel Weights
42.8 Install Wheel to Cast Hub
42.9 Install Dual Wheel to Hub
42.10 Adjust and Tighten ? Inner Drive Wheels with Standard Hubs
42.11 Adjust and Tighten ? Dual Wheels with Standard Hubs
42.12 Adjust and Tighten ? 10-Bolt Heavy-Duty Hubs
42.13 Adjust and Tighten ? 12-Bolt Heavy-Duty Hubs
42.14 Adjust and Tighten – Wheel on Flanged Axle
42.15 Tread Settings – Single Wheel
42.16 Tread Settings – Single Wheel with Flanged Axle
42.17 Wheel Settings – 16-Position
42.18 Tread Settings – Dual Wheel
42.19 Tread Settings – Triple Wheel
42.20 Clamp-on Dual Usage
43 Operator?s Station – General Information
43.1 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (2010/52/EU)
43.2 Avoid Contact with Agricultural Chemicals
43.3 Clean Vehicle of Hazardous Pesticides
43.4 Keep Riders Off Machine
43.5 Keep Operator Station Window and Door Closed
43.6 Use Seat Belts
43.7 Use Emergency Exit
43.8 Monitor Bracket Mounts
44 Seats
44.1 Adjust ComfortCommand? Seat
44.2 Adjust Heated Leather Seat
44.3 Adjust ActiveSeat?
44.4 Adjust ComfortCommand? with HCS Plus Cab Suspension Seat
44.5 Adjust CommandARM? Position
44.6 Operator Presence Sensor
44.7 Use Instructional Seat
45 Steering Column
45.1 Adjust Steering Wheel and Column
45.2 Operate Horn
46 Mirrors
46.1 Manual Mirror
46.2 Electric Mirror
46.3 Telescoping Heated Electric Mirror
47 Steps
47.1 Position Left-hand Steps
47.2 Right-Hand Service Steps
48 Wiper Washer
48.1 Operate Front Wiper and Washer
48.2 Operate Rear Wiper and Washer
48.3 Operate Right-Hand Wiper and Washer
49 Lights
49.1 Light Identification (Version A)
49.2 Light Identification (Version B)
49.3 Configurable Lights
49.4 Steering Column Light Controls (Version A)
49.5 Steering Column Light Controls (Version B)
49.6 Exit Lights
49.7 Operate Turn Signals and High or Low Beam Road Lights
49.8 Safety Lights and Devices
49.9 CommandARM? Light Buttons
49.10 Hazard Lights and Extremity Warning Lights
49.11 Trailering Lights
49.12 Rotary Beacon Light
49.13 7-Pin Outlet (Equipped with Version A Lighting)
49.14 7-Pin Outlet (Equipped with Version B Lighting)
50 Accessories
50.1 Pull-Down Sunshade
50.2 Install Business Band or Citizens Band (CB) Radio and Antenna
50.3 Auxiliary Power Strip Use
50.4 Accessory Electrical Outlet Use
50.5 Connect Compatible Electronic Equipment
50.6 Configure Tractor for GPS or Radar
50.7 Refrigerator or Storage Space
51 HVAC
51.1 Climate Controls
51.2 HVAC Settings?Generation 4 CommandCenter?
52 Performance Ballasting
52.1 General Ballasting Information
52.2 Select Ballast
52.3 Calculate Maximum Permissible Download on Trailer Hitch
52.4 General Guidelines for Tractor Weight Based on PTO Power
52.5 General Weight Split Guidelines
52.6 Ballast Options
52.7 Ballast Suggestions for Specific Types of Implements
52.8 Calculate Tractor Ballast Package
52.9 Tire Sidewall Information
52.10 Unballasted Tractor Weight Chart
52.11 Worksheet to Calculate Ballast Changes
52.12 Controlling Power Hop-MFWD Tractors
52.13 Using Quik-Tatch? Weights
52.14 Rear Wheel Weight Use
52.15 Install Wheel Weights-Flanged Axles
52.16 Install Outer Wheel Weights-70 kg (154 lb) and 900 kg (1984 lb)
52.17 Liquid Ballast Use
52.18 Implement and Tractor Codes
52.19 Measure Wheel Slip-Manually
53 Transport
53.1 Drive Tractor on Roads
53.2 Transport with Ballast
53.3 Towed Mass
53.4 Tow Loads
53.5 Freeing a Mired Machine
53.6 Tow Points
53.7 Tow Mode
53.8 Towing Tractor
53.9 Transporting on Flat-Bed Carrier
53.10 Tie-Down on Transport Carrier
54 Fuel, Lubricants, and Coolant – General Information
54.1 Determine Tractor Engine Type
54.2 Minimizing the Effect of Cold Weather on Diesel Engines
54.3 Oil Filters
55 Fuel
55.1 Diesel Fuel
55.2 Supplemental Diesel Fuel Additives
55.3 BioDiesel Fuel
55.4 Lubricity of Diesel Fuel
55.5 Handling and Storing Diesel Fuel
55.6 Avoid Static Electricity Risk When Refueling
55.7 Fill Fuel Tank
55.8 Testing Diesel Fuel
55.9 Fuel Filters
56 Diesel Exhaust Fluid (DEF)
56.1 Diesel Exhaust Fluid (DEF) ? Use in Selective Catalytic Reduction (SCR) Equipped Engines
56.2 Storing Diesel Exhaust Fluid (DEF)
56.3 Refilling Diesel Exhaust Fluid (DEF) Tank
56.4 Fill DEF Tank – FT4/Stage IV Engine
56.5 Testing Diesel Exhaust Fluid (DEF)
56.6 Disposal of Diesel Exhaust Fluid (DEF)
57 Engine Oil
57.1 Diesel Engine Oil Service Interval for Operation at High Altitude
57.2 Diesel Engine Oil ? Tier 2 and Stage II
57.3 Engine Oil and Filter Service Intervals ? Tier 2 and Stage II Engines
57.4 Diesel Engine Oil ? Tier 3 and Stage III
57.5 Engine Oil and Filter Service Intervals ? Tier 3 and Stage III A ? PowerTech? Plus Engines
57.6 John Deere Break-In Plus? Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
57.7 Diesel Engine Oil ? Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
57.8 Engine Oil and Filter Service Intervals ? Interim Tier 4, Final Tier 4, Stage IIIB, Stage IV, and Stage V Engines
58 Engine Coolant
58.1 Diesel Engine Coolant (engine with wet sleeve cylinder liners)
58.2 Operating in Warm Temperature Climates
58.3 Water Quality for Mixing with Coolant Concentrate
58.4 Testing Coolant Freeze Point
58.5 Disposing of Coolant
59 Other Lubricants
59.1 Gear Oil
59.2 Grease
59.3 MFWD Axle Housing Oil
59.4 Corn Head Grease
59.5 Lubricant Storage
59.6 Alternative and Synthetic Lubricants
59.7 Mixing of Lubricants
59.8 Transmission and Hydraulic Oil
59.9 Powershift Transmission Recalibration
60 Service – General Information
60.1 Do Not Modify Fuel System
60.2 Do Not Open High-Pressure Fuel System
60.3 Bleed Fuel System
60.4 Diesel Particulate Filter Service
60.5 Service Sections Overview
60.6 Service Tasks Performed As Required
60.7 Identify Tractor Engine Emissions Status
60.8 Open Hood
60.9 Jack Up the Tractor – Lifting Points and Support Stand Placement
60.10 Service and Connect STC? (Snap-to-Connect) Fittings
60.11 High-Pressure Washer Use
60.12 Identify Zinc-Flake Coated Fasteners
60.13 Unified Inch Bolt and Screw Torque Values
60.14 Metric Bolt and Screw Torque Values
61 Service – Predelivery Checklist
61.1 Predelivery Checklist
62 Service – Delivery Checklist and Certificate
62.1 Delivery Checklist and Certificate
63 Break-In Service (100 Hours or Less)
63.1 Perform Break-In Checks
64 Service – Record Charts
64.1 Engine Oil and Filter Change
64.2 As Required Service
64.3 Annual Service
64.4 10 Hour or Daily Service
64.5 50 Hour Service
64.6 250 Hour Service
64.7 500 Hour Service
64.8 750 Hour Service
64.9 1000 Hour Service
64.10 1250 Hour Service
64.11 1500 Hour Service
64.12 1750 Hour Service
64.13 2000 Hour Service
64.14 2250 Hour Service
64.15 2500 Hour Service
64.16 2750 Hour Service
64.17 3000 Hour Service
64.18 3250 Hour Service
64.19 3500 Hour Service
64.20 3750 Hour Service
64.21 4000 Hour Service
64.22 4250 Hour Service
64.23 4500 Hour Service
64.24 4750 Hour Service
64.25 5000 Hour Service
64.26 5250 Hour Service
64.27 5500 Hour Service
64.28 5750 Hour Service
64.29 6000 Hour Service
64.30 Services Beyond 6000 Hours
65 Service – Clean
65.1 Diesel Particulate Filter (DPF)?Final Tier 4/Stage IV Engine
65.2 Exhaust Filter/Diesel Particulate Filter (DPF) Ash Handling and Disposal
65.3 Exhaust Filter Disposal
65.4 Engine Cooling System
65.5 Exhaust Enclosure
65.6 Access DEF Tank Drain Plug
65.7 DEF Tank
65.8 Clean Display
65.9 Dual Beam Radar Sensor
65.10 Optional Fuel Water Separator
65.11 Optional Fuel Water Separator Filter Element
65.12 MFWD Axle Breather Filter
65.13 Hydraulic Oil Suction Screen
65.14 Paint Finish
65.15 ILS? Axle Internal Tie Rod Ball Joint Boots
66 Service – Check
66.1 Engine Coolant Level
66.2 Coolant Freeze Point
66.3 Water Separator
66.4 Engine and Exhaust Compartments
66.5 Air Conditioning System
66.6 Engine Water Pump Weep Hole – Tier 2/Stage II Engine
66.7 Engine Water Pump Weep Hole – Final Tier 4/Stage IV Engine
66.8 Vari-Cool? Fan Drive and Belt?Final Tier 4/Stage IV Engine
66.9 Fuel Tank Sump
66.10 MFWD Axle Housing Oil Level
66.11 MFWD or ILS? Wheel Hub Oil Level
66.12 Trailer Hydraulic Brakes
66.13 Trailer Air Brakes
66.14 Engine Oil Level
66.15 Transmission-Hydraulic Oil Level
66.16 Tires
66.17 Secondary Brake
66.18 NEUTRAL Start System
66.19 Transmission PARK System
66.20 Manually Operated Hitch
66.21 Remote Controlled Hitch
66.22 Tow Hitch (Piton Fix)
66.23 Ball-Type Tow Hitch
66.24 Pick-Up Hitch Tow-Hook
66.25 Engine Air Intake System?Final Tier 4/Stage IV Engine
66.26 Engine Air Intake System?Tier 2/Stage II or Interim Tier 4/Stage IIIB Engine
66.27 Cab Suspension Accumulator Charge Pressure
66.28 Seat Belts
66.29 ILS? Upper and Lower Rod and Head End Accumulator Charge Pressure
66.30 Auxiliary Drive Belt and Drive Belt Tensioner
66.31 Engine Valve Clearance
67 Service – Tighten
67.1 Wheel and Wheel Weight Bolts
67.2 Use Wheel Tightening Stand
67.3 Use Wheel Torque Wrench Adapter
67.4 Rear Wheel Weight Bolts
67.5 Front Wheel Bolts
67.6 Rear Drive Wheel to Cast Hub Bolts
67.7 Rear Steel Wheel to Hub Bolts
67.8 Rear Steel Wheels?Cast Hub Bolts
67.9 Rear Wheel Bolts?Heavy-Duty Cast 10-Bolt Hubs
68 Service – Change
68.1 Vari-Cool? Fan Belt – 9.0L Final Tier 4/Stage IV Engines
68.2 Vari-Cool? Fan Drive Bushings, Seals, and Wear Pads?9.0L Final Tier 4/Stage IV Engine
68.3 Auxiliary Drive Belt
68.4 Engine Oil and Filter
68.5 Fuel Filters
68.6 Cab Classification According to EN 15695-1 (for Application of Crop Protection Chemicals and Liquid Fertilizer) (2010/52/EU)
68.7 Cab Recirculation Air Filter
68.8 Cab Fresh Air Filter
68.9 Engine Primary and Secondary Air Filters
68.10 Fuel Tank Vent Filter
68.11 SCV Pilot Valve Filter
68.12 DEF Tank Vent Filter?Final Tier 4/Stage IV Engine
68.13 DEF Header Filter?Final Tier 4 or Stage IV Engine
68.14 Differential Oil
68.15 Drain 16-Speed Transmission
68.16 IVT?/AutoPowr? and e23?Transmissions-Hydraulic Oil
68.17 Drain ILS?
68.18 Transmission-Hydraulic Oil Filter
68.19 Transmission-Hydraulic Oil and Filters
68.20 MFWD or ILS? Wheel Hub Oil
68.21 MFWD Axle Housing Oil
68.22 Trailer Air Brake Air Dryer Filter
68.23 Access DEF Dosing Unit Filter?Final Tier 4/Stage IV Engine
68.24 DEF Dosing Unit Filter?Final Tier 4/Stage IV Engine
68.25 Engine Crankshaft Damper
68.26 Transmission Torsional Damper
68.27 Engine Coolant
69 Service – Lubricate
69.1 MFWD U-Joints
69.2 ILS? King Pins, Tie Rod Ends, Pivot Fittings, and Suspension Cylinders
69.3 Rear Hitch
69.4 Deluxe Stabilizers
69.5 Front Hitch
69.6 Wagon Hitch
69.7 Pick-Up Hitch
69.8 MFWD Axle King Pins, Tie Rod Ends, Axle Pivot Fittings, and Steering Cylinders (1300 MFWD Axle)
69.9 MFWD Axle King Pins, Tie Rod Ends, Axle Pivot Fittings, and Steering Cylinders (1500 MFWD Axle)
69.10 ILS? Inboard U-Joint
69.11 Cab Suspension
69.12 Front PTO Drive Shaft
69.13 Draft Link Support Shaft Bushing
69.14 ILS? Axle Internal Tie Rod Ball Joints
69.15 Vari-Cool? Fan Drive?Final Tier 4/Stage IV Engine
70 Service – Electrical
70.1 Service – Electrical Overview
70.2 Welding Near Electronic Control Units
70.3 Keep Electronic Control Unit Connectors Clean
70.4 Compressed Air Use
70.5 High-Pressure Washers Use
70.6 Disconnect Battery?Final Tier 4/Stage IV Engine
70.7 Handling Batteries Safely
70.8 Service Batteries and Connectors
70.9 Access Load Center Fuses
70.10 Access Front Load Center
70.11 Access Master Fuses
70.12 Access Implement Power Relay Module Fuses
70.13 Handle Halogen Light Bulbs Safely
70.14 Change Front HID/LED Light Assembly
70.15 Change Front Grille Halogen Light Bulbs
70.16 Adjust Front Grille Lights
70.17 Adjust Headlights
70.18 Change Front, Side And Rear Cab Roof Light Bulb
70.19 Change Brake or Turn Signal Light Bulb
70.20 Change Dome Light Bulb
70.21 Change Extremity Warning Light Bulb
70.22 Change Trailering Light Bulb
71 Troubleshooting – Procedures
71.1 Engine
71.2 Transmission
71.3 Hydraulic System
71.4 Hitch
71.5 Selective Control Valve (SCV)
71.6 TouchSet Depth Control
71.7 Electrical System
71.8 Operator Enclosure
71.9 Tractor Operation
71.10 ILS? Troubleshooting
71.11 Steering System
71.12 Premium Radio
72 Troubleshooting – Diagnostic Trouble Codes (DTC)
72.1 STOP and Service Alert Indicators
72.2 Information Indicator
72.3 Access Diagnostic Trouble Codes
73 Service – Storage
73.1 Place Tractor in Storage
73.2 Remove Tractor from Storage
73.3 Paint Finish Care
74 Specifications
74.1 Engine
74.2 Capacities
74.3 Hydraulic System
74.4 Transmission and Power Train
74.5 Hitch, Drawbar, and PTO
74.6 Electrical System
74.7 Other Equipment
74.8 Sound